Travis Industries 616 GSR Bedienungsanleitung



616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 1 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

WARNINGS

•MakesurethegascontrolvalveisOFFandtheheateriscoolpriortoconductingservice.

•Failuretopositionthepartsinaccordancewiththesediagramsorfailuretouseonlypartsspecificallyapprovedwiththis

appliancemayresultinpropertydamageorpersonalinjury.

•Ifusingpropane(LP),converttheappliancebeforeinstallingthelogs(seetheownersmanualfordetails).

Compatibility

616GSR

Packing List

•8‐PieceTraditionalLogSet

(notshown)



FrontLogSupports,(4)10‐24Kepsnuts

RearAirDeflector,RearLog

Support



BagofRockWool,BagofEmbers

Burner Installation

NOTE:Theinsertshouldbeinplace,withthegaslineandventattachedandthefirebacksinstalled(seeowner’smanualfor

furtherdetails).

1. Removetherearburner.

 

Removethisscrew

(

4”n

utd

riv

)

.



616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 2 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

2. Removethe3screwsfromthebackoftherearburnerusinga¼”nutdriver.

 

3. Attachtherearairdeflectortotherearburnerwiththescrewsremovedinthepreviousstep.

 

4. Replacetherearburnerandsecurewiththeattachmentscrew.





Thetwotabsontherear

burnerrestontopofthe

frontburner.



616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 3 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

5. Installtherearlogshelf.



6. Attachthefrontlogsupportswiththe4includednuts.

NOTE:Theleftfrontlogsupportshouldbepositionedlikethephotobelow:







616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 4 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

Rock Wool Placement

7. Placetherockwoolasfollows:

a. Brushtherockwoolusingastiffbrushinaloose,gauze‐likelayer.



TIP:Holdtherockwoolinatightwadwithonehandwhilebrushingwiththeother.



Notehowtherockwoolisapproximately1/8”thickovertheburnerports.

TIP:Feelfreetoapplyagenerousamountofrockwooltogainadarkerflameandabrightercoalbed.









616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 5 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

Log and Ember Chunks Placement

Thelogsarefragile,especiallyafterbeingexposedtoheat.

•Theburnermustbecorrectlypositionedbeforeinstallingthelogs.Makesuretheburnerisfullyseated.

8. Placetherearlogasshownbelow.

NOTE:Theleftandrightmiddlelogsneedtobepushedbacktightagainsttherearburner.









Movethelogforwarduntilitrestsagainstthetabsontheburners.







616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 6 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

9. Placetheleftmiddlelogasshownbelow.



10. Placetherightmiddlelogasshownbelow.





616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 7 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

11. Placetheleftfrontlogasshown.



12. Placetherightfrontlogasshown.





616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 8 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

13. Placetheemberchunksasshownbelow.Notethathalfthebagofembersisleftover.



14. Re‐applytherockwoolovertheemberchunksalongthefrontburnerandbetweenthetwofrontlogsforanaturallook.

TIP:Applyingrockwoolinthecracksofthelogs(seebelow)helpstoaddsmallpointsofglow,butmaydampentheoverallglow

ofthelogs.

TIP:Naturalgas(NG)canusemorerockwoolthanpropane(LP).

NOTE:Initialapplicationofrockwoolmaycause“matting”overburnerports.Turningtheunitonandthenoffagainwillloosen

therockwool,resultinginabetterflame.

 





616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 9 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

15. Placetheleftcrosslogasshown.

NOTE:Thethreecross‐logsmakeitdifficulttoapplymorerockwool.Addthemafteryouhavefinishedapplyingtherockwool

andemberchunks.



16. Placethemiddlecrosslogasshown.





616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 10 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.



17. Placetherightcrosslogasshown.



18. Theinsertshouldbetest‐burnedwiththeglassframeinplacepriortoleavingtheinstallation.Seetheowner’smanualfordetails

onfinalizingtheinstallation(adjustingtheairshutter,etc.).

19. Checktheexhaustrestrictorsettingbeforefinalizingtheinstallation.

Restrictor Settings

Traditional Logs

Natural Gas Short Vent

(25’ or less)#3 (stock)

Natural Gas Tall Vent

(25’ or more)#3 (stock)

Propane Short Vent

(25’ or less)#1

Propane Tall Vent

(25’ or more)#3 (stock)



Andere Handbücher für 616 GSR

Inhaltsverzeichnis

Andere Travis Industries Kamin im Innenbereich Handbücher

Travis Industries

Travis Industries Pro Builder 42 Linear GSB2 Bedienungsanleitung

Travis Industries

Travis Industries 564 Bedienungsanleitung

Travis Industries

Travis Industries 564 SS GS2 Bedienungsanleitung

Travis Industries

Travis Industries ProBuilder 54 Linear Bedienungsanleitung

Travis Industries

Travis Industries 864 TRV Bedienungsanleitung

Travis Industries

Travis Industries 864 TRV Deluxe Bedienungsanleitung

Travis Industries

Travis Industries 864 TRV Bedienungsanleitung

Travis Industries

Travis Industries Revolution 36CF Bedienungsanleitung

Travis Industries

Travis Industries 21 TRV GreenSmart Bedienungsanleitung

Travis Industries

Travis Industries 31 DVI GSB2 Bedienungsanleitung

Travis Industries

Travis Industries DVS GSR2 NB Insert Bedienungsanleitung

Travis Industries

Travis Industries 4415 HO ST Bedienungsanleitung

Travis Industries

Travis Industries 864 HO NB Bedienungsanleitung

Travis Industries

Travis Industries 36 CF II Handbuch

Travis Industries

Travis Industries DVL EF Bedienungsanleitung

Travis Industries

Travis Industries 864 HO NB GSR2 Bedienungsanleitung

Travis Industries

Travis Industries 864 HO NB Bedienungsanleitung

Travis Industries

Travis Industries 6015 HO GSR2 Bedienungsanleitung

Travis Industries

Travis Industries Xtreme 6020 Bedienungsanleitung

Travis Industries

Travis Industries 864 HO GSR2 Bedienungsanleitung

Travis Industries

Travis Industries Flush Wood Insert Bedienungsanleitung

Travis Industries

Travis Industries 564 Bedienungsanleitung

Travis Industries

Travis Industries Xtrordinair ProBuilder 36 CleanFace MV Bedienungsanleitung

Travis Industries

Travis Industries GreenSmart 2 Fireplace 564 SS GSR2 Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch