Swisher Z-MAX ZT2560 Bedienungsanleitung

OWNER’S MANUAL

ZT2560

25 HP – 60” CUT

1602 CORPORATE DRIVE, P.O. BOX 67, WARRENSBURG, MISSOURI 64093

PHONE 660-747- 1 3 FAX 660-747- 650

Manufacturing quality lawn care equipment since 1945

Made In The

USA

CELEBRATING OVER 60 YEARS OF INNOVATION

1945 - 2006

11849 Rev. 06-046

STARTING SERIAL # L506-017001

LIMITED WARRANTY

The manufa turer’s warranty to the original onsumer pur haser is: This produ t is free

from defe ts in materials and workmanship for a period of two (2) years from the date of

pur hase by the original onsumer pur haser. We will repair or repla e, at our dis retion,

parts found to be defe tive due to materials or workmanship. This warranty is subje t to the

following limitations and ex lusions:

In the event you have a laim under this warranty, you must return the produ t to an

authorized servi e dealer. All transportation harges, damage, or loss in urred during

transportation of parts submitted for repla ement or repair under this warranty shall be borne

by the pur haser. Should you have any questions on erning this warranty, please onta t

us toll-free at 1-800-222-8183. The model number, serial number, date of pur hase, and the

name of the authorized Swisher dealer from whom you pur hased the mower will be needed

before any warranty laim an be pro essed.

THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL

DAMAGES AND ANY IMPLIED WARRANTIES ARE LIMITED TO THE SAME TIME

PERIODS STATED HEREIN FOR ALL EXPRESSED WARRANTIES. Some states do not

allow the limitation of onsequential damages or limitations on how long an implied warranty

may last, so the above limitations or ex lusions may not apply to you. This warranty gives

you spe ifi legal rights and you may have other rights, whi h vary from state-to-state. This is

a limited warranty as defined by the Magnuson-Moss A t of 1975.

1) Engine Warranty All engines utilized on our produ ts have a separate warranty

extended to them by the individual engine manufa turer. Any

engine servi e diffi ulty is the responsibility of the engine

manufa turer and in no way is Swisher Mower Co., In . or its

agents responsible for the engine warranty. The Briggs &

Stratton Engine Servi e Hot-Line is 1-800-233-3723. The

Te umseh Engine Servi e Hot-Line is 1-800-558-5402.

2) Commercial Use This prod ct is not intended for commercial se and

carries no commercial warranty.

3) Limitation This warranty applies only to produ ts whi h have been

properly assembled, adjusted, and operated in a ordan e

with the instru tions ontained within this manual. This

warranty does not apply to any produ t of Swisher Mower

Co., In ., that has been subje t to alteration, misuse, abuse,

improper assembly or installation, shipping damage, or to

normal wear of the produ t.

4) Ex lusions Ex luded from this warranty are normal wear, normal

adjustments, and normal maintenan e.

CONTENTS

LIMITED WARRANTY…………

OPERATION………………..……….

INTRODUCTION………………

Features……………………………………

General……………………………………..

Starting………………………………………

Before Operating……………………

Grass Height of Cut………………

Un rating & Assembly……………

Controls………...……..………………….

SYMBOLS & DECALS……….

SERVICE & ADJUSTMENTS..

SAFETY INSTRUCTIONS…….

Adjusting De k Height…………..

General use and safety rules…

De k Level……………………………….

Slope Operation…………………….

De k Belt Repla ement…………

Children Safety……………………….

Hydro Belt Repla ement…………

SPECIFICATIONS……………..

Seat Adjustment…………………………

CUSTOMER

Parking Brakes…………………………

RESPONSIBILITY……………

WIRING SCHEMATIC…………..

Operator Presen e……………….

PARTS BREAKDOWN…………..

Tires……………………………………………

TROUBLESHOOTING……………

Blade Maintenan e…………………..

MOWER IDENTIFICATION……..

Battery………………………………………

REPLACEMENT PARTS………..

