Sunjoy D-DN1377SAL-A Bedienungsanleitung

377S AL

Assembly Instruction

WARNING: For Outdoor Use Only.

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. If odor continues, keep away from the

appliance and immediately call your gas

supplier or fire department.

WARNING:

Improper installation, adjustment, alteration,

service or maintenance can cause injury or

property damage. Read the installation,

operating and maintenance instructions

thoroughly before installing or servicing this

Propane tank not included

AA battery needed, not included

equipment.

WARNING

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or

any other appliance.

An LP

-cylinder not connected for use should not be stored in the vicinity of this or any other

appliance.

DANGER

CARBON MONOXIDE HAZARD

This appliance can produce carbon monoxide which has no odor.

Using it in an enclosed space can kill you.

Never use this appliance in an enclosed space such as a camper, tent,

car or home.

This appliance complies with “ANSI Z21.97-2012/CSA 2.41-2012, Outdoor Decorative Gas Appliances.

1 of 12

Item# D-DN1377SAL-A / L-DN1377SAL-A

(Table)

TABLE OF CONTENTS

2 of 12

GENERAL INFORMATION

IMPORTANT

Please take time to read these instr

uctions thoroughly and follow each step carefully for

safe and easy operation. Keep this manual to consumer for installer and consumer

future reference/use.

For technical assistance on assembly or replacement parts. In the continental U.S., you can cal

l us

toll

-free at 1-866-578-6569 from 8 a.m. to 5 p.m. CST Monday –Friday. In the continental Canada,

you can call us toll

-free at 1-844-SUNJOY1 (1-844-786-5691) from 8 a.m. to 5 p.m. CST Monday –

Friday. You can fax the replacement part form which is in

the box to (740)-283-3549 .You can also

send us an email to

customer.care@sunjoydirect.com.

General information …………….…….………………….………………..………….…… 2

Specification……….…

…………………………………….……………….……….……… 3

portant safety information and precaution……………….….….….….…….……... 3-4

Expanded view……………………………………………………….……….……..……

....5

Parts list……………………….………………………….…………………………….……

Installation………………………….………………………..………………….…….………7

Location………………………………………………………………………

.…….…….…..8

Set up……………………………………………………………….…………….……...……8

Gas connection …

……………………………….……………….……………….……… 8-9

Operation……………………………………………………………….……………...……..9

Leak check………………………………………………………….…………………...……9

Ignite lighting………………………………………………………….…………………. 9

-10

Storage and Maintenance………………………………………….……...............… 10

-11

Trouble shooting ………

………………………………………...….………………..…...11

Limited warranty……………………………………………………………….….…… 11

-12

Cleaning and maintenance………………………………………………………………

SPECIFICATION

L-DN1377SAL-A

50,000BTU/HR

Propane

-LP

20 lb. LP

-Gas cylinder

11 Inches W.C.

2.18mm

Max.250 PSI

IMPROTANT SAFETY INFORMATION AND PRECAUTION

When the appliance is for connection to a fixed piping system,the installation must conform with

local codes ,or in the

absences of local codes with the National Fuel Gas Code, ANSI Z223.1/NFPA54;

International Fuel Gas Code,Natural Gas and Propane Installation Code,CSA B149.1;or Propane

Storage and Handling Code,B149.2,as applicable.

The LP gas supply cylinder to be used must be:

1- Constructed and marked in accordance with the U.S. Department of Transportation (D.O.T.)

Specifications for LP-Gas Cylinders, or the Standard for Cylinders, Spheres and Tubes for

transportation of Dangerous Goods and Commission, CAN/CSA-B339 as applicable;

2- Provided with a listed overfilling prevention device;

3- Provided with a cylinder connection device compatible with the connection for the appliance.



Always place the appliance on a firm and level surface.

Solid fuels shall not be burned in this gas appliance. Burn ONLY Tempered Glass (INCLUDED).

The appliance shall be used only outdoors in a well-ventilated space and shall not be used in a

building, garage or any other enclosed area.

When in use, keep the appliance area clear and at least 40 in / 101.6 cm side clearance from

combustible materials, gasoline and other flammable liquid and vapors. Do not use the appliance

under overhead combustible surfaces. Certain items or materials, w

hen stored under the appliance or

nearby, will be subjected to radiant heat and could be damaged.

Inspect the hose assembly and burner prior to each use. If there is evidence of excessive abrasion

or wear or if the hose or burner is damaged,

it must be replaced by appropriate part form the

manufacturer.

Inspect the gas connections of the appliance prior to each use. Do not to operate the unit if there is a

3 of 12

Model NO.

Rated Heat Input

Fuel

Gas Supply

Manifold Pressure

Orifice Size (diameter)

Gas Supply Pressure

gas leak. Have the appliance inspected annually by a qualified service person.

The pressure regulator and hose assembly provided with the appliance must be used.

replacement part must be the same

as the part specified by manufacturer.

The

The assembly of LP-gas and leak checking, please refer to the “Gas connection” on page 8 and “leak

Test” on page 9.

