Sundance Spas CAMDEN 780 Bedienungsanleitung

owner’s manual

6530-436W Rev. C

780

Camden™ | Certa™ | Chelsee™| Dover™| Hamilton™

S E R I E S

Attention New Spa Owner!

Congratulations on the purchase of your new Sundance®780 Series spa! The

following is a list of automated functions and maintenance recommendations

for your new spa. Automated functions have been listed below in an attempt

to suppress any operational concerns you may have during startup and the

rst 24-hours of ownership! Maintenance recommendations are listed in an

attempt to stress their importance in protecting your new spa.

Automated Operations

Approximately two minutes after power is applied to the spa, the rst ltration/

heating cycle turns on pump 1 (Section 9.0, page 25). In Certa/Chelsee/

Hamilton models, an automatic ve minute “blow-out” function also activates

pump 2 for a period of ve minutes to ush all lines. Then, after ve minutes,

pump 2 turns off and pump 1 continues to operate for the duration of the cycle.

Note: This function only occurs during the rst ltration/heating cycle each day.

Maintain Healthy Spa Water

Always maintain your hot tub’s water chemistry within the following

parameters as dened by the Association of Pool and Spa Professionals/USA:

pH 7.4-7.6

Free chlorine 3.0-4.0 ppm

Free bromine 2.0-4.0 ppm

Total Alkalinity 100-120 ppm

Calcium Hardness 150-250 ppm

!TO DECREASE RISK OF INFECTION OR DISEASE! Always main-

tain your spa lter as outlined below to ensure healthy spa water.

Refer to pages 31-32for additional information.

Required Filter Maintenance

Your new hot tub is equipped with an advanced 2-stage MicroClean™water

ltration system that provides unsurpassed water quality! To ensure maximum

water quality at all times, you should clean and reuse the larger pleated lter

cartridge every month and replace (throw away) the smaller MicroClean lter

cartridge every 3 months, or earlier as necessary. The smaller MicroClean

lter cartridge is designed to be thrown away! Attempts to reuse this lter

cartridge may result in the re-release of unwanted particles back into the spa.

See pages 31-32 for detailed lter cartridge replacement instructions.

Required Water Maintenance

!TO DECREASE RISK OF INFECTION OR DISEASE! You should

replace the spa’s water every 3 months. The frequency depends on a number

of variables including frequency of use, number of users, and attention paid

to water quality maintenance. You will know it is time for a change when

you cannot control sudsing and/or you can no longer get the normal feel or

sparkle to the water, even though the key water balance measurements are

all within the proper parameters. See pages 37-39 for additional information.