V-belts……………………………………..

MAINTENANCE LOG……………..

Engine………………………………………..

SWISHER HISTORY……………..

Overall Unit Care………….………..

Transporting Safety……………….

INTRODUCTION

Congrat lations

Thank you for pur hasing a Swisher Zero Turn mower. This ma hine is built for the greatest

effi ien y and rapid mowing of large areas. Conveniently lo ated ontrols and dual

ommer ial grade hydrostati transmissions regulated by steering levers, ontribute to the

ma hine’s performan e.

This man al is a val able doc ment. Following the instr ctions for se, service,

maintenance, etc. can greatly increase the life-span of yo r machine .

General

In this operator’s manual, left and right, ba kward and forward are used in relation to the normal

operators position.

Read Before Operating

This ma hine is onstru ted only for mowing grass on lawns and other free and even ground

without obsta les. This ma hine is not intended for ommer ial use. The manufa turer’s

dire tions on erning operation, maintenan e, and repairs must be arefully followed.

This ma hine must only be operated, maintained, and repaired by persons that are familiar

with the ma hine’s spe ial hara teristi s and who are well versed in safety instru tions.

A ident prevention regulations, other general safety regulations, o upational safety rules,

and traffi regulations must be followed without fail.

Unauthorized modifi ations to the design of the ma hine may absolve the manufa turer

from liability for any resulting personal injury or property damage.

Read engine manufa turer’s

operating and maintenan e

instru tions.

Read and observe all safety

instru tions on your mower and in the

manual

Che k engine oil.

Che k fuel aps to sure that they

are in pla e.

Set ontrol handles outward – setting parking

brake

Be sure mower blades are turned off –

PTO swit h pushed down.

Know how to stop the engine – Turn key to

off

Know how to stop the unit – Return ontrol

handles to neutral

NOTE:

If you have never used a Zero Turn mower before, refer to

the Operation Controls se tion of this manual before

attempting to operate one for the first time.

INTRODUCTION

Uncrating & Assembly

Dispose of top and side panels of the rate.

Remove loose parts and pa king material

Cut any banding or strapping that may be holding the mower to the rate.

Disengage spark plug wire and pla e where it annot make a onne tion.

Raise the mower de k to its highest position..

Disengage the parking brakes by pla ing the handle ontrols in the upright position.

Open the transmission valves at the rear of the unit by pulli

ng the release rods and

lo king them in pla e. SEE INSTRUCTION DECAL AT THE REAR OF THE UNIT.

Carefully push the mower off the rate to a safe and level area.

Che k engine oil. All engines are filled with oil and tested at the fa tory. Verify oil level

and add if ne essary before starting engine. SEE ENGINE OWNER’S MANUAL

Che k the battery. If the battery is put into servi e after the “month & year” of the date

on the battery, then it may need to be harged with a 12 volt harger for a minimum of 1

hour, but no more than 2 hours at a rate of 6 to 10 amps.

Atta h battery ables to battery. Always attach the positive terminal first.

Install steering levers. Remove the bolts from the ontrol arms on the mower. Align

the holes in the lever with the holes in the ontrol arms and atta h with the bolts provided.

Make s re both bolts on both handles are tight.

Close the transmission valves at the rear of the unit. SEE INSTRUCTION DECAL AT

THE REAR OF THE UNIT.

Re onne t spark plug wire.

Che k tire pressure on all four wheels. REFER TO UNIT SPECIFICATIONS TABLE

TOOLS REQUIRED:

2 - ½” Wren hes or ½” So ket with drive rat het

Tire pressure gauge

Nail bar or law hammer

Wire snips

To Remove The Mower From The Crate

SYMBOLS & DECALS

Triangle Danger Decal – OD55

Swisher Flag U.S.A.– OD39 Notice Do Not Alter Wiring Decal– OD74

Operator ust Be Seated Decal– OD73

Flying Debris Decal – OD43

No Step Decal – OD11

OD45- Warning Decal

SYMBOLS & DECALS cont.

