Sundstrom SR 100 Technisches Handbuch

2020-06-04

OI01H-2021 SR 100 1

Operation Instruction

SR 100

Half mask APR

Revision: 04

General information

Instructions for use for SR 100 APR should be read before use.

Together with filters/cartridges from the Sundström filter range in accordance with the NIOSH approval label.

Three sizes S/M, M/L and L/XL.

Together with compressed air attachment SR 307 and SR 358 or SR 359 compressed air supply tube in

accordance with NIOSH approval label for SAR.

When selecting equipment for SR 100 some of the factors that should be considered are as follows:

• Type of pollutants

• Concentrations

• Work intensity

• Protection requirements in addition to respiratory protective advice.

Risk assessment should be carried by a person who has suitable training and experience in the area.

2020-06-04

OI01H-2021 SR 100 2

Unpacking the SR 100

Check that the equipment is complete in accordance

with the packing list, and that no transport damages

have occurred.

Packing list:

•Half mask

•Pre-filter holder

•Cleaning tissue

•ID-tag

•Pre-filter

•Storage bag

•Instruction for use

2020-06-04

OI01H-2021 SR 100 3

1. Filter

2020-06-04

OI01H-2021 SR 100 4

1.1 Check that you have

selected the correct filter.

1.2 During work in

atmospheres containing both

particulates and gases/vapors

(such as spray painting) the

particulate filter and chemical

cartridge should be

combined.

1.3 Place the P100

particulate filter on top of the

cartridge. Grasp both

protective elements. Squeeze

hard until you hear the P100

snap onto the cartridge a

snap.Attempt to pull the filter

and cartridge apart to check

that they are properly

connected.

1.4 Place a coin it in the

space between the lower lip

of the particulate filter and the

small tab moulded into the

side of the cartridge.

Push firmly and twist the coin

until the filter pops off.

1. Filter

2020-06-04

OI01H-2021 SR 100 5

1.5 Fit the filter/combined

filter in the mask so that the

arrows on the filter point

towards the user’s face.

Carefully check that the edge

of the filter is in the internal

groove of the filter mounting

all around.

1.6 Fit pre-filter SR 221 in the

pre-filter holder.

Pre-filter prevents premature

clogging of the main filter.

The pre-filter holder prevents

damage to the main filter.

N.B. The pre-filter is a pre-

filter only and cannot be used

as a substitute for particulate

filter P100.

1.7 Press it into place on the

filter.

2. Donning

2020-06-04

OI01H-2021 SR 100 6

2.1 Remove any hood,

glasses or ear protection from

head.

Holding the respirator in one

hand, grab the locking buckle

and pull on the head strap

until the pad or cradle is tight

against the respirator.

2.2 Take out any twists or

tangles.

2.3 Holding the strap buckle,

pull the strap over your head

and put it around your neck.

2.4 Let the mask hang on

your chest.

2. Donning

2020-06-04

OI01H-2021 SR 100 7

2.5 Grab the pad or cradle

with one hand and the filter or

cartridge with the other.

2.6 Hold the mask against

your face.

2.7 Pull the pad or cradle

over your head and place it

on the crown of the head.

Wiggle the respirator until it

fits comfortably.

Perform a fit check.

3. Adjusting the harness

2020-06-04

OI01H-2021 SR 100 8

3.1 Reach behind your neck

and grab the free end of the

harness strap.

3.2 Pull the free end away

from the neck until buckle

pops open.

3.3 Pull on the free end of the

strap until the respirator seats

comfortably on your face.

Use your thumb and

forefinger to squeeze the

buckle shut.

3.4 Wiggle the respirator until

it seats comfortably.

4. Negative fit check

2020-06-04

OI01H-2021 SR 100 9

4.1 Install a protective

element.

Snap the pre-filter holder onto

the protective element.

4.2 Donning the respirator.

4.3 Place the palm of your

hand lightly over the hole on

the pre-filter holder to make it

tight.

Inhale gently, the respirator should pull inward on the face. Hold

your breath, the respirator should remain collapsed on the face.

Remove the palm of your hand from the pre-filter holder. Breathe

normally.

If any leakage is detected, check the inhalation and exhalation

valves, adjust the straps of head harness or switch to alternative

size of the respirator. Repeat the fit check until there is no

leakage.

NOTE!

Do not push so hard that the respirator´s shape is affected.

5. Change the inhalation membrane 6. Change the head harness

2020-06-04

OI01H-2021 SR 100 10

5.1 Reach inside the

respirator and gently pull out

the inhalation membrane.

5.2 Check the edge of the

inhalation valve. Gently

stretch the flap until it slips

over the stud.

6.1 Detach the head harness

by pushing the two

connection points towards the

filter attachment.

6.2 Check that the straps are

not twisted and snap on the

new harness by putting each

plastic swivel into the

contoured slot and pulling it

until it snaps in.

Andere Handbücher für SR 100

Inhaltsverzeichnis

Andere Sundstrom Atemwegsprodukt Handbücher

Sundstrom

Sundstrom SR561 Technisches Handbuch

Sundstrom

Sundstrom SR 200 Technisches Handbuch

Sundstrom

Sundstrom SR 100 APR Bedienungsanleitung

Sundstrom

Sundstrom SR 200 Montageanleitung

Sundstrom

Sundstrom SR 84 Bedienungsanleitung

Sundstrom

Sundstrom SR561 Installations- und Benutzerhandbuch

Sundstrom

Sundstrom SR570 Installations- und Benutzerhandbuch

Sundstrom

Sundstrom SR 500 Bedienungsanleitung

Sundstrom

Sundstrom SR 500 Bedienungsanleitung

Sundstrom

Sundstrom SR 90 Airline Bedienungsanleitung

Sundstrom

Sundstrom SR 100 M/L Handbuch

Sundstrom

Sundstrom SR307 Technisches Handbuch

Sundstrom

Sundstrom SR 905 Bedienungsanleitung

Sundstrom

Sundstrom SR 200 Bedienungsanleitung

Sundstrom

Sundstrom SR 90 Airline Bedienungsanleitung

Sundstrom

Sundstrom SR 900 Bedienungsanleitung

Sundstrom

Sundstrom SR 100 Bedienungsanleitung

Sundstrom

Sundstrom SR 200 Bedienungsanleitung

Sundstrom

Sundstrom SR 900 Bedienungsanleitung

Sundstrom

Sundstrom SR 900 Bedienungsanleitung

Sundstrom

Sundstrom SR 500 Bedienungsanleitung

Sundstrom

Sundstrom SR 507 Technisches Handbuch

Sundstrom

Sundstrom SR540 Bedienungsanleitung

Sundstrom

Sundstrom SR 540 EX Bedienungsanleitung

Beliebte Atemwegsprodukt Handbücher anderer Marken

Omron

Omron COMP A-I-R NE-C801 Bedienungsanleitung

CERES

CERES nosko nebulizer kit Bedienungsanleitung

Dr.Frei

Dr.Frei NE-SM1 Bedienungsanleitung

North

North 5400 series Bedienungsanleitung

John Bunn

John Bunn Neb-u-Lite LX2 Bedienungsanleitung

DeVilbiss

DeVilbiss UltraNeb Bedienungsanleitung

Sperian

Sperian Panther Hip-Pac P9684 Series Bedienungsanleitung

Dräger

Dräger X-plore 6570 Bedienungsanleitung

3M 8000 Series Bedienungsanleitung

Respironics

Respironics SideStream HS860 Bedienungsanleitung

JARDIBRIC

JARDIBRIC KPBRU20 Bedienungsanleitung

Ombra

Ombra 63506 Bedienungsanleitung

Lotus

Lotus M-9520A Bedienungsanleitung

Philips

Philips Respironics EE Leak 1 AF541 Bedienungsanleitung

EVOLU

EVOLU Nano AiR MINI Bedienungsanleitung

Ambu

Ambu SPUR II Bedienungsanleitung

MSA AUER

MSA AUER 3S-PF Bedienungsanleitung

MSA

MSA C420 Bedienungsanleitung