Sundance Spas 680 Series Bedienungsanleitung

BurlingtonTM • DenaliTM • TacomaTM

6530-680, Rev. B

Attention New Spa Owner!

Congratulations on the purchase of your new Sundance® 680 series

spa! The following is a list of automated functions and maintenance

recommendations for your new spa. Automated functions have been

listed below in an attempt to suppress any operational concerns you may

have during startup and the rst 24-hours of ownership! Maintenance

recommendations are listed in an attempt to stress their importance in

protecting your new spa.

Automated Operations

Approximately two minutes after power is applied to the spa, the rst

ltration/heating cycle turns on pump 1. In Burlington models, an automatic

ve minute “blow-out” function also activates pump 2 for a period of ve

minutes to ush all lines. Then, after ve minutes, pump 2 turns off and

pump 1 continues to operate for the duration of the cycle. Note: this function

only occurs during the rst ltration/heating cycle each day.

Maintain Healthy Spa Water

Always maintain your spa’s water chemistry within the following parameters

as dened by the Association of Pool And Spa Professionals/USA:

Always maintain your spa lter as outlined below to ensure healthy spa

water. Refer to page 29 for additional information.

Required Filter Maintenance

Your new spa is equipped with an advanced water ltration system that

provides unsurpassed water quality! To ensure maximum water quality at

all times, you should clean and reuse the lter cartridge every month. See

page 25 for detailed lter cleaning/replacement instructions.

Required Water Maintenance

You should replace the spa’s water every 3 months. The frequency

depends on a number of variables including frequency of use, number of

users, and attention paid to water quality maintenance. You will know it

is time for a change when you cannot control sudsing and/or you can no

longer get the normal feel or sparkle to the water, even though the key

water balance measurements are all within the proper parameters. See

page 29 for additional information.

pH 7.2 - 7.4

Free Chlorine 3-5 ppm

Free Bromine 4-6 ppm

Total Alkalinity 100-120 ppm

Calcium Hardness 150-250 ppm

Table of Contents

1.0 Important Spa Owner Information..................................1

2.0 FCC Notice........................................................................1

3.0 Important Safety Instructions.........................................2

3.1 Important CSA Safety Information (Canada Only).............4

3.2 Hyperthermia .....................................................................5

3.3 Cautions.............................................................................6

3.4 General Electrical Safety Instructions................................6

4.0 Choosing A Location.......................................................7

4.1 Outdoor Location ...............................................................8

4.2 Indoor Location ..................................................................8

5.0 Power Requirements .......................................................9

6.0 Electrical Wiring Instructions .......................................11

7.0 Spa Fill Up Procedure ...................................................14

8.0 Control Functions ..........................................................19

8.1 Control Panel ...................................................................19

8.2 Spa Features And Controls..............................................20

9.0 Operating Instructions ..................................................21

9.1 Setting Water Temperature ..............................................21

9.2 Activate Pumps ................................................................21

9.3 Light Button......................................................................22

9.4 Adjusting Individual Jet Flow ...........................................22

9.5 Selecting Desired Massage Action ..................................22

9.6 Air Controls ......................................................................22

10.0 Automatic Filtration Cycles ..........................................23

10.1 Standard Filtration/Heating Modes (F1 - F3)...................23

10.2 Economy Filtration/Heating Modes (F4 - F6)...................23

10.3 Lock Modes (L1 - L2).......................................................23

10.4 Selecting The Filtration/Heating Mode.............................23

11.0 Spa Maintenance............................................................25

11.1 Cleaning The Filter...........................................................25

11.2 Draining and Refilling.......................................................25

11.3 Cleaning The Spa Interior................................................27

11.4 Maintaining The Cover.....................................................27

11.5 Maintaining The Synthetic Cabinet..................................27

11.6 Winterizing .......................................................................28

11.7 Restarting Your Spa in Cold Weather..............................28

12.0 Water Quality Maintenance ...........................................29

12.1 pH Control........................................................................29

