Sundance Spas Kingston 980 Series Bedienungsanleitung

P.N.:6530-397D Rev. A 980™ Series

Owner’s manual

Kingston™ Claremont™

Attention New Hot Tub Owner!

Congratulations on the purchase of your new Sundance®Spas hot tub!

The following is a list of automated functions performed by your hot tub.

These functions are listed below in an attempt to suppress any operational

concerns you may have during the rst 24 hours of ownership! Also listed

below are important maintenance recommendations you should observe

on a regular basis to protect your new investment.

Maintain Healthy Spa Water

Always maintain your hot tub’s water chemistry within the following

parameters:

With CLEARRAY® Without CLEARRAY

pH 7.4-7.6 7.4-7.6

Free chlorine no less than 1.0 ppm 3.0-4.0 ppm

Free Bromine no less than 2.0 ppm 2.0-4.0 ppm

Total Alkalinity 100-150 ppm 100-150 ppm

Calcium Hardness 150-250 ppm 150-250 ppm

IMPORTANT: CLEARRAY Water Purication System is factory in-

stalled. If the CLEARRAY system is altered or is not operating efcient-

ly follow the “without CLEARRAY” water chemistry parameters. Such

parameters are dened by the Association of Pool and Spa Profes-

sionals. CLEARRAY requires an annual lamp replacement to properly

sanitize your water.

!TO DECREASE RISK OF INFECTION OR DISEASE!

Always

maintain your spa lter as outlined below to ensure healthy spa water.

Refer to pages 56-58 for additional information.

Required Filter Maintenance

Your new hot tub is equipped with an advanced

MicroClean®

Ultra water

ltration system that provides unsurpassed water quality! To ensure

maximum water quality at all times, you should replace the lter cartridge

every six months, or earlier as necessary. The lter cartridge is designed

to be thrown away! Attempts to reuse the lter cartridge may result in

the re-release of unwanted particles back into the hot tub. See pages

56-58 for detailed lter cartridge replacement instructions.

Required Water Replacement

!TO DECREASE RISK OF INFECTION OR DISEASE!

You

should replace the hot tub’s water every 3 to 6 months. The frequency

depends on a number of variables including frequency of use, number of

users, and attention paid to water quality maintenance. You will know it is

time for a change when you cannot control sudsing and/or you can no

longer get

the normal feel or sparkle to the water, even though the key

water balance measurements are all within the proper parameters. See

pages 63-65 for additional information.

****** Spa operation subject to change without notice ******

980™ Series

Table of Contents

1.0 Important Hot Tub Owner Information............................1

2.0 FCC Notice ........................................................................1

3.0 Important Safety Instructions for all Spa Owners .........2

3.1 Entrapment Risk .......................................................................... 6

3.2 Hyperthermia ............................................................................... 7

3.3 Important Additional CSA Safety Instructions (Canada Only)...... 8

4.0 Locating Your Sundance Hot Tub ...................................8

4.1 Outdoor Location ......................................................................... 9

4.2 Indoor Location .......................................................................... 10

4.3 Location for the SunSmart™ 2.0 System................................... 11

5.0 General Electrical Safety Instructions..........................12

6.0 Electrical Installation Instructions (240V Service).......12

7.0 Power Requirements......................................................16

7.1 North American 60 Hz Power Options ....................................... 16

7.2 Export 50 Hz Power Options...................................................... 17

8.0 Hot Tub Fill Up Procedure..............................................18

9.0 Hot Tub Features ............................................................23

9.1 Claremont™ Hot Tub Features .................................................. 23

9.2 Claremont Massage/Waterfall Selector Diagram....................... 24

9.3 Claremont Air Controls Diagram ................................................ 25

9.4 Kingston™ Hot Tub Features..................................................... 26

9.5 Kingston Massage/Waterfall Selector Diagram ......................... 27

9.6 Kingston Air Controls Diagram................................................... 28

10.0 Registration and Start-up...............................................29

10.1 Start-up Sequence..................................................................... 29

10.2 Register Your New Spa.............................................................. 29

10.3 Home Menu ............................................................................... 31

11.0 Operating Instructions ...................................................33

11.1 Activating the Jets Pumps and Blower....................................... 33

11.2 Lights Menu ............................................................................... 34

11.3 Music Menu................................................................................ 37

11.4 Connecting the BLUEWAVE® System with

your Bluetooth® device.............................................................. 38

