Toro 30184 ProLine Bedienungsanleitung

Operator’s Manual

English (GB)

Form No. 3324–377

ProLine

13hp–92cm Mid–Size Mower

30184—200000001 & Up

The Toro Company – 1998

Introduction

Thank you for purchasing a Toro product.

All of us at Toro want you to be completely satisfied

with your new product, so feel free to contact your

local Authorized Service Dealer for help with service,

genuine replacement parts, or other information you

may require.

Whenever you contact your Authorized Service

Dealer or the factory, always know the model and

serial numbers of your product. These numbers will

help the Service Dealer or Service Representative

provide exact information about your specific

product. You will find the model and serial number

plate located in a unique place on the product as

shown below

m–3775

1. Model

and Serial Number Plate

For your convenience, write the product model and

serial numbers in the space below.

Model No:

Serial No.

Read this manual carefully to learn how to operate

and maintain your product correctly. Reading this

manual will help you and others avoid personal injury

and damage to the product. Although we design,

produce and market safe, state-of-the-art products,

you are responsible for using the product properly

and safely. You are also responsible for training

persons, who you allow to use the product, about safe

operation.

The warning system in this manual identifies

potential hazards and has special safety messages that

help you and others avoid personal injury, even death.

DANGER, WARNING and CAUTION are signal

words used to identify the level of hazard. However,

regardless of the hazard, be extremely careful.

DANGER signals an extreme hazard that will cause

serious injury or death if the recommended

precautions are not followed.

WARNING signals a hazard that may cause serious

injury or death if the recommended precautions are

not followed.

CAUTION signals a hazard that may cause minor or

moderate injury if the recommended precautions are

not followed.

Two other words are also used to highlight

information. “Important” calls attention to special

mechanical information and “Note” emphasizes

general information worthy of special attention.

The left and right side of the machine is determined

from the normal operator’s position.

The engine exhaust from this product

contains chemicals known to the State of

California to cause cancer, birth defects,

or other reproductive harm.

IMPORTANT: This engine is not equipped

with a spark arrester muffler. It is a violation

of California Public Resource Code Section

4442 to use or operate this engine on any

forest–covered, brush–covered or

grass–covered land. Other states or federal

areas may have similar laws.

Contents

Page

Safety 2.

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Slope Chart 4. . . . . . . . . . . . . . . . . . . . . . . . .

Symbols Glossary

5. . . . . . . . . . . . . . . . . . .

Symbols Glossary

6. . . . . . . . . . . . . . . . . . .

Symbols Glossary

7. . . . . . . . . . . . . . . . . . .

Gasoline and Oil 8. . . . . . . . . . . . . . . . . . . . . . . .

Recommended Gasoline

8. . . . . . . . . . . . . .

Stabilizer/Conditioner 9. . . . . . . . . . . . . . . .

Filling the Fuel Tank 9. . . . . . . . . . . . . . . . .

Check Engine Oil Level 9. . . . . . . . . . . . . . .

Assembly 10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Loose Parts 10. . . . . . . . . . . . . . . . . . . . . . . . .

Install Front Castors 11. . . . . . . . . . . . . . . . . .

Install Upper Handle 11. . . . . . . . . . . . . . . . .

Connect Throttle Cable 13. . . . . . . . . . . . . . .

Install Blade Control (PTO) Rod 14. . . . . . . .

Install Shift Lever 14. . . . . . . . . . . . . . . . . . .

Mount Fuel Tank 15. . . . . . . . . . . . . . . . . . . .

Operation 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Think Safety First 16. . . . . . . . . . . . . . . . . . .

Controls 16. . . . . . . . . . . . . . . . . . . . . . . . . . .

Parking Brake 17. . . . . . . . . . . . . . . . . . . . . . .

Starting and Stopping

the Engine 18. . . . . . . . . . . . . . . . . . . . . . . .

Operating Blade Control (PTO) 19. . . . . . . . .

The Safety Interlock System 19. . . . . . . . . . .

Page

Driving Forward or Backward 20. . . . . . . . . .

Lower Control Bar Operation 21. . . . . . . . . .

Stopping the Machine 21. . . . . . . . . . . . . . . .

Adjusting Height-of-Cut 22. . . . . . . . . . . . . .

Height-of-Cut Chart 23. . . . . . . . . . . . . . . . . .

Maintenance 24. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Service Interval Chart 24. . . . . . . . . . . . . . . .

Air Cleaner 25. . . . . . . . . . . . . . . . . . . . . . . . .