780 SERIES

Table of Contents

1.0 Important Spa Owner Information............................................ 1

2.0 FCC Notice.................................................................................. 1

3.0 Important Safety Instructions for all Spa Owners .................. 2

3.1 Entrapment Risk .......................................................................... 6

3.2 Hyperthermia ............................................................................... 7

3.3 Important Additional CSA Safety Instructions (Canada Only)...... 8

3.4 General Electrical Safety Instructions.......................................... 8

4.0 Choosing A Location ................................................................. 9

4.1 Outdoor Location ....................................................................... 10

4.2 Indoor Location .......................................................................... 10

5.0 Power Requirements ............................................................... 11

5.1 North American 60 Hz Power Options ....................................... 12

5.2 Export 50 Hz Power Options...................................................... 13

6.0 Electrical Wiring Instructions ................................................. 14

7.0 Spa Fill Up Procedure.............................................................. 18

8.0 Control Functions.................................................................... 23

8.1 Control Panel ............................................................................. 23

8.2 General Spa Features And Controls .......................................... 24

9.0 Operating Instructions ............................................................ 25

9.1 Setting Water Temperature ....................................................... 25

9.2 Activate Jets Pumps .................................................................. 26

9.3 Selecting Desired Massage Action ............................................ 26

9.4 Air Controls ................................................................................ 26

9.5 Multi-Colored LED Light Operation............................................ 26

9.6 Jets ............................................................................................ 27

9.7 Waterfall Operation .................................................................... 27

9.8 Optional Audio System (Certa/Chelsee/Hamilton Only)............. 28

10.0 Automatic Filtration Cycles .................................................... 29

10.1 Standard Filtration/Heating Modes (F0-F3) ............................... 29

10.2 Economy Filtration/Heating Modes (F4-F6)............................... 29

10.3 Lock Modes (L1-L2)................................................................... 29

10.4 Selecting The Filtration/Heating Mode....................................... 30

11.0 Spa Maintenance...................................................................... 31

11.1 Cleaning The Filter..................................................................... 31

11.2 Draining And Relling................................................................. 33

11.3 Pillow Care................................................................................. 34

780 SERIES

11.4 Cleaning The Spa Interior.......................................................... 35

11.5 Vinyl Cover Care And Maintenance ........................................... 35

11.6 Maintaining The Synthetic Cabinet ............................................ 36

11.7 Winterizing ................................................................................. 36

11.8 Restarting Your Spa in Cold Weather ........................................ 37

12.0 Water Quality Maintenance ..................................................... 37

12.1 pH Control.................................................................................. 38

12.2 Sanitizing ................................................................................... 38

12.3 CD Ozone Water Maintenance System ..................................... 39

13.0 Error Conditions/Error Messages .......................................... 40

13.1 Summer Logic............................................................................ 40

13.2 Overheat Condition.................................................................... 40

13.3 Panel displays SN1.................................................................... 40

13.4 Panel displays SN2.................................................................... 41

13.5 Panel displays FL1 or FL2 ......................................................... 41

13.6 Panel displays COL ................................................................... 41

13.7 Panel displays ICE..................................................................... 41

13.8 Panel displays - - - .................................................................... 42

14.0 Troubleshooting Procedures .................................................. 42

14.1 None of the Components Operate (e.g. Pump, Light) .............. 42

14.2 Pump Does Not Operate but Light Does ................................... 42

14.3 Poor Jet Action........................................................................... 43

14.4 Water is Too Hot......................................................................... 43

14.5 No Heat...................................................................................... 43

15.0 North American Dover Convertible Circuit Diagram ............ 44

16.0 North American Camden Circuit Diagram ............................. 45

17.0 North American Certa/Chelsee/Hamilton Circuit Diagram... 46

18.0 Export Dover Circuit Diagram................................................. 47

19.0 Export Camden Circuit Diagram............................................. 48

20.0 Export Certa/Chelsee/Hamilton Circuit Diagram .................. 49

21.0 Optional SunSurround™ Stereo Receiver Functions .......... 50

21.1 Stereo Receiver Control Functions............................................ 50

21.2 Stereo Audio Receiver Specications ........................................ 58

21.3 CD/MP3/WMA folder/le hierarchy ............................................ 59

21.4 Stereo Audio Receiver Troubleshooting..................................... 61

21.5 Standard Wireless Remote Control Functions........................... 62

21.6 iPod®/MP3 Player Connection .................................................. 64

21.7 Wireless Remote Battery Replacement Procedure ................... 65

Page 1

780 SERIES

1.0 Important Spa Owner Information

Your new Sundance®780 Series Spa is constructed to the highest

standards and is capable of providing many years of trouble-free use.

However, because heat retentive materials are utilized to insulate

the spa for efficient operation, an uncovered acrylic spa surface and

wall fittings directly exposed to sunlight and high temperatures for an

extended period are subject to permanent damage or discoloration.

Damage caused by exposing the spa to this abuse is not covered under

warranty. We recommend that you always keep the spa full of water

when it is exposed to direct sunlight and that you keep the insulating

cover in place at all times when the spa is not in use. Read and carefully

follow the requirements for your spa’s support base found in Section 4.0

titled, “Choosing a Location” (Page 9).

We constantly strive to offer the finest spas available, therefore

modifications and enhancements may be made which affect the

specifications, illustrations and/or instructions contained herein.

2.0 FCC Notice

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These

limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used

in accordance with the instructions, may cause harmful interference to

radio communications. However, there is no guarantee that interference

will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be

determined by turning the equipment off and on, the user is encouraged

to try to correct the interference by one or more of the following

measures:

1. Rearrange or relocate the receiving antenna.

2. Increase the separation between the equipment and receiver

3. Connect the equipment into an outlet on a circuit different from the

circuit connected.