12.2 Sanitizing .........................................................................29

12.3 Optional CD Ozone Water Maintenance System ............30

13.0 Error Conditions/Error Messages ................................31

13.1 Panel Displays SN1 .........................................................31

13.2 Panel Displays SN2 .........................................................31

13.3 Panel Displays FL1..........................................................31

13.4 Panel Displays FL2..........................................................31

13.5 Panel Displays COL.........................................................31

13.6 Panel Displays ICE ..........................................................31

13.7 Panel Displays OH...........................................................32

13.8 Panel Displays - - - - .......................................................32

14.0 Troubleshooting Procedures ........................................33

14.1 None of The Components Operate..................................33

14.2 Pump Does Not Operate but Light Does.........................33

14.3 Poor Jet Action.................................................................33

14.4 Water is Too Hot ..............................................................33

14.5 No Heat............................................................................34

15.0 Denali/Tacoma Convertible Circuit Diagram (60Hz) ...35

16.0 Burlington Circuit Diagram (60Hz) ...............................36

17.0 Denali/Tacoma Export Circuit Diagram (50Hz)............37

18.0 Burlington Export Circuit Diagram (50Hz) ..................38

Page 1

1.0 Important Spa Owner Information

Your Sundance® 680 series spa is constructed to the highest standards

and is capable of providing many years of trouble-free use. However,

because heat retentive materials are utilized to insulate the spa for effi-

cient operation, an uncovered spa surface directly exposed to sunlight

and high temperatures for an extended period is subject to permanent

damage. Damage caused by exposing the spa to this abuse is not

covered by warranty. We recommend that you always keep the spa

full of water when it is exposed to direct sunlight and that you keep the

Sundance premium insulating cover in place at all times when the spa

is not in use. Read and carefully follow the requirements for your spa’s

support base found in section 4.0 titled, “Choosing a Location” (page 7).

Sundance constantly strives to offer the finest spas available,

therefore modifications and enhancements may be made which

affect the specifications, illustrations and/or instructions contained

herein.

2.0 FCC Notice

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These

limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used

in accordance with the instructions, may cause harmful interference to

radio communications. However, there is no guarantee that interference

will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be deter-

mined by turning the equipment off and on, the user is encouraged to

try to correct the interference by one or more of the following measures:

1. Rearrange or relocate the receiving antenna.

2. Increase the separation between the equipment and receiver

3. Connect the equipment into an outlet on a circuit different from the

circuit connected.

4. Consult the dealer or an experienced radio/TV technician for help.

Changes or modifications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.

Page 2

3.0 Important Safety Instructions

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY!

When installing and using this electrical equipment, basic safety precau-

tions should always be followed, including:

1. WARNING: To reduce the risk of injury, do not permit children to use

this product unless they are closely supervised at all times.

2. WARNING: A grounding wire connector is provided on this unit to

connect a minimum No. 8 AWG (8.4mm2) solid copper conduc-

tor between this unit and any metal equipment, metal enclosures

of electrical equipment, metal water pipe, or conduit within 5 feet

(1.5m) of the unit.

3. DANGER: Risk of Accidental Drowning. Extreme caution must be

exercised to prevent unauthorized access by children. To avoid

accidents, ensure that children cannot use this spa unless they are

supervised at all times.

4. DANGER: Risk of Injury. The suction fittings in this spa are sized to

match the specific water flow created by the pump. Should the need

arise to replace the suction fittings or the pump, be sure that the

flow rates are compatible. Never operate the spa if the suction fit-

tings are broken or missing. Never replace a suction fitting with one

rated less than the flow rate marked on the original suction fitting.

5. DANGER: Risk of Electric Shock. Install at least 5 feet (1.5m) from

all metal surfaces. As an alternative, a spa may be installed within

5 feet (1.5m) of metal surfaces if each metal surface is permanently

connected (bonded) by a minimum No. 8 AWG (8.4mm2) solid cop-

per conductor attached to the wire connector on the grounding lug,

inside the equipment compartment on the equipment box.

6. DANGER: Risk of Electric Shock. Do not permit any electrical appli-

ance, such as a light, telephone, radio, television, etc. within 5 feet

(1.5m) of a spa, unless such appliances are built-in by the manufac-

turer.

7. ELECTRICAL SUPPLY: The electrical supply for this product

must include a suitably rated switch or circuit breaker to open all

ungrounded supply conductors to comply with section 422-20 of the

Page 3

National Electrical Code/USA, ANSI/NFPA 70. The disconnect must

be readily accessible and visible to the spa occupant but installed at

least 5 feet (1.5m) from the spa water.

8. WARNING: To Reduce the Risk of Injury:

9. The water in a spa should never exceed 104°F (40°C). Water

temperatures between 100°F (38°C) and 104°F (40°C) are consid-

ered safe for a healthy adult. Lower water temperatures are recom-

mended for young children and when spa use exceeds 10 minutes.

