Sundance Spas 880 Series Bedienungsanleitung

880

owner’s manual

6530-395T Rev. A

Attention New Hot Tub Owner!

Congratulations on the purchase of your new Sundance®hot tub! The following is

a list of automated functions performed by your hot tub. These functions are listed

below in an attempt to suppress any operational concerns you may have during the

rst 24-hours of ownership! Also listed below are important maintenance recom-

mendations you should observe on a regular basis to protect your new investment.

Automated Spa Operations

Your new hot tub is equipped with an automated “blow-out” cycle that clears all

plumbing lines daily to promote maximum water sanitation. Each day at 12:00 PM

(noon), pump 2, pump 3 (Maxxus Models Only) and the blower will automatically

turn on for a period of one minute, then go off. Then pump 1 will turn on and run

for one minute to complete the blow-out cycle. Be aware, the factory programmed

blow-out cycle cannot be canceled or altered!

Maintain Healthy Spa Water

Always maintain your hot tub’s water chemistry within the following parameters as

dened by the Association of Pool And Spa Professionals:

pH 7.4-7.6

Free chlorine 3.0-4.0 ppm

Free Bromine 2.0-4.0 ppm

Total Alkalinity 100-120 ppm

Calcium Hardness 150-250 ppm

Always maintain your spa lter as outlined below to ensure healthy spa water. Refer

to pages 58-59 for additional information.

Required Filter Maintenance

Your new hot tub is equipped with an advanced MicroClean Plus water ltration

system that provides unsurpassed water quality! To ensure maximum water quality

at all times, you should replace the lter cartridge every six months, or earlier as

necessary. The lter cartridge is designed to be thrown away! Attempts to reuse the

lter cartridge may result in the re-release of unwanted particles back into the hot

tub. See pages 53-

for detailed lter cartridge replacement instructions.

Required Water Replacement

You should replace the hot tub’s water every 3 to 6 months. The frequency depends

on a number of variables including frequency of use, number of users, and atten-

tion paid to water quality maintenance. You will know it is time for a change when

you cannot control sudsing and/or you can no longer get

the normal feel or sparkle

to the water, even though the key water balance measurements are all within the

proper parameters. See pages 58-59 for additional information.