4. Consult the dealer or an experienced radio/TV technician for help.

Changes or modications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.

Page 2

780 SERIES

3.0 Important Safety Instructions for all Spa Owners

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY!

This spa was manufactured to meet the standards and specications

outlined in the “Virginia Graeme Baker Pool and Spa Safety Act” (VGB

Safety Act). When installing and using this spa, basic safety precautions

should always be followed, including:

1. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

Extreme caution must be exercised to prevent unauthorized access by•

children.

To avoid accidents, ensure that children do not use this spa unless•

supervised at all times. Adult supervision is a critical safety factor in

preventing children from drowning.

Use the straps and clip tie downs to secure the spa cover when not in •

use. This will help discourage unsupervised children from entering the

spa. Keep the spa cover secure in high-wind conditions.

There is no representation that the cover, clip tie-downs, or actual locks •

will prevent access to the spa.

2. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

Keep hair, loose articles of clothing or hanging jewelry away from suction•

ttings, rotating jets or other moving components to avoid entrapment

that could lead to drowning or severe injury.

Never use the spa unless all suction guards, lter, lter lid, or skimmer •

assembly are installed to prevent body and/or hair entrapment.

Never operate or use the spa if the lter, lter lid, or skimmer assembly •

are broken or any part of the skimmer assembly is missing. Please

contact your dealer or nearest service center for service.

The suction ttings and suction covers in this spa are sized to match the •

specic water ow created by the pump(s). If it is necessary to replace

the suction ttings, suction covers or pump(s), be sure that the ow rates

are compatible and are in compliance with the VGB Safety Act.

Never replace a suction tting or suction cover with one rated less than •

the ow rate marked on the original suction tting. Using improper suction

ttings or suction covers can create a body or hair suction entrapment

hazard that may lead to drowning or severe injury.

3. !DANGER: RISK OF SEVERE INJURY FROM ELECTRIC

SHOCK OR DEATH FROM ELECTROCUTION!

Install the spa at least 5 feet (1.5m), from all metal surfaces. As an•

alternative, a spa may be installed within 5 feet of metal surfaces if each

metal surface is permanently connected (bonded) by a minimum No. 8

AWG (8.4 mm²) solid copper conductor attached to the wire connector on

the grounding lug, inside the equipment compartment on the equipment

box.

Page 3

780 SERIES

A grounding wire connector is provided on this unit to connect a•

minimum No. 8 AWG (8.4 mm²) solid copper conductor between this

unit and any metal equipment, metal enclosures of electrical equipment,

metal water pipe, or conduit within 5 feet (1.5m) of the unit.

Never permit any electrical appliance, such as a light, telephone, radio,•

television, etc. within 5 feet (1.5m) of a spa unless such appliances are

built-in by the manufacturer.

Never bring any electrical appliances into or near the spa.•

Never operate any electrical appliances from inside the spa or when you•

are wet.

The electrical supply for this product must include a suitably rated switch•

or circuit breaker to open all ungrounded supply conductors to comply

with section 422-20 of the National Electrical Code/USA, ANSI/NFPA 70.

The disconnecting means must be readily accessible and visible to the

spa occupant but installed at least 5 feet (1.5m), from the spa.

The electrical circuit supplied for the hot tub must include a suitable•

ground fault circuit interrupter (GFCI) as required by NEC Article 680-42.

4. !WARNING: RISK OF SEVERE INJURY OR DEATH!

Extreme caution must be exercised to prevent diving or jumping into•

the spa or slipping and falling, which could result in unconsciousness,

drowning, or serious injury. Remember that wet surfaces can be very

slippery.

Never stand, walk or sit on the top railing of the spa.•

5. !WARNING: RISK OF HYPERTHERMIA (OVER-HEATING)

CAUSING SEVERE INJURY, BURNS, WELTS OR DEATH!

Water temperature in excess of 104°F (40°F) may be injurious to your •

health.

Refer to section 3.2 Hyperthermia for specic causes and symptoms of •

this condition.

The water in the spa should never exceed 104°F (40°C). Water •

temperatures between 100°F (38°C) and 104°F (40°C) are considered

safe for a healthy adult.

