Weltem Americool HPC-3000 Bedienungsanleitung

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

Owner’s Manual

MODEL : HPC-3000 / HPC-5000 /

WPC-7000 / WPC-9000 / WPC-15000

Please read and save these instructions. Read carefully before attempting to assemble,

install, operate or maintain the product described.

Protect yourself and others by observing all safety information. Failure to comply with

instructions could result in personal injury andlor property damage! Retain instructions

for future reference.

AmeriCool by Weltem Portable Air Condioners feature spot cooling for large

areas where cooling of the enre area is not praccal. A dedicated spot cooling

thermostat controls the unit in this applicaon. These air condioners can also

be used in smaller areas for room cooling.

A control panel provides ease of use and contains a self-diagnosc funcon and

display, showing operang modes, room and set temperatures, and faults. If an

abnormal operaon occurs, a visual display of the fault is shown. Caster wheels

are included for easy portability. Suitable applicaons include: a factory or work

place, industrial kitchen, computer room, emergency cooling, outdoor event, etc.

Aer unpacking the unit, carefully inspect unit for any damage that may

have occurred during transit. Check for any loose, missing, or damaged parts.

Descripon

Unpacking

Portable Air Conditioners

HPC-3000

HPC-5000 WPC-7000

WPC-9000

WPC-15000

page 2

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

Table of Contents

IMPORTANT SAFETY INSTRUCTIONS...........................................................4

INTRODUCTION..........................................................................................6

PRODUCT DESCRIPTION.............................................................................6

ASSEMBLY(HPC-3000).................................................................................7

Component Parts

Power Cord Holder

Discharge Ducts / Supply Air Duct

Exhaust Flange(Oponal)

Ambient Air Adapters(Oponal)

ASSEMBLY(HPC-5000).................................................................................8

Component Parts

Power Cord Holder

Rubber Stoppers

Discharge Ducts / Supply Air Duct

Exhaust Flange(Oponal)

Ambient Air Adapters(Oponal)

ASSEMBLY(WPC-7000,9000)......................................................................9

Component Parts

Power Cord Holder

Top Fan Exhaust Flange

Discharge Ducts / Supply Air Duct

Ambient Air Adapters(Oponal)

ASSEMBLY(WPC-15000)............................................................................10

Component Parts

Power Cord Holder

Discharge Ducts / Supply Air Duct

Exhaust Flange

Ambient Air Adapters(Oponal)

INSTALLATION GUIDE...............................................................................11

Moving the Unit

Plugging in the Unit

OPERATION..............................................................................................13

Control Panel

page 3

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

Thank you for selecng this AmeriCool by Weltem Portable Air Condioner.

It provides you with spot cooling for large areas where cooling of an enre

area is not praccal or possible. Please read this manual before installing

the HPC-3000, HPC-5000, WPC-7000, WPC-9000 or WPC-15000 as it pro-

vides important informaon that should be followed during installaon

and maintenance of the Portable Air Condioner, allowing you to correct-

ly set up your system for the maximum safety and performance. Included

is informaon on customer support and service, if it is required. If you

experience a problem with the unit, please refer to the Troubleshoong

secon in this manual to correct the problem. If the problem is not cor-

rected, please collect informaon so that the Technical Support personnel

can more eﬀecvely assist you.

MAINTENANCE.............................................................................................14

Filter Cleaning

Spring Replacement

TROUBLESHOOTING.....................................................................................17

Alarm Codes

Troubleshoong Chart

SPECIFICATIONS............................................................................................20

WIRING DIAGRAM........................................................................................22

SHIPPING LIST...............................................................................................25

OBTAINING SERVICE.....................................................................................25

LIMITED WARRANTY.....................................................................................27

page 4

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

IMPORTANT SAFETY INSTRUCTIONS:

(SAVE THESE INSTRUCTIONS)

Please read this manual carefully for instrucons on correct installaon and

usage. Please read all safety instrucons.

1. Transport and store the unit in an upright posion only. Leave the unit in an

upright posion for at least 3 hours before use.

2. Always place the unit on an even, level surface.

3. Ensure the unit is connected to a grounded ulity of the correct rang / capacity.

4. The unit will cool when the room temperature is between 64.4°F - 113°F (18°C

- 45°C) depending on the thermostat seng.

5. DO NOT use this unit for funcons other than those described in this User’s

Manual.

