Travis Industries GreenStart Igniter 3 Bedienungsanleitung

GreenStart Igniter 3 for Freestanding Stoves

Installation Instructions (SKU 94400955)

Page 1 of 14 17602077.docx— 12/10/19 © Travis Industries, Inc.

Compatibility

Answer (2020 Compliant) or older Answer (Serial Number 1102-074894 or greater)

Endeavor (2020 Compliant) or older Endeavor (Serial Number 1103-55526 or greater)

Liberty (2020 Compliant) or older Liberty (Serial Number 1105-38119 or greater)

Cape Cod Stove

Evergreen Stove

Rockport Stove

Table of Contents

Compatibility ...............................................................................................................................................1



Table of Contents........................................................................................................................................1



Electrical Requirements.............................................................................................................................1



Packing List.................................................................................................................................................2



Installation Tips...........................................................................................................................................3



All Stove Models – Igniter Hose Clamp ....................................................................................................3



Using a Room Blower Outlet with the GreenStart 2 Igniter (US/Canada Only) ....................................4



Installation ...................................................................................................................................................5



Igniter Operation.......................................................................................................................................12



Warnings ................................................................................................................................................12



Operating Tips........................................................................................................................................12



Igniter Instructions..................................................................................................................................13



Electrical Requirements

USA or CANADA: This kit requires 8 amps, 120 Volt AC.

REMOVE AND DISCARD THE SHIPPING BRACKET

Remove and discard this shipping bracket and 2 screws (use a ¼” nutdriver).

GreenStart Igniter 3 for Freestanding Stoves

Installation Instructions (SKU 94400955)

Page 2 of 14 17602077.docx— 12/10/19 © Travis Industries, Inc.

Packing List

Igniter Firebrick



Igniter (the igniter and cover box together are referred to as

“igniter assembly”)

Compressor Assembly



(2) Cover Plates

Cape Cod (10/19 or Later) Universal

2 Cover Boxes

Cape Cod (9/19 or earlier) Universal



2 Wire Loom Sections

(2) Cable Holders

Gasket

Lock-tie

Cord Restraint

Igniter Spacer

(7) 10-24 x ½” screws

(2) Magnets (Used for Cape Cod/Rockport/Evergreen without blower

only)

GreenStart Igniter 3 for Freestanding Stoves

Installation Instructions (SKU 94400955)

Page 3 of 14 17602077.docx— 12/10/19 © Travis Industries, Inc.

Installation Tips

Remove the shipping bracket from the pump box before proceeding with installation.

The igniter assembly must be installed before placing the stove.

If using a blower, install it first.

It is not necessary to install the blower first on the Endeavor, if applicable.

Wood placement is the key. Experiment with different sizes of wood and wood placement until you find a method that

works best for your wood quality and kindling.

The compressor assembly must be placed as shown in the instructions. Placing it on its side, near hot components, or

in a location where temperatures go below 40F will void the warranty and may lead to premature failure.

All Stove Models – Igniter Hose Clamp

A hose clamp is attached to each igniter hose. You will need to set the clamp while attaching the hose to

the igniter. See the photos below.

GreenStart Igniter 3 for Freestanding Stoves

Installation Instructions (SKU 94400955)

Page 4 of 14 17602077.docx— 12/10/19 © Travis Industries, Inc.

Using a Room Blower Outlet with the GreenStart 2 Igniter (US/Canada Only)

An extra outlet for the room blower is included with the GreenStart Igniter 3 for Freestanding Stoves. To

access this outlet remove the top of the pump box using a 5/16” nutdriver.

The outlet ships inside the housing. Route it through the slot and use the included strain-relief to hold the

cable in place (see pictures below). Replace the cover.

GreenStart Igniter 2 for Freestanding Stoves

Installation Instructions (SKU 94400951)

Page 5 of 14 17602077.docx — 12/10/19 © Travis Industries, Inc.

Installation

Modify the firebrick inside the firebox as shown below.

Cape Cod

Evergreen, Rockport, Endeavor, Liberty, Answer

4"x9"

Remove this cover

plate (5/32” Hex

Wrench) and replace

the firebrick.

Remove this brick and

replace it with the igniter

firebrick. The Evergreen

uses the brick included

with the igniter, the

Rockport uses the brick

included with the stove.

GreenStart Igniter 2 for Freestanding Stoves

Installation Instructions (SKU 94400951)

Page 6 of 14 17602077.docx — 12/10/19 © Travis Industries, Inc.

Cape Cod (9/19 or Earlier)

Remove the cover plate and bracket

Endeavor, Liberty, Evergreen & Rockport, Answer

and Cape Cod (10/19 or Later)

Remove the igniter knock-out on the rear of the stove.

This is best done by snipping one of the tabs holding

the knock-out in place then bending the knock-out

repeatedly until it comes loose.

GreenStart Igniter 2 for Freestanding Stoves

Installation Instructions (SKU 94400951)

Page 7 of 14 17602077.docx — 12/10/19 © Travis Industries, Inc.

The knock-out may be discarded.

Remove the igniter cover plate and gasket. Retain the gasket and screws.

Install the igniter spacer using the screws and gasket removed in step 6. Make sure to use the screws that

were removed with the gasket.

Attach the igniter with gasket to the igniter sleeve using the screws and gasket included in this kit. Note that the

igniter gasket is placed between the sleeve and igniter assembly.

GreenStart Igniter 2 for Freestanding Stoves

Installation Instructions (SKU 94400951)

Page 8 of 14 17602077.docx — 12/10/19 © Travis Industries, Inc.

NOTE: The brass nipple faces down.

Place the compressor assembly on the floor next to the stove.

Attach the igniter wires to the compressor assembly wires.

Attach the ¼” tube to the nipple on the igniter.

GreenStart Igniter 2 for Freestanding Stoves

Installation Instructions (SKU 94400951)

Page 9 of 14 17602077.docx — 12/10/19 © Travis Industries, Inc.

Attach the cover plate and igniter cover box over the igniter (cover plates are included with the stove).

Pre-2020 Endeavors – For these stoves the cover plate and cover box are not required. If you do wish to the

conceal the igniter, use self-drilling screws (not included) to secure the cover box to the back of the stove.

Cape Cod 9/19 or Earlier

uses cover plate included with stove.

Everything Else

Use included cover plate see page 2 for details

NOTE: This tab is bent flat on the Answer and

Cape Cod (10/19 or Later)

Place the compressor assembly on the floor behind the stove.

NOTE: An extra outlet may be used with the Cape Cod stove; see page 3.

GreenStart Igniter 2 for Freestanding Stoves

Installation Instructions (SKU 94400951)

Page 10 of 14 17602077.docx — 12/10/19 © Travis Industries, Inc.

Route the igniter switch from the compressor assembly underneath the stove.

Stoves with Blower (except Answer)

Attach the igniter switch bracket to the bottom of the rheostat bracket with two screws.

Stoves without Blower (except Answer)

Attach the igniter switch to the bottom of the stove using the two included magnets.

Answer Only

Attach the igniter switch to the bottom of the stove using the two included screws.

Inhaltsverzeichnis

Andere Travis Industries Kaminzubehör Handbücher

Travis Industries

Travis Industries 98500668 Bedienungsanleitung

Travis Industries

Travis Industries 98500677 Bedienungsanleitung

Travis Industries

Travis Industries 250-02736 Bedienungsanleitung

Travis Industries

Travis Industries ProBuilder 36 Bedienungsanleitung

Travis Industries

Travis Industries 96100110 Bedienungsanleitung

Travis Industries

Travis Industries 250-05727 Bedienungsanleitung

Travis Industries

Travis Industries 228-30035 Bedienungsanleitung

Travis Industries

Travis Industries 33 DVI Bedienungsanleitung

Travis Industries

Travis Industries 95600654 Bedienungsanleitung

Travis Industries

Travis Industries 564 EF-I Bedienungsanleitung

Travis Industries

Travis Industries 95900388 Bedienungsanleitung

Travis Industries

Travis Industries Rosario DVS Face Bedienungsanleitung

Travis Industries

Travis Industries 95900352 Bedienungsanleitung

Travis Industries

Travis Industries Fireplace Xtrordinair GreenStart Apex 42 Bedienungsanleitung

Travis Industries

Travis Industries Arbor Bedienungsanleitung

Travis Industries

Travis Industries 96100150 Bedienungsanleitung

Travis Industries

Travis Industries 54PB Bedienungsanleitung

Travis Industries

Travis Industries DVS EG Firebacks Bedienungsanleitung

Travis Industries

Travis Industries 864 TRV 31K Bedienungsanleitung

Travis Industries

Travis Industries 95100055 Bedienungsanleitung

Travis Industries

Travis Industries Olympic Bedienungsanleitung

Travis Industries

Travis Industries 616 GSR Insert Bedienungsanleitung

Travis Industries

Travis Industries 4237 Bedienungsanleitung

Travis Industries

Travis Industries Bon-Fyre Bedienungsanleitung

Beliebte Kaminzubehör Handbücher anderer Marken

Valor

Valor L2 1700K Bedienungsanleitung

Exodraft

Exodraft Xzense Bedienungsanleitung

Whalen

Whalen Ruso MNFP62BF23-6 Bedienungsanleitung

Lopi

Lopi Hearthview 864 Bedienungsanleitung

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Bedienungsanleitung

EdilKamin

EdilKamin SERBATOIO 250 Kurzanleitung

Bronpi

Bronpi KIT-1 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Bedienungsanleitung

Superior

Superior ASD3628-TI Bedienungsanleitung

pleasant hearth

pleasant hearth OFP28WG Bedienungsanleitung

IHP

IHP Astria Series Bedienungsanleitung

Firegear

Firegear FG-H-2110SS Bedienungsanleitung

Nibe

Nibe Contura C i31 Bedienungsanleitung

kozy heat

kozy heat KZK-052 Bedienungsanleitung

SimpliFire

SimpliFire SF-WM36 Bedienungsanleitung

Bluegrass Living

Bluegrass Living BC18NR Kurzanleitung

pleasant hearth

pleasant hearth IRIS SCROLL Bedienungsanleitung

Cooke

Cooke Glass Wind Guard Bedienungsanleitung