Trust GReddy Profec Bedienungsanleitung

EXTREMEPOWERENHANCEMENTPRODUCTSBYGREDDY

Pleasereadthismanualthoroughlybeforeinstallationandoperation.

取扱説明書

instructionmanual

All manuals and user guides at all-guides.com

all-guides.com

Thank you very much for your recent purchase: GReddy Profec. Please read this manual

thoroughly before installation and operation. We hope this instruction manual will be helpful

to you whether you are a novice or a technician. This product is intended for off-road use.

Please keep this manual for future reference.

Please read.

Please read

Disclaimer

To the best of our knowledge, the information contained herein is accurate.

However, neither TRUST CO., LTD or any of its subsidiaries assumes any liability

whatsoever for the accuracy or completeness of the information contained herein. All

materials may present unknown hazards and should be used with caution. In particular,

improper use of our products and their inappropriate combination with other products and

substances may produce harmful results which cannot be anticipated. Final determination

of the suitability of any material is the sole responsibility of the user. Although certain

hazards are described herein, we cannot guarantee that these are the only hazards that

may exist. All service performed on internal parts and equipment should be provided by

qualified technicians.

All manuals and user guides at all-guides.com

Introduction

TableofContents

Disclaimers

PartsList

ProductFeatures

Productdescription/Beforeinstallation

Installationoverview(Actuatortype)

Powerunitwiringinstructions/Pressuresensorhoseroutinginstructions

Installingthesolenoidvalveunit

Installingthesolenoidvalveunit(Actuatortype)

Installingthesolenoidvalve(Externalwastegatetype)

Controlunitinstallation

Basicoperation

Opearatinginstructions

Quickreferencematrix

SETUPoverview

PATTERN

DIRECTION ／ BRIGHT

UNIT ／ ALARM

LASTBOOST

STARTTYPE

DATALOCK

Programmingoverview

SET

GAIN

STARTBOOST

PEAK

WARNING

LIMITER

SCRAMBLE

SWITCHMODE

Shortcutcommands

Troubleshooting/Testmode

Boostsettingtips

Factorydefaultsettings/Troubleshooting

Service

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・

・・

・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・

・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・

・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・

P3〜6

P10

P11

P12,13

P14

P15

P16

P17

P17,18

P19,20

P21

P22

P23

P24

P25

P26

P27,28

P29

P30

P31

P32

P33

P34

P35

P36

P37

P38

P39

P40

P41

P42

PleaseRead

TableofContents

Contents Installation Configurations Boostsettings Troubleshooting

Operations

Contents Installation Configurations Boostsettings TroubleshootingOperations

All manuals and user guides at all-guides.com

Contents

Please read carefully

Theseinstructionsareintendedforqualiﬁedpersonnelonly.

Toreducetheriskofelectricalshock,donotperformanyservicing

otherthanthatcontainedintheInstallationandTroubleshooting

Instructionsunlessyouarequaliﬁedtodoso.Referallservicingto

qualiﬁedservicepersonnel.

Warning

Thissymbolindicatesthathazardsarepresent

withintheequipment.Thesehazardsmaybeof

suﬃcienttocauseseriousbodilyinjuryif

installedimproperly.Thesymbolmayalso

appearonschematics.

Caution

Theexclamationpoint,withinanequilateral

triangle,isintendedtoalerttheusertothe

presenceofimportantinstallation,servicing,and

operatinginstructionsinthedocuments

accompanyingtheequipment.

Important Precautionsbeforeinstallation.Thewordmay

alsoappearonschematics.

Safetyadvice

All manuals and user guides at all-guides.com

Contents

Pleasereadcarefully

Safetyadvice

Warning

Installationandtuningofthisproductshouldonlybeperformedbyatrained

specialistwhoisveryfamiliarwiththeautomobileʼ smechanical,electrical

andfuelmanagementsystems.Ifinstalledbyanuntrainedperson,itmay

causedamagetotheunitaswellasthevehicle.

