Sundance Spas Camdenl Certa Bedienungsanleitung

780

owner’s manual

Camden™ | Certa™ | Chelsee™| Dover™ | Hamilton™

6530-436T Rev. B

Attention New Spa Owner!

Congratulations on the purchase of your new Sundance®780 Series

spa! The following is a list of automated functions and maintenance

recommendations for your new spa. Automated functions have been

listed below in an attempt to suppress any operational concerns you may

have during startup and the rst 24-hours of ownership! Maintenance

recommendations are listed in an attempt to stress their importance in

protecting your new spa.

Automated Operations

Approximately two minutes after power is applied to the spa, the rst ltration/

heating cycle turns on pump 1 (Section 9.0, page 23). In Certa/Chelsee/

Hamilton models, an automatic ve minute “blow-out” function also activates

pump 2 for a period of ve minutes to ush all lines. Then, after ve minutes,

pump 2 turns off and pump 1 continues to operate for the duration of the

cycle. Note: this function only occurs during the rst ltration/heating cycle

each day.

Maintain Healthy Spa Water

Always maintain your hot tub’s water chemistry within the following

parameters as dened by the Association of Pool And Spa Professionals/

USA:

pH 7.4-7.6

Free chlorine 3.0-4.0 ppm

Free bromine 2.0-4.0 ppm

Total Alkalinity 100-120 ppm

Calcium Hardness 150-250 ppm

Always maintain your spa lter as outlined below to ensure healthy spa water.

Refer to pages 35-36 for additional information.

Required Filter Maintenance

Your new hot tub is equipped with an advanced 2-stage MicroClean™water

ltration system that provides unsurpassed water quality! To ensure maximum

water quality at all times, you should clean and reuse the larger pleated lter

cartridge every month and replace (throw away) the smaller MicroClean lter

cartridge every 3 months, or earlier as necessary. The smaller MicroClean

lter cartridge is designed to be thrown away! Attempts to reuse this lter

cartridge may result in the re-release of unwanted particles back into the spa.

See page 29 for detailed lter cartridge replacement instructions.

Required Water Maintenance

You should replace the spa’s water every 3 months. The frequency depends

on a number of variables including frequency of use, number of users, and

attention paid to water quality maintenance. You will know it is time for a

change when you cannot control sudsing and/or you can no longer get

the normal feel or sparkle to the water, even though the key water balance

measurements are all within the proper parameters. See pages 35-36 for

additional information.

