Thule 9027 Bedienungsanleitung

QUICK START GUIDE for: APEX SWING AWAY 9027

DO NOT

• Attach swing arm and upright

assembly as shown (STEP 1).

• Pull back on Auto Pin to engage in

receiver hole. Use knob to tighten.

Lock (STEP 3).

• Load heaviest bike ﬁrst - front to

the right (STEP 7).

• Alternate bike direction.

• Secure bicycle to rack with rubber

straps and black safety strap

through the frames and around

the mast of the rack (STEP 9).

• Check tightness of all bolts

and knobs periodically

(every 6 months).

• Check rubber straps for wear

and replace if worn.

• Install on a trailer or other towed

vehicle.

• Put more than 2 bikes on a class

1 hitch.

• Do not “overstretch” the straps.

• Use the rack while traveling on dirt

roads.

• Use the rack to carry tandems or

recumbents.

• Put more than the intended number

of bikes on the rack.

APEX SWING AWAY 9027

part

description

part number

qty.

AApex Swing Bike Carrier / — 1

Bcradle overmold / 8523503001 8

Cswing arm assembly / — 1

DM8 lock knob / 753190902 1

EApex 2” hitch adaptor / 8523134001 1

F1/2" lock nut / 853558402 2

Gwasher 12mm / 951122454 4

H1/2 - 13 bolt x 5.5"/ 8535583 2

Ihitch tool / 8535524 1

Jripple strap / 8523006001 12

Kanti-sway with overmold / 8523037001 4

Lanti-sway angled extension / 8523108001 2

Mbuckle strap / 753203017 1

N.75 open end wrench / 8523138001 1

Olock, 2 cylinders, 2 keys per each part / — —

Plock cylinder change key / 8531251 1

QM8 X 30 ﬂat head screw / 8523136001 2

LQ N O P

F G H I J K

PARTS INCLUDED

1CARRIER ASSEMBLY /

• Position stinger assembly in bracket of swing arm assembly as illustrated.

• Install 1/2 – 13 x 5.5" bolt, ﬂat washer and lock nut as illustrated.

• Tighten ﬁrmly using Thule tools provided.

• Position upright assembly in swing arm assembly bracket as illustrated.

• Engage lock-up pin and loosely thread lower locking handle.

• Install 1/2 – 13 x 5.5" bolt, ﬂat washer and lock nut as illustrated.

• Tighten ﬁrmly using Thule tools provided.

2TRANSPORTING CARRIER /

• Carrier can be easily handled / carried using handhold at the back of the carrier.

WARNINGS / LIMITATIONS •

• Number of bicycles should not exceed designated

carrying capacity for your speciﬁc Apex Swing Away.

• 9027 (4 bike) max carrying capacity = 140 lbs.

• Check tightness of all bolts and knobs periodically.

• Check straps for wear and replace if worn.

• Not intended for off-road use.

• Not intended for tandems or recumbents.

• Failure to use strap may result in loss of bicycles.

• Your vehicle must be equipped with a 2" receiver.

4BICYCLE TRANSPORTATION /

• Lift Hitch Switch

Lever as illustrated.

• With the other hand lift bike arm

assembly upward until the Hitch

Switch “clicks” into position.

•

Reverse operation to store or when

traveling with no bike attached.

3STINGER INSTALLATION /

FOR 2" RECEIVERS ATTACH 2" ADAPTER

• Attach carrier to receiver by pulling back

gently on Auto Pin while sliding stinger

into receiver.

• Using hex key attach adapter sleeve to

stinger with two M8 x 30 ﬂat head screws.

• Once Auto Pin clears receiver lip, release

Auto Pin so that it rests against receiver.

• Push carrier in until Auto Pin engages

with the receiver hole as illustrated.

• Install lock cylinder into lock knob on

stinger assembly with Change Key.

NOTE: Knob will not tighten fully

without lock cylinder inserted.

• Firmly tighten locking knob to secure

carrier in receiver.

• Load heaviest bike ﬁrst onto the inner most cradles - handle bars facing passenger side of vehicle.

• Fasten cradle straps.

• Use Thule Frame Adaptor (#982XT, sold separately) for bikes without traditional top tubes.

A B

• Attach cradle straps to cradles and anti-sway cages.

• Attach anti-sway angled extension to underside of cradles 1 and 4 as illustrated.

A B C

8ATTACHING HOLD FAST ANTI-SWAY CAGES

• To attach anti-sway cage, hold horizontal with smooth edge facing down and slide C-slot opening onto Anti-Sway Extension / Cradle. Swing down to vertical position.

