Whalen Shelby WSF72SY26C Bedienungsanleitung

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION.

PLEASE READ AND KEEP FOR FUTURE REFERENCE.

Date 2019-04-22 Rev. 0001-A

Shelby 72in Fireplace

Model # WSF72SY26C

# WSF72SY26M

ADULT ASSEMBLY REQUIRED

If you have any questions regarding assembly or if parts are missing, DO NOT return this item to the

store where it was purchased. Please call our toll-free customer service number and have your

instructions and parts list ready to provide the model name, part name or factory number:

1-866-942-5362

Pacific Standard Time: 8:30 a.m. - 4:30 p.m., Monday - Friday

Or visit our website www.whalenfurniture.com

Or e-mail your request to: parts@whalenfurniture.com

LOT NUMBER:

DATE PURCHASE

QUALITY GUARANTEE

We are confident that you will be delighted with your Whalen Furniture purchase.

Should this product be defective in workmanship or materials or fail under normal use, we will repair or

replace it for up to one (1) year from date of purchase. Every Whalen Furniture product is designed to meet

your highest expectations. We guarantee that you will immediately see the value of our fine furniture.

This warranty gives you specific legal rights and you may also have other rights which vary from State to State.

Customer Service: 1-866-942-5362

8:30 a.m. - 4:30 p.m., PST, Monday to Friday

www.whalenfurniture.com

MANUFACTURER: Whalen Furniture Manufacturing

CATALOG : Shelby 72in Fireplace

MODEL #: WSF72SY26C / WSF72SY26M

MADE IN CHINA

M A X I M U M R E C O M M E N D E D W E I G H T L O A D S

Place TV behind the stopper

Fits up to most 203.2 cm / 80 in. flat panel TVs

Maximum load 61.2 kg / 135 lb

Maximum load 22.7 kg / 50 lb

THIS UNIT IS NOT INTENDED FOR USE WITH CRT TVS. USE ONLY WITH FLAT

PANEL TVS AND AUDIO/VIDEO EQUIPMENT MEETING RECOMMENDED SIZE AND WEIGHT LIMITS.

NEVER USE WITH LARGER/HEAVIER THAN RECOMMENDED FLAT PANEL TVS OR EQUIPMENT. TO

AVOID INSTABILITY, PLACE FLAT PANEL TV IN THE CENTRE OF THE UNIT; THE BASE OF THE

TELEVISION MUST BE ABLE TO REST ON THE SUPPORTING SURFACE OF THE UNIT WITHOUT

OVER-HANGING THE EDGES. IMPROPERLY POSITIONED FLAT PANEL TVS, OR FLAT PANEL TVS

OR OTHER EQUIPMENT THAT EXCEED RECOMMENDED SIZE AND WEIGHT LIMITS COULD FALL

OFF OR BREAK THE UNIT, CAUSING POSSIBLE SERIO

US INJURY.

IMPORTANT

Before you begin: Open, identify and count all parts prior to assembly. Lay out parts on a flat and non-

abrasive surface. You will need the parts identified on page 4 and 5 of this instruction manual.

NOTE: IT IS VERY IMPORTANT TO USE GLUE WITH THE DOWELS. EXCESS GLUE CAN BE

WIPED OFF WITH A DAMP CLOTH.

Insert Dowel at least half way by tapping lightly with a rubber mallet (not included), IF NECESSARY.

CAM LOCK SYSTEM OPERATION

HOW THE KNOCK DOWN (KD) ASSEMBLY SYSTEM WORKS

1. Screw the Cam Bolt into the pre-drilled small holes on the panel. Connect both panels together; making sure

the Cam Bolt goes into the pre-drilled hole at the end of the panel with the Cam Lock.

2. Insert the Cam Lock into the pre-drilled large hole in the panel. Make sure the arrow on the Cam Lock is

pointed towards the Cam Bolt.

3. Once the Cam Bolt is connected inside the Cam Lock, take a Phillips screwdriver (not included) and

tighten the Cam Lock clockwise.

4. Plug the Cam Lock Cover into the cross slot of the Cam Locks to conceal the cam.

You are now ready to assemble the KD unit.

FINAL

1 2 43

Parts and Hardware List

Please read completely through the instructions and verify that all listed parts and hardware are present

before beginning assembly.

A- Top Panel (Qty. 1) B- Fixed Shelf (Qty. 1) C- Bottom Panel (Qty. 1

)

D- Left Side Panel (Qty. 1) E- Right Side Panel (Qty. 1) F- Left Lower Partition (Qty. 1)

G- Right Lower Partition (Qty. 1) H- Upper Partition (Qty. 1) I- Middle Crossbar Assembly (Qty. 1)

J- Middle Left Stile (Qty. 1) K- Middle Right Stile (Qty. 1) L- Base Front Molding (Qty. 1)

M- Left Bottom Molding (Qty. 1) N- Right Bottom Molding (Qty. 1) O- Base Rear Stretcher (Qty. 1)

P- Base Front Stretcher (Qty. 1) Q- Door (Qty. 2) R- Door Glass Insert (Qty. 2)

S- Adjustable Shelf (Qty. 2) T- Upper Back Panel (Qty. 1) U- Lower Back Panel (Qty. 2)

Parts and Hardware List

Please read completely through the instructions and verify that all listed parts and hardware are

present before beginning assembly.