Hydro Release - 10280

Danger/Warning De al - 10276

Throttle/Choke De al - 10271

Parking Brake De al

Right - 10279

Parking Brake De al

Left - 10270

Key/PTO De al - 10273

10542 Repla ement Parts De al

10274 Z-Max De al

OD99125 Medium Swisher De al

10275 XZT60 De al Small

10281 Height Adjustment De al

OD9128 60” De k White De al

Decals Not Shown

SAFETY INSTRUCTIONS

These instr ctions are for yo r safety. Read them caref lly.

General Use

Read all instru tions in this operator’s manual

and on the ma hine before starting it. Ensure that

you understand them and then abide by them.

Learn how to use the ma hine and its ontrols

safely and learn how to stop qui kly. Also learn to

re ognize the safety de als.

Only allow the ma hine to be used by adults

who are familiar with its use.

Make sure nobody else is in the area of the

ma hine when you start the engine, engage the

drive, or run the ma hine.

Stop the ma hine if someone enters the work

area.

Clear the area of obje ts su h as stones, toys,

steel wire, et . that may be ome aught in the

blades and thrown out.

Do Not Use this machine witho t the

Discharge Ch te in place.

This Safety Alert Symbol indicates important messages in

this man al. When yo see this symbol, caref lly read the

message that follows and be alert to the possibility of

personal inj ry.

NOTE:

If you have never used a Zero

Turn mower before, refer to the

Operation Controls se tion of

this manual before attempting to

operate one for the first time.

Stop the engine and dis onne t the spark plug

before leaning the dis harge de k.

Never take passengers. The ma hine is only

intended for use by one person.

Always look around before and during reversing

maneuvers.

Slow down before turning.

Shut down the mower de k when not mowing.

Be areful when rounding fixed obje ts, so that

the blades do not hit them.

Only operate the ma hine in daylight or other

well-lit onditions.

Keep the ma hine a safe distan e from holes or

other irregularities in the ground.

Never use the ma hine if you are tired, if you

have onsumed al ohol, or if you are taking other

drugs or medi ations that an affe t your vision,

judgment, or oordination.

Beware of traffi when working near or rossing

a road.

SAFETY INSTRUCTIONS

General Use Contin ed

Remember

The operator is responsible

for avoiding dangers or

accidents.

Never leave the ma hine unsupervised with the

engine running. Always shut down the blades,

engage the parking brakes, stop the engine, and

remove the ignition key before leaving the ma hine.

Never allow hildren or other persons not

trained in the use of the ma hine to use or servi e

it. Lo al laws may regulate the age of the user.

Make sure that you have first aid equipment lose

at hand when using the ma hine.

Never use the ma hine when barefoot. Always

wear prote tive shoes or boots.

Always wear approved prote tive glasses or a full

visor when assembling or driving.

Ear Prote tion is re ommended

Never wear loose lothing that an get aught in

moving parts.

WARNING

When sing the

machine, approved

personal protective

eq ipment shall be

sed. Personal

protective

eq ipment cannot

eliminate the risk of

inj ry, b t it will

red ce the degree of

inj ry if an accident

does occ r. Ask

yo r retailer for help

in choosing the right

eq ipment.

SAFETY INSTRUCTIONS

Slope Operation

Remove obsta les su h as stones, tree bran hes, et .

Mow up and down, not side to side. Never drive the rider on

terrain that slopes more than 10 degrees.

Avoid starting or stopping on a slope. If the tires begin to

slip, shut down the blades and drive slowly down the slope.

Always drive evenly and slowly on slopes.

Make no sudden hanges in speed or dire tion.

Avoid unne essary turns on slopes, and if it proves

ne essary, turn slowly and gradually downward, if possible.

Wat h for holes, ruts, or bumps. On uneven terrain, the

ma hine an tip more easily. Long grass an hide obsta les.

Drive slowly and use small movements of the steering

ontrols.