Place smooth curved surface against bicycle and attach strap as shown.

• Mount bikes in alternate directions.

A B

• Secure bikes to mast of carrier with black strap.

10 REAR COMPARTMENT ACCESS /

• Loosen lower locking

handle completely

and pull pin to open

carrier.

• While pushing bottom half of bike

arm assembly open, rotate upright

assembly as illustrated. In full open

position lock-up pin will engage

bracket.

A B

lock-up pin

broche de verrouillage

pasador de cierre

lower locking handle

poignée de

verrouillage inférieure

asa inferior de cierre

11 OPENING CARRIER /

• Insert hold-open pin into locking position when fully open to prevent carrier from swinging closed.

hold-open pin

12 CLOSING CARRIER /

• Pull Lock-up pin to release upper arm assemby and

rotate bike arms to stop position.

• Close carrier. Lock-up pin will click into

closed position.

• Tighten lower locking handle ﬁrmly.

WARNING: Before operating

your vehicle, tighten

locking handle ﬁrmly.

lower locking handle

lock-up pin

13 SECURITY

INSTALLING END CAP LOCK CORE

• Install lock cylinder into locking end cap with

Change Key.

USING LOCKING CABLE /

• Lock bikes to carrier with cable lock.

Inhaltsverzeichnis

Andere Thule Fahrradzubehör Handbücher

Thule

Thule Yepp Nexxt Mini Bedienungsanleitung

Thule

Thule Yepp 2 Mini Bedienungsanleitung

Thule

Thule Cross-Country Skiing & Hiking Kit Bedienungsanleitung

Thule

Thule Thule EuroPower 915 Bedienungsanleitung

Thule

Thule 973-24 Bedienungsanleitung

Thule

Thule Chariot Corsaire Rain Cover Bedienungsanleitung

Thule

Thule Cadence Bedienungsanleitung

Thule

Thule Yepp Nexxt Mini 12080101 Bedienungsanleitung

Thule

Thule Kit 2021 Bedienungsanleitung

Thule

Thule ezHitch Bedienungsanleitung

Thule

Thule Pack 'n Pedal Sport Bedienungsanleitung

Thule

Thule RideAlong Bedienungs- und Sicherheitshinweise

Thule

Thule 100061 Bedienungsanleitung

Thule

Thule YEPP RACK Bedienungsanleitung

Thule

Thule RideAlong 100106 Bedienungsanleitung

Thule

Thule Chariot Chinook 1 Bedienungsanleitung

Thule

Thule Yepp Maxi Easyfit 12020211 Bedienungsanleitung

Thule

Thule Chariot Cab 2 Bedienungsanleitung

Thule

Thule Sidearm 594XT Bedienungsanleitung

Thule

Thule Sprint 569 Bedienungsanleitung

Thule

Thule Yepp Nexxt 2 Maxi Bedienungsanleitung

Thule

Thule coaster xt Bedienungsanleitung

Thule

Thule Sidearm 594XT Bedienungsanleitung

Thule

Thule Chariot Cross 1 Bedienungsanleitung

Beliebte Fahrradzubehör Handbücher anderer Marken

Sigma

Sigma BC 16.16 Bedienungsanleitung

Playcore

Playcore Dero Setbacks Bedienungsanleitung

VDO Cyclecomputing

VDO Cyclecomputing x3dw Bedienungsanleitung

Cateye

Cateye RAPID X2 Bedienungsanleitung

buratti meccanica

buratti meccanica Clorofilla Trail Bedienungsanleitung

Shimano

Shimano SG-8R20 Betriebsanleitung

BOB

BOB YAK Bedienungsanleitung

APLIC

APLIC 303303/20190717TW012 Bedienungsanleitung

SRAM

SRAM AXS BlipBox Bedienungsanleitung

Garmin

Garmin EDGE 500 Bedienungsanleitung

Shimano

Shimano FD-RX810 Bedienungsanleitung

Cateye

Cateye V2C - Gebrauchsanweisung

KMART

KMART 43115907 Bedienungsanleitung

SIGMA SPORT

SIGMA SPORT Buster 2000 Bedienungsanleitung

NVO Components

NVO Components STEM Bedienungsanleitung

DAXYS

DAXYS BP188 Bedienungsanleitung

XLC

XLC BV-W17 Bedienungsanleitung

Deda Elementi

Deda Elementi SUPERBOX Bedienungsanleitung