Lower water temperatures are recommended for young children •

(children are especially sensitive to hot water) and when spa use may

exceed 10 minutes.

The Consumer Products Safety Commission/USA has stated that the •

water temperature in a spa should not exceed 104°F (40°C).

Always test the spa water temperature before entering the spa. The user•

should measure the water temperature with an accurate thermometer

since the tolerance of water temperature-regulating devices may vary as

much as +/- 5°F (2°C).

Page 4

780 SERIES

6. !WARNING: RISK OF SEVERE INJURY OR DEATH!

Since excessive water temperatures have a high potential for causing•

fetal damage during the early months of pregnancy, if pregnant or

possibly pregnant, consult your physician before using a spa.

Pregnant or possibly pregnant women should limit spa water •

temperatures to 100°F (38°C).

Persons suffering from obesity or a medical history of heart disease, low •

or high blood pressure, circulatory system problems, diabetes, infectious

diseases or immune deciency syndromes should consult a physician

before using a spa.

If you experience breathing difculties in association with using or •

operating your spa, discontinue use and consult your physician.

Persons using medication should consult a physician before using a spa •

since some medication may induce drowsiness, while other medication

may affect heart rate, blood pressure, and circulation.

Persons suffering from any condition requiring medical treatment, the •

elderly, or infants should consult with a physician before using a spa.

The use of alcohol, drugs, or medication before or during spa use may•

lead to unconsciousness with the possibility of drowning.

7. !WARNING: RISK OF SEVERE INJURY OR DEATH!

Prolonged immersion in a spa may be injurious to your health.•

Observe a reasonable time limit when using the spa. Exposures at•

higher temperatures can cause high body temperature (over-heating).

Symptoms may include dizziness, nausea, fainting, drowsiness, and

reduced awareness. These effects could possibly result in drowning or

serious injury.

Never use a spa immediately following strenuous exercise. Enter and•

exit the spa slowly. Wet surfaces can be slippery.

8. !WARNING: TO DECREASE RISK OF INFECTION OR

DISEASE!

To reduce the risk of • contracting a waterborne

illness (e.g. an infection,

bacteria or virus) and/or respiratory ailments

, maintain water chemis-

try within the parameters listed on the inside cover of this manual and

consult with a licensed engineer regarding proper ventilation if installed

indoors or in an enclosed area.

People with infectious diseases should not use a spa to avoid water •

contamination, which could result in spreading infections to others.

Always shower before and after using your spa. Maintain water •

chemistry in accordance with manufacturer’s instructions. Failure to

do so may result in contracting a waterborne

illness (e.g. an infection,

bacteria or virus).

Page 5

780 SERIES

9. !WARNING: In addition to maintenance of lters and water

chemistry, proper ventilation is recommended to reduce the risk of

contracting a waterborne

illness (e.g. an infection, bacteria or virus)

and/or respiratory ailments

that could be present in the air or water.

Consult a licensed architect or building contractor to determine your

specic needs if installing your hot tub indoors.

10. CAUTION: TO DECREASE RISK OF PRODUCT DAMAGE.

Maintain water chemistry in accordance with manufacturer’s instructions.•

Proper chemical maintenance of spa water is necessary to maintain safe •

water and prevent possible damage to spa components.

11. NOTE:

This spa is not intended nor designed to be used in a commercial or•

public application. The spa buyer shall determine whether there are any

code restrictions on the use or installation of this spa since local code

requirements vary from one locality to another.

Hot Tub Safety Literature

To ensure you have a safe and enjoyable hot tub experience,

learn all you can about hot tub safety and emergency procedures.

Especially useful are the brochures listed below:

Children Aren’t Waterproof•

• Pool and Spa Emergency Procedures For Infants and Children

• Layers of Protection

• The Sensible Way to Enjoy Your Spa or Hot Tub

The Association of Pool and Spa Professionals publishes these

brochures. To acquire a brochure:

• Ask your hot tub dealer (they may have copies)

• Go to http://www.apsp.org

• Conduct your own search on the internet

• Write to the following address:

The Association of Pool and Spa Professionals

2111 Eisenhower Avenue

Alexandria VA 22314

703.838.0083

Page 6

780 SERIES

3.1 Entrapment Risk

The Consumer Products Safety Commission/USA has reported that

users of pools and spas have become entrapped (stuck) to drain and/or

suction ttings causing death, drowning, or serious injury (see diagram

below). This spa was manufactured to meet the standards and specica-

tions outlined in the “Virginia Graeme Baker Pool and Spa Safety Act”

(VGB Safety Act). Entrapment risk can be minimized if proper precau-

tions are taken.