Do not mow wet grass. It is slippery, and the tires an loose

their grip, so that the ma hine slides.

Do not try to stabilize the ma hine by putting a foot on the

ground.

Serious a idents may o ur if you fail to be on guard for

hildren in the area of the ma hine. Children are often attra ted

to the ma hine and mowing work. Never assume that hildren

will stay put where you last saw them.

Keep hildren away from the mowing area and under lose

supervision by another adult.

Shut off the ma hine if hildren enter the work area.

Never allow a hild to ride with you.

Never allow hildren to operate the ma hine.

Be extra autious near orners, bushes, trees, or other

obje ts that blo k your view.

Children

Remember

The operator is

responsible for

avoiding dangers or

accidents.

Andere Handbücher für Z-MAX ZT2560

Andere Swisher Rasenmäher Handbücher

Swisher

Swisher COMMERCIAL PRO Bedienungsanleitung

Swisher

Swisher ZT2766KZ Bedienungsanleitung

Swisher

Swisher ZT2866 Bedienungsanleitung

Swisher

Swisher ST60022Q Bedienungsanleitung

Swisher

Swisher ZT2760B Bedienungsanleitung

Swisher

Swisher Z-MAX ZT2350A Bedienungsanleitung

Swisher

Swisher ST50022STDQ Bedienungsanleitung

Swisher

Swisher FC10544CL Bedienungsanleitung

Swisher

Swisher FT1150 Bedienungsanleitung

Swisher

Swisher T1360B1; T1360T; T1360H; T1360K; T13560; RK1360; T14560; T17560; T18560;... Bedienungsanleitung

Swisher

Swisher Commercial Pro Response Z21554CPHO Bedienungsanleitung

Swisher

Swisher PREDATOR TALON WBRC11524C Bedienungsanleitung

Swisher

Swisher PST5022 Bedienungsanleitung

Swisher

Swisher Trim-N-Mow Plus STS67522BS Bedienungsanleitung

Swisher

Swisher Z Series Bedienungsanleitung

Swisher

Swisher Ride King Bedienungsanleitung

Swisher

Swisher Z-MAX ZT2560 Bedienungsanleitung

Swisher

Swisher L213-224001 Bedienungsanleitung

Swisher

Swisher T1260, T1360, T1460 Bedienungsanleitung

Swisher

Swisher FT1150 Bedienungsanleitung

Swisher

Swisher T844CH Bedienungsanleitung

Swisher

Swisher ZT2452 Bedienungsanleitung

Swisher

Swisher POL10544HD Bedienungsanleitung

Swisher

Swisher WB80042F Bedienungsanleitung

Beliebte Rasenmäher Handbücher anderer Marken

RHINO

RHINO 1958 Bedienungsanleitung

Wolf Garten

Wolf Garten Compact plus 40 B Bedienungsanleitung

Cub Cadet

Cub Cadet LTX 1045 Bedienungsanleitung

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Bedienungsanleitung

Challenge

Challenge CH18V2 Betriebsanleitung

TALEN TOOLS

TALEN TOOLS AVR HGM30 Bedienungsanleitung

DEWEZE

DEWEZE ATM-725 Bedienungsanleitung

Weed Eater

Weed Eater 180083 Bedienungsanleitung

Husqvarna

Husqvarna Poulan Pro PP185A42 Bedienungsanleitung

Better Outdoor Products

Better Outdoor Products Quick Series Bedienungsanleitung

Cub Cadet

Cub Cadet 23HP Z-Force 60 Betriebsanleitung

MTD

MTD 795, 792, 791, 790 Bedienungsanleitung

Toro

Toro Groundsmaster 3505-D Bedienungsanleitung

Dennis

Dennis FT 610 Bedienungsanleitung

MTD

MTD 126-220-000 Bedienungsanleitung

Toro

Toro 74806 Bedienungsanleitung

Stihl

Stihl RMA 443 PV Bedienungsanleitung

Yard-Man

Yard-Man 3700-0 Bedienungsanleitung