Toro 98-9880 Bedienungsanleitung

FORM NO. 3321–698

TOWER REPAIR KIT

for LAWN TRACTORS

PART

No. 98–9880

INSTALLATION

INSTRUCTIONS

Loose

Parts

Note: Use the chart below to identify parts used for assembly.

DESCRIPTION QTY. USE

Pivot rod

Hex Spacer nut, 3/8–16 x 1” (26 mm)

Screw

, 3/8–16 x 1/2” (13 mm) hex socket head

Threadlocker adhesive #242

Installation Instructions

Read before installing

Installation

1. Drain the fuel tank; refer to operator’s manual.

POTENTIAL HAZARD

•In certain conditions gasoline is extremely

flammable and highly explosive.

WHAT CAN HAPPEN

•A fire or explosion from gasoline can burn

you, others, and cause property damage.

HOW TO AV

OID THE HAZARD

•Drain gasoline from the fuel tank when the

engine is cold. Do this outdoors in an open

area. Wipe up any gasoline that spills.

•Never drain gasoline near an open flame or

where gasoline fumes may be ignited by a

spark.

•Never smoke a cigarette, cigar or pipe.

2. Remove the left side screw securing the fuel tank

rod and tilt rod up. Set the fuel tank on engine to

gain access to the back side of the dash (Fig. 1).

Figure 1

1. Fuel

tank rod

2. Screw 3. Tower

3. Loosen flange nuts on deck lever pivot rod. Tap

pivot loose from mounting position (Fig. 2).

4. Remove pivot rod, pivot rod clamps, flange

nuts,washers, haripins and wedge nuts. Discard

all pieces except the flange nuts, washers, and

haripins (Fig 2).

Note: In removing the pivot shaft, rotate it

upward and slide out of deck

engagement lever.

m–4047

Figure 2

1. Pivot

rod

Pivot rod clamp

3. W

edge nut

Flange nut

Flat washer

6. Hairpin

5. Place a straight edge aligned across the ends of

the depressed areas (Fig. 3) on the tower. Scribe

a short mark, in line with the ends, at the center

of the third rib from the top on both sides. With

the straight edge aligned through the center of

the third rib, scribe a short mark across the

vertical mark. Drill a 13/32” diameter hole on

each side of the tower at these locations.

m–4042

Figure 3

1. 13/32”

Dia. hole

Depressed area

Rib #3

6. Install the new pivot rod through the deck

engagement lever. Install the two washers and

hairpins, previously removed, on either side of

the deck engagement lever.

7. Install the flange nuts, previously removed

(Fig. 4), with the flange toward the outside.

m–4043

Figure 4

1. Pivot

rod

Hex spacer

Socket head screw

Flange nut

5. Hairpin

Flat washer

8. Thread a hex spacer nut onto each end of the

pivot rod. Equally adjust each spacer so that the

assembly just fits inside the tower (Fig. 4).

Note: If rod is not threaded equally into each

spacer, screws may not fully screw into

the spacers.

9. Tighten the flange nuts against the hex spacers,

while holding the spacers with a wrench.

10. Apply Loctite adhesive, supplied with the kit, to

the threads of the 3/8–16 x 1/2” (13mm) screws.

Thread the screws into the spacers. Tighten

sufficiently, being careful not to deform the

plastic.

11. Reinstall the fuel tank.

Andere Toro Traktorzubehör Handbücher

Toro

Toro 22521 Bedienungsanleitung

Toro

Toro Z MASTER 79402 Bedienungsanleitung

Toro

Toro 08752 Bedienungsanleitung

Toro

Toro 22414 Bedienungsanleitung

Toro

Toro Direct Drive Power Box Rake Bedienungsanleitung

Toro

Toro 25427 Bedienungsanleitung

Toro

Toro 136-6311 Bedienungsanleitung

Toro

Toro Field Pro 604 Bedienungsanleitung

Toro

Toro 08865 Bedienungsanleitung

Toro

Toro BU-003867 Bedienungsanleitung

Toro

Toro 04651 Bedienungsanleitung

Toro

Toro 08733 Bedienungsanleitung

Toro

Toro 79181 Bedienungsanleitung

Toro

Toro 111-6032 Bedienungsanleitung

Toro

Toro 119-9604 Bedienungsanleitung

Toro

Toro 03667 Bedienungsanleitung

Toro

Toro 136-8545 Bedienungsanleitung

Toro

Toro Sitework Systems 22420 Bedienungsanleitung

Toro

Toro Greensmaster TriFlex 3300 Series Bedienungsanleitung

Toro

Toro Wheel Horse 79361 Bedienungsanleitung

Toro

Toro 04504 Bedienungsanleitung

Toro

Toro 132-4164 Bedienungsanleitung

Toro

Toro 04479 Bedienungsanleitung

Toro

Toro 78269 Bedienungsanleitung

Beliebte Traktorzubehör Handbücher anderer Marken

Land Pride

Land Pride SGC0548 Bedienungsanleitung

Swisher

Swisher Versa Commercial Pro VSP50 Bedienungsanleitung

matev

matev FPS-FKH-Kioti CX 2510 Bedienungsanleitung

matev

matev SCA-130 Bedienungsanleitung

Avantco

Avantco A425119 Bedienungsanleitung

FTS

FTS G-FTL Series Bedienungsanleitung

Sami

Sami 150-50 Bedienungsanleitung

CAMSO

CAMSO TTS 30 Series Bedienungsanleitung

Luda

Luda tractorCam S Bedienungsanleitung

HLA

HLA BALE KNIFE Series Bedienungsanleitung

P.Lindberg

P.Lindberg 9059890 Betriebsanleitung

Ventrac

Ventrac KD482 Bedienungsanleitung

Original Tractor Cabs

Original Tractor Cabs 4421381 Datenblatt

Grouser Products

Grouser Products 760 Bedienungsanleitung

Degelman

Degelman Landroller Programmierhandbuch

Bush Hog

Bush Hog BS1 Series Bedienungsanleitung

MX MX A104 Bedienungsanleitung

Bush Hog

Bush Hog DSP8 Bedienungsanleitung