Wacker Neuson GV 7000A Bedienungsanleitung

www.wackergroup.com

Generator

GV 7000A

GV 7003A

OPERATOR’S MANUAL

0157387en 004

1106

0157387EN

DANGER

CARBON MONOXIDE

Using a generator indoors CAN KILL YOU IN MINUTES.

Generator exhaust contains carbon monoxide (CO). This is a poison you cannot see or

smell. If you can smell the generator exhaust, you are breathing CO. But even if you cannot

smell the exhaust, you could be breathing CO.

• NEVER use a generator inside homes, garages, crawlspaces, or other partly enclosed

areas. Deadly levels of carbon monoxide can build up in these areas. Using a fan or

opening windows and doors does NOT supply enough fresh air.

• ONLY use a generator outside and far away from windows, doors, and vents. These

openings can pull in generator exhaust.

Even when you use a generator correctly, CO may leak into the home. ALWAYS use a

battery-powered or battery-backup CO alarm in the home.

If you start to feel sick, dizzy, or weak after the generator has been running, move to fresh

air RIGHT AWAY. See a doctor. You could have carbon monoxide poison.

GV 7000A/7003A Table of Contents

wc_bo0157387004enTOC.fm 1

1. Foreword 3

2. Safety Information 4

2.1 Operating Safety .................................................................................. 5

2.2 Operator Safety while using Internal Combustion Engines .................. 6

2.3 Service Safety ...................................................................................... 7

2.4 Label Locations .................................................................................... 8

2.5 Safety and Operating Labels ................................................................ 9

3. Technical Data 11

3.1 Generator ........................................................................................... 11

3.2 Engine ................................................................................................ 13

3.3 Sound Specifications .......................................................................... 13

4. Operation 14

4.1 Determining Power Requirements ..................................................... 14

4.2 Outdoor Installation ............................................................................ 16

4.3 Indoor Installation ............................................................................... 16

4.4 Generator Derating ............................................................................. 17

4.5 Use of Extension Cords ...................................................................... 18

4.6 Grounding the Generator ................................................................... 20

4.7 Operating Heavy Loads ...................................................................... 20

4.8 Control Panel ...................................................................................... 21

4.9 Before Starting ................................................................................... 23

4.10 To Start ............................................................................................... 24

4.11 To Stop ............................................................................................... 24

Table of Contents GV 7000A/7003A

wc_bo0157387004enTOC.fm 2

5. Maintenance 25

5.1 Engine Maintenance ............................................................................25

5.2 Periodic Maintenance Schedule ..........................................................25

5.3 Engine Oil ............................................................................................26

5.4 Air Cleaner ..........................................................................................27

5.5 Spark Plug ...........................................................................................28

5.6 Engine Speed ......................................................................................29

5.7 Storage ................................................................................................30

5.8 Transport .............................................................................................30

5.9 Troubleshooting ...................................................................................31

5.10 Electrical Schematic—GV 7000A ........................................................32

5.11 Electrical Schematic—GV 7003A ........................................................33

Foreword

wc_si000108gb.fm 3

1. Foreword

This manual provides information and procedures to safely operate

and maintain this Wacker model. For your own safety and protection

from injury, carefully read, understand and observe the safety

instructions described in this manual.

Keep this manual or a copy of it with the machine. If you lose this

manual or need an additional copy, please contact Wacker

Corporation. This machine is built with user safety in mind; however,

it can present hazards if improperly operated and serviced. Follow

operating instructions carefully! If you have questions about operating

or servicing this equipment, please contact Wacker Corporation.

The information contained in this manual was based on machines in

production at the time of publication. Wacker Corporation reserves the

right to change any portion of this information without notice.

All rights, especially copying and distribution rights, are reserved.

No part of this publication may be reproduced in any form or by any

means, electronic or mechanical, including photocopying, without

express written permission from Wacker Corporation.

Any type of reproduction or distribution not authorized by Wacker

Corporation represents an infringement of valid copyrights and will be

prosecuted. We expressly reserve the right to make technical

modifications, even without due notice, which aim at improving our

machines or their safety standards.

Safety Information GV 7000A / 7003A

wc_si000108gb.fm 4

2. Safety Information

This manual contains DANGER, WARNING, CAUTION, and NOTE

callouts which must be followed to reduce the possibility of personal

injury, damage to the equipment, or improper service.

This is the safety alert symbol. It is used to alert you to potential

personal injury hazards. Obey all safety messages that follow this

symbol to avoid possible injury or death.

DANGER indicates a hazardous situation which, if not avoided, will

result in death or serious injury.

WARNING indicates a hazardous situation which, if not avoided, could

result in death or serious injury.

CAUTION indicates a hazardous situation which, if not avoided, could

result in minor or moderate injury.

CAUTION: Used without the safety alert symbol, CAUTION indicates

a potentially hazardous situation which, if not avoided, may result in

property damage.

Note: Contains additional information important to a procedure.