DANGER: RISK OF PERSONAL INJURY OR DEATH!

Never operate the spa if a suction tting, suction cover, lter,

lter lid or skimmer assembly are broken, damaged or missing.

1. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

Hair entrapment: May occur if hair is entangled, knotted or snagged

in a drain suction or skimmer assembly. This has been reported in

persons who when submerge themselves underwater, allowing hair

to come close and/or within the reach of the suction ttings, suction

covers or skimmer assembly.

Keep hair away from suction ttings, suction covers, lter, lter lid or •

skimmer assembly.

Children are at risk for hair entrapment if swimming under water.•

Never allow children to play or get near the suction ttings, suction •

covers, lter, lter lid or skimmer assembly.

2. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

Limb entrapment: May occur when a limb becomes entrapped,

inserted or sucked into a suction or outlet opening.

Always keep suction ttings, suction covers, lter, lter lid or skimmer •

assembly in place when operating to avoid limb entrapment.

Never allow children to play or get near the suction ttings, suction •

covers, lter, lter lid or skimmer assembly.

Suction Fittings,

Suction Covers

(locations vary

by models)

Filter, Filter

Lid, Skimmer

Assembly

(location and

style vary by

models)

Andere Handbücher für CAMDEN 780

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sundance Spas Whirlpool Handbücher

Sundance Spas

Sundance Spas Marin 880 Bedienungsanleitung

Sundance Spas

Sundance Spas 400 series Montageanleitung

Sundance Spas

Sundance Spas 850 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Hamilton Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Altmar Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas CONSTANCE 6530-512X Bedienungsanleitung

Sundance Spas

Sundance Spas Solo Betriebsanleitung

Sundance Spas

Sundance Spas Hawthorne Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR Bedienungsanleitung

Sundance Spas

Sundance Spas CAMEO Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR 880 Bedienungsanleitung

Sundance Spas

Sundance Spas 780 series Bedienungsanleitung

Sundance Spas

Sundance Spas 850Export Series Betriebsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 850 Series Betriebsanleitung

Sundance Spas

Sundance Spas Export 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Kingston 980 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Edison Bedienungsanleitung

Sundance Spas

Sundance Spas Portofino Series Montageanleitung

Sundance Spas

Sundance Spas Camden Bedienungsanleitung

Sundance Spas

Sundance Spas Denali 680 Series Bedienungsanleitung

Beliebte Whirlpool Handbücher anderer Marken

Bestway

Bestway Lay-Z-Spa 54189 Bedienungsanleitung

Jacuzzi

Jacuzzi ARGA ARG101C0110 Stücklistenhandbuch

Softub

Softub PRESTIGE Bedienungsanleitung

JNJ SPAS

JNJ SPAS SPA-318 Installationshandbuch

KIRAMI

KIRAMI Comfort Family Bedienungsanleitung

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Bedienungsanleitung

HoMedics

HoMedics FB-655HJ-GB Bedienungsanleitung

Everyday Hot Tubs

Everyday Hot Tubs 530 Bedienungsanleitung

anko

anko SS-601A Bedienungsanleitung

Jacuzzi

Jacuzzi Duetta 6042 Bedienungsanleitung

Pooli

Pooli OS030979B Bedienungsanleitung

Jacuzzi

Jacuzzi alimia Bedienungsanleitung

ab Solares Smart Spa Bedienungsanleitung

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Bedienungsanleitung

Outsunny

Outsunny 848-047V70 Bedienungsanleitung

Aquatic

Aquatic INFINITY 1 Bedienungsanleitung

Master Spas

Master Spas MP Force Bedienungsanleitung

Asteria

Asteria 5630 Bedienungsanleitung