Table of Contents

1.0 Important Spa Owner Information............................................ 1

2.0 FCC Notice.................................................................................. 1

3.0 Important Safety Instructions................................................... 2

3.1 Important CSA Safety Instructions (Canada Only)....................... 4

3.2 Hyperthermia ............................................................................... 5

3.3 Cautions....................................................................................... 6

3.4 General Electrical Safety Instructions.......................................... 6

4.0 Choosing A Location ................................................................. 7

4.1 Outdoor Location ......................................................................... 8

4.2 Indoor Location ............................................................................ 8

5.0 Power Requirements ................................................................. 9

5.1 North American 60Hz Power Options ........................................ 10

5.2 Export 50Hz Power Options....................................................... 11

6.0 Electrical Wiring Instructions ................................................. 12

7.0 Spa Fill Up Procedure.............................................................. 15

8.0 Control Functions.................................................................... 21

8.1 Control Panel ............................................................................. 21

8.2 General Spa Features And Controls .......................................... 22

9.0 Operating Instructions ............................................................ 23

9.1 Setting Water Temperature ....................................................... 23

9.2 Activate Jets Pumps .................................................................. 23

9.3 Selecting Desired Massage Action ............................................ 24

9.4 Air Controls ................................................................................ 24

9.5 Multi-Colored LED Light Operation............................................ 24

9.6 Rotating Jets.............................................................................. 25

9.7 Non-Rotating Jets ...................................................................... 26

9.8 Waterfall Operation .................................................................... 26

9.9 Optional Audio System (Certa/Chelsee/Hamilton Only)............. 26

10.0 Automatic Filtration Cycles .................................................... 27

10.1 Standard Filtration/Heating Modes (F0-F3) ............................... 27

10.2 Economy Filtration/Heating Modes (F4-F6)............................... 27

10.3 Lock Modes (L1-L2)................................................................... 27

10.4 Selecting The Filtration/Heating Mode....................................... 28

11.0 Spa Maintenance...................................................................... 29

11.1 Cleaning The Filter..................................................................... 29

11.2 Draining And Relling................................................................. 31

11.3 Pillow Care................................................................................. 33

11.4 Cleaning The Spa Interior.......................................................... 33

11.5 Maintaining the Cover................................................................ 33

11.6 Maintaining The Synthetic Cabinet ............................................ 34

11.7 Winterizing ................................................................................. 34

11.8 Restarting Your Spa in Cold Weather ........................................ 35

12.0 Water Quality Maintenance ..................................................... 35

12.1 pH Control.................................................................................. 35

12.2 Sanitizing ................................................................................... 36

12.3 CD Ozone Water Maintenance System ..................................... 36

13.0 Error Conditions/Error Messages .......................................... 37

13.1 Summer Logic............................................................................ 37

13.2 Overheat Condition.................................................................... 37

13.3 Panel displays SN1.................................................................... 37

13.4 Panel displays SN2.................................................................... 37

13.5 Panel displays FL1 or FL2 ......................................................... 38

13.6 Panel displays COL ................................................................... 38

13.7 Panel displays ICE..................................................................... 38

13.8 Panel displays - - - .................................................................... 38

14.0 Troubleshooting Procedures .................................................. 39

14.1 None of the Components Operate (e.g. Pump, Light) .............. 39

14.2 Pump Does Not Operate but Light Does ................................... 39

14.3 Poor Jet Action........................................................................... 39

14.4 Water is Too Hot......................................................................... 39

14.5 No Heat...................................................................................... 39

15.0 North American Dover Convertible Circuit Diagram ............ 41

16.0 North American Camden Circuit Diagram ............................. 42

17.0 North American Certa/Chelsee/Hamilton Circuit Diagram... 43

19.0 Export Camden Circuit Diagram............................................. 45

20.0 Export Certa/Chelsee/Hamilton Circuit Diagram .................. 46

21.0 Optional SunSound™Stereo Receiver Functions ............... 47

21.1 SunSound Audio Receiver Specications.................................. 53

21.2 Audio System Remote Control................................................... 55

21.3 Optional MP3 Player Connection............................................... 56

Page 1

1.0 Important Spa Owner Information

Your new Sundance®780 Series Spa is constructed to the highest

standards and is capable of providing many years of trouble-free use.

However, because heat retentive materials are utilized to insulate the

spa for efficient operation, an uncovered acrylic spa surface and wall fit-

tings directly exposed to sunlight and high temperatures for an extended

period are subject to permanent damage or discoloration. Damage

caused by exposing the spa to this abuse is not covered under war-

ranty. We recommend that you always keep the spa full of water when

it is exposed to direct sunlight and that you keep the insulating cover in

place at all times when the spa is not in use. Read and carefully follow

the requirements for your spa’s support base found in Section 4.0 titled,

“Choosing a Location” (Page 7).

We constantly strive to offer the finest spas available, therefore

modifications and enhancements may be made which affect the

specifications, illustrations and/or instructions contained herein.

2.0 FCC Notice

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These

limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used

in accordance with the instructions, may cause harmful interference to

radio communications. However, there is no guarantee that interference

will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be deter-

mined by turning the equipment off and on, the user is encouraged to try

to correct the interference by one or more of the following measures:

1. Rearrange or relocate the receiving antenna.

2. Increase the separation between the equipment and receiver

3. Connect the equipment into an outlet on a circuit different from the

circuit connected.

4. Consult the dealer or an experienced radio/TV technician for help.

Changes or modications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.