DANGER

WARNING

CAUTION

GV 7000A / 7003A Safety Information

wc_si000108gb.fm 5

2.1 Operating Safety

BACKFEED FROM THE GENERATOR INTO THE PUBLIC POWER

DISTRIBUTION SYSTEM CAN CAUSE SERIOUS INJURY OR

DEATH TO UTILITY WORKERS!

Improper connection of generator to a building's electrical system can

allow electrical current from the generator to backfeed into utility lines.

This may result in electrocution of utility workers, fire, or explosion.

Connections to a building's electrical system must be made by a

qualified electrician and comply with all applicable laws and electrical

codes.

If connected to a building's electrical system the generator must meet

the power, voltage, and frequency requirements of the equipment in

the building. Differences in power, voltage, and frequency

requirements may exist and improper connection may lead to

equipment damage, fire, and personal injury or death.

Familiarity and proper training are required for the safe operation of

equipment. Equipment operated improperly or by untrained personnel

can be dangerous. Read the operating instructions contained in both

this manual and the engine manual and familiarize yourself with the

location and proper use of all controls. Inexperienced operators should

receive instruction from someone familiar with the equipment before

being allowed to operate the machine.

2.1.1 NEVER operate the generator when open containers of fuel, paint, or

other flammable liquids are near.

2.1.2 NEVER operate the generator, or tools attached to the generator, with

wet hands.

2.1.3 NEVER use worn electrical cords. Severe electrical shock and

equipment damage may result.

2.1.4 NEVER run the electrical cords under the generator, or over vibrating

or hot parts.

2.1.5 NEVER enclose or cover the generator when it is in use or when it is

hot.

2.1.6 NEVER overload the generator. The total amperage of the tools and

equipment attached to the generator must not exceed the load rating

of the generator.

2.1.7 NEVER operate the machine in snow, rain, or standing water.

2.1.8 NEVER allow untrained personnel to operate or service the generator.

The generator set should be set up by a trained electrician.

2.1.9 ALWAYS store the equipment properly when it is not being used.

Equipment should be stored in a clean, dry location out of the reach of

children.

DANGER

WARNING

Safety Information GV 7000A / 7003A

wc_si000108gb.fm 6

2.1.10 ALWAYS be sure the machine is on a firm, level surface and will not

tip, roll, slide, or fall while operating.

2.1.11 ALWAYS transport the generator in an upright position.

2.1.12 ALWAYS keep the machine at least one meter (three feet) away from

structures, buildings, and other equipment during use.

2.1.13 ALWAYS keep the area immediately surrounding and underneath the

machine clean, neat, and free of debris and combustible materials.

Make sure that the area overhead is clear of debris that could fall onto

or into the machine or exhaust compartment.

2.1.14 ALWAYS remove all tools, cords, and other loose items from the

generator before starting it.

2.1.15 DO NOT ground this generator.

2.2 Operator Safety while using Internal Combustion Engines

Internal combustion engines present special hazards during operation

and fueling. Read and follow the warning instructions in the engine

owner’s manual and the safety guidelines below. Failure to follow the

warnings and safety guidelines could result in severe injury or death.

2.2.1 DO NOT run the machine indoors or in an enclosed area such as a

deep trench unless adequate ventilation, through such items as

exhaust fans or hoses, is provided. Exhaust gas from the engine

contains poisonous carbon monoxide gas; exposure to carbon

monoxide can cause loss of consciousness and may lead to death.

2.2.2 DO NOT smoke while operating the machine.

2.2.3 DO NOT smoke when refueling the engine.

2.2.4 DO NOT refuel a hot or running engine.

2.2.5 DO NOT refuel the engine near an open flame.

2.2.6 DO NOT spill fuel when refueling the engine.

2.2.7 DO NOT run the engine near open flames.

2.2.8 DO NOT start the engine if fuel has spilled or a fuel odor is present.

Move the generator away from the spill and wipe the generator dry

before starting.

2.2.9 ALWAYS refill the fuel tank in a well-ventilated area.

2.2.10 ALWAYS replace the fuel tank cap after refueling.

2.2.11 ALWAYS check the fuel lines and the fuel tank for leaks and cracks

before starting the engine. Do not run the machine if fuel leaks are

present or the fuel lines are loose.

DANGER

GV 7000A / 7003A Safety Information

wc_si000108gb.fm 7

2.3 Service Safety

Poorly maintained equipment can become a safety hazard! In order

for the equipment to operate safely and properly over a long period of

time, periodic maintenance and occasional repairs are necessary. If

the generator is experiencing problems or is being serviced, attach a

“DO NOT START” sign to the control panel to notify other people of its

condition.

2.3.1 DO NOT use gasoline or other types of fuels or flammable solvents to

clean parts, especially in enclosed areas. Fumes from fuels and

solvents can become explosive.

2.3.2 DO NOT attempt to clean or service the machine while it is running.

2.3.3 DO NOT modify the equipment without the express written approval of

the manufacturer.

