Sundance Spas Maxxus Betriebsanleitung

Maxxus

Installation & Owner’s Manual

Maxxus

Installation & Owner’s Manual

Attention New Hot Tub Owner!

Congratulations on the purchase of your new Sundance Hot Tub! The

following is a list of automated functions performed by your hot tub.

These functions are listed below in an attempt to suppress any

operational concerns you may have during the first 24-hours of owner-

ship! Also listed below are important maintenance recommendations

you should observe on a regular basis to protect your new investment.

Automated Operations

Your new hot tub is equipped with an automated “blow-out” cycle that

clears all plumbing lines daily to promote maximum water sanitation.

Each day at 12:00 PM (noon), pump 2 and pump 3 will automatically

turn on for a period of one minute, then go off. Then pump 1 will turn

on and run for one minute to complete the cycle. Be aware, the factory

programmed blow-out cycle cannot be canceled or altered! However, If

you set one of four programmable skimming/heating cycles to overlap or

start at 12:00 (noon), pump 1 will turn on as programmed and operate

for the duration of the programmed cycle, overriding the factory “blow-

out” cycle. See page 28 for detailed skimming/heating cycle program-

ming instructions.

Filter Maintenance

Your new hot tub is equipped with an advanced 2-stage MicroCleanTM

water filtration system that provides unsurpassed water quality! To

ensure maximum water quality at all times, you should clean and reuse

the larger pleated filter cartridge every month and replace (throw-away)

the smaller MicroClean cartridge every 3 months, or as needed. The

smaller cartridge is designed as a throw-away cartridge! Attempts to

reuse this cartridge will result in the re-release of particles trapped within

it’s fibrous body back into the hot tub. For this reason, always replace it!

See page 32-33 for detailed filter replacement instructions.

Water Maintenance

You will want to replace the hot tub’s water every 3 to 6 months. The

frequency depends on a number of variables including the frequency of

use, number of users, attention paid to water quality maintenance, etc.

You will know it is time for a change when you cannot control sudsing

and/or you can no longer get the normal feel or sparkle to the water,

even though the key water balance measurements are all within the

proper parameters. See page 37 for additional information.

Table of Contents

1.0 Important Hot Tub Owner Information..................................1

2.0 Important Safety Instructions...................................................2

3.0 Locating Your Sundance Hot Tub............................................8

4.0 General Electrical Safety Instructions....................................9

5.0 Electrical Installation Instructions (240V Service) ............11

6.0 Power Requirements..................................................................12

7.0Start-Up Instructions.................................................................13

8.0 Operating Instructions .............................................................17

8.1 View....................................................................................................................17

8.2 SunGlowTM Light...........................................................................................17

8.3 Perimeter Lights............................................................................................17

8.4 Jet/Air Controls Diagram..........................................................................18

8.5 Jets 1................................................................................................................19

8.6 Jets 2................................................................................................................19

8.7 Jets 3................................................................................................................19

8.8 Selecting The Desired Massage Action..............................................19

8.9 Adjusting Fluidix Intelli-Jets......................................................................19

8.10 Air Controls.....................................................................................................20

8.11Optional SunSoundTM Audio System...................................................20

9.0 Automatic Filtration Cycles.....................................................27

9.1 Standard Skimming/Heating Mode.....................................................27

9.2 Economy Skimming/Heating Mode....................................................27

9.3 Selecting Standard or Economy Skimming/Heating Mode......28

9.4 Preset Skimming/Heating Cycles..........................................................28

9.5 Clean-Up “Blow-Out” Cycle......................................................................28

10.0 Programming Instructions.......................................................28

10.1 Adjusting Time of Day...............................................................................28

10.2 Changing Skimming/Heating Cycles..................................................29

10.3 Programming The Change Filter Reminder......................................30

10.4 Programming Circulation Pump Run Time.......................................30

10.5 Locking Skimming/Heating Cycles......................................................31

10.6 Panel Lock.......................................................................................................31

10.7 Temperature SettingLock..........................................................................31

11.0 Hot Tub Maintenance..............................................................32

11.1 Cleaning the Filter.....................................................................................32

11.2Draining and Refilling...............................................................................34

11.3 Cleaning the Hot Tub Interior...............................................................35

11.4 Pillow Care....................................................................................................35

11.5 Maintaining the Wood Cabinet............................................................35

11.6 Maintaining the Optional Synthetic Cabinet..................................36

11.7 Maintaining the Cover.............................................................................36

11.8 Winterizing....................................................................................................36

11.9 Restarting your Hot Tub in Cold Weather ......................................37

12.0 Water Quality Maintenance...................................................37

12.1 pH Control.....................................................................................................38