V- Firebox Support (Qty. 1) Fireplace Insert (Qty. 1) Remote control with battery (Qty. 1)

(1) Cam Lock (2) Cam Bolt (3) M8 x 30 mm Wood Dowel (4) #8 x 1-1/2” Screw

(Qty. 39+1 extra) (Qty. 39+1 extra) (Qty. 48+2 extra) (Qty. 32+1 extra)

(5) Acrylic Stopper (6) #8 x 1” Screw (7) #3 x 5/8” Black Screw (8) #3 x 5/8” Washer Head Screw

(Qty. 1) (Qty. 2) (Qty. 4+1 extra) (Qty. 35+1 extra)

(9) #4 x 5/8” Zinc Screw (10) 2” Self-tapping Screw (11) Metal Bracket (12) Cam Lock Cover

(Qty. 24+1 extra) (Qty. 2+1 extra) (Qty. 2) (Qty. 20+1 extra)

(13) Shelf Support (Qty. 8+1 extra) (14) Knob (Qty. 2) (15) 28 mm Knob Bolt (Qty. 2)

(16) Rubber Bumper (Qty. 4+1 extra) (17) Hinge (Qty. 4) Glue (Qty. 1)

Touch-up Pen (Qty. 1) Tipping Restraint Hardware Kit (Qty. 2)

(Included in plastic bag)

Tools required (not included): Phillips screwdriver, stud finder, power drill, pencil, measure tape, and 3

mm/0.1 drill bit.

Assembly Instructions

1. Unpack the unit and confirm that you have all the hardware and required parts. Assemble the unit on a

carpeted floor or the empty carton to avoid any scratch.

2. Securely screw the Cam Bolts (2) into the designated small holes on the Fixed Shelf (B), Bottom Panel

(C), Lower Partitions (F and G) using a Phillips screwdriver, as shown in the illustration.

3. Insert two Wood Dowels (3) into the inner holes of the Middle Crossbar Assembly (I). Tap in with a

rubber mallet, if necessary. Make sure that you use a small amount of glue with both ends of all dowels.

4. Align the drilled holes on the Fixed Shelf (B) with the inserted Wood Dowel (3) on the Middle Crossbar

Assembly (I), and then press them together. Attach the Middle Crossbar Assembly (I) in place by

engaging three Cam Locks (1) (Refer to page 3 on Cam Lock system operation supplement).

Assembly Instructions

5. Align and attach the Base Rear Stretcher (O) to the Bottom Panel (C) with three wood dowels (3) and

four cam locks (1), as shown.

6. Align and attach the Middle Left Stile (J) to the Left Lower Partition Panel (F) by using two Wood

Dowels (3) and three Cam Locks (1).

7. Repeat last step to combine the Middle Right Stile (K) with the Right Lower Partition Panel (G)

together.

Assembly Instructions

8. Glue four Wood Dowels (3) into the inner holes of the Lower Partition Panels (F and G) and attach

them to the Fixed Shelf (B) by engaging four Cam Locks (1).

9. Glue four Wood Dowels (3) into the bottom holes of the Lower Partition Panels (F and G) and position

the Bottom Panel (C) onto the inserted Wood Dowels (3). Attach the Bottom Panel (C) in place with

four 1-1/2” Wood Screws (4).

Assembly Instructions

10. Securely screw the Cam Bolts (2) into the designated small holes on the Left and Right Side Panels (D

and E) using a Phillips screwdriver.

11. Glue three Wood Dowels (3) into the inner holes on the Left Bottom Molding (M) and fasten it to the

Left Side Panel (D) with six 1-1/2” Wood Screws (4).

12. Repeat last step to combine the Right Bottom Molding (N) with the Right Side Panel (E) together.

Assembly Instructions

13. Glue ten Wood Dowels (3) into the large holes on the Bottom Panel (C), Base Rear Stretcher (O) and

Fixed Shelf (B) at both ends.

14. Align the large holes on the Left Side Panel (D) with the inserted Wood Dowels (3). Firmly press them

together and fasten it in place by engaging five Cam Locks (1).

15. Repeat last step to attach Right Side Panel (E) at the other end.

16. Align and attach the Base Front Stretcher (P) to the Bottom Panel (C) with three wood dowels (3) and

four cam locks (1) as shown.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Whalen Kamin im Innenbereich Handbücher

Whalen

Whalen SF122B-26A Bedienungsanleitung

Whalen

Whalen FP32EC23I-1BC Bedienungsanleitung

Whalen

Whalen WSF48FM23R-AO Bedienungsanleitung

Whalen

Whalen Middleton WSF32WV23-DB Bedienungsanleitung

Whalen

Whalen Middleton WSF60WV23-DB Bedienungsanleitung

Whalen

Whalen WMFP60FH-14 Bedienungsanleitung

Whalen

Whalen Glenmore WS03061226 Bedienungsanleitung

Whalen

Whalen Middleton WSF48WV23-DB Bedienungsanleitung

Whalen