10. Since excessive water temperatures have a high potential for caus-

ing fetal damage during the early months of pregnancy, pregnant or

possibly pregnant women should limit spa water temperatures to

100°F (38°C). If pregnant, please consult your physician before

using a spa.

11. Before entering the spa, the user should measure the water tem-

perature with an accurate thermometer since the tolerance of water

temperature-regulating devices may vary as much as +/- 5°F (2°C).

12. The use of alcohol, drugs, or medication before or during spa use

may lead to unconsciousness with the possibility of drowning.

13. Persons suffering from obesity or a medical history of heart disease,

low or high blood pressure, circulatory system problems, diabetes,

infectious diseases or immune deficiency syndromes should consult

a physician before using a spa. If you experience breathing dif-

ficulties in association with using or operating your spa, discontinue

use and consult your physician.

14. Persons using medication should consult a physician before using

a spa since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

15. Always shower before and after using your spa. To reduce the pos-

sibility of contracting a waterborne illness, always maintain water

chemistry within the parameters listed on the inside cover of this

manual. If you or other bathers experience such a condition, dis-

continue use and seek medical attention.

Page 4

3.1 IMPORTANT CSA SAFETY INSTRUCTIONS (CANADA ONLY)

When using this electrical equipment, basic safety precautions should

always be followed, including the following:

1. READ AND FOLLOW ALL INSTRUCTIONS.

2. A green colored terminal or a terminal marked G, Gr, Ground,

Grounding or the symbol* is located inside the supply terminal

box or compartment. To reduce the risk of electric shock, this

terminal must be connected to the grounding means provided in the

electric supply service panel with a continuous copper wire

equivalent in size to the circuit conductors that supply this

equipment (*IEC Publication 417, Symbol 5019).

3. At least two lugs marked “Bonding Lugs” are provided on the

external surface or on the inside of the supply terminal box/

compartment. To reduce the risk of electric shock, connect the local

common bonding grid in the area of the spa to these terminals with

an insulated or bare copper conductor not smaller than No. 6 AWG

(10mm2).

4. All field-installed metal components such as rails, ladders, drains

or other similar hardware within 10 feet (3m) of the spa shall be

bonded to the equipment grounding buss with copper conductors

not smaller than No. 6 AWG (10mm2).

5. SAVE THESE INSTRUCTIONS

WARNING: Children should not use spas without adult supervision.

WARNING: Do not use spas unless all suction guards are installed to

prevent body and hair entrapment.

WARNING: People with infectious diseases should not use a spa.

WARNING: To avoid injury, exercise care when entering or exiting the

spa.

WARNING: Do not use drugs or alcohol before or during the use of a

spa to avoid unconsciousness and possible drowning.

Page 5

WARNING: Pregnant or possibly pregnant women should consult a

physician before using a spa.

WARNING: Water temperature in excess of 38°C (104°F) may be

injurious to your health.

WARNING: Before entering the spa, measure the water temperature

with an accurate thermometer.

WARNING: Do not use a spa immediately following strenuous exercise.

WARNING: Prolonged immersion in a spa may be injurious to your

health.

WARNING: Do not permit electric appliances (such as light, telephone,

radio, television, etc.) within 5 feet (1.5m) of this spa unless factory

installed.

CAUTION: Maintain water chemistry in accordance with manufacturer’s

instructions.

WARNING: The use of alcohol or drugs can greatly increase the risk of

fatal hyperthermia in spas.

3.2 HYPERTHERMIA

Prolonged immersion in hot water may induce hyperthermia. A description

of the causes, symptoms, and effects of hyperthermia are as follows:

Hyperthermia occurs when the internal temperature of the body reaches

a level several degrees above the normal body temperature of 98.6°F

(37°C). The symptoms of hyperthermia include drowsiness, lethargy, and

an increase in the internal temperature of the body. The effects of hyper-

thermia include:

A Unawareness of impending hazard;

B. Failure to perceive heat;

C. Failure to recognize the need to exit spa;

D. Physical inability to exit spa;

E. Fetal damage in pregnant women; and

F. Unconsciousness and danger of drowning.

Page 6

3.3 CAUTIONS

1. Persons suffering from heart disease, diabetes, high or low blood

pressure, and any condition requiring medical treatment, pregnant

women, the elderly, or infants should consult with a physician before

using a spa.