6. DO NOT lt the unit.

7. DO NOT cover or obstruct the unit’s inlet and/or outlet grilles.

8. DO NOT use the unit in areas where it will be exposed to rain or water.

9. NEVER unplug the unit while it is operang

10. DO NOT place any foreign objects on the unit.

11. DO NOT operate the unit with wet or damp hands.

12. DO NOT allow chemical substances to come in contact with the unit.

13. DO NOT operate the unit in the presence of ﬂammable substances or vapors

such as alcohols, pescides, gasoline, etc.

14. DO NOT use the plug to start or to stop the unit. Always use the control panel

to start and to stop the unit.

15. Always turn oﬀ the unit when it is not in use, and unplug the power plug from

the electrical outlet.

DO NOT use the unit in wet environments, such as a

laundry room, to avoid risk of electrical shock

DO NOT operate the unit in explosive or ﬂammable

environments

WARNING

page 5

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

16. Always turn the unit oﬀ and unplug the main power plug from the electrical

outlet before cleaning, moving, or performing maintenance.

17. AVOID the use of adapter plugs or extension cords. If it is necessary to use an

extension cord or an adapter plug to operate the unit, ensure that they are

correctly rated for the applicaon. Consult local qualiﬁed electrician and all

local electrical codes to ensure proper setup. Any extension cord used with

the device must be rated for a minimum of 15A.

18. DO NOT unplug the unit by pulling on the electrical cord. Keep the electrical

cord away from heat sources and always completely unroll the cord to avoid

overheang. If the power cord becomes damaged, a qualiﬁed service agent,

qualiﬁed electrician, or similarly qualiﬁed person must replace it, in order to

avoid a hazard or shock.

19. The ﬁlters must be used with the product at all mes. When the ﬁlters are

removed for cleaning, always ensure that the unit has been turned oﬀ and

unplugged from the electrical outlet.

20. Regularly clean the ﬁlters to maintain eﬃciency. If the ﬁlters are not cleaned

regularly, the units output performance and eﬃciency will decline and en-

ergy consumpon will increase.

21. DO NOT operate the unit with a damaged power cord or plug, aer it mal-

funcons, or if the unit has been dropped or damaged.

22. Only use the unit in the upright posion on a even, ﬂat surface. Unit must be

posioned at least 24 inches (60 cm) from the nearest object in any direc-

on.

23. Stop operaon immediately if abnormal noise or odor is noced. Contact

local service center.

DO NOT operate a unit with a damaged power cord

WARNING

page 6

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

INTRODUCTION

PRODUCT DESCRIPTION

The informaon provided in this manual covers 13,200 – 60,000 BTU/

HR AmeriCool by Weltem Portable Air Condioners, their basic funcons,

operang procedures, opons available and emergency situaons. It also

includes informaon on how to ship, store, handle, and install the equip-

ment. Only detailed requirements of the Weltem Americool Portable Air

Condioners are described herein, and installaon must be carried out

in accordance with this manual. Electrical installaon must also carefully

follow local legislaon and regulaons. Only qualiﬁed personnel should

conduct these installaons as failure to acknowledge electrical hazards

could prove to be fatal.

AmeriCool by Weltem Portable Air Condioners feature spot cooling for

large areas where cooling of the enre area is not praccal or pos-

sible. A dedicated spot cooling thermostat controls the unit in this

applicaon. These air condioners can also be used in smaller areas

for room cooling.

A control panel provides ease of use and contains self-diagnosc

funcons and displays, showing operang modes, room and set tem-

peratures, and faults. If an abnormal operaon occurs, a visual display

of the fault is shown.

Caster wheels are included for ease of portability.

Suitable applicaons include: factory or work place, industrial kitchen,

computer room, emergency cooling, outdoor event, etc.

page 7

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

ASSEMBLY(HPC-3000)

Cool air outlet hose

Display / Control board

Top fan wire grille

Evaporator / ﬁlter

Guide bar for

condensate

water tank

Figure 1 – Front and Right Side View

Condenser / ﬁlter

Figure 2 – Rear and Le Side View

Power cord holder

Electrical access panel

Casters

Figure 3 – Power Cord Holder aachment

Figure 4 – Cool Air Outlet aachment

Figure 5

Figure 6

An exhaust ﬂange can be purchased

separately. Exhaust ﬂange ﬁts over

the top exhaust fan duct improving

cooling eﬃciency, allowing hot air to

be exhausted to another locaon.

1. Remove exhaust ﬂange from carton.

2. Place exhaust ﬂange on the top of

air condioner.

3. Use screws (enclosed inside of box

with exhaust ﬂange) to install

exhaust ﬂange on air condioner as

shown in Figure 5.

An ambient air adapter can be

purchased separately. Air adapter

ﬁts over the condenser to duct

condenser air to the unit to

improve cooling eﬃciency.