Table of Contents

1.0 Important Hot Tub Owner Information............................1

2.0 Important safety instructions ..........................................2

3.0 Locating Your Sundance Hot Tub ...................................7

3.1 Outdoor Location ......................................................................... 7

3.2 Indoor Location ............................................................................ 8

4.0 General Electrical Safety Instructions............................9

5.0 Electrical Installation Instructions (240V Service).........9

6.0 Maxxus Power Requirements........................................13

7.0 Altamar/Cameo/Capri/Marin/Majesta/Optima

Power Requirements......................................................14

8.0 Hot Tub Fill Up Procedure..............................................15

9.0 Hot Tub Features (All Models) .......................................20

9.1 Main Control Panel Functions.................................................... 20

9.2 LCD Screen Functions............................................................... 21

10.0 Operating Instructions ...................................................29

10.1 View Button................................................................................ 29

10.2 Light Button (Main Control Panel).............................................. 29

10.3 AquaTerrace™ Light Control Panel ........................................... 29

10.4 Air Injection ................................................................................ 30

10.5 Activate Jets Pump 1 ................................................................. 30

10.6 Activate Jets Pump 2/Pump 3.................................................... 30

10.7 Selecting The Desired Massage Action ..................................... 31

10.8 Adjusting Fluidix Reex And Intelli-Jets ..................................... 31

10.9 Air Controls ................................................................................ 32

10.10 Waterfall Control ........................................................................ 32

10.11 Fragrance Dispenser ................................................................. 32

10.12 Optional SunSound™ Audio System ......................................... 33

10.13 Maxxus Massage/Waterfall Selector Diagram ........................... 34

10.14 Maxxus Air Controls Diagram .................................................... 35

10.15 Optima Massage/Waterfall Selector Diagram............................ 36

10.16 Optima Air Controls Diagram ..................................................... 37

10.17 Cameo Massage/Waterfall Selector Diagram............................ 38

10.18 Cameo Air Controls Diagram ..................................................... 39

10.19 Majesta Massage/Waterfall Selector Diagram........................... 40

10.20 Majesta Air Controls Diagram .................................................... 41

10.21 Altamar Massage/Waterfall Selector Diagram ........................... 42

10.22 Altamar Air Controls Diagram .................................................... 43

10.23 Marin Massage/Waterfall Selector Diagram .............................. 44

10.24 Marin Air Controls Diagram........................................................ 45

10.25 Capri Massage/Waterfall Selector Diagram............................... 46

10.26 Capri Air Controls Diagram ........................................................ 47

11.0 Heating Modes ................................................................48

11.1 Standard Mode (Factory Default)............................................... 48

11.2 Economy Mode.......................................................................... 48

11.3 Selecting Standard or Economy Mode ...................................... 48

11.4 Clean-Up “Blow-Out” Cycle........................................................ 48

12.0 Programming Instructions.............................................49

12.1 Programming Filter/Circulation Pump (Standard Mode)............ 49

12.2 Programmable Heat Cycles (Economy Mode Only) .................. 49

12.3 Adjusting Time of Day................................................................ 51

12.4 Main Control Panel Lock............................................................ 51

12.5 Temperature Setting Lock .......................................................... 52

12.6 Programming the Change Filter Reminder ................................ 52

13.0 Hot Tub Maintenance......................................................53

13.1 Replacing the Filter Cartridge .................................................... 53

13.2 Draining And Relling................................................................. 55

13.3 Cleaning The Hot Tub Interior.................................................... 56

13.4 Pillow Care................................................................................. 56

13.5 Maintaining the Synthetic or TerraStone Cabinet....................... 56

13.6 Maintaining The Cover............................................................... 57

13.7 Winterizing ................................................................................. 57

13.8 Restarting Your Hot Tub in Cold Weather .................................. 58

14.0 Water Quality Maintenance............................................58

14.1 pH Control.................................................................................. 58

14.2 Sanitizing ................................................................................... 59

14.3 Other Additives........................................................................... 59

14.4 Ozone Water Maintenance System ........................................... 59

14.5 Handrail Maintenance................................................................ 60

15.0 Troubleshooting - Display Messages ...........................60

16.0 Troubleshooting - Procedures.......................................62

17.0 North American 60Hz Maxxus Electrical Wiring

Diagram ..........................................................................65

18.0 North American 60Hz Altamar/Cameo/Capri/

Majesta/Optima/Marin Electrical Wiring Diagram........66

19.0 North American 60Hz Cameo/Optima Electrical

Wiring Diagram ...............................................................67

20.0 Export 50Hz Maxxus Electrical Wiring Diagram ..........68

21.0 Circuit Board Pin Assignments .....................................69

22.0 Typical Hot Tub Wiring Diagrams A-B (North

American 60 Hz Models Only) .......................................70

23.0 Optional SunSound™Stereo Receiver Features.........71

23.1 SunSound Stereo Receiver Button Controls.............................. 71

23.2 SunSound Stereo Receiver General Controls ........................... 71

22.3 SunSound Stereo Receiver Operation....................................... 72

23.4 SunSound Stereo Receiver Troubleshooting............................. 74

23.5 SunSound Stereo Receiver CD Player Operation ..................... 75

23.6 Stereo Receiver Specications.................................................. 76

23.7 Standard Wireless Remote Control Functions........................... 77

23.8 Wireless Remote Battery Replacement Procedure ................... 79

23.9 iPod™ Docking Station.............................................................. 80

23.10 Generic MP3 Player Operation.................................................. 81

Page 1

1.0 Important Hot Tub Owner Information

Your Sundance®hot tub is constructed to the highest standards and is

capable of providing many years of trouble-free use. However, because

heat retentive materials are utilized to insulate the hot tub for ef-

cient operation, an uncovered hot tub surface and wall ttings directly

exposed to sunlight and high temperatures for an extended period

are subject to permanent damage or discoloration. Damage caused

by exposing the hot tub to this abuse is not covered under warranty.

We recommend that you always keep the hot tub full of water when it

is exposed to direct sunlight and that you keep the Sundance insulat-

ing cover in place at all times when the hot tub is not in use. Read and

carefully follow the requirements for your hot tub’s support base found in

the Section 3.0 titled, “Locating Your Sundance Hot Tub” (page 7) or as

prescribed by your authorized Sundance Spas dealer.

Sundance hot tubs constantly strives to offer the nest hot tubs

available, therefore, modications and enhancements may be made

which affect the specications, illustrations and/or instructions

contained herein.