Donotworkonavehiclethathasrecentlybeenshutoﬀ.Theexhaustsystem

maybeextremelyhotandcouldcauseburninjury.

Professionalinstallationisrecommended.Thereisariskofinjuryifperformed

byanuntrainedperson.

Besuretoinspectandexamineallmountingsurfacesandlocations.

Improperlymountedcontrollerscanfallwhiledrivingthevehicle.Thiscould

causeseriousinjuryordamage.

Donotattempttooperatetheproductwhiledriving.Doingsomaycausean

accident.

Beforemovingthevehicle,makesurethatyourworkareaisclearoftoolsand

issafetodrivethrough.Makesurethattherearenotoolsorobjectsinthecar

thatwillkeepyoufromoperatingthevehicleinasafemanner.

Makesurethattheinstallationoffuelsensorsisdonesomewherethatiswell

ventilated.Fuelisﬂammableandmaycauseseriousinjuryifnothandled

properly.

Whenusingsolderingironsandnippers,pleasereadtheiroperatingmanuals

priortouse.Improperuseofthisequipmentmayleadtoinjuryorillness.

All manuals and user guides at all-guides.com

Safetyadvice Pleasereadcarefully

Contents

Caution

Increasingboostlevelsisapracticethatisnotadvisedbyoriginal

equipmentautomobilemanufacturers.Whiledoingsowillleadtomore

poweroutput,itcanverywellleadtoenginedamageorcompleteengine

failureifdoneimproperly.Theadditionofmorepowertoanyvehicle

requiresduecautionwhilethedriverbecomesacclimated.TRUSTCo.,LTD.

anditssubsidiariesarenotliableforanydamageorinjurythatmayarise

fromtheuseofthedevice.

Dependingonthevehicle,someapplicationswilltriggera“fuelcut”when

raisingtheboostpressure,inthesecircumstances,youneedane-manage

orsimilarunittothecontrolfuelcut.

Incorrectwiringcouldleadtodamagetoyourcarselectricalsystem.

Besuretoverifythatallthesensorsareinstalledusingsealingtape.After

installationofsensors,besuretocheckforleakssuchasoil,coolantand/or

fuel.

Donotdisassembletheproduct.Doingsowillleadtotheforfeitof

warrantycoverage.

Whenmakingwireconnections,besuretoremovethekeyfromthe

ignition,anddisconnectthenegativeterminalofthebattery.

Donotinstallinelectricallynoisyenvironmentssuchasignitionsignal

areas.Thiscouldleadtosensorglitchormalfunction.

All manuals and user guides at all-guides.com

all-guides.com

Safetyadvice Pleasereadcarefully

Contents

Important

Theproductisforracingvehiclesonly.

ThisproductisforuseONLYonvehicleswitha12Velectricalsystem.

Pleasemakesuretoreadthesafetyprecautionsdescribedineachcategory.

TRUSTCO.,LTDTEL:0479(77)3000

3155-5OdaiShibayama-machiSanbu-gunChiba,Japan289-1605

All manuals and user guides at all-guides.com

SensorunitControlunit Solenoidvalveunit

4Φhose(1m)

Double-sidedtape

6Φhose(1m)

“Y”connector

Airﬁlter Instructionmanual

4Φhose(1m)Solenoidvalveharness（1.5m）

6Φhoseﬁttingx2

Hoseclampx2

Valveunitbracket

M4bolt&nutx2

M6boltx1

Anti-vibration

isolatorx2

Ifyoufindyouaremissingparts,pleasebringthistotheattentionofyour

AuthorizedGReddyDealerorcontactGReddyPerformanceProductsdirectly.

Adjustable

mountingbracket

TRUSTSUPERTUNINGSYSTEMSAIMEDATREALCOMPETITORS

ご使用の前にこの取扱説明書をよくお読みになり、十分理解された上で

正しくお使いください。

取扱説明林

Instructionmanual

Contents

PartsList

All manuals and user guides at all-guides.com

ProductFeatures

Contents

-UtilizesOLED(organiclight-emittingdiode)displayforimprovedviewingangles&

brightness.