Page 2

3.0 Important Safety Instructions

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY!

When installing and using this electrical equipment, basic safety precau-

tions should always be followed, including:

1. WARNING: To reduce the risk of injury, do not permit children to use

this product unless they are closely supervised at all times.

2. WARNING: A grounding wire connector is provided on this unit to

connect a minimum No. 8 AWG (8.4mm²) solid copper conductor

between this unit and any metal equipment, metal enclosures of

electrical equipment, metal water pipe, or conduit within 5 feet (1.5m)

of the unit.

3. DANGER: Risk of Accidental Drowning. Extreme caution must be

exercised to prevent unauthorized access by children. To avoid

accidents, ensure that children cannot use this spa unless they are

supervised at all times.

4. WARNING: Risk of Injury. The suction ttings in this spa are sized to

match the specic water ow created by the pump. If it is necessary

to replace the suction ttings or the pump, be sure that the ow rates

are compatible. Because of the risk of injury,

Never operate or use the spa if the lter, lter lid, or skimmer •

assembly are broken or any part of the skimmer assembly is

missing. Please contact your dealer or nearest service center for

service.

Never replace a suction tting with one rated less than the ow •

rate marked on the original suction tting.

5. DANGER: Risk of Injury. The suction ttings in this spa are sized to

match the specic water ow created by the pump. Should the need

arise to replace the suction ttings or the pump, be sure that the ow

rates are compatible. Never operate the spa if the suction ttings are

broken or missing. Never replace a suction tting with one rated less

than the ow rate marked on the original suction tting.

6. DANGER: Risk of Electric Shock. Install at least 5 feet (1.5m) from

all metal surfaces. As an alternative, a spa may be installed within

5 feet (1.5m) of metal surfaces if each metal surface is permanently

connected (bonded) by a minimum No. 8 AWG (8.4mm²) solid cop-

per conductor attached to the wire connector on the grounding lug,

inside the equipment compartment on the equipment box.

7. DANGER: Risk of Electric Shock. Do not permit any electrical

appliance, such as a light, telephone, radio, television, etc. within

Page 3

5 feet (1.5m) of a spa, unless such appliances are built-in by the

manufacturer.

8. ELECTRICAL SUPPLY: The electrical supply for this product

must include a suitably rated switch or circuit breaker to open all

ungrounded supply conductors to comply with Section 422-20 of the

National Electrical Code, ANSI/NFPA 70. The disconnect must be

readily accessible and visible to the spa occupant but installed at

least 5 feet (1.5m) from the spa water.

9. WARNING: To Reduce the Risk of Injury:

10. The water in a spa should never exceed 104°F (40°C). Water

temperatures between 100°F (38°C) and 104°F (40°C) are consid-

ered safe for a healthy adult. Lower water temperatures are recom-

mended for young children and when spa use exceeds 10 minutes.

11. Since excessive water temperatures have a high potential for caus-

ing fetal damage during the early months of pregnancy, pregnant

or possibly pregnant women should limit spa water temperatures

to 100°F (38°C). If pregnant, please consult your physician before

using a spa.

12. Before entering the spa, the user should measure the water tem-

perature with an accurate thermometer since the tolerance of water

temperature-regulating devices may vary as much as +/- 5°F (2°C).

13. The use of alcohol, drugs, or medication before or during spa use

may lead to unconsciousness with the possibility of drowning.

14. Persons suffering from obesity or a medical history of heart disease,

low or high blood pressure, circulatory system problems, diabetes,

infectious diseases or immune deciency syndromes should consult

a physician before using a spa. If you experience breathing difcul-

ties in association with using or operating your spa, discontinue use

and consult your physician.

15. Persons using medication should consult a physician before using

a spa since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

16. Always shower before and after using your spa. To reduce the pos-

sibility of contracting a waterborne illness, always maintain water

chemistry within the parameters listed on the inside cover of this

manual. If you or other bathers experience such a condition, discon-

tinue use and seek medical attention.