1. Remove air adapter from carton.

2. Place air adapter on the side of

air condioner.

3. Use screws (enclosed inside of

box with air adapter) to install

the adapter on the air

condioner as shown in Figure 6.

1. Remove the power cord

holder from the accessory pack

2. Place the power cord holder

on the rear of the unit as shown

in Figure 3

3. Use screws to install the power

cord holder to the rear of the unit

(screws inside the accessory pack)

1. Remove the cool air outlet

hose from the box

2. Place the cool air outlet

hose on the front top of the

unit as shown in Figure 4

3. Use screws to install the cool

air outlet hose to the front of

the unit (screws aached to

the cool air outlet hose)

Condensate water tank

(Water level is sensed, and

the unit operaon is

stopped when tank is full.

An alarm will be displayed.

Empty the tank and replace

to resume operaon)

Component Parts

Power Cord Holder Discharge Ducts /

Supply Air Duct

EXHAUST FLANGE(Oponal) AMBIENT AIR ADAPTER

(Oponal)

page 8

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

ASSEMBLY(HPC-5000)

Figure 12

Figure 8 – Rear and Le Side View

Rubber stoppers

Condenser / ﬁlter

Power cord holder

Casters

Electrical

access panel

Cool air outlet hose

Display / Control board

Top fan wire grille

Guide bar for

condensate

water tank

Figure 7 – Front and Right Side View

Evaporator / ﬁlter

Condensate water tank

(Water level is sensed, and

the unit operaon is

stopped when tank is full.

An alarm will be displayed.

Empty the tank and

replace to resume

operaon)

Figure 9 – Power Cord Holder aachment

1. Remove the power cord

holder from the accessory

pack

2. Place the power cord

holder on the rear of the

unit as shown in Figure 8

3. Use screws to install the

power cord holder to the

rear of the unit (screws

inside the accessory pack)

1. Remove the rubber stoppers

from the accessory pack

2. Place the rubber stoppers on

the rear of the unit as shown in

Figure 10

3. Use screws to install the

rubber stoppers to the rear of

the unit (screws inside the

accessory pack)

Figure 10 – Rubber Stopper aachment

An exhaust ﬂange can be purchased

separately. Exhaust ﬂange ﬁts over the top

exhaust fan duct improving cooling

eﬃciency, allowing hot air to be exhausted

to another locaon.

1. Remove exhaust ﬂange from carton.

2. Place exhaust ﬂange on the top of air

condioner.

3. Use screws (enclosed inside of box with

exhaust ﬂange) to install exhaust ﬂange

on air condioner as shown in Figure 12.

ure 11 – Cool Air Outlet aachment

1. Remove the cool air outlet

hose(s) from the box

2. Place the cool air outlet hose(s)

on the front top of the unit as

shown in Figure 11

3. Use screws to install the cool air

outlet hose(s) to the front of the

unit (screws aached to the cool

air outlet hose)

Component Parts

Power Cord Holder Rubber Stoppers

Discharge Ducts /

Supply Air Duct EXHAUST FLANGE (Oponal)

page 9

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

ASSEMBLY(WPC-7000,9000)

Cool air outlet hose

Front and Right Side View

Display / Control board

Top fan exhaust ﬂange

Evaporator / ﬁlter

Guide bar for condensate water tank

Condensate water tank (Water level is

sensed, and the unit operaon is stopped

when tank is full. An alarm will be

displayed. Empty the tank and replace to

resume operaon)

Figure 15

Figure 14

Figure 16

Back and Le Side View

Condenser / ﬁlter

Power cord holder

Caster

Electrical access

panel

Figure 17

1. Take out the cord holder from

the accessory box.

2. Place the cord holder on the

back side of air condioner.

3. Use screws (enclosed inside of

accessory box with cord holder)

to install the cord holder on the

air condioner as shown in

Figure 16.

1. Remove the top fan exhaust

ﬂange from carton.

2. Place the top fan exhaust ﬂange

on the top of air condioner.

3. Use screws (enclosed inside of

box with the top fan exhaust

ﬂange) to install the top fan

exhaust ﬂange on air condioner

as shown in Figure 17.

Component Parts

POWER CORD HOLDER TOP FAN EXHAUST FLANGE

Figure 13

AMBIENT AIR ADAPTER (Oponal)

An ambient air adapter can be purchased separately. Air adapter ﬁts over the

condenser to duct condenser air to the unit to improve cooling eﬃciency.

1. Remove air adapter from carton.

2. Place air adapter on the rear of air condioner.

3. Use screws (enclosed inside of box with air adapter) to install the adapter

on the air condioner as shown in Figure 13.

page 10

Owner’s Manual

HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000

Figure 18 Figure 19

1. Remove cool air outlet hose(s) from

carton.

2. Place the cool air outlet hose(s) on

the front top of air condioner.

3. Use screws (enclosed inside of box

with cool air outlet hose(s) to install

the cool air outlet hose(s) on the air

condioner as shown in Figure 18.

An ambient air adapter can be

purchased separately. Air adapter ﬁts

over the condenser to duct

condenser air to the unit to improve

cooling eﬃciency.

1. Remove air adapter from carton.

2. Place air adapter on the side of air

condioner.

3. Use screws (enclosed inside of box

with air adapter) to install the

adapter on the air condioner as

shown in Figure 19.

DISCHARGE DUCTS

/SUPPLY AIR DUCT

AMBIENT AIR ADAPTER

(Oponal)

Cool air outlet

Front and Right Side View

Display / Control board

Top fan exhaust ﬂange

Evaporator / ﬁlter Condenser / ﬁlter

Figure 21

Figure 20

Figure 22

Figure 23

Back and Le Side View

Condenser / ﬁlter

Power cord holder

Caster

Electrical access panel

Drain pump hose connector

Handle

Drain pump included

1. Remove cool air outlet hose(s) from

carton.

2. Place the cool air outlet hose(s) on

the front top of air condioner.

3. Use screws (enclosed inside of box

with cool air outlet hose(s) to install

the cool air outlet hose(s)

on the air condioner as shown in

Figure 23.

1. Take out the cord holder

from the accessory box.

2. Place the cord holder on

the back side of air condioner.

3. Use screws (enclosed inside of

accessory box ith cord

holder)to install the cord

holder on the air condioner

as shown in Figure 22.

POWER CORD HOLDER DISCHARGE DUCTS

/SUPPLY AIR DUCT

Component Parts

ASSEMBLY(WPC-15000)

Andere Handbücher für Americool HPC-3000

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Weltem Klimaanlage Handbücher

Weltem

Weltem AmeriCool WPC-23000 Bedienungsanleitung

Weltem

Weltem WPC-3000 Bedienungsanleitung

Weltem

Weltem Americool HPC-3000 Bedienungsanleitung

Weltem

Weltem Icen WPC-9000 Bedienungsanleitung

Weltem

Weltem AmeriCool WMC-2500 Bedienungsanleitung

Weltem

Weltem Icen WPC-7000 Bedienungsanleitung

Weltem

Weltem Icen WPC-23000 Bedienungsanleitung

Weltem

Weltem WPW-4000 Bedienungsanleitung

Weltem

Weltem WPC-3000N Bedienungsanleitung

Weltem

Weltem WPC-6000 Bedienungsanleitung

Weltem

Weltem WSC-4000 Bedienungsanleitung

Weltem

Weltem AmeriCool WPC-18000 Bedienungsanleitung

Weltem

Weltem AMERICOOL WPC-36003 Bedienungsanleitung

Weltem

Weltem AMERICOOL Bedienungsanleitung

Weltem

Weltem WPC-5000 Bedienungsanleitung

Weltem

Weltem WPC-4000 Bedienungsanleitung

Weltem

Weltem WPW-4000 Bedienungsanleitung

Beliebte Klimaanlage Handbücher anderer Marken

Spheros

Spheros CC 355 Bedienungsanleitung

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Bedienungsanleitung

Panasonic

Panasonic CS-E12HKEW Bedienungsanleitung

nedis

nedis ACMB1WT7 Bedienungsanleitung

Samsung

Samsung AR KV Series Leitfaden

Daikin

Daikin FCFV50A Bedienungsanleitung

Fujitsu

Fujitsu Inverter ASBA30JFC Bedienungsanleitung

Toshiba

Toshiba RAS-M10SMUV-E Bedienungsanleitung

Daikin

Daikin FXLQ20MAVE Bedienungsanleitung

Hitachi

Hitachi RAS-E24CAK Bedienungsanleitung

CIAT

CIAT Magister 2 Series Leitfaden

Bestron

Bestron AAC6000 Bedienungsanleitung

Hisense

Hisense 7K Technisches Handbuch

Frigidaire

Frigidaire FFRE0533S1E0 Bedienungsanleitung

Samsung

Samsung AS09HM3N Bedienungsanleitung

Frigidaire

Frigidaire CRA073PU11 Betriebsanleitung

Soleus Air

Soleus Air GB-PAC-08E4 Bedienungsanleitung

McQuay

McQuay MCK020A Bedienungsanleitung