Travis Industries 616 GSR Bedienungsanleitung



616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 1 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

WARNINGS

MakesurethegascontrolvalveisOFFandtheheateriscoolpriortoconductingservice.

Failuretopositionthepartsinaccordancewiththesediagramsorfailuretouseonlypartsspecificallyapprovedwiththis

appliancemayresultinpropertydamageorpersonalinjury.

Ifusingpropane(LP),converttheappliancebeforeinstallingthelogs(seetheownersmanualfordetails).

Compatibility

616GSR

Packing List

  



10‐PieceTraditionalLogSet  RearAirDeflector,RearLogSupport.BagofRockWool,BagofEmbers

NGandLPcompatible.



Burner Installation

NOTE:Theinsertshouldbeinplace,withthegaslineandventattachedandthefirebacksinstalled(seeowner’smanualfor

furtherdetails).

1. Removetherearburner.

 

Removethe1or2burner

screws(1/4”nutdriver).



616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 2 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

2. Removethe3screwsfromthebackoftherearburnerusinga¼”nutdriver.

 



3. Attachtherearairdeflectortotherearburnerwiththescrewsremovedinthepreviousstep.

 



4. Replacetherearburnerandsecurewiththeattachmentscrew(s).





Thetwotabsonthe rear

burnerrestontopofthe

frontburner.



616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 3 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

5. Installtherearlogshelf.



Rock Wool Placement

6. Placetherockwoolasshownbelow.Useastiffbrushtoapplytherockwoolinaloose,gauze‐likelayer.



TIP:Holdtherockwoolinatightwadwithonehandwhilebrushingwiththeother.

  



Notehowtherockwoolisapproximately1/8”thickoverthe

burnerports.

TIP:Feelfreetoapplyagenerousamountofrockwooltogain

adarkerflameandabrightercoalbed.



616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 4 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

Log and Ember Chunks Placement

Thelogsarefragile,especiallyafterbeingexposedtoheat.

Theburnermustbecorrectlypositionedbeforeinstallingthelogs.Makesuretheburnerisfullyseated.

7. Placetherearlogasshownbelow.



 



  

Pullthelogforwarduntilitrestsagainstthetabsontheburners.





616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 5 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

8. Placetherightmiddlelogasshownbelow.Therightmiddlelogneedstobepushedbacktightagainsttherearburner.



 



9. Placetheleftmiddlelogasshownbelow.Theleftmiddlelogneedstobepushedbacktightagainsttherearburner.

 



 



616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 6 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

10. Placetherightfrontlogasshown.

  

  



11. Placetheleftfrontlogasshown.

 

 



616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 7 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

12. Placeemberchunksinthegapsbetweenleftandrightmiddlelogs

 



13. Placetherightcrosslogasshownbelow.

 

 







616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 8 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

14. Placethemiddlecrosslogasshownbelow.

 

 



15. Placetheleftcrosslogasshownbelow.

 

 



616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 9 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

16. Placefrontemberlogasshownbelow.

 

 



17. Placethetwigchunkasshownbelow.



 



616 GSR Traditional Log Set Version 2

Installation Instructions (SKU94500947)



Page 10 of 10 17601921 — 3/24/16 © Travis Industries, Inc.

18. Placetheemberchunksinthefrontcornersandalongthefrontoftheburner.Usetheemberchunkstocoverscrewheadsbutdo

notplacethemoverporting.





19. Re‐applytherockwoolovertheemberchunksalongthefrontburnerandbetweenthetwofrontlogsforanaturallook.

TIP:Applyingrockwoolinthecracksofthelogshelpstoaddsmallpointsofglow,butmaydampentheoverallglowofthelogs.

TIP:Naturalgas(NG)canusemorerockwoolthanpropane(LP).

NOTE:Initialapplicationofrockwoolmaycause“matting”overburnerports.Turningtheunitonandthenoffagainwillloosen

therockwool,resultinginabetterflame.



20. Theinsertshouldbetest‐burnedwiththeglassframeinplacepriortoleavingtheinstallation.Seetheowner’smanualfordetails

onfinalizingtheinstallation(adjustingtheairshutter,etc.).

21. Checktheexhaustrestrictorsettingbeforefinalizingtheinstallation.

Restrictor Settings

Traditional Logs

Natural Gas Short Vent

(25’ or less)#3 (stock)

Natural Gas Tall Vent

(25’ or more)#3 (stock)

Propane Short Vent

(25’ or less)#1

Propane Tall Vent

(25’ or more)#3 (stock)



Andere Handbücher für 616 GSR

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Travis Industries Kamin im Innenbereich Handbücher

Travis Industries

Travis Industries 616 Diamond-Fyre GSR Bedienungsanleitung

Travis Industries

Travis Industries Large Flush Wood Insert Bedienungsanleitung

Travis Industries

Travis Industries DVS Ember-Fyre 2.1 Log Bedienungsanleitung

Travis Industries

Travis Industries 864 See Through GreenSmart 2 Bedienungsanleitung

Travis Industries

Travis Industries Lopi Bedienungsanleitung

Travis Industries

Travis Industries 6015 HO GSR2 Bedienungsanleitung

Travis Industries

Travis Industries 564 HO Bedienungsanleitung

Travis Industries

Travis Industries 21 DV RV Bedienungsanleitung

Travis Industries

Travis Industries Spirit 300 GS Bedienungsanleitung

Travis Industries

Travis Industries Xtrordinair 44 Elite Bedienungsanleitung

Travis Industries

Travis Industries 21 TRV GSR2 Bedienungsanleitung

Travis Industries

Travis Industries Avalon 796 top flue Bedienungsanleitung

Travis Industries

Travis Industries DVL Insert EF II Bedienungsanleitung

Travis Industries

Travis Industries GreenSmart Fireplace 564 SS Bedienungsanleitung

Travis Industries

Travis Industries 36 CF II Bedienungsanleitung

Travis Industries

Travis Industries DVS FIREPLACE Bedienungsanleitung

Travis Industries

Travis Industries DVS GSR Bedienungsanleitung

Travis Industries

Travis Industries 864 TRV GS2 Bedienungsanleitung

Travis Industries

Travis Industries 21E Bedienungsanleitung

Travis Industries

Travis Industries 1750 Bedienungsanleitung

Travis Industries

Travis Industries DVL GSR2 NB Bedienungsanleitung

Travis Industries

Travis Industries 564 LedgeStone Bedienungsanleitung

Travis Industries

Travis Industries DVS Insert EF II Bedienungsanleitung

Travis Industries

Travis Industries 864 TRV GSR2 Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch