Truma AquaGo basic Bedienungsanleitung

Professional decalciﬁcation kit for Truma AquaGo®

Table of contents

Intended use .......................................................................... 3

Functional description .......................................................... 3

Scope of delivery ................................................................... 3

Safety instructions ................................................................ 4

Operating instructions .......................................................... 7

Decalcification frequency ......................................................... 7

Preparing for decalcification .................................................... 8

Connecting the circulation pump ............................................. 8

Carrying out the decalcification process ............................... 10

Cleaning the circulation pump .............................................. 10

Flushing the water system ..................................................... 11

Stopping decalcification ......................................................... 11

Accessories .......................................................................... 11

Technical data, pump ......................................................... 11

Troubleshooting .................................................................. 12

MANUFACTURER LIMITED WARRANTY ........................ 13

Legend

1 Easy Drain Lever

2 Outlet hose

3 Inlet hose

4 Socket (12 pin)

5 Plug

6 POWER switch

7 Control panel

8 Connector cable

(circulation pump)

Circulation adapter

Figure 2

Overview

Figure 1

Circulation pump

Figure 3

Trademark information

Truma AquaGo®, referred to as AquaGo below.

Intended use

The Professional decalcification kit for AquaGo

is used to decalcify AquaGo instant water heat-

ers. Other applications are not approved.

Functional description

The Professional decalcification kit for AquaGo

pumps a decalcification solution through the

AquaGo instant water heater with the aid of a

circulation pump. This dissolves and flushes out

calcium residues.

Scope of delivery

• Service case

• Circulation adapter with connected circula-

tion pump and outlet hose

• AquaGo professional decalcification

• Operating instructions

For decalcification you will also need the

following:

• Acid-resistant bucket with a capacity of at

least 2gallons (7.5 l)

• Personal protective equipment

Safety instructions

The operating instructions supplied with the

AquaGo instant water heater are part of these

operating instructions for the Professional de-

calcification kit for AquaGo.

Read and follow this information to avoid

injuries during installation and operation.

Safety symbols and signal words

indicates a hazardous situation

which, if not avoided, could result in death or

serious injury.

indicates a hazardous situation

which, if not avoided, could result in minor or

moderate injury.

is used to address practices not

related to physical injury.

Other important information or tips

Installation and service must be performed

by an expert. Improper installation, altera-

tion, service or maintenance can cause

property damage, personal injury or loss of

life.

California Proposition 65 lists chemical sub-

stances known to the state to cause cancer,

birth defects, death, serious illness or other re-

productive harm. This product may consist of

such substances or such substances may be

formed from components of the product.

Injuries caused by the Easy Drain Lever!

• Never actuate the Easy Drain Lever as long

as the AquaGo is under water pressure

and/or is still hot.

Sensitive surfaces (e. g. marble)

may be damaged through contact with the

decalcification agent. Immediately remove

splashes of decalcification agent on these

surfaces.

Keep decalcification product/solution safe

from unauthorized access (e.g. children and

animals).

For safety reasons, once the decalcification

process has started it must not be stopped

until the system has been flushed (see “Flush-

ing the water system”, page 11).

Danger of crushing/pinching of fingers

when the Easy Drain Lever is closed!

Never put fingers between Easy Drain Lever

and water inlet filter or latch.

The use of non-original AquaGo profes-

sional decalcification (e.g. vinegar) for de-

calcification can cause chemical reactions

and produce hazardous substances that

could enter the drinking water supply.

• Do not mix AquaGo professional decal-

cification with other substances to avoid

chemical reactions and production of haz-

ardous substances.

• Only use AquaGo professional decalcifica-

tion to decalcify the AquaGo to avoid:

– chemical reactions and production of

hazardous substances,

– damage to your AquaGo,

– and the voiding of your warranty.

– Call your local AquaGo dealer or service

provider or see www.truma.net for more

information to obtain AquaGo profes-

sional decalcification.

Irritation of skin and eyes in case of con-

tact with decalcification agent

Wear protective gloves, eye protection and

face protection to avoid contact.

• Never use the water supply in the RV dur-

ing decalcification.

• In case of skin contact with the decalcifica-

tion agent, immediately rinse the affected

area with plenty of water.

• In case of eye contact, hold eyelid open and

rinse with running water for 10 – 15min.

Remove contact lenses, if present and easy

to do. Continue rinsing. Consult an eye

specialist.

• If you swallow the decalcification agent,

immediately rinse your mouth and drink

plenty of water in small sips. Do not vomit.

Consult a doctor.

Risk of damage in frosty

conditions. In frosty conditions there is a risk

that water in pipes, faucets and appliances

could freeze. This can cause considerable

damage. For more information see “Winter

operation” in the operating instructions for the

AquaGo instant water heater.

Operating instructions

Decalcification takes about 2.5 hours.

If, during installation, it is difficult to install

the filter cartridge or circulation adapter,

use a small amount of soap on the O-rings.

Never use grease because the O-rings are not

resistant to grease.

You will find more information about the

access door in the operating instructions

for the AquaGo instant water heater.

