SportsPlay 801-312-H Bedienungsanleitung

801-312-H See Saw 6 Seat

Page 1

Rev. 09/10/2010

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

www.sportsplayinc.com

IMPORTANT

PLEASE READ THESE INSTRUCTIONS BEFORE COMMENCING ASSEMBLY. Please retain

this instruction sheet in your files. It contains important replacement

parts information. All equipment must be installed in accordance with these

instructions. It is important to use and maintain all public playground

equipment properly. Playground equipment, which is improperly maintained,

can cause serious injury. Periodical inspections, maintenance, repair and/or

replacement of damaged parts is necessary for safe operation of equipment.

Appropriate publications, available at no charge, from the consumer product

safety commission, include “A Handbook for Public Playground safety”. You

can receive your free copy by calling 1-301-504-7908.

PACKING LIST

HARDWARE BAG

CTN

Hardware Bag

105-017

2 3/8” Pipe Plug

503-501

Elbow

196-802

1/2” x 1/2” Socket Set Screw

803-522

Fulcrum

116-550

5/16” x 3” B.H. Bolt

803-523

Sleeve

116-543

5/16” x 2 1/4” B.H. Bolt

803-524

Handle

326-501

5/16” Lock Washer

803-925

Seat Boards

216-512

5/16” x 1” B.H. Nut

BDL

803-601

Pipe 2 3/8” OD x 3’6” Long

416-400

1/4” Socket Key

PIPE

803-226H

Pipe Supports

416-350

3/16” Socket Key

PIPE

803-602

Pipe 7’ Long 2 3/8” OD

516-350

PermaBond Threadlocker Tube

343-501

“T” Fitting

805-532

Warning Label

805-534

SportsPlay Label

Maintenance Checklist

1 CTN 1 BDL 7 PIPE 9 TOTAL PCS 350# Weight Class 70

801-312-H See Saw 6 Seat

Page 2

Rev. 09/10/2010

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

www.sportsplayinc.com

GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS:

Stationary & portable equipment –use/fall zones should extend a minimum of 6

feet in all directions from the perimeter of the equipment ground space.

This area should be covered with the required amount of resilient safety

surfacing material. For some equipment –use/fall zones can overlap. See

Consumer Product Safety Commission guidelines. Diameter & depth of footings

illustrated are satisfactory in most applications for pipe sizes up to 2 3/8”

diameter. Varying soil & climactic conditions may require deeper & heavier

footings in some areas. Check local building codes.

DETAIL: Permanent Installation Suggested Bracing Method

•If resilient surfacing is to be less than 12”, then additional pipe

should be put in concrete to maintain proper finish grade for

equipment.

USE AREA & FOOTING LAYOUT:

801-312-H See Saw 6 Seat

Page 3

Rev. 09/10/2010

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

www.sportsplayinc.com

GENERAL INSTRUCTIONS:

Car tires (not furnished) or some other shock-absorbing material should be

embedded in the ground beneath the seats to minimize the risk of injury due

to abrupt contact with the ground. Also, lengths of standard 2 x 4’s can be

easily positioned between the pipe rails to prevent children from putting

their feet between the rails.

GENERAL MAINTENANCE INSTRUCTIONS:

Check MONTHLY for loose bolts, damaged or broken parts. Tighten and/or

replace immediately.

SPECIFIC ASSEMBLY AND INSTALLATION:

NOTE:

All button head nuts are placed on the pipe side of the spots where

attached and the lock washers are placed on the Bolts. DO NOT tighten

nuts more than hand-tight until entire assembly is completed.

STEP #1:

Assemble frame by first attaching one leg to 8’ long top rail using

elbow. Tighten with set screws. Slide fulcrum over top rail to elbow by

leg, then sleeve so holds fulcrum in place. Tighten sleeve with set

screw to bottom of top rail. Attach middle leg to center fitting and

slide over top rail. Position so middle leg will be 3’7” from first leg.

Tighten to top rail. Then slide another fulcrum onto the top rail down

to the center fitting, followed by another sleeve. Tighten sleeve to

bottom of top rail so holds fulcrum against center fitting. Finally

slide last sleeve, then fulcrum onto top rail, position last leg into

elbow and onto top rail. Slide last fulcrum and sleeve back up against

elbow and secure with set screws. DO NOT attach see saws at this time.

STEP #2:

Using assembled frame as your template, mark and dig footing holes.

STEP #3:

Prop in holes, leaving 15-18” distance from resilient surface to top of

frame, plumb, level and pour concrete. Allow at least 48 hours for

concrete to harden.

STEP #4:

After concrete has hardened, attach the rest of the equipment. Use the

5/16” x 2 1/4” button head bolts, lock washers and button head nuts to

attach the long pipe supports to the fulcrums. Use the 5/16” x 3” button

head bolts, lock washers and button head nuts to attach the seat and

handle to the pipe supports. Use Threadlocker on all button head

fasteners. Drive pipe plugs into the open ends of the pipe supports.

STEP #5:

Attach Warning Label and Manufacturer’s Identification Label to a clean

surface. The labels should be attached in a location where they are

clearly visible and legible and away from normal hand and foot placement

areas. The labels must be replaced if they become illegible, destroyed

or are missing. Contact your SportsPlay distributor for replacement

labels.

Inhaltsverzeichnis

Andere SportsPlay Spielgeräte und Spielplatzausstattung Handbücher

SportsPlay

SportsPlay 902-795 Bedienungsanleitung

SportsPlay

SportsPlay 581-838H Bedienungsanleitung

SportsPlay

SportsPlay LAUREN Bedienungsanleitung

SportsPlay

SportsPlay Miss Abby Installations- und Betriebshandbuch

SportsPlay

SportsPlay 581-643H Bedienungsanleitung

SportsPlay

SportsPlay Seth Mega Installations- und Betriebshandbuch

SportsPlay

SportsPlay 511-152 Bedienungsanleitung

SportsPlay

SportsPlay 902-293 6' IND. SECTIONAL SLIDE Bedienungsanleitung

SportsPlay

SportsPlay 511-146P Bedienungsanleitung

SportsPlay

SportsPlay 581-830-8F Bedienungsanleitung

SportsPlay

SportsPlay 581-438F Bedienungsanleitung

SportsPlay

SportsPlay 581-438M Bedienungsanleitung

SportsPlay

SportsPlay Independent Spiral Slide Bedienungsanleitung

SportsPlay

SportsPlay 511-109 Bedienungsanleitung

SportsPlay

SportsPlay SUPER SLIDE Bedienungsanleitung

SportsPlay

SportsPlay ZACK Bedienungsanleitung

SportsPlay

SportsPlay 301-146 10' MGR Bedienungsanleitung

SportsPlay

SportsPlay Bobbie 911-124 Bedienungsanleitung

SportsPlay

SportsPlay 902-875 Bedienungsanleitung

SportsPlay

SportsPlay 902-290 Bedienungsanleitung

SportsPlay

SportsPlay HERCULES CLIMBER VII Bedienungsanleitung

SportsPlay

SportsPlay 581-630-8M Bedienungsanleitung

SportsPlay

SportsPlay 581-238F Bedienungsanleitung

SportsPlay

SportsPlay Value Series Bedienungsanleitung

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung