Sundance Spas Burlington Bedienungsanleitung

680

Owner’s manual

Burlington™| Denali™ | Hartford™| Hawthorne™ | Tacoma™

6530-681T Rev. B

Attention New Spa Owner!

Congratulations on the purchase of your new Sundance®680 Series

spa! The following is a list of automated functions and maintenance

recommendations for your new spa. Automated functions have been

listed below in an attempt to suppress any operational concerns you may

have during startup and the rst 24 hours of ownership! Maintenance

recommendations are listed in an attempt to stress their importance in

protecting your new spa.

Automated Operations

Approximately two minutes after power is applied to the spa, the rst

ltration/heating cycle turns on pump 1. In Hartford and Hawthorne models,

an automatic ve minute “blow-out” function also activates pump 2 for a

period of ve minutes to ush all lines. Then, after ve minutes, pump 2

turns off and pump 1 continues to operate for the duration of the cycle.

Note: this function only occurs during the rst ltration/heating cycle each

day.

Maintain Healthy Spa Water

Always maintain your spa’s water chemistry within the following parameters

as dened by the Association of Pool And Spa Professionals/USA:

pH 7.4-7.6

Free Chlorine 3.0-4.0 ppm

Free Bromine 2.0-4.0 ppm

Total Alkalinity 100-120 ppm

Calcium Hardness 150-250 ppm

Always maintain your spa lter as outlined below to ensure healthy spa

water. Refer to pages 34-35 for additional information.

Required Filter Maintenance

Your new spa is equipped with an advanced water ltration system that

provides unsurpassed water quality! To ensure maximum water quality at all

times, you should clean and reuse both lter cartridges every month or as

needed. See page 30 for detailed lter cleaning/replacement instructions.

Required Water Maintenance

You should replace the spa’s water every 3 months. The frequency

depends on a number of variables including frequency of use, number of

users, and attention paid to water quality maintenance. You will know it

is time for a change when you cannot control sudsing and/or you can no

longer get the normal feel or sparkle to the water, even though the key

water balance measurements are all within the proper parameters. See

pages 34-35 for additional information.

Table of Contents

1.0 Important Spa Owner Information............................................ 1

2.0 FCC Notice.................................................................................. 1

3.0 Important Safety Instructions................................................... 2

3.1 Important CSA Safety Instructions (Canada only) ....................... 4

3.2 Hyperthermia ............................................................................... 5

3.3 Cautions ...................................................................................... 6

3.4 General Electrical Safety Instructions.......................................... 6

4.0 Choosing A Location ................................................................. 7

4.1 Outdoor Location ......................................................................... 8

4.2 Indoor Location............................................................................ 8

5.0 Power Requirements ................................................................. 9

5.1 North American 60Hz Power Options........................................ 10

5.2 Export 50Hz Power Options .......................................................11

6.0 Electrical Wiring Instructions ................................................. 12

7.0 Spa Fill Up Procedure.............................................................. 16

8.0 Control Functions.................................................................... 21

8.1 Control Panel............................................................................. 21

8.2 General Spa Features And Controls.......................................... 22

9.0 Operating Instructions ............................................................ 23

9.1 Setting Water Temperature ....................................................... 23

9.2 Activate Pumps.......................................................................... 23

9.3 SunGlow™ Light Operation (Denali and Tacoma Models) ........ 24

9.4 Standard Light Operation (Burlington, Hartford and

Hawthorne Models) .................................................................. 24

9.5 Optional Multi-Colored LED Light System Operation

(Burlington, Hartford and Hawthorne Models) ........................... 24

9.6 Adjusting Individual Jet Flow ..................................................... 25

9.7 Selecting Desired Massage Action ........................................... 26

9.8 Air Controls................................................................................ 26

9.9 Optional Audio System .............................................................. 26

10.0 Automatic Filtration Cycles .................................................... 27

10.1 Standard Filtration/Heating Modes For Models Without

Circulation Pump Option............................................................ 27

10.2 Standard Filtration/Heating Modes For Models With

Circulation Pump Option............................................................ 27

10.3 Economy Filtration/Heating Modes (F4-F6)............................... 27

10.4 Lock Modes (L1-L2)................................................................... 27

10.5 Selecting The Filtration/Heating Mode ...................................... 28

10.6 Filtration Modes for Spas Without Circulation Pump Option ..... 28

10.7 Filtration Modes for Spas With Circulation Pump Option .......... 29

11.0 Spa Maintenance...................................................................... 30

11.1 Cleaning The Filter .................................................................... 30

11.2 Draining and Relling ................................................................ 31

11.3 Pillow Care (All Models Except Denali) ..................................... 32

11.4 Cleaning The Spa Interior.......................................................... 33

11.5 Maintaining The Cover .............................................................. 33

11.6 Maintaining The Synthetic Cabinet............................................ 33

11.7 Winterizing................................................................................. 33

11.8 Restarting Your Spa in Cold Weather........................................ 34

12.0 Water Quality Maintenance ..................................................... 34

12.1 pH Control ................................................................................. 35

12.2 Sanitizing ................................................................................... 35

12.3 CD Ozone Water Maintenance System..................................... 35

13.0 Error Conditions/Error Messages .......................................... 36

13.1 Summer Logic (Spas With Circulation Pump Option)................ 36

13.2 Panel displays SN1 ................................................................... 36

13.3 Panel displays SN2 ................................................................... 36

13.4 Panel Flashes FL1 or FL2 (Spas Without Circulation

Pump Option) ............................................................................ 36

13.5 Panel Flashes FL1 or FL2 (Spas With Circulation

Pump Option) ............................................................................ 37

13.6 Panel displays COL ................................................................... 37

13.7 Panel Displays ICE.................................................................... 37

13.8 Panel Displays OH .................................................................... 37

13.9 Panel displays - - -.................................................................... 38

14.0 Troubleshooting Procedures.................................................. 38

14.1 None of the Components Operate (e.g. Pump, Light).............. 38

14.2 Pump Does Not Operate but Light Does ................................... 38

14.3 Poor Jet Action .......................................................................... 39

14.4 Water is Too Hot ........................................................................ 39

14.5 No Heat ..................................................................................... 39

15.0 North American Denali/Tacoma Convertible Circuit

Diagram (60Hz)......................................................................... 40

16.0 North American Burlington Models (60Hz) ........................... 41

17.0 North American Hartford and Hawthorne Models (60Hz) .... 42

18.0 Export Denali/Tacoma Circuit Diagram (50Hz)...................... 43

19.0 Export Burlington Circuit Diagram (50Hz)............................. 44

20.0 Export Hartford and Hawthorne Circuit Diagram (50Hz)...... 45

21.0 Optional SunSoundTM Stereo Receiver Functions

(Burlington, Hartford and Hawthorne Models Only)............. 46

21.1 Optional SunSound Audio Receiver Specications................... 51

Page 1

1.0 Important Spa Owner Information

Your Sundance®680 Series spa is constructed to the highest standards

and is capable of providing many years of trouble-free use. However, be-

cause heat retentive materials are utilized to insulate the spa for efcient

operation, an uncovered spa surface and wall ttings directly exposed

to sunlight and high temperatures for an extended period are subject

to permanent damage or discoloration. Damage caused by exposing

the spa to this abuse is not covered under warranty. We recommend

that you always keep the spa full of water when it is exposed to direct

sunlight and that you keep the Sundance premium insulating cover in

place at all times when the spa is not in use. Read and carefully follow

the requirements for your spa’s support base found in Section 4.0 titled,

“Choosing a Location” (page 7).

Sundance constantly strives to offer the finest spas available,

therefore modifications and enhancements may be made which

affect the specifications, illustrations and/or instructions contained

herein.

2.0 FCC Notice

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These

limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used

in accordance with the instructions, may cause harmful interference to

radio communications. However, there is no guarantee that interference

will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be deter-

mined by turning the equipment off and on, the user is encouraged to try

to correct the interference by one or more of the following measures:

1. Rearrange or relocate the receiving antenna.

2. Increase the separation between the equipment and receiver

3. Connect the equipment into an outlet on a circuit different from the

circuit connected.

4. Consult the dealer or an experienced radio/TV technician for help.

Changes or modications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.