11.5 Acoustics Settings Menu............................................................ 39

11.6 CLEARRAY on Demand ............................................................ 40

11.7 Selecting The Desired Massage Action ..................................... 40

11.8 Adjusting Fluidix Reex, Nex, ST, Intelli-Jets

And Focus-Relief ....................................................................... 40

980™ Series

11.9 Air Controls ................................................................................ 41

11.10 Waterfall Control ........................................................................ 41

11.11 Fragrance Dispenser ................................................................. 41

12.0 Programming and Operation Instructions ...................42

12.1 Draining the SunCooler.............................................................. 43

12.2 Programming the Heating Mode................................................ 45

12.3 Programming the Primary Filtration ........................................... 46

12.4 Programming the Secondary Filtration ...................................... 47

12.5 Cleanup Cycle............................................................................ 48

12.6 Blow-Out Cycle .......................................................................... 48

12.7 Water Care Programming .......................................................... 48

12.8 SunSmart 2.0 Wi-Fi Setup ......................................................... 51

12.9 Programming the Time and Date ............................................... 52

12.10 Locking the Spa ......................................................................... 53

12.11 Programming the Language ...................................................... 54

12.12 Units Display.............................................................................. 55

12.13 System Information.................................................................... 55

13.0 Hot Tub Maintenance......................................................56

13.1 Cleaning/Replacing the Filter Cartridge..................................... 56

13.2 Removing the cabinet panels..................................................... 58

13.3 Draining And Relling................................................................. 59

13.4 Cleaning The Hot Tub Interior.................................................... 60

13.5 Pillow Care................................................................................. 61

13.6 Maintaining the Hot Tub Cabinet................................................ 61

13.7 Cover Care And Maintenance.................................................... 61

13.8 Winterizing ................................................................................. 62

13.9 Restarting Your Hot Tub in Cold Weather .................................. 63

14.0 Water Quality Maintenance............................................63

14.1 pH Control.................................................................................. 64

14.2 Sanitizing ................................................................................... 64

14.3 CLEARRAY Water Purication System ..................................... 65

14.4 CLEARRAY Bulb Replacement and Quartz

Tube Maintenance ..................................................................... 66

14.5 Other Additives........................................................................... 68

14.6 Handrail Maintenance................................................................ 68

15.0 Troubleshooting - Display Messages ...........................69

16.0 Troubleshooting - Procedures.......................................72

17.0 Typical Hot Tub Wiring Diagrams A-B

(North American 60 Hz Models Only)............................74

980™ Series

18.0 Circuit Board Electrical Wiring Diagram ......................75

18.1 North American 60 Hz Electrical Wiring Diagram ...................... 75

18.2 Export 50 Hz Electrical Wiring Diagram..................................... 76

18.3 North American 60Hz Dip Switch Settings................................. 77

18.4 Export 50Hz Dip Switch Settings ............................................... 78

18.5 Dual Service 50Hz Connection.................................................. 80

18.6 Single Service 50Hz Connection ............................................... 80

18.7 Three Service 50Hz Connection................................................ 81

Page 1

980™ Series

1.0 Important Hot Tub Owner Information

Your Sundance®Spa hot tub is constructed to the highest standards

and is capable of providing many years of trouble-free use. However,

because heat retentive materials are utilized to insulate the hot tub for

efcient operation, an uncovered hot tub surface and wall ttings directly

exposed to sunlight and high temperatures for an extended period are

subject to permanent damage or discoloration. Damage caused by

exposing the hot tub to this abuse is not covered under warranty. We

recommend that you always keep the hot tub full of water when it is

exposed to direct sunlight and that you keep the Sundance insulating

cover in place at all times when the hot tub is not in use. Read and

carefully follow the requirements for your hot tub’s support base found in

the Section 4.0 titled, “Locating Your Sundance Hot Tub” (page 8) or

as prescribed by your authorized Sundance Spas dealer.

Sundance hot tubs constantly strives to offer the nest hot tubs

available, therefore, modications and enhancements may be made

which affect the specications, illustrations and/or instructions contained

herein.

2.0 FCC Notice

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These

limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used

in accordance with the instructions, may cause harmful interference to

radio communications. However, there is no guarantee that interference

will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be

determined by turning the equipment off and on, the user is encouraged

to try to correct the interference by one or more of the following

measures:

1. Rearrange or relocate the receiving antenna;

2. Increase the separation between the equipment and receiver;

3. Connect the equipment into an outlet on a circuit different from the

circuit connected;

4. Consult the dealer or an experienced radio/TV technician for help.

(Changes or modications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment).