FCC Notice

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These

limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used

in accordance with the instructions, may cause harmful interference to

radio communications. However, there is no guarantee that interference

will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be deter-

mined by turning the equipment off and on, the user is encouraged to try

to correct the interference by one or more of the following measures:

1. Rearrange or relocate the receiving antenna;

2. Increase the separation between the equipment and receiver;

3. Connect the equipment into an outlet on a circuit different from the

circuit connected;

4. Consult the dealer or an experienced radio/TV technician for help.

(Changes or modications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.)

Page 2

2.0 Important safety instructions

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY

When installing and using this electrical equipment, basic safety precau-

tions should always be followed, including:

1. WARNING: To reduce the risk of injury, do not permit children to use

this product unless they are closely supervised at all times.

2. WARNING: A grounding wire connector is provided on this unit to

connect a minimum No. 8 AWG (8.4mm²) solid copper conduc-

tor between this unit and any metal equipment, metal enclosures

of electrical equipment, metal water pipe, or conduit within 5 feet

(1.5m) of the unit.

3. DANGER: Risk of Accidental Drowning. Extreme caution must be

exercised to prevent unauthorized access by children. To avoid acci-

dents, ensure that children cannot use this hot tub unless they are

supervised at all times.

4. DANGER: Risk of Injury. The suction ttings in this spa are sized to

match the specic water ow created by the pump. If it is necessary

to replace the suction ttings or the pump, be sure that the ow rates

are compatible. Because of the risk of injury,

Never operate or use the spa if the lter, lter lid, or skimmer •

assembly are broken or any part of the skimmer assembly is

missing. Please contact your dealer or nearest service center for

service.

Never replace a suction tting with one rated less than the ow •

rate marked on the original suction tting.

5. DANGER: Risk of Injury. The suction ttings in this hot tub are sized

to match the specic water ow created by the pump. Should the

need arise to replace the suction ttings or the pump, be sure that

the ow rates are compatible. Never operate the hot tub if the suc-

tion ttings are broken or missing. Never replace a suction tting

with one rated less than the ow rate marked on the original suction

tting.

6. DANGER: Risk of Electric Shock. Install at least 5 feet (1.5m), from

all metal surfaces. As an alternative, a hot tub may be installed

within 5 feet of metal surfaces if each metal surface is permanently

connected (bonded) by a minimum No. 8 AWG (8.4mm²) solid cop-

per conductor attached to the wire connector on the grounding lug,

inside the equipment compartment on the equipment box.

7. DANGER: Risk of Electric Shock. Do not permit any electrical appli-

ance, such as a lights, telephones, radios, televisions, etc. within 5

feet (1.5m) of a hot tub unless such appliances are built-in by the

manufacturer.

Page 3

8. Electrical Supply: The electrical supply for this product must

include a suitably rated switch or circuit breaker to open all

ungrounded supply conductors to comply with Section 422-20 of the

National Electrical Code, ANSI/NFPA 70. The disconnect must be

readily accessible and visible to the hot tub occupant but installed at

least 5 feet (1.5m), from the hot tub water.

9. WARNING: To Reduce the Risk of Injury:

10. The water in the hot tub should never exceed 104°F (40°C). Water

temperatures between 100°F (38°C) and 104°F (40°C) are consid-

ered safe for a healthy adult. Lower water temperatures are recom-

mended for young children and when hot tub use may exceed 10

minutes.

11. Since excessive water temperatures have a high potential for caus-

ing fetal damage during the early months of pregnancy, pregnant or

possibly pregnant women should limit hot tub water temperatures

to 100°F (38°C). If pregnant, please consult your physician before

using a hot tub.

12. Before entering the hot tub, the user should measure the water tem-

perature with an accurate thermometer since the tolerance of water

temperature-regulating devices may vary as much as +/- 5°F (2°C).

13. The use of alcohol, drugs, or medication before or during hot tub use

may lead to unconsciousness with the possibility of drowning.

14. Persons suffering from obesity or a medical history of heart disease,

low or high blood pressure, circulatory system problems, diabetes,

infectious diseases or immune deciency syndromes should consult

a physician before using a hot tub. If you experience breathing dif-

culties in association with using or operating your hot tub, discon-

tinue use and consult your physician.

15. Persons using medication should consult a physician before using a

hot tub since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

16. Always shower before and after using your hot tub. To reduce the

possibility of contracting a waterborne illness, always maintain water

chemistry within the parameters listed on the inside cover of this

manual. If you or other bathers experience such a condition, discon-

tinue use and seek medical attention.