Page 2

3.0 Important Safety Instructions

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY!

When installing and using this electrical equipment, basic safety precau-

tions should always be followed, including:

1. WARNING: To reduce the risk of injury, do not permit children to use

this product unless they are closely supervised at all times.

2. WARNING: A grounding wire connector is provided on this unit to

connect a minimum No. 8 AWG (8.4mm2) solid copper conductor

between this unit and any metal equipment, metal enclosures of

electrical equipment, metal water pipe, or conduit within 5 feet (1.5m)

of the unit.

3. DANGER: Risk of Accidental Drowning. Extreme caution must be

exercised to prevent unauthorized access by children. To avoid

accidents, ensure that children cannot use this spa unless they are

supervised at all times.

4. DANGER: Risk of Injury. The suction ttings in this spa are sized to

match the specic water ow created by the pump. Should the need

arise to replace the suction ttings or the pump, be sure that the ow

rates are compatible. Never operate the spa if the suction ttings are

broken or missing. Never replace a suction tting with one rated less

than the ow rate marked on the original suction tting.

5. WARNING: Risk of Injury. The suction ttings in this spa are sized to

match the specic water ow created by the pump. If it is necessary

to replace the suction ttings or the pump, be sure that the ow rates

are compatible. Because of the risk of injury,

Never operate or use the spa if the lter, lter lid, or skimmer •

assembly are broken or any part of the skimmer assembly is

missing. Please contact your dealer or nearest service center for

service.

Never replace a suction tting with one rated less than the ow •

rate marked on the original suction tting.

6. DANGER: Risk of Electric Shock. Install at least 5 feet (1.5m) from

all metal surfaces. As an alternative, a spa may be installed within

5 feet (1.5m) of metal surfaces if each metal surface is permanently

connected (bonded) by a minimum No. 8 AWG (8.4mm²) solid cop-

per conductor attached to the wire connector on the grounding lug,

inside the equipment compartment on the equipment box.

7. DANGER: Risk of Electric Shock. Do not permit any electrical appli-

ance, such as a light, telephone, radio, television, etc. within 5 feet

Page 3

(1.5m) of a spa, unless such appliances are built-in by the manufac-

turer.

8. ELECTRICAL SUPPLY: The electrical supply for this product must

include a suitably rated switch or circuit breaker to open all un-

grounded supply conductors to comply with Section 422-20 of the

National Electrical Code/USA, ANSI/NFPA 70. The disconnect must

be readily accessible and visible to the spa occupant but installed at

least 5 feet (1.5m) from the spa water.

9. WARNING: To Reduce the Risk of Injury:

10. The water in a spa should never exceed 104°F (40°C). Water tem-

peratures between 100°F (38°C) and 104°F (40°C) are considered

safe for a healthy adult. Lower water temperatures are recommend-

ed for young children and when spa use exceeds 10 minutes.

11. Since excessive water temperatures have a high potential for caus-

ing fetal damage during the early months of pregnancy, pregnant

or possibly pregnant women should limit spa water temperatures to

100°F (38°C). If pregnant, please consult your physician before us-

ing a spa.

12. Before entering the spa, the user should measure the water tem-

perature with an accurate thermometer since the tolerance of water

temperature-regulating devices may vary as much as +/- 5°F (2°C).

13. The use of alcohol, drugs, or medication before or during spa use

may lead to unconsciousness with the possibility of drowning.

14. Persons suffering from obesity or a medical history of heart disease,

low or high blood pressure, circulatory system problems, diabetes,

infectious diseases or immune deciency syndromes should consult

a physician before using a spa. If you experience breathing difcul-

ties in association with using or operating your spa, discontinue use

and consult your physician.

15. Persons using medication should consult a physician before using

a spa since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

16. Always shower before and after using your spa. To reduce the pos-

sibility of contracting a waterborne illness, always maintain water

chemistry within the parameters listed on the inside cover of this

manual. If you or other bathers experience such a condition, discon-

tinue use and seek medical attention.