Decalcification frequency

Lime scale occurs especially as a result of pre-

cipitation from “hard” water. The AquaGo must

be decalcified regularly depending on water

hardness and hot water consumption.

Recommended decalcification frequency

per year

Water hardness

mg/l CaCO3

Very hard

>180

124

Hard

121 – 180

113

Moderately

hard

61 – 120

112

Soft

0 – 60

111

Usage*

low normal high

* Hot water consumption (approximately)

low 635 gallon/year 2400 l/year

normal 1585 gallon/year 6000 l/year

high 6350 gallon/year 24000 l/year

Preparing for decalcification

• Dissolve 5 AquaGo professional decalcifica-

tion tablets in an acid-resistant bucket in

1.3gallons (5 l) of drinking water. (Duration

approx. 10 min.).

• Open the access door of the AquaGo.

(See “Opening the access door” in the op-

erating instructions for the AquaGo instant

water heater.)

• Switch the AquaGo off at the

POWERswitch(6).

• Open the hot water faucet and wait until

cold water comes.

• Leave the hot water faucet open in order to

depressurize and vent the water system.

• Interrupt the water supply.

• Wait until no more water runs and the water

system is depressurized.

• Attach “Attention Decalcification” signs to all

water withdrawal points (included with the

AquaGo professional decalcification kit).

Connecting the circulation pump

• Remove the water inlet filter. (see Figure 4)

Easy Drain Lever

Water inlet ﬁlter

Latch

Figure 4

If the O-rings are damaged or

missing, the decalcification solution may

leak during the decalcification process.

Before inserting the circulation adapter (9),

check that the O-rings are in place and intact

(see Figure 2, page 2).

• Insert the circulation adapter (9) and close

the Easy Drain Lever (1) (see Figure 5).

Figure 5

• Place the circulation pump (10) and outlet

hose (2) in the bucket with the decalcifica-

tion solution. (see Figure 6)

Figure 6

Carrying out the decalcification

process

Damage to circulation pump (10)

if it runs dry. Make sure that the circulation

pump (10) is immersed before you switch on

the power (see Figure 6).

• Remove the socket (4) from the control pan-

el(7) of the AquaGo and connect it with the

plug (5).

• Run the circulation pump (10) for 2 hours un-

der supervision.

Figure 7

Cleaning the circulation pump

• Remove the socket (4) from the plug (5).

• Dispose of the remaining decalcification

product in accordance with the statutory

regulations of the respective country in

which it is used.

• Place the circulation pump (10) and the out-

let hose (2) in a bucket with drinking water.

• Connect the socket (4) and the plug (5).

Run the circulation pump (10) for about

5minutes.

• Unplug the socket (4) from the plug (5) and

remove the circulation pump (10) from the

bucket.

Andere Handbücher für AquaGo basic

Inhaltsverzeichnis

Andere Truma Boiler Handbücher

Truma

Truma Therme Bedienungsanleitung

Truma

Truma AquaGo basic Bedienungsanleitung

Truma

Truma AquaGo comfort Bedienungsanleitung

Truma

Truma Therme Bedienungsanleitung

Truma

Truma Ultrastore Rapid Bedienungsanleitung

Truma

Truma UltraRapid Bedienungsanleitung

Truma

Truma Therme Bedienungsanleitung

Truma

Truma Ultrastore Bedienungsanleitung

Truma

Truma AquaGo basic Bedienungsanleitung

Truma

Truma AquaGo basic Bedienungsanleitung

Truma

Truma Therme Bedienungsanleitung

Truma

Truma AquaGo AU Betriebsanleitung

Truma

Truma Ultrastore Rapid Bedienungsanleitung

Truma

Truma UltraRapid LPG Bedienungsanleitung

Truma

Truma B 14 Bedienungsanleitung

Truma

Truma AquaGo basic Bedienungsanleitung

Truma

Truma AquaGo basic Bedienungsanleitung

Truma

Truma BGA 14 Bedienungsanleitung

Beliebte Boiler Handbücher anderer Marken

Kenmore

Kenmore 153.582400 Bedienungsanleitung

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Bedienungsanleitung

clage

clage E-Mini Series Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-180 Bedienungsanleitung

Bradford White

Bradford White EF Series Bedienungsanleitung

Eccotemp

Eccotemp 40-H Bedienungsanleitung

Dimplex

Dimplex ECSd125-580 Leitfaden

Dux

Dux 32FCR6N Bedienungsanleitung

Noritz

Noritz N-132M Gebrauchsanweisung

TESY

TESY GCV7/4S 10047 Technisches Datenblatt

A.O. Smith

A.O. Smith Gphe 50 Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Fehlerbehebungshandbuch

Koryo

Koryo KWHZF15Y Bedienungsanleitung

Pentair

Pentair PSC-14-4-02 Bedienungsanleitung

GE 40M06AAG Montageanleitung

Thermor

Thermor AEROMAX SPLIT 2 Bedienungsanleitung

American Hometec

American Hometec AHQ-B03X Bedienungsanleitung

PVI

PVI MAXIM Bedienungsanleitung