Page 2

980™ Series

3.0 Important Safety Instructions for all Spa Owners

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY!

This spa was manufactured to meet the standards and specications

outlined in the “Virginia Graeme Baker Pool and Spa Safety Act” (VGB

Safety Act). When installing and using this spa, basic safety precautions

should always be followed, including:

1. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

• Extreme caution must be exercised to prevent unauthorized access

by children.

• To avoid accidents, ensure that children do not use this spa unless

supervised at all times. Adult supervision is a critical safety factor in

preventing children from drowning.

• Use the straps and clip tie downs to secure the spa cover when not

in use. This will help discourage unsupervised children from entering

the spa. Keep the spa cover secure in high-wind conditions.

• There is no representation that the cover, clip tie-downs, or actual

locks will prevent access to the spa.

2. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

• Keep hair, loose articles of clothing or hanging jewelry away from

suction ttings, rotating jets or other moving components to avoid

entrapment that could lead to drowning or severe injury.

• Never use the spa unless all suction guards, lter, lter lid, or skimmer

assembly are installed to prevent body and/or hair entrapment.

• Never operate or use the spa if the lter, lter lid, or skimmer

assembly are broken or any part of the skimmer assembly is missing.

Please contact your dealer or nearest service center for service.

• The suction ttings and suction covers in this spa are sized to match the

specic water ow created by the pump(s). If it is necessary to replace

the suction ttings, suction covers or pump(s), be sure that the ow

rates are compatible and are in compliance with the VGB Safety Act.

• Never replace a suction tting or suction cover with one rated less

than the ow rate marked on the original suction tting. Using

improper suction ttings or suction covers can create a body or hair

suction entrapment hazard that may lead to drowning or severe injury.

3. !DANGER: RISK OF SEVERE INJURY FROM ELECTRIC

SHOCK OR DEATH FROM ELECTROCUTION!

• Install the spa at least 5 feet (1.5m), from all metal surfaces. As an

alternative, a spa may be installed within 5 feet of metal surfaces

if each metal surface is permanently connected (bonded) by a

minimum No. 8 AWG (8.4 mm²) solid copper conductor attached

to the wire connector on the grounding lug, inside the equipment

compartment on the equipment box.

Page 3

980™ Series

• A grounding wire connector is provided on this unit to connect a

minimum No. 8 AWG (8.4 mm²) solid copper conductor between

this unit and any metal equipment, metal enclosures of electrical

equipment, metal water pipe, or conduit within 5 feet (1.5m) of the

unit.

• Never permit any electrical appliance, such as a light, telephone,

radio, television, etc. within 5 feet (1.5m) of a spa unless such

appliances are built-in by the manufacturer.

• Never bring any electrical appliances into or near the spa.

• Never operate any electrical appliances from inside the spa or when

you are wet.

• The electrical supply for this product must include a suitably rated

switch or circuit breaker to open all ungrounded supply conductors

to comply with section 422-20 of the National Electrical Code/

USA, ANSI/NFPA 70. The disconnecting means must be readily

accessible and visible to the spa occupant but installed at least 5

feet (1.5m), from the spa.

• The electrical circuit supplied for the hot tub must include a suitable

ground fault circuit interrupter (GFCI) as required by NEC Article

680-42.

4. !WARNING: RISK OF SEVERE INJURY OR DEATH!

• Extreme caution must be exercised to prevent diving or jumping

into the spa or slipping and falling, which could result in

unconsciousness, drowning, or serious injury. Remember that wet

surfaces can be very slippery.

• Never stand, walk or sit on the top railing of the spa.

5. !WARNING: RISK OF HYPERTHERMIA (OVER-HEATING)

CAUSING SEVERE INJURY, BURNS, WELTS OR DEATH!

• Water temperature in excess of 104°F (40°C) may be injurious to

your health.

• Refer to Section 3.2 Hyperthermia for specic causes and symptoms

of this condition.

• The water in the spa should never exceed 104°F (40°C). Water

temperatures between 100°F (38°C) and 104°F (40°C) are

considered safe for a healthy adult.

• Lower water temperatures are recommended for young children

(children are especially sensitive to hot water) and when spa use

may exceed 10 minutes.

• The Consumer Products Safety Commission/USA has stated that

the water temperature in a spa should not exceed 104°F (40°C).

• Always test the spa water temperature before entering the spa.

The user should measure the water temperature with an accurate

thermometer since the tolerance of water temperature-regulating

devices may vary as much as +/- 5°F (2°C).