Children and adults should be alerted to the hazards of high surface temperatures and should

stay away to avoid burns or prevent clothing ignition.

Young children and pets should be carefully supervised when they are in the area of the

appliance.

Any guard or other protective device removed for servicing the appliance must be replaced

prior to operation.



Clothing or other flammable materials should not be hung from the appliance.

Do not use the appliance if any part has been under water. Immediately call a qualified technician to

inspect the appliance and to replace any par

t of the control system and any gas control which has been

under water.

LP-gas supply cylinder to be used must be constructed and marked in accordance with the

specifications for LP

-gas cylinders of the U.S. Department of Transportation (DOT).

The cylinder supplies system must be arranged for vapor withdrawal and the cylinder must include a

collar to protect the cylinder valve.

Use only 20 lb / 9 kg LP-Gas cylinders.

Do not burn wood or any other materials in this appliance.

The appliance must be isolated from the gas supply piping system by

closing its individual manual shutoff valve during any pressure testing of

the gas supply piping system at test pressure equal to or less than 1/2psi

(3.5kPa).

Properly place the hose out of pathways where people may trip over it or in areas where there may

be subject to accidental damage.

The burner must be replaced prior to the appliance being put into operation if it is evident that the

burner is damaged. The replacement

burner must be the same as the part specified by manufacturer.

The cleaning of the appliance including the burner, please refer to “Clean and Maintenance” on page

12.

4 of 12

EXPANDED VIEW

5 of 12

Parts List

NO.

Qty

1 (4.1KG)

Fire Bowl

Hardware Bag

No.

Description

Qty

Picture

Bolt M6x15

Flat Washer M6

Spring Washer M6

Hex Key M6

6 of 12

Cullet (Tempered Glass)

Armor Plate Screen

Windshield 1

Windshield 2

Ignition Wire

Battery Box

Control Knob

Control Valve

Pressure Regulator

Nozzle Subassembly

Thermocouple

Nozzle Support Bar

Burner

Description

Lazy Susan

Table Top

Main Body

Base

INSTALLATION

Installation will be much easier with two or more people.

Fig 1: Put Table Top (B) on Main Body (C), then use Bolt (AA) to lock them from the

bottom up.

Fig 2: Put Lazy Susan (A) on Table Top (B).

7 of 12

LOCATION

Your Gas appliance must be installed on a flat, stable surface, away from any combustible materials or

construction.

SET-UP

Your Gas appliance comes assembled, ready for a Gas connection.

-Remove the appliance from container box and place it on any level, outdoor, non-combustible

surface.

NOTE: Do not place this appliance on grass or dirt area. This may prevent proper safety venting.

-Open the gas door, put the cylinder inside.

-Unscrew the battery box as shown in Fig 1.Insert the negative electrode side of the battery into the

bottom of battery box as shown in Fig 2. Then screw the battery box as shown in Fig 3.

OFF

HIGH

OFF

HIGH

LOW

Fig 1

Fig 2

Fig 3

Note: If the battery of the pulse electronic igniter runs out of power, please replace the new battery as

above.

Gas Connection

1- Open the door, put the chain and control valve outside. See Fig 4.

-Put the cylinder into the cylinder rack. See Fig 5.

-Connect the regulator and the cylinder as per Fig.6. Make sure there is no leakage or damage

(please refer to “Leak Test” on page 9 and the damage checking on page 4).

4- Fix the cylinder by the chain. See Fig 7.

Fig 4

Fig 5

8 of 12

Fig 7

Fig 6

OPERATION

LEAK TEST

!!!WARNING!!!

Do not use an open flame to check for leaks.



Do not smoke during testing.

Do not test indoors.

Turn on the gas cylinder valve. Apply 50% soap and 50% water solution to the gas hose and

connections between the control knob and gas cylinder.

If something is leaking, you will see bubbles form. In case of leaks, turn off the gas supply, undo the

leaking connection, re-connect it and try again. If the leak persists, consult Customer Service Center for

OFF

assistance.

If the connection is sound, continue to the next step.

IGNITE LIGHTING

HIGH

1- Make sure control valve is OFF.

-Turn on gas tank valve.

3- Press in and turn control valve knob counterclockwise

to High to ignite. See the figure to the right.

-If burner is lit, do not stop pressing in the control valve knob for

a minute to heat the thermocouple.

LOW

5- When control valve knob is released, the burner should be lit. If not, turn control valve knob

clockwise to OFF. Wait 5 minutes after completing Step 3 before attempting to re-ignite.

Press in and turn control valve knob to desired heat input, HIGH ~ LOW.

9 of 12

A leak check must be performed whenever the gas cylinder is replaced.

-Make sure the control knob is on the “OFF” position.

Make sure the gas cylinder is correctly and securely connected to the pressure regulator, without

over tightening it.

NOTE: While in use, the burner flame should be mainly blue in appearance with a small amount of yellow.

The flame can be identified by the following figure.