Page 4

3.1 Important CSA Safety Instructions (Canada only)

When using this electrical equipment, basic safety precautions should

always be followed, including the following:

1. READ AND FOLLOW ALL INSTRUCTIONS.

2. A green colored terminal or a terminal marked G, Gr, Ground,

Grounding or the symbol* is located inside the supply terminal box

or compartment. To reduce the risk of electric shock, this terminal

must be connected to the grounding means provided in the electric

supply service panel with a continuous copper wire equivalent in

size to the circuit conductors that supply this equipment (*IEC Publi-

cation 417, Symbol 5019).

3. At least two lugs marked “Bonding Lugs” are provided on the exter-

nal surface or on the inside of the supply terminal box/compartment.

To reduce the risk of electric shock, connect the local common bond-

ing grid in the area of the spa to these terminals with an insulated or

bare copper conductor not smaller than No. 6 AWG (10mm²).

4. All eld-installed metal components such as rails, ladders, drains or

other similar hardware within 10 feet (3m) of the spa shall be bonded

to the equipment grounding buss with copper conductors not smaller

than No. 6 AWG (10mm²).

5. SAVE THESE INSTRUCTIONS

WARNING: Children should not use spas without adult supervision.

WARNING: Do not use spas unless all suction guards are installed to

prevent body and hair entrapment.

WARNING: People with infectious diseases should not use a spa.

WARNING: To avoid injury, exercise care when entering or exiting the

spa.

WARNING: Do not use drugs or alcohol before or during the use of a

spa to avoid unconsciousness and possible drowning.

WARNING: Pregnant or possibly pregnant women should consult a

physician before using a spa.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sundance Spas Whirlpool Handbücher

Sundance Spas

Sundance Spas ALTAMAR 880 Gebrauchs- und Wartungshandbuch

Sundance Spas

Sundance Spas 850 Series Betriebsanleitung

Sundance Spas

Sundance Spas Maxxus Betriebsanleitung

Sundance Spas

Sundance Spas ALTAMAR Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Spas Bedienungsanleitung

Sundance Spas

Sundance Spas Marin 880 Bedienungsanleitung

Sundance Spas

Sundance Spas 850 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas CAMDEN 780 Bedienungsanleitung

Sundance Spas

Sundance Spas 850Export Series Betriebsanleitung

Sundance Spas

Sundance Spas CONSTANCE 6530-512X Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR 880 Bedienungsanleitung

Sundance Spas

Sundance Spas CAMEO Bedienungsanleitung

Sundance Spas

Sundance Spas Hawthorne Bedienungsanleitung

Sundance Spas

Sundance Spas Altamar 880 series Bedienungsanleitung

Sundance Spas

Sundance Spas Solo Betriebsanleitung

Sundance Spas

Sundance Spas maxxus 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Portofino Series Montageanleitung

Sundance Spas

Sundance Spas Hamilton Bedienungsanleitung

Sundance Spas

Sundance Spas CAMEO Betriebsanleitung

Sundance Spas

Sundance Spas Altmar Bedienungsanleitung

Beliebte Whirlpool Handbücher anderer Marken

Bestway

Bestway Lay-Z-Spa 54189 Bedienungsanleitung

Jacuzzi

Jacuzzi ARGA ARG101C0110 Stücklistenhandbuch

Softub

Softub PRESTIGE Bedienungsanleitung

JNJ SPAS

JNJ SPAS SPA-318 Installationshandbuch

KIRAMI

KIRAMI Comfort Family Bedienungsanleitung

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Bedienungsanleitung

HoMedics

HoMedics FB-655HJ-GB Bedienungsanleitung

Everyday Hot Tubs

Everyday Hot Tubs 530 Bedienungsanleitung

anko

anko SS-601A Bedienungsanleitung

Jacuzzi

Jacuzzi Duetta 6042 Bedienungsanleitung

Pooli

Pooli OS030979B Bedienungsanleitung

Jacuzzi

Jacuzzi alimia Bedienungsanleitung

ab Solares Smart Spa Bedienungsanleitung

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Bedienungsanleitung

Outsunny

Outsunny 848-047V70 Bedienungsanleitung

Aquatic

Aquatic INFINITY 1 Bedienungsanleitung

Master Spas

Master Spas MP Force Bedienungsanleitung

Asteria

Asteria 5630 Bedienungsanleitung