Page 4

3.1 Important CSA Safety Instructions (Canada Only)

When using this electrical equipment, basic safety precautions should

always be followed, including the following:

1. READ AND FOLLOW ALL INSTRUCTIONS.

2. A green colored terminal or a terminal marked G, Gr, Ground,

Grounding or the symbol*is located inside the supply terminal box

or compartment. To reduce the risk of electric shock, this terminal

must be connected to the grounding means provided in the elec-

tric supply service panel with a continuous copper wire equivalent

in size to the circuit conductors that supply this equipment (*IEC

Publication 417, Symbol 5019).

3. At least two lugs marked “Bonding Lugs” are provided on the exter-

nal surface or on the inside of the supply terminal box/compartment.

To reduce the risk of electric shock, connect the local common bond-

ing grid in the area of the spa to these terminals with an insulated or

bare copper conductor not smaller than No. 6 AWG (10mm²).

4. All eld-installed metal components such as rails, ladders, drains

or other similar hardware within 10 feet (3m) of the spa shall be

bonded to the equipment grounding buss with copper conductors not

smaller than No. 6 AWG (10mm²).

5. SAVE THESE INSTRUCTIONS.

WARNING: Children should not use spas without adult supervision.

WARNING: Do not use spas unless all suction guards are installed to

prevent body and hair entrapment.

WARNING: People with infectious diseases should not use a spa.

WARNING: To avoid injury, exercise care when entering or exiting the

spa.

WARNING: Do not use drugs or alcohol before or during the use of a

spa to avoid unconsciousness and possible drowning.

WARNING: Pregnant or possibly pregnant women should consult a

physician before using a spa.

Page 5

WARNING: Water temperature in excess of 38 °C (104 °F) may be

injurious to your health.

WARNING: Before entering the spa, measure the water temperature

with an accurate thermometer.

WARNING: Do not use a spa immediately following strenuous exercise.

WARNING: Prolonged immersion in a spa may be injurious to your

health.

WARNING: Do not permit electric appliances (such as lights, tele-

phones, radios, televisions, etc.) within 5 feet (1.5m) of this spa unless

factory installed.

CAUTION: Maintain water chemistry in accordance with manufacturer’s

instructions.

WARNING: The use of alcohol or drugs can greatly increase the risk of

fatal hyperthermia in spas.

3.2 Hyperthermia

Prolonged immersion in hot water may induce hyperthermia. A descrip-

tion of the causes, symptoms, and effects of hyperthermia are as

follows:

Hyperthermia occurs when the internal temperature of the body reaches

a level several degrees above the normal body temperature of 98.6°F

(37°C). The symptoms of hyperthermia include drowsiness, lethargy,

and an increase in the internal temperature of the body. The effects of

hyperthermia include:

A Unawareness of impending hazard;

B. Failure to perceive heat;

C. Failure to recognize the need to exit spa;

D. Physical inability to exit spa;

E. Fetal damage in pregnant women; and

F. Unconsciousness and danger of drowning.

Page 6

3.3 Cautions

1. Persons suffering from heart disease, diabetes, high or low blood

pressure, and any condition requiring medical treatment, pregnant

women, the elderly, or infants should consult with a physician before

using a spa.

2. The Consumer Products Safety Commission/USA has stated that

the water temperature in a spa should not exceed 104°F (40°C).

Immersion in water in excess of 104°F (40°C) can be hazardous to

your health.

3. Observe a reasonable time limit when using the spa. Long expo-

sures at higher temperatures can cause high body temperature.

Symptoms may include dizziness, nausea, fainting, drowsiness, and

reduced awareness. These effects could possibly result in drowning.

4. Do not use the spa under the inuence of alcohol, narcotics, or other

drugs. Use of the spa under these conditions may lead to serious

consequences.

5. Always test the spa water temperature before entering the spa.

Enter and exit the spa slowly. Wet surfaces can be very slippery.

6. Never bring any electrical appliances into or near the spa. Never

operate any electrical appliances from inside the spa or when you

are wet unless such appliances are built-in by the manufacturer.

7. Proper chemical maintenance of spa water is necessary to maintain

safe water and prevent possible damage to spa components.

8. Use the straps and clip tie downs to secure the cover when not in

use. This will help to discourage unsupervised children from enter-

ing the spa and keep the spa cover secure in high-wind conditions.

There is no representation that the cover, clip tie-downs, or actual

locks will prevent access to the spa.

3.4 General Electrical Safety Instructions

Your new Sundance® 780 Series Spa is equipped with a "state-of-

the-art" equipment system. It contains the most advanced safety and

self-protective equipment in the industry. Nonetheless, this spa must

be installed properly to ensure dependable usage. Please contact your

local Sundance dealer or local building department should you have any

questions regarding your installation.

Proper grounding is extremely important. Sundance spas are equipped

with a current collector system. A pressure wire connector is provided

on the surface of the control box, located outside the equipment door

(Figure-B, page 14) to permit connection of a bonding wire between

this point and any ground metal equipment, metal water pipe or conduit

within 5 feet (1.5m) of the spa, or copper clad grounding rod buried

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sundance Spas Whirlpool Handbücher

Sundance Spas

Sundance Spas CONSTANCE 6530-512X Bedienungsanleitung

Sundance Spas

Sundance Spas Camden Bedienungsanleitung

Sundance Spas

Sundance Spas 780 series Bedienungsanleitung

Sundance Spas

Sundance Spas Portofino Series Montageanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR 880 Bedienungsanleitung

Sundance Spas

Sundance Spas Hawthorne Bedienungsanleitung

Sundance Spas

Sundance Spas CAMDEN 780 Bedienungsanleitung

Sundance Spas

Sundance Spas 850Export Series Betriebsanleitung

Sundance Spas

Sundance Spas Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas CAMDEN 780 Bedienungsanleitung

Sundance Spas

Sundance Spas 400 series Montageanleitung

Sundance Spas

Sundance Spas Burlington Bedienungsanleitung

Sundance Spas

Sundance Spas 850 Series Betriebsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Altamar 880 series Bedienungsanleitung

Sundance Spas

Sundance Spas 850 Series Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR 880 Gebrauchs- und Wartungshandbuch

Sundance Spas

Sundance Spas Hamilton Bedienungsanleitung

Sundance Spas

Sundance Spas Denali 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas CAMEO Bedienungsanleitung

Sundance Spas

Sundance Spas Spas Bedienungsanleitung

Sundance Spas

Sundance Spas Edison Bedienungsanleitung

Beliebte Whirlpool Handbücher anderer Marken

Bestway

Bestway Lay-Z-Spa 54189 Bedienungsanleitung

Jacuzzi

Jacuzzi ARGA ARG101C0110 Stücklistenhandbuch

Softub

Softub PRESTIGE Bedienungsanleitung

JNJ SPAS

JNJ SPAS SPA-318 Installationshandbuch

KIRAMI

KIRAMI Comfort Family Bedienungsanleitung

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Bedienungsanleitung

HoMedics

HoMedics FB-655HJ-GB Bedienungsanleitung

Everyday Hot Tubs

Everyday Hot Tubs 530 Bedienungsanleitung

anko

anko SS-601A Bedienungsanleitung

Jacuzzi

Jacuzzi Duetta 6042 Bedienungsanleitung

Pooli

Pooli OS030979B Bedienungsanleitung

Jacuzzi

Jacuzzi alimia Bedienungsanleitung

ab Solares Smart Spa Bedienungsanleitung

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Bedienungsanleitung

Outsunny

Outsunny 848-047V70 Bedienungsanleitung

Aquatic

Aquatic INFINITY 1 Bedienungsanleitung

Master Spas

Master Spas MP Force Bedienungsanleitung

Asteria

Asteria 5630 Bedienungsanleitung