Engine Oil 26. . . . . . . . . . . . . . . . . . . . . . . . .

Tire Pressure 28. . . . . . . . . . . . . . . . . . . . . . . .

Cleaning the Cooling System 28. . . . . . . . . . .

Spark Plug 29. . . . . . . . . . . . . . . . . . . . . . . . .

Cutting Blades

30. . . . . . . . . . . . . . . . . . . . . .

Adjusting Blade Brake

32. . . . . . . . . . . . . . . .

Greasing and Lubrication 33. . . . . . . . . . . . . .

Brake 34. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel Tank 35. . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel Filter 36. . . . . . . . . . . . . . . . . . . . . . . . . .

Replacing the Wheel Belt 36. . . . . . . . . . . . .

Replacing the Traction Belt 37. . . . . . . . . . . .

Replacing the Mower Belts

37. . . . . . . . . . . .

Adjusting Grass\Mud Scraper 38. . . . . . . . . .

Replacing the Grass Deflector 38. . . . . . . . . .

Wiring Diagram 39. . . . . . . . . . . . . . . . . . . . .

Cleaning and Storage 40. . . . . . . . . . . . . . . . .

Troubleshooting 41. . . . . . . . . . . . . . . . . . . . . . . . .

 !  % ! # ! !#   "

    $ "  "" &  

"   !! "  #"  !! !&!"!

"  % "&

 "!  % ! # %" &# #" # "!

 % ! #     

"& "! &     " # " 

#"#  

Safety

Toro designed this lawn mower for cutting and

mulching grass, or, when equipped with a grass bag,

for catching cut grass. Any use for purposes other

than these could prove dangerous to the operator or to

bystanders.

Note: This engine is not equipped with a spark

arrester muffler. Operating this mower on any

forest-covered, brush-covered, or unimproved

grass-covered land without an approved spark arrester

muffler may violate your state law.

POTENTIAL HAZARD

•Engine exhaust contains carbon monoxide,

which is an odorless, deadly poison.

WHAT CAN HAPPEN

•Carbon monoxide can kill you and is also

known to the State of California to cause

birth defects.

HOW TO AV

OID THE HAZARD

•Do not run engine indoors or in an enclosed

area.

To ensure maximum safety, best performance, and

to gain knowledge of the product, it is essential

that you and any other operator of the lawn

mower read and understand the contents of this

manual before the motor is ever started. Pay

particular attention to the safety alert symbol

which means CAUTION, WARNING, OR

DANGER — “personal safety instruction.” Read

and understand the instruction because it has to

do with safety. Failure to comply with instruction

may result in personal injury.

General

Lawn Mower Safety

The following instructions have been adapted from

the ANSI/OPEI standard B71.1—1998 and ISO

standard 5395:1990(E). Information or terminology

specific to Toro lawn mowers is enclosed in

parenthesis.

This cutting machine is capable of amputating hands

and feet and throwing objects. Failure to observe the

following safety instructions could result in serious

injury or death.

Training

•Read the instructions carefully. Be familiar with

the controls and the proper use of the equipment

before starting.

•See manufacturer’s instructions for proper

operation and installation of accessories. Only use

accessories approved by the manufacturer.

•Never allow children or people unfamiliar with

these instructions to use the mower. Local

regulations may restrict the age of the operator.

•Never mow while people, especially children, or

pets are nearby. Stop mower if anyone enters the

area.

Tragic accidents can occur if the operator is not alert

to the presence of children. Children are often

attracted to the mower and the mowing activity.

Never assume that children will remain where you

last saw them.

•Keep children out of the mowing area and under

the watchful care of a responsible adult.

•Be alert and turn mower off if children enter the

area.

•Use extra care when approaching blind corners,

shrubs, trees, or other objects that may obscure

vision.

•Keep in mind that the operator or user is

responsible for accidents or hazards occurring to

other people or their property.

Preparation

•While mowing, always wear substantial footwear

and long trousers.

•Do not operate the equipment when barefoot or

wearing open sandals.

•Always wear safety goggles or safety glasses with

side shields when operating mower.

•Thoroughly inspect the area where the equipment

is to be used and remove all stones, sticks, wires,

bones, and other foreign objects.

•Warning: Gasoline is highly flammable. Take

the following precautions:

– Store fuel in containers specifically

designed for this purpose.

Safety

– Refuel outdoors only and do not smoke

while refuelling.

– Add fuel before starting the engine. Never

remove the cap of the fuel tank or add

gasoline while the engine is running or

when the engine is hot.

– If gasoline is spilled, do not attempt to start

the engine but move the machine away

from the area of spillage and avoid creating

any source of ignition until gasoline vapors

have dissipated.

– Replace all fuel tank and container caps

securely.

– If the fuel tank has to be drained, do this

outdoors.

•Replace faulty mufflers.

•Before using, always visually inspect to see that

the blades, blade bolts, and cutter assembly are not

worn or damaged. Replace worn or damaged

blades and bolts in sets to preserve balance.

•On multibladed machines, take care as rotating

one blade can cause other blades to rotate.

Operation

•Do not operate the engine in a confined space

where dangerous carbon monoxide fumes can

collect.

•Mow only in daylight or in good artificial light.

•Always be sure of your footing on slopes.

•Walk; never run.

•Keep a firm hold on the handle.

•For wheeled rotary machines, mow across the face

of slopes, never up and down.

•Exercise extreme caution when changing direction

on slopes.

•Do not mow excessively steep slopes.

•Use extreme caution when reversing or pulling the

mower towards you.

•Before and while moving backwards, look behind

and down for small children.

•Stop the blade(s) if the mower has to be tilted for

transportation when crossing surfaces other than

grass and when transporting the mower to and

from the area to be mowed.

•Never operate the mower with damaged or

missing guards or shields, or without safety

devices; for example, deflectors and/or grass

catchers in place.

•Do not change the engine governor settings or

overspeed the engine.

•Disengage all blade and drive clutches before

starting the engine.

•Start the engine or switch on the motor carefully

according to instructions and with feet well away

from the blade(s).

•Do not tilt when starting the engine or switching

on the motor, unless the mower has to be tilted for

starting. In this case, do not tilt it more than

absolutely necessary and lift only the part which is

away from the operator.

•Do not start the engine when standing in front of

the discharge chute.

•Do not put hands or feet near or under rotating

parts. Keep clear of the discharge opening at all

times.

•Never pick up or carry a mower while the engine

is running.

•Stop the engine and disconnect the spark plug lead

– before clearing blockages or unclogging

chute;

– before checking, cleaning, or working on

the mower;

– after striking a foreign object. Inspect the

mower for damage and make repairs before

restarting and operating the mower;

– if mower starts to vibrate abnormally (check

immediately).

•Stop the engine

– whenever you leave the mower;

– before refuelling.

Safety

•Reduce the throttle setting during engine run-out

and, if the engine is provided with a shut-off

valve, turn the fuel off at the conclusion of

mowing.

•Stop the blade(s) when crossing gravel drives,

walks, or roads.

•Shut the engine (motor) off and wait until the

blade comes to complete stop before removing

grass catcher

•Do not operate the mower while under the

influence of alcohol or drugs.

•If the equipment should start to vibrate

abnormally, stop the engine (motor) and check

immediately for the cause. Vibration is generally a

warning of trouble.

Slopes are a major factor related to slip and fall

accidents which can result in a severe injury. If you

feel uneasy on a slope, do not mow it.

•Watch for holes, ruts, or bumps. Tall grass can

hide obstacles.

•Do not mow near drop-offs, ditches, or

embankments. The operator could lose footing or

balance.

•Do not mow on wet grass. Reduced footing could

cause slipping.

Maintenance and Storage

•Keep all nuts, bolts (especially blade attachment

bolts), and screws tight to be sure the equipment is

in safe working condition.

•Never store the equipment with gasoline in the

tank inside a building where fumes may reach an

open flame or spark.

•Allow the engine to cool before storing in any

enclosure.

•To reduce the fire hazard, keep the engine,

muffler, battery compartment, and gasoline storage

area free of grass, leaves, or excessive grease.

•Check the grass catcher frequently for wear or

deterioration.

•Replace worn or damaged parts for safety.

•Use extra care when handling gasoline; vapors are

explosive.

•tamper with safety devices. Check their proper

operation regularly.

•Keep the mower free of grass, leaves, or other

debris build-up. Clean up oil or fuel spillage.

•Stop and inspect the equipment if you strike an

object. Repair, if necessary, before restarting.

•Never attempt to make wheel height adjustments

while the engine (motor) is running.

•Always disconnect electric mowers (live operated)

before cleaning, repairing, or adjusting.

•Grass catcher components are subject to wear,

damage, and deterioration, which could expose

moving parts or allow objects to be thrown.

Frequently check components and replace with

manufacturer’s recommended parts when

necessary.

•Mower blades are sharp and can cut. Wrap the

blade(s) or wear gloves, and use extra caution

when servicing them.

•Do not change the engine governor setting or

overspeed the engine.

•To ensure the best performance and safety,

purchase only genuine Toro replacement parts and

accessories.

Do not use “will fit” parts and

accessories; they may cause a safety hazard.

Safety

Slope

Chart

Read all safety instructions on pages 2–9.

Safety

Symbols

Glossary

Safety alert triangle–

Read operator

’

s manual

Caustic liquids, chemical

burns to fingers or hand

First aid, flush with water

Fire, open light & smoking

prohibited

Eye protection must

be worn

Caution, toxic risk

Safety alert symbol

symbol within triangle

indicates a hazard

Fire or open flame

Explosion

Do not dispose of lead

battery in garbage

Stay a safe distance

from the machine

Stay safe distance

from machine

Stay safe distance

from machine

Keep children away

from battery

Safety

Symbols Glossary

Cutting of foot

Severing of toes & fingers,

Thrown or flying objects,

Do not open or

remove safety shields

hile engine is running

Blade retaining bolts must be

orqued to 101–108 N.m

Do not operate without safety

Severing of toes or foot,

mower blade

Machine being transported

rotary mower blade

hole body exposure

mower blade

Severing of fingers or hand,

Thrown or flying objects,

whole body exposure

Keep guards and safety

sheilds in place

Fuel shut off

control operation

Hot surface, burns to

fingers or hands

Blade cutting element-

height adjustment (mm)

Stop engine before

leaving operator position

101–108 N.

shield in place

Finger & hand engagement,

belt drive

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Toro Rasenmäher Handbücher

Toro

Toro Groundsmaster 4500-D Bedienungsanleitung

Toro

Toro 74776 Bedienungsanleitung

Toro

Toro 74765 Bedienungsanleitung

Toro

Toro Greensmaster 3250-D 04383 Bedienungsanleitung

Toro

Toro 70131 Bedienungsanleitung

Toro

Toro 30873 Bedienungsanleitung

Toro

Toro TIMECUTTER HD 75201 Bedienungsanleitung

Toro

Toro TimeCutter MX 3450 74750 Bedienungsanleitung

Toro

Toro Recycler 22284 Bedienungsanleitung

Toro

Toro Groundsmaster 360 31200 Series Bedienungsanleitung

Toro

Toro Z14-38 TimeCutter Z 74402 Bedienungsanleitung

Toro

Toro ProLine 22026 Bedienungsanleitung

Toro

Toro 74177 Bedienungsanleitung

Toro

Toro LT3340 Bedienungsanleitung

Toro

Toro 30856 Bedienungsanleitung

Toro

Toro GrandStand74529 Bedienungsanleitung

Toro

Toro GrandStand 7450TE Bedienungsanleitung

Toro

Toro 29732 Bedienungsanleitung

Toro

Toro timecutter zs 4200t Bedienungsanleitung

Toro

Toro e-cycler 20360 Bedienungsanleitung

Toro

Toro Super Bagger 20838 Bedienungsanleitung

Toro

Toro Super Recycler 21681 Bedienungsanleitung

Toro

Toro 20833 Bedienungsanleitung

Toro

Toro Z Master 4000 Series Bedienungsanleitung

Beliebte Rasenmäher Handbücher anderer Marken

RHINO

RHINO 1958 Bedienungsanleitung

Wolf Garten

Wolf Garten Compact plus 40 B Bedienungsanleitung

Cub Cadet

Cub Cadet LTX 1045 Bedienungsanleitung

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Bedienungsanleitung

Challenge

Challenge CH18V2 Betriebsanleitung

TALEN TOOLS

TALEN TOOLS AVR HGM30 Bedienungsanleitung

DEWEZE

DEWEZE ATM-725 Bedienungsanleitung

Weed Eater

Weed Eater 180083 Bedienungsanleitung

Husqvarna

Husqvarna Poulan Pro PP185A42 Bedienungsanleitung

Better Outdoor Products

Better Outdoor Products Quick Series Bedienungsanleitung

Cub Cadet

Cub Cadet 23HP Z-Force 60 Betriebsanleitung

MTD

MTD 795, 792, 791, 790 Bedienungsanleitung

Dennis

Dennis FT 610 Bedienungsanleitung

MTD

MTD 126-220-000 Bedienungsanleitung

Stihl

Stihl RMA 443 PV Bedienungsanleitung

Yard-Man

Yard-Man 3700-0 Bedienungsanleitung

AIRFORCE

AIRFORCE F-15 Gen 3 Bedienungsanleitung

MTD

MTD 050 thru 062 Bedienungsanleitung