Stuart Turner WASTEFLO BC3 Handbuch

BC3 – Boiler Condensate Pump

Installation, Operation & Maintenance Instructions

In the box Safety

zIf pump fails, the safety float switch will shut off boiler

operation.

zPump suitable for boiler with heat output 200 kW

(0.68 m Btu/h) condensate PH value >2.2+.

Do not handle pump in wet conditions or with wet

hands

zTo reduce the risk of electric shock, ensure electrical

supply is permantently wired to earth.

zDisconnect supply before opening.

zThis appliance should ONLY be fitted and serviced by a

competent & qualified installer.

zThis applicance must be provided with means for

disconnection that is incorporated into the fixed wiring in

accordance with the relevant local wiring regulations.

zThis appliance is not intended for use by persons

(including children) with reduced physical, sensory or

mental capabilities, or lack of experience and knowledge,

unless they have been given supervision or

instruction concerning use of the appliance by a person

responsible for their safety.

zThis appliance must be earthed.

Speciﬁcation

zInlet up to 27 mm

zTank capacity: 2 litre

zHigh level safety cut-out

zOutlet size: 6 or 10 mm

zMaximum water temperature: 60 oC

Performance

X 1

10 mm I.D. x 6 m

X 1 – Cable clamp

X 2 – Cable ties

X 2 – Cable clamp

screws

2 m

WASTEFLO

Installation Electrical connections

zLive: Brown

zNeutral: Blue

zSafety switch: 2 x Black Earth – Yellow/Green

Stuart Turner Ltd, Henley-on-Thames, Oxfordshire RG9 2AD ENGLAND

Tel: +44 (0) 1491 572655, Fax: +44 (0) 1491 573704

info@stuart-turner.co.uk www.stuart-turner.co.uk

Position the pump alongside the boiler

so that the water flows into the top inlet

hole.

Connect the supplied 6 m length of

10 mm I.D. tubing to the pump outlet

using cable ties supplied.

Ensure that there are no kinks or trapped

parts.

zIf it is not possible to create a downward slope, you must

create an inverted U directly above the pump at the

highest point.

zWhere the tubing from the pump is connected directly to

the soil stack or waste pipe, there must always be either a

waste trap after the tubing connection or a 75 mm U trap

formed within the tubing.

zWhere the outlet from the pump is connected to an

external soil and vent stack extra care is necessary

to ensure that the condensate pipe could not be blocked

through the condensate freezing.

zThis pump is designed to sit level on its base or be fitted

level to a vertical surface. Mounting brackets are factory

fitted to the unit.

Power Supply

z230 V AC 50 Hz 0.8 A

zClass I appliance

z3.0 A safety switch, normally closed

The pre-wired switch must always be utilised.

zIf a fused plug is used, a 3 amp fuse is recommended.

Commissioning & Maintenance

zBefore servicing the pump, make sure the electrical power

is disconnected at the fuse box for both the pump and

boiler.

zWhen commissioning the pump please check for debris in

the pump tank. Remove any material that might block the

drain line or drain into the Boiler Condensate Pump.

zThe pump reservoir can be removed with ease for

cleaning purposes by undoing the screw located at the

front of the pump, depressing the front and allowing the

reservoir to be moved downwards (care should be taken

as there may be water in the reservoir). Note:

The pump does not need to be removed from its fixings to

clean the reservoir. The quick release outlet barb can be

removed very easily by twisting and pulling out.

zThe pump should be flushed through with anti-bacterial

wash every 6 months to avoid sludge build up in the pump

reservoir. Note: Contractors should satisfy themselves that

any chemicals used are suitable and will not damage the

pump.

zIf the supply cord is damaged the pump must be switched

off until the supply cord is replaced by a suitably qualified

person to avoid a hazard.

zIMPORTANT: The pre-wired switch must always be utilised,

this will stop the boiler system in the event of pump

failure.

zPump should be filled with water until motor runs, check

for leaks and proper discharge of water.

Contact TechAssist for

further help.

Issue No. 4219/3–02 Pt. No. 20061

4060/STU

5 m

BOILER

N E

MAX 3 AMP

PUMP

L L

N N

E E

Andere Stuart Turner Wasserpumpe Handbücher

Stuart Turner

Stuart Turner Supersub 460A Bedienungsanleitung

Stuart Turner

Stuart Turner FLOMATE MBF 12 Montage- und Bedienungsanleitung

Stuart Turner

Stuart Turner CH 4-30 FL Leitfaden

Stuart Turner

Stuart Turner Monsoon Extra S1.4 bar Leitfaden

Stuart Turner

Stuart Turner 46601 Leitfaden

Stuart Turner

Stuart Turner supersub 230a Betriebsanleitung

Stuart Turner

Stuart Turner techflo qt Leitfaden

Stuart Turner

Stuart Turner CH4-30 Leitfaden

Stuart Turner

Stuart Turner PH 45 ES Leitfaden

Stuart Turner

Stuart Turner AQUABOOST iMatic 0304 1S-CMT/8 450 Leitfaden

Stuart Turner

Stuart Turner Jet 55-45 Leitfaden

Stuart Turner

Stuart Turner Supersub 150VA Leitfaden

Stuart Turner

Stuart Turner PH 45 TS S Leitfaden

Stuart Turner

Stuart Turner Stuart SPU 130 Mini Leitfaden

Stuart Turner

Stuart Turner SHOWERMATE TP S1.5 bar Twin Leitfaden

Stuart Turner

Stuart Turner Wasteflo Montage- und Bedienungsanleitung

Stuart Turner

Stuart Turner Monsoon Series Leitfaden

Stuart Turner

Stuart Turner CH 4-30 B Leitfaden

Stuart Turner

Stuart Turner PH 35 ES Leitfaden

Stuart Turner

Stuart Turner CH 3-30 CI Leitfaden

Stuart Turner

Stuart Turner Showermate U2.6 bar Single Leitfaden

Stuart Turner

Stuart Turner Monsoon U1.5 bar Twin Leitfaden

Stuart Turner

Stuart Turner monsoon extra Bedienungsanleitung

Stuart Turner

Stuart Turner AQUABOOST MAB Leitfaden

Beliebte Wasserpumpe Handbücher anderer Marken

Neptun

Neptun NPHW 5500 Bedienungsanleitung

Sensidyne

Sensidyne Gilian BDX-II Montage- und Bedienungsanleitung

Draper

Draper 47808 Bedienungsanleitung

Trolla

Trolla 12820 Bedienungsanleitung

Sunfab

Sunfab SVH Series Bedienungsanleitung

WilTec

WilTec 50740 Bedienungsanleitung

Fieldmann

Fieldmann FVC 5015 EK Bedienungsanleitung

Everbilt

Everbilt EFSUB5-122HD Bedienungsanleitung

Graco

Graco Husky 3300e Bedienungsanleitung

esotec

esotec 101018 Bedienungsanleitung

moyno

moyno 2000 CC Bedienungsanleitung

Becker

Becker BASIC VASF 2.80/1-0.AC230 Bedienungsanleitung

Sykes AmeriPumps

Sykes AmeriPumps GP100M Fehlerbehebungshandbuch

DUROMAX

DUROMAX XP WX Series Bedienungsanleitung

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Bedienungsanleitung

Franklin Electric

Franklin Electric IPS Bedienungsanleitung

Xylem

Xylem e-1532 Series Bedienungsanleitung

Milton Roy

Milton Roy PRIMEROYAL Bedienungsanleitung