2.3.4 DO NOT allow water to accumulate around the base of the machine.

If water is present, move the machine and allow the machine to dry

before servicing.

2.3.5 DO NOT service the machine if your clothing or skin is wet.

2.3.6 DO NOT allow untrained personnel to service this equipment. Only

trained electrical technicians should be allowed to service the electrical

components of this equipment.

2.3.7 ALWAYS keep the machine clean and labels legible. Replace all

missing and hard-to-read labels. Labels provide important operating

instructions and warn of dangers and hazards.

2.3.8 ALWAYS replace the safety devices and guards after repairs and

maintenance.

2.3.9 ALWAYS let the engine cool before transporting or servicing it.

2.3.10 ALWAYS keep hands, feet, and loose clothing away from the moving

parts on the generator and engine.

2.3.11 ALWAYS turn the engine off before servicing the machine. If the

engine has electric start, disconnect the negative terminal on the

battery before servicing the machine.

2.3.12 ALWAYS keep the fuel lines in good condition and properly connected.

Leaking fuel and fumes are extremely explosive.

WARNING

Safety Information GV 7000A / 7003A

wc_si000108gb.fm 8

2.4 Label Locations

wc_gr001298

PETROL

GASOLINA

ISSINCI

BENZIN

CALDO !

HEISS !

HOT !

CHAUD !

DANGER

GEFAHR

PELIGRO

DANGER

GEFAHR

PELIGRO

DANGER

Andere Handbücher für GV 7000A

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Wacker Neuson Tragbarer Generator Handbücher

Wacker Neuson

Wacker Neuson GP 5600A Bedienungsanleitung

Wacker Neuson

Wacker Neuson GP 4000 Bedienungsanleitung

Wacker Neuson

Wacker Neuson GP 2500A Bedienungsanleitung

Wacker Neuson

Wacker Neuson G 25 Bedienungsanleitung

Wacker Neuson

Wacker Neuson G 100 Bedienungsanleitung

Wacker Neuson

Wacker Neuson GPS9700A Bedienungsanleitung

Wacker Neuson

Wacker Neuson G50 Bedienungsanleitung

Wacker Neuson

Wacker Neuson GP 5600A Bedienungsanleitung

Wacker Neuson

Wacker Neuson G70 Bedienungsanleitung

Wacker Neuson

Wacker Neuson GV 2500A Betriebsanleitung

Wacker Neuson

Wacker Neuson GPS 9700 Betriebsanleitung

Wacker Neuson

Wacker Neuson GH 3500 Bedienungsanleitung

Wacker Neuson

Wacker Neuson GP 3800A Bedienungsanleitung

Wacker Neuson

Wacker Neuson GP 6600A Bedienungsanleitung

Wacker Neuson

Wacker Neuson GP 2500A Bedienungsanleitung

Wacker Neuson

Wacker Neuson GV 3800A Bedienungsanleitung

Wacker Neuson

Wacker Neuson GPi 1700 Bedienungsanleitung

Wacker Neuson

Wacker Neuson GS 12Ai Bedienungsanleitung

Wacker Neuson

Wacker Neuson GS 5.6A Bedienungsanleitung

Wacker Neuson

Wacker Neuson GV 5000A Bedienungsanleitung

Wacker Neuson

Wacker Neuson G 14 Bedienungsanleitung

Wacker Neuson

Wacker Neuson GP 3800A Bedienungsanleitung

Wacker Neuson

Wacker Neuson GPS 5600A Bedienungsanleitung

Wacker Neuson

Wacker Neuson GV 5000A Bedienungsanleitung

Beliebte Tragbarer Generator Handbücher anderer Marken

Kohler

Kohler 20EORZ Bedienungsanleitung

Powerhorse

Powerhorse 83171 Bedienungsanleitung

HURST

HURST ML-630-SI Bedienungsanleitung

ETQ

ETQ TG4000 Bedienungsanleitung

Briggs & Stratton

Briggs & Stratton 40265 Einrichtungshandbuch

ConMed

ConMed 7550 Bedienungsanleitung

Owon

Owon Waveform Generator Bedienungsanleitung

evertz

evertz 7700 Series Bedienungsanleitung

Power Stroke

Power Stroke PS906025 Bedienungsanleitung

Firefly

Firefly Cygnus CYG2400/460/24 Bedienungsanleitung

Draper

Draper PG950S Firmware-Update

PowerBoss

PowerBoss PowerBoss Bedienungsanleitung

SDMO

SDMO SH 4000 Bedienungsanleitung

EINHELL

EINHELL STE 5500 Bedienungsanleitung

Wanco

Wanco WI3000P Bedienungsanleitung

Full Boar

Full Boar FBT-3300 Bedienungsanleitung

Dwyer Instruments

Dwyer Instruments ASG Bedienungsanleitung

Westinghouse

Westinghouse WH1000i Series Bedienungsanleitung