12.2 Sanitizing.......................................................................................................38

12.3 Other Additives...........................................................................................38

12.4 Optional SunZoneTM Water Maintenance System.......................38

12.5 Handrail Maintenance..............................................................................39

13.0 Troubleshooting - Display Messages ..................................39

14.0 Troubleshooting - Procedures................................................41

15.0 Electrical Wiring Diagram (Domestic 60 Hz)....................44

16.0 Electrical Wiring Diagram (Export 50 Hz).........................45

17.0 Typical Spa Wiring Diagrams A-B (Domestic 60 Hz)......46

1.0 Important Hot Tub Owner Information

Your Sundance hot tub is constructed to the highest stan-

dards and is capable of providing many years of trouble-free

use. However, because heat retentive materials are utilized

to insulate the hot tub for efficient operation, an uncovered

hot tub surface directly exposed to sunlight and high tem-

peratures for an extended period is subject to permanent

damage. Damage caused by exposing the hot tub to this

abuse is not covered by warranty. We recommend that you

always keep the hot tub full of water when it is exposed to

direct sunlight and that you keep the Sundance insulating

cover in place at all times when the hot tub is not in use.

Read and carefully follow the requirements for your hot tub’s

support base found in the section 3.0 titled, “Locating Your

Sundance Hot tub” (page 8).

Sundance Spas constantly strives to offer the finest hot

tubs available, therefore, modifications and enhancements

may be made which affect the specifications, illustrations

and/or instructions contained herein.

FCC Notice

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These lim-

its are designed to provide reasonable protection against harmful interfer-

ence in a residential installation. This equipment generates, uses and can

radiate radio frequency energy and, if not installed and used in accor-

dance with the instructions, may cause harmful interference to radio com-

munications. However, there is no guarantee that interference will not

occur in a particular installation. If this equipment does cause harmful

interference to radio or television reception, which can be determined by

turning the equipment off and on, the user is encouraged to try to correct

the interference by one or more of the following measures: l) Rearrange

or relocate the receiving antenna; 2) Increase the separation between the

equipment and receiver; 3) Connect the equipment into an outlet on a cir-

cuit different from the circuit connected; 4) Consult the dealer or an expe-

rienced radio/TV technician for help. (Changes or modifications not

expressly approved by the party responsible for FCC compliance could

void the user’s authority to operate this equipment.)

Page 1

2.0 IMPORTANT SAFETY INSTRUCTIONS

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY

When installing and using this electrical equipment, basic safety precautions

should always be followed, including:

1) WARNING: To reduce the risk of injury, do not permit children to use this

product unless they are closely supervised at all times.

2) WARNING: A grounding wire connector is provided on this unit to con-

nect a minimum No. 8 AWG (8.4mm2) solid copper conductor between

this unit and any metal equipment, metal enclosures of electrical equip-

ment, metal water pipe, or conduit within 5 feet (1.5m) of the unit.

3) DANGER: Risk of Accidental Drowning. Extreme caution must be exer-

cised to prevent unauthorized access by children. To avoid accidents,

ensure that children cannot use this hot tub unless they are supervised

at all times.

4) DANGER: Risk of Injury. The suction fittings in this hot tub are sized to

match the specific water flow created by the pump. Should the need

arise to replace the suction fittings or the pump, be sure that the flow

rates are compatible. Never operate the hot tub if the suction fittings are

broken or missing. Never replace a suction fitting with one rated less than

the flow rate marked on the original suction fitting.

5) DANGER: Risk of Electric Shock. Install at least 5 feet (1.5m), from all

metal surfaces. As an alternative, a hot tub may be installed within 5 feet

of metal surfaces if each metal surface is permanently connected (bond-

ed) by a minimum No. 8 AWG (8.4 mm2) solid copper conductor

attached to the wire connector on the grounding lug, inside the equip-

ment compartment on the equipment box.

6) DANGER: Risk of Electric Shock. Do not permit any electrical appliance,

such as a light, telephone, radio, television, etc. within 5 feet of a hot tub

unless such appliances are built-in by the manufacturer.

7) ELECTRICAL SUPPLY: The electrical supply for this product must

include a suitably rated switch or circuit breaker to open all ungrounded

supply conductors to comply with section 422-20 of the National

Electrical Code, ANSI/NFPA 70. The disconnect must be readily accessi-

ble and visible to the hot tub occupant but installed at least 5 feet (1.5m),

from the hot tub water.