2. The Consumer Products Safety Commission/USA has stated that

the water temperature in a spa should not exceed 104°F (40°C).

Immersion in water in excess of 104°F (40°C) can be hazardous to

your health.

3. Observe a reasonable time limit when using the spa. Long expo-

sures at higher temperatures can cause high body temperature.

Symptoms may include dizziness, nausea, fainting, drowsiness, and

reduced awareness. These effects could possibly result in drown-

ing.

4. Do not use the spa under the influence of alcohol, narcotics, or

other drugs. Use of the spa under these conditions may lead to seri-

ous consequences.

5. Always test the spa water temperature before entering the spa.

Enter and exit the spa slowly. Wet surfaces can be very slippery.

6. Never bring any electrical appliances into or near the spa. Never

operate any electrical appliances from inside the spa or when you

are wet unless such appliances are built-in by the manufacturer.

7. Proper chemical maintenance of spa water is necessary to maintain

safe water and prevent possible damage to spa components.

8. Use the straps and clip tie downs to secure the cover when not in

use. This will help to discourage unsupervised children from enter-

ing the spa and keep the spa cover secure in high-wind conditions.

There is no representation that the cover, clip tie-downs, or actual

locks will prevent access to the spa.

3.4 GENERAL ELECTRICAL SAFETY INSTRUCTIONS

Your new Sundance® spa is equipped with a “state-of-the-art” equip-

ment system. It contains the most advanced safety and self-protective

equipment in the industry. Nonetheless, this spa must be installed prop-

erly to ensure dependable usage. Please contact your local Sundance

dealer or local building department should you have any questions

regarding your installation.

Proper grounding is extremely important. Sundance spas are equipped

with a current collector system. A pressure wire connector is provided

on the surface of the control box, located outside the equipment door

(Figure-B, page 13) to permit connection of a bonding wire between

Andere Handbücher für 680 Series

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sundance Spas Whirlpool Handbücher

Sundance Spas

Sundance Spas Denali 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Edison Bedienungsanleitung

Sundance Spas

Sundance Spas CAMDEN 780 Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR 880 Gebrauchs- und Wartungshandbuch

Sundance Spas

Sundance Spas Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Altmar Bedienungsanleitung

Sundance Spas

Sundance Spas Maxxus Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Maxxus Betriebsanleitung

Sundance Spas

Sundance Spas Architectural Series Bedienungsanleitung

Sundance Spas

Sundance Spas 850Export Series Betriebsanleitung

Sundance Spas

Sundance Spas Portofino Series Montageanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas CAMDEN 780 Bedienungsanleitung

Sundance Spas

Sundance Spas 850 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Camden Bedienungsanleitung

Sundance Spas

Sundance Spas Export 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR 880 Bedienungsanleitung

Sundance Spas

Sundance Spas Hawthorne Bedienungsanleitung

Sundance Spas

Sundance Spas Altamar 880 series Bedienungsanleitung

Sundance Spas

Sundance Spas Hamilton Bedienungsanleitung

Sundance Spas

Sundance Spas Marin 880 Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Beliebte Whirlpool Handbücher anderer Marken

Bestway

Bestway Lay-Z-Spa 54189 Bedienungsanleitung

Jacuzzi

Jacuzzi ARGA ARG101C0110 Stücklistenhandbuch

Softub

Softub PRESTIGE Bedienungsanleitung

JNJ SPAS

JNJ SPAS SPA-318 Installationshandbuch

KIRAMI

KIRAMI Comfort Family Bedienungsanleitung

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Bedienungsanleitung

HoMedics

HoMedics FB-655HJ-GB Bedienungsanleitung

Everyday Hot Tubs

Everyday Hot Tubs 530 Bedienungsanleitung

anko

anko SS-601A Bedienungsanleitung

Jacuzzi

Jacuzzi Duetta 6042 Bedienungsanleitung

Pooli

Pooli OS030979B Bedienungsanleitung

Jacuzzi

Jacuzzi alimia Bedienungsanleitung

ab Solares Smart Spa Bedienungsanleitung

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Bedienungsanleitung

Outsunny

Outsunny 848-047V70 Bedienungsanleitung

Aquatic

Aquatic INFINITY 1 Bedienungsanleitung

Master Spas

Master Spas MP Force Bedienungsanleitung

Asteria

Asteria 5630 Bedienungsanleitung