-Monitorboostpressureinrealtime.3selectabledisplaypatternsforboostpressure

-ByseparatingtheControlunitfromthePowerunit,theProfecgreatlyimprovesthe

installationprocess.

-Additionalﬂushmountingoptionsduetothethin11mmthickdesign.

-180-degreerotatabledisplayscreenforﬂexibilityinthelayoutofcontrolsand

installationoptions.

-High-performancepressuresensorsupportsupto300kPa(43.5psi).

-HighcapacitycompactsolenoidvalveandthenewCPUincreasethespeedofthe

controller.

-Conﬁgurableboostmodes:LO,HI,andSCRAMBLE.

-AdjustableSET%,STARTBOOSTandGAIN%settingsensurestableboostcurves.

-Warningfunctionwhenexceedingthepresetboostvalue.

-Limitercontrolfunction:todecreaseboostwhenabovethealarmsetting.

-Lastboostfunction:toconﬁrmthehighestboostvaluesetinthemostrecentboost

session.

-Peakholdfunction:capableofrecallingthemaximumboostpressurevalue

recorded.

-Datalockfunction:toprotecttheprogrammedsettingsandavoidaccidental

changes.

All manuals and user guides at all-guides.com

・Makesurethatengineiscoolwhenyoubegintheinstallation.



・Makesurethathosesarelongenoughtoreachvalveunit,beforeyoumountit.

・Beforetheinstallation,findthelocationsofwastegate,boostcontrolsolenoid

valve,fuelpressureregulator.

1.Display

2.SELECTswitch

3.MODEswitch

4.SETDIAL

Controlunit

3 4

Powerunit

5.Mountingflange

6.Mainharness

7.BoostPressureSensor

8.Valveunitharnessconnector

Pleasereadcarefully

ProductDescription

BeforeInstallation

Installation

Tools&Instruments

・Multi-meter(Over15Vmeasurementcapability)

・Wirecutters

・+Phillipsand-SlottedScrewdrivers

・Pliers

・10mmwrench

・Wirecutters

・Solderingiron

・Crimpingtool

・Electricaltape

・Spliceconnectors

・Solderingiron

・Cableties

Forthetechnician

Fortheuser

Pleasereturnthismanualtothecustomerwheninstallationandmountingare

completed.

Whenthepersonotherthantheownerusesavehicle,pleasetellhim/herthat

Profecisinstalledandpassthisinstructionmanualtotheperson.

All manuals and user guides at all-guides.com

Inhaltsverzeichnis

Andere Trust Autozubehör Handbücher

Trust

Trust HS-8100 Bedienungsanleitung

Beliebte Autozubehör Handbücher anderer Marken

James Baroud

James Baroud Odyssey Bedienungsanleitung

Motorola

Motorola i50sx Bedienungsanleitung

Yakima

Yakima 9MM STANDARD BIKE MOUNT Bedienungsanleitung

Feniex

Feniex T3 Bedienungsanleitung

Renault

Renault 77 11 423 180 Bedienungsanleitung

Kia

Kia E8300-4D000 Bedienungsanleitung

Brink

Brink 756843 Bedienungsanleitung

Whispbar

Whispbar K085W Bedienungsanleitung

v.link

v.link CI-VL2-PC-HSD Bedienungsanleitung

Viking

Viking Stack-Rack Kurzanleitung zur Einrichtung

Aries

Aries 203015 Bedienungsanleitung

Choetech

Choetech AT0005 Bedienungsanleitung

ZZ2

ZZ2 ZZAIR-PRO Bedienungsanleitung

Holman

Holman 4A80L Bedienungsanleitung

Thule

Thule 2075 Bedienungsanleitung

Motorola

Motorola T325 Bedienungsanleitung

TAUBENREUTHER

TAUBENREUTHER 16-3950 Installationsanleitung

DV8

DV8 FBJL-02 Bedienungsanleitung