Sundstrom SR 99 Bedienungsanleitung

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

1 of 13

Operating Instruction

SR 99 Compressed air filter

SR 99H Air heater

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

2 of 13

General information

Breathable air must meet at least the following purity

requirements:

- the impurities must be maintained at a minimum, and must never

exceed the hygienic limit value.

- the content of mineral oil must be so low that no smell of oil will

be detectable (the odour limit is around 0.3 mg/m3).

- the dew point of the air must be so low that no water will be

precipitated out and no freezing will occur inside the equipment.

- For further particulars of breathable air, see EN 132:1998, EN

12021:1998 and possibly other national regulations.

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

3 of 13

Use

SR 99

The filter has two outlets, one of which

is plugged prior to delivery.

Fit the safety coupling supplied.

The inlet thread of the filter is 1 /2” BSP

female. Fit a suitable coupling/nipple.

The filter drain is opened automatically

when the air supply is shut off. The drain

can also be opened manually. The filter

should be drained once per working

shift.

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

4 of 13

The filter element is fitted prior to

delivery. Note the date on the label at

the outside of the filter housing to be

enable you to keep track of the date

when the filter should be changed.

The SR 99 is equipped with keyhole

mountings for mounting it on a wall,

but it can also be stood on a suitable

surface.

Use

SR 99/H

Connect the air heater to an earthed

power outlet.

Connect the air supply to the

compressed air filter.

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

5 of 13

Turn the presetting knob clockwise until

the green lamp lights up. Then gradually

increase the output until the required

temperature of the outlet air is reached.

The maximum attainable temperature is

around 85 °C.

Connect the compressed air tube from

the air heater to the control valve of the

face piece.

To get best heat efficiency make sure

that the compressed air tube between

the air heater and control valve is as

short as possible (5 to 10 m) and that the

compressed air tube is not lying in snow

etc.

To switch off the heater element, turn the

presetting knob anticlockwise as far as it

will go, and disconnect the power supply

plug.

The overheating protection in the

electrical distribution box may trip

if, for example, the air flow is interrupted.

The red warning lamp will then indicate

that this has occurred.

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

6 of 13

To reset the overheating protection,

proceed as follows:

Switch off the heater element by turning

the presetting knob anti-clockwise as far

as it will go. The green lamp will then be

switched off.

Allow the heater element to cool down.

Press the reset button.

Switch on the heater element as

described earlier.

Filter change

Under normal operating conditions, the

filter element has a useful life of around

six months. However, the useful life may

vary widely, depending on the condition

of the compressed air system and the

air flow rate through the filter. The

condition of the filter element can be

assessed by weighing. The original

weight is shown on the filter element. If

the weight has increased by about 100-

150 grams, the filter should be changed.

If the smell or taste of the impurities

become detectable, the filter should

immediately be changed:

Shut off the air inlet.

Press in the ring on the underside of the

drain valve to depressurize the filter.

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

7 of 13

Loosen the hose between the regulator

and filter lid by pushing the red sleeve on

the coupling and disconnect the hose

from the lid.

Unscrew the knobs of the filter housing

and remove the lid.

Remove the used filter element. Clean

and wipe if necessary.

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

8 of 13

Check the seals and change if they are

damaged.

Mount the new filter element. This has

identical ends and can be fitted either

way round.

Then assemble the filter:

Refit the cover.

Connect the hose between the control

valve and filter lid by pushing the hose

into the connector.

Tighten the knobs alternately by hand

until the lid meets the filter housing.

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

9 of 13

Cleaning

Clean the outside of the filter as

necessary, using soapy water and a

sponge or brush. The filter can also be

blown clean with the compressed air or

flushed with water.

This also applies to the SR 99H that has

degree of protection IP65 and can thus

be flushed with water.

However, always switch off the power

supply and disconnect the power supply

plug before cleaning.

The regulator with pre-collector and

drain bowl should preferably be cleaned

in conjunction with changing the filter

element.