Page 4

980™ Series

6. !WARNING: RISK OF SEVERE INJURY OR DEATH!

• Since excessive water temperatures have a high potential for

causing fetal damage during the early months of pregnancy, if

pregnant or possibly pregnant, consult your physician before using a

spa.

• Pregnant or possibly pregnant women should limit spa water

temperatures to 100°F (38°C).

• Persons suffering from obesity or a medical history of heart disease,

low or high blood pressure, circulatory system problems, diabetes,

infectious diseases or immune deciency syndromes should consult

a physician before using a spa.

• If you experience breathing difculties in association with using or

operating your spa, discontinue use and consult your physician.

• Persons using medication should consult a physician before using

a spa since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

• Persons suffering from any condition requiring medical treatment, the

elderly, or infants should consult with a physician before using a spa.

• The use of alcohol, drugs, or medication before or during spa use

may lead to unconsciousness with the possibility of drowning.

7. !WARNING: RISK OF SEVERE INJURY OR DEATH!

• Prolonged immersion in a spa may be injurious to your health.

• Observe a reasonable time limit when using the spa. Exposures

at higher temperatures can cause high body temperature (over-

heating). Symptoms may include dizziness, nausea, fainting,

drowsiness, and reduced awareness. These effects could possibly

result in drowning or serious injury.

• Never use a spa immediately following strenuous exercise. Enter

and exit the spa slowly. Wet surfaces can be slippery.

8. !WARNING: TO DECREASE RISK OF INFECTION OR

DISEASE!

• To reduce the risk of contracting a waterborne

illness (e.g. an infec-

tion, bacteria or virus) and/or respiratory ailments

, maintain water

chemistry within the parameters listed on the inside cover of this

manual and consult with a licensed engineer regarding proper venti-

lation if installed indoors or in an enclosed area.

• People with infectious diseases should not use a spa to avoid water

contamination, which could result in spreading infections to others.

• Always shower before and after using your spa. Maintain water

chemistry in accordance with manufacturer’s instructions. Failure to

do so may result in contracting a waterborne

illness (e.g. an infec-

tion, bacteria or virus).

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sundance Spas Whirlpool Handbücher

Sundance Spas

Sundance Spas Marin 880 Bedienungsanleitung

Sundance Spas

Sundance Spas CONSTANCE 6530-512X Bedienungsanleitung

Sundance Spas

Sundance Spas Camdenl Certa Bedienungsanleitung

Sundance Spas

Sundance Spas Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Edison Bedienungsanleitung

Sundance Spas

Sundance Spas Solo Betriebsanleitung

Sundance Spas

Sundance Spas Altmar Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Spas Bedienungsanleitung

Sundance Spas

Sundance Spas Camden Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 780 series Bedienungsanleitung

Sundance Spas

Sundance Spas CAMEO Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Maxxus Bedienungsanleitung

Sundance Spas

Sundance Spas Hamilton Bedienungsanleitung

Sundance Spas

Sundance Spas 850 Series Betriebsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR Bedienungsanleitung

Sundance Spas

Sundance Spas 850Export Series Betriebsanleitung

Sundance Spas

Sundance Spas 850 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Hawthorne Bedienungsanleitung

Sundance Spas

Sundance Spas Export 680 Series Bedienungsanleitung

Beliebte Whirlpool Handbücher anderer Marken

Bestway

Bestway Lay-Z-Spa 54189 Bedienungsanleitung

Jacuzzi

Jacuzzi ARGA ARG101C0110 Stücklistenhandbuch

Softub

Softub PRESTIGE Bedienungsanleitung

JNJ SPAS

JNJ SPAS SPA-318 Installationshandbuch

KIRAMI

KIRAMI Comfort Family Bedienungsanleitung

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Bedienungsanleitung

HoMedics

HoMedics FB-655HJ-GB Bedienungsanleitung

Everyday Hot Tubs

Everyday Hot Tubs 530 Bedienungsanleitung

anko

anko SS-601A Bedienungsanleitung

Jacuzzi

Jacuzzi Duetta 6042 Bedienungsanleitung

Pooli

Pooli OS030979B Bedienungsanleitung

Jacuzzi

Jacuzzi alimia Bedienungsanleitung

ab Solares Smart Spa Bedienungsanleitung

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Bedienungsanleitung

Outsunny

Outsunny 848-047V70 Bedienungsanleitung

Aquatic

Aquatic INFINITY 1 Bedienungsanleitung

Master Spas

Master Spas MP Force Bedienungsanleitung

Asteria

Asteria 5630 Bedienungsanleitung