Page 2

8) WARNING: To Reduce the Risk of Injury:

a) The water in a hot tub should never exceed 104 °F (40 °C). Water tem-

peratures between 100 °F (38 °C) and 104 °F (40 °C) are considered

safe for a healthy adult. Lower water temperatures are recommended for

young children and when hot tub use exceeds 10 minutes. Note: For

exercise, the water temperature should not exceed 90 °F (32 °C).

b) Since excessive water temperatures have a high potential for causing fetal

damage during the early months of pregnancy, pregnant or possibly preg-

nant women should limit hot tub water temperatures to100 °F (38 °C). If

pregnant, please consult your physician before using a hot tub.

c) Before entering the hot tub, the user should measure the water tempera-

ture with an accurate thermometer since the tolerance of water temper-

ature-regulating devices may vary as much as +/- 5 °F (2 °C).

d) The use of alcohol, drugs, or medication before or during hot tub use may

lead to unconsciousness with the possibility of drowning.

e) Persons suffering from obesity or a medical history of heart disease, low

or high blood pressure, circulatory system problems, or diabetes should

consult a physician before using a hot tub.

f) Persons using medication should consult a physician before using a hot

tub since some medication may induce drowsiness, while other medica-

tion may affect heart rate, blood pressure, and circulation.

IMPORTANT CSA SAFETY INSTRUCTIONS

(CANADA ONLY)

When using this electrical equipment, basic safety precautions should

always be followed, including the following:

a) READ AND FOLLOW ALL INSTRUCTIONS.

b) A green colored terminal or a terminal marked G, Gr, Ground, Grounding

or the symbol*is located inside the supply terminal box or compart-

ment. To reduce the risk of electric shock, this terminal must be con-

nected to the grounding means provided in the electric supply service

panel with a continuous copper wire equivalent in size to the circuit

conductors that supply this equipment.

*IEC Publication 417, Symbol 5019.

Page 3

c) At least two lugs marked “Bonding Lugs” are provided on the external sur-

face or on the inside of the supply terminal box/compartment. To reduce

the risk of electric shock, connect the local common bonding grid in the

area of the hot tub to these terminals with an insulated or bare copper

conductor not smaller than No. 6AWG.

d) All field-installed metal components such as rails, ladders, drains or other

similar hardware within 10 feet (3m) of the hot tub shall be bonded to

the equipment grounding buss with copper conductors not smaller than

No. 6 AWG.

e) SAVE THESE INSTRUCTIONS.

WARNING: Children should not use hot tubs without adult supervision.

AVERTISSEMENT: NE PAS LAISSER LES ENFANTS UTILISER LA CUVE DE

RELAXATION SANS SURVEILLANCE.

WARNING: Do not use hot tubs unless all suction guards are installed to

prevent body and hair entrapment.

AVERTISSEMENT: NE PAS UTILISER LA CUVE DE RELAXATION SI LES

GRILLES DE PRISE D’ASPIRATION NE SONT PAS TOUTES EN PLACE,.POUR

EVITER QUE LES CHEVEUX OU UNE PARTIE DU CORPS SOIENT ASPIRES.

WARNING:People with infectious diseases should not use a hot tub.

AVERTISSEMENT: LES PERSONNES ATTEINTES DE MALADIES INFEC-

TIEUSES NE DEVRAIENT PAS UTILISER LA CUVE DE RELAXATION.

WARNING: To avoid injury, exercise care when entering or exiting the hot

tub.

AVERTISSEMENT: POUR EVITER DES BLESSURES, SOYEZ PRUDENT EN

ENTRANT ET SORTANT DE LA CUVE DE RELAXATION.

WARNING: Do not use drugs or alcohol before or during the use of a hot

tub to avoid unconsciousness and possible drowning.

Page 4

AVERTISSEMENT: POUR EVITER L’EVANOUISSEMENT ET LA NOYADE

EVENTUELLE, NE PRENDRE NI DROGUE NI ALCOOL AVANT D’UTILISER LA

CUVE DE RELAXATION NI QUAND ON S’Y TROUVE.

WARNING: Pregnant or possibly pregnant women should consult a physi-

cian before using a hot tub.

AVERTISSEMENT: LES FEMMES ENCEINTES, QUE LEUR GROSSESSE

SOIT CONFIRMEE OU NON, DEVRAIENT CONSULTER UN MEDECIN AVANT

D’UTILISER LA CUVE DE RELAXATION.

WARNING: Water temperature in excess of 40 °C (104 °F) may be injurious

to your health.

AVERTISSEMENT: IL PEUT ETRE DANGEREUX POUR LA SANTE DE SE

PLONGER DANS DE L’EAU A PLUS DE 40 °C.

WARNING: Before entering the hot tub, measure the water temperature

with an accurate thermometer.

AVERTISSEMENT: AVANT D’UTILISER UNE CUVE DE RELAXATION

MESURER LA TEMPERATURE DE L’EAU A L’AIDE D’UN THERMOMETRE

PRECIS.

WARNING: Do not use a hot tub immediately following strenuous exercise.

AVERTISSEMENT: NE PAS UTILISER LA CUVE DE RELAXATION IMMEDI-

ATEMENT APRES UN EXERCICE FATIGANT.

WARNING: Prolonged immersion in a hot tub may be injurious to your

health.