Page 4

Important CSA safety instructions (Canada only)

When using this electrical equipment, basic safety precautions should

always be followed, including the following:

1. READ AND FOLLOW ALL INSTRUCTIONS.

2. A green colored terminal or a terminal marked G, Gr, Ground,

Grounding or the symbol* is located inside the supply termi-

nal box or compartment. To reduce the risk of electric shock, this

terminal must be connected to the grounding means provided in the

electric supply service panel with a continuous copper wire equiva-

lent in size to the circuit conductors that supply this equipment. *IEC

Publication 417, Symbol 5019.

3. At least two lugs marked “Bonding Lugs” are provided on the exter-

nal surface or on the inside of the supply terminal box/compartment.

To reduce the risk of electric shock, connect the local common bond-

ing grid in the area of the hot tub to these terminals with an insulated

or bare copper conductor not smaller than No. 6 AWG (10mm²).

4. All eld-installed metal components such as rails, ladders, drains

or other similar hardware within 10 feet (3m) of the hot tub shall be

bonded to the equipment grounding buss with copper conductors not

smaller than No. 6 AWG (10mm²).

5. SAVE THESE INSTRUCTIONS.

WARNING: Children should not use hot tubs without adult supervision.

WARNING: Do not use hot tubs unless all suction guards are installed to

prevent body and hair entrapment.

WARNING: People with infectious diseases should not use a hot tub.

WARNING: To avoid injury, exercise care when entering or exiting the

hot tub.

WARNING: Do not use drugs or alcohol before or during the use of a hot

tub to avoid unconsciousness and possible drowning.

WARNING: Pregnant or possibly pregnant women should consult a

physician before using a hot tub.

WARNING: Water temperature in excess of 40°C (104°F) may be injuri-

ous to your health.

Andere Handbücher für 880 Series

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sundance Spas Whirlpool Handbücher

Sundance Spas

Sundance Spas Camden Bedienungsanleitung

Sundance Spas

Sundance Spas CAMDEN 780 Bedienungsanleitung

Sundance Spas

Sundance Spas Burlington Bedienungsanleitung

Sundance Spas

Sundance Spas Edison Bedienungsanleitung

Sundance Spas

Sundance Spas Hawthorne Bedienungsanleitung

Sundance Spas

Sundance Spas Export 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Denali 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Spas Bedienungsanleitung

Sundance Spas

Sundance Spas ALTAMAR 880 Bedienungsanleitung

Sundance Spas

Sundance Spas 680 Series Bedienungsanleitung

Sundance Spas

Sundance Spas CAMEO Betriebsanleitung

Sundance Spas

Sundance Spas Solo Betriebsanleitung

Sundance Spas

Sundance Spas Maxxus Bedienungsanleitung

Sundance Spas

Sundance Spas Maxxus Betriebsanleitung

Sundance Spas

Sundance Spas ALTAMAR 880 Gebrauchs- und Wartungshandbuch

Sundance Spas

Sundance Spas Altamar 880 series Bedienungsanleitung

Sundance Spas

Sundance Spas Altmar Bedienungsanleitung

Sundance Spas

Sundance Spas 880 Series Bedienungsanleitung

Sundance Spas

Sundance Spas Portofino Series Montageanleitung

Sundance Spas

Sundance Spas CAMEO Bedienungsanleitung

Sundance Spas

Sundance Spas CAMDEN 780 Bedienungsanleitung

Beliebte Whirlpool Handbücher anderer Marken

Bestway

Bestway Lay-Z-Spa 54189 Bedienungsanleitung

Jacuzzi

Jacuzzi ARGA ARG101C0110 Stücklistenhandbuch

Softub

Softub PRESTIGE Bedienungsanleitung

JNJ SPAS

JNJ SPAS SPA-318 Installationshandbuch

KIRAMI

KIRAMI Comfort Family Bedienungsanleitung

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Bedienungsanleitung

HoMedics

HoMedics FB-655HJ-GB Bedienungsanleitung

Everyday Hot Tubs

Everyday Hot Tubs 530 Bedienungsanleitung

anko

anko SS-601A Bedienungsanleitung

Jacuzzi

Jacuzzi Duetta 6042 Bedienungsanleitung

Pooli

Pooli OS030979B Bedienungsanleitung

Jacuzzi

Jacuzzi alimia Bedienungsanleitung

ab Solares Smart Spa Bedienungsanleitung

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Bedienungsanleitung

Outsunny

Outsunny 848-047V70 Bedienungsanleitung

Aquatic

Aquatic INFINITY 1 Bedienungsanleitung

Master Spas

Master Spas MP Force Bedienungsanleitung

Asteria

Asteria 5630 Bedienungsanleitung