Cleaning

Regulator with pre-collector SR 99

Shut of the air inlet.

Push the ring at the bottom of the pre-

collector to depressurize the filter.

Drawn up by:

2010-02-02 / JR

OI03H-2618 SR 99

Revision:

Reviewed:

Page:

10 of 13

Remove the guard. Slide the black

locking device down and turn the guard

anti-clockwise (bayonet mounting).

Remove the drain bowl. Push it upwards

and turn it anti-clockwise (bayonet

mounting). Wash the bowl in hot water

(not solvent!) at a maximum of 60 °C.

Remove the pre-collector element by

turning it anti-clockwise.

Blow the parts clean with compressed

air. Check that the drain outlet is not

obstructed.

Andere Handbücher für SR 99

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sundstrom Atemwegsprodukt Handbücher

Sundstrom

Sundstrom SR562 Installations- und Benutzerhandbuch

Sundstrom

Sundstrom SR 900 Bedienungsanleitung

Sundstrom

Sundstrom SR 700 Bedienungsanleitung

Sundstrom

Sundstrom SR500EX Bedienungsanleitung

Sundstrom

Sundstrom SR 900 Bedienungsanleitung

Sundstrom

Sundstrom SR 500 Bedienungsanleitung

Sundstrom

Sundstrom SR 200 APR Bedienungsanleitung

Sundstrom

Sundstrom SR 90 Airline Bedienungsanleitung

Sundstrom

Sundstrom SR540 Bedienungsanleitung

Sundstrom

Sundstrom SR570 Bedienungsanleitung

Sundstrom

Sundstrom SR 520 Bedienungsanleitung

Sundstrom

Sundstrom SR 500 EX Bedienungsanleitung

Sundstrom

Sundstrom SR500EX Installations- und Benutzerhandbuch

Sundstrom

Sundstrom SR 900 Bedienungsanleitung

Sundstrom

Sundstrom SR 100 APR Bedienungsanleitung

Sundstrom

Sundstrom SR307 Technisches Handbuch

Sundstrom

Sundstrom SR 200 Bedienungsanleitung

Sundstrom

Sundstrom SR 550 Bedienungsanleitung

Sundstrom

Sundstrom SR 520 Installations- und Benutzerhandbuch

Sundstrom

Sundstrom SR 90 Airline Bedienungsanleitung

Sundstrom

Sundstrom SR 200 Bedienungsanleitung

Sundstrom

Sundstrom SR570 Bedienungsanleitung

Sundstrom

Sundstrom SR 507 Technisches Handbuch

Sundstrom

Sundstrom SR561 Bedienungsanleitung

Beliebte Atemwegsprodukt Handbücher anderer Marken

Omron

Omron COMP A-I-R NE-C801 Bedienungsanleitung

CERES

CERES nosko nebulizer kit Bedienungsanleitung

Dr.Frei

Dr.Frei NE-SM1 Bedienungsanleitung

North

North 5400 series Bedienungsanleitung

John Bunn

John Bunn Neb-u-Lite LX2 Bedienungsanleitung

DeVilbiss

DeVilbiss UltraNeb Bedienungsanleitung

Sperian

Sperian Panther Hip-Pac P9684 Series Bedienungsanleitung

Dräger

Dräger X-plore 6570 Bedienungsanleitung

3M 8000 Series Bedienungsanleitung

Respironics

Respironics SideStream HS860 Bedienungsanleitung

JARDIBRIC

JARDIBRIC KPBRU20 Bedienungsanleitung

Ombra

Ombra 63506 Bedienungsanleitung

Lotus

Lotus M-9520A Bedienungsanleitung

Philips

Philips Respironics EE Leak 1 AF541 Bedienungsanleitung

EVOLU

EVOLU Nano AiR MINI Bedienungsanleitung

Ambu

Ambu SPUR II Bedienungsanleitung

MSA AUER

MSA AUER 3S-PF Bedienungsanleitung

MSA

MSA C420 Bedienungsanleitung