AVERTISSEMENT: RESTER TROP LONGTEMPS DANS LA CUVE DE RELAX-

ATION PEUT ETRE DANGEREUX POUR LA SANTE.

WARNING: Do not permit electric appliances (such as lights, telephone,

radio, television, etc.) within 5 feet (1.5m) of this hot tub unless such appli-

ances are built-in by the manufacturer.

AVERTISSEMENT: NE PAS PLACER D’APPAREIL ELECTRIQUE (LUMINAIR,

TELEPHONE, RADIO, TELEVISEUR, ETC.) A MOINS DE 1.5M DE LA CUVE

DE RELAXATION, SAUF SI INSTALLÉ À LA MANIFACTURE.

Page 5

CAUTION: Maintain water chemistry in accordance with manufacturer’s

instructions.

ATTENTION: LA TENEUR DE L’EAU EN MATIERES DISSOUTES DOIT ETRE

CONFORME AUX DIRECTIVES DU FABRICANT.

WARNING: The use of alcohol or drugs can greatly increase the risk of fatal

hyperthermia in hot tubs.

AVERTISSEMENT: LA CONSOMMATION D’ALCOOL OU DE DROGUE AUG-

MENTE CONSIDERABLEMENT LES RISQUES D’HYPERTHERMIE MORTELLE

DANS UNE CUVE DE RELAXATION.

SAVE THESE INSTRUCTIONS

HYPERTHERMIA

Prolonged immersion in hot water may induce hyperthermia. A description of

the causes, symptoms, and effects of hyperthermia are as follows:

Hyperthermia occurs when the internal temperature of the body reaches a

level several degrees above the normal body temperature of 98.6°F (37°C).

The symptoms of hyperthermia include drowsiness, lethargy, and an increase

in the internal temperature of the body. The effects of hyperthermia include:

a) Unawareness of impending hazard;

b) Failure to perceive heat;

c) Failure to recognize the need to exit hot tub;

d) Physical inability to exit hot tub;

e) Fetal damage in pregnant women; and

f) Unconsciousness and danger of drowning.

A warning sign is provided in your warranty packet. Please install it

at a location near your spa, where it is visible to the user of the hot

tub. For additional or replacement signs please contact your local

Sundance Spas dealer and reference item number #6530-082.

Page 6

Andere Handbücher für Maxxus

Inhaltsverzeichnis

Andere Sundance Spas Whirlpool Handbücher

Sundance Spas

Sundance Spas ALTAMAR 880 Gebrauchs- und Wartungshandbuch

Sundance Spas

Sundance Spas Altamar 880 series Bedienungsanleitung

Sundance Spas

Sundance Spas 780 series Bedienungsanleitung

Sundance Spas

Sundance Spas Marin 880 Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Maxxus Bedienungsanleitung

Sundance Spas

Sundance Spas Hawthorne Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 850 Series Betriebsanleitung

Sundance Spas

Sundance Spas Hamilton Bedienungsanleitung

Sundance Spas

Sundance Spas CAMEO Bedienungsanleitung

Sundance Spas

Sundance Spas Export 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 400 series Montageanleitung

Sundance Spas

Sundance Spas Portofino Series Montageanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Camden Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas CAMEO Betriebsanleitung

Sundance Spas

Sundance Spas 850 Series Bedienungsanleitung

Sundance Spas

Sundance Spas maxxus 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Denali 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas CAMDEN 780 Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR 880 Bedienungsanleitung

Beliebte Whirlpool Handbücher anderer Marken

Bestway

Bestway Lay-Z-Spa 54189 Bedienungsanleitung

Jacuzzi

Jacuzzi ARGA ARG101C0110 Stücklistenhandbuch

Morphy Richards

Morphy Richards Essentials PC4006 Bedienungsanleitung

Softub

Softub PRESTIGE Bedienungsanleitung

JNJ SPAS

JNJ SPAS SPA-318 Installationshandbuch

KIRAMI

KIRAMI Comfort Family Bedienungsanleitung

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Bedienungsanleitung

HoMedics

HoMedics FB-655HJ-GB Bedienungsanleitung

Everyday Hot Tubs

Everyday Hot Tubs 530 Bedienungsanleitung

anko

anko SS-601A Bedienungsanleitung

Jacuzzi

Jacuzzi Duetta 6042 Bedienungsanleitung

Pooli

Pooli OS030979B Bedienungsanleitung

Jacuzzi

Jacuzzi alimia Bedienungsanleitung

ab Solares Smart Spa Bedienungsanleitung

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Bedienungsanleitung

Outsunny

Outsunny 848-047V70 Bedienungsanleitung

Aquatic

Aquatic INFINITY 1 Bedienungsanleitung

Master Spas

Master Spas MP Force Bedienungsanleitung