YELLO W TIPS

H IGH

LO W

BLU E

Correct Flame

Incorrect Flame

BLUE

LOW

Warning: Lighting the appliance improperly could lead to an unsafe condition.

7- Press in and turn the control valve knob clockwise to OFF to shut down appliance. Close the gas

cylinder valve when the appliance is not in use.

(CAUTION: Do not kink flexible gas hose. If it is kinked, a gas leak could occur.)

STORAGE AND MAINTENANCE

To obtain the best performance from your appliance, you must perform the following storage and

maintenance activities on a regular basis:

Allow at least 35 minutes for the appliance to cool down after use, before disconnecting and

removing the gas cylinder.

Store the gas cylinder in a dry, well-ventilated and sheltered area protected from inclement weather

and dust, out of the reach of children, and not in a building, garage or any other closed area.

The appliance may be stored indoors only if the cylinder is disconnected and removed.

Keep the appliance area clear and free from combustible materials, gasoline and other flammable

vapors and liquids.



Installation and repair should be done by a qualified service person. The appliance should be

inspected before use and at least annually by a qua

lified service person. More frequent cleaning

may be required as necessary it is imperative that the control compartment,

Burner and circulating air passageways of the appliance be kept clean.

If disassemble the burner when cleaning the appliance, please reassemble

it according to the picture on the right to make sure the burner induction tunnel is

on and exactly cover the orifice base.

It is imperative that the control compartment, burner and

circulating air passageways of the appliance

be kept clean. It is recommended not to disassemble

the burner.

10 of 12

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sunjoy Gartenmöbel Handbücher

Sunjoy

Sunjoy ROYALE DOME TOP Bedienungsanleitung

Sunjoy

Sunjoy 10’x12’ Benen Gazebo L-GZ215PST-1 Bedienungsanleitung

Sunjoy

Sunjoy A102012700 Bedienungsanleitung

Sunjoy

Sunjoy A102009100 Bedienungsanleitung

Sunjoy

Sunjoy LDN916SAL Betriebsanleitung

Sunjoy

Sunjoy L-GZ038PST-3 Bedienungsanleitung

Sunjoy

Sunjoy Windsor L-GZ717PST-C Bedienungsanleitung

Sunjoy

Sunjoy Kroger L-GZ407PST-2 Bedienungsanleitung

Sunjoy

Sunjoy A102032640 Bedienungsanleitung

Sunjoy

Sunjoy D-WA004PAL-B Bedienungsanleitung

Sunjoy

Sunjoy A101000700 Bedienungsanleitung

Sunjoy

Sunjoy A101003701 Bedienungsanleitung

Sunjoy

Sunjoy A104004110 Bedienungsanleitung

Sunjoy

Sunjoy A102032651 Bedienungsanleitung

Sunjoy

Sunjoy D-GZ399PST-J Bedienungsanleitung

Sunjoy

Sunjoy L-BB050PCO-1 Bedienungsanleitung

Sunjoy

Sunjoy A106000520 Bedienungsanleitung

Sunjoy

Sunjoy L-GZ472PST-C-A Bedienungsanleitung

Sunjoy

Sunjoy L-GZ916PST-D Bedienungsanleitung

Sunjoy

Sunjoy A103000106 Bedienungsanleitung

Sunjoy

Sunjoy A102001703 Bedienungsanleitung

Sunjoy

Sunjoy D-GZ842PST-AS-235 Bedienungsanleitung

Sunjoy

Sunjoy Rona 38115107 Bedienungsanleitung

Sunjoy

Sunjoy L-GZ492PST Bedienungsanleitung

Beliebte Gartenmöbel Handbücher anderer Marken

Belleze

Belleze 014-HG-20074 Bedienungsanleitung

Hatteras Hammocks

Hatteras Hammocks DCA1-K-HH Bedienungsanleitung

Kozyard

Kozyard Morgan Aluminum Pergola Bedienungsanleitung

Lemeks

Lemeks Palmako PA120-5959 Installationshandbuch

OLT

OLT 24 Bedienungsanleitung

forest-style

forest-style HACIENDA 2354 Bedienungsanleitung

Courtyard Creations

Courtyard Creations RUS0188-WM Bedienungsanleitung

RPR

RPR OLLIE CHAIR Bedienungsanleitung

kingsley-bate

kingsley-bate MC-55 Bedienungsanleitung

Weltevree

Weltevree Carrier Bedienungsanleitung

Grange Fencing

Grange Fencing Elite Arch Bedienungsanleitung

Grosfillex

Grosfillex AUVENT YR14 Bedienungsanleitung

X-METAL

X-METAL EAGLE 33511 Bedienungsanleitung

Anova

Anova FBW6R Bedienungsanleitung

Outsunny

Outsunny 84A-090 Bedienungsanleitung

Ivy Terrace

Ivy Terrace IVTD212 Bedienungsanleitung

Breezesta

Breezesta FANBACK ADIRONDACK AD-0101 Bedienungsanleitung

hanit

hanit SUTTON 1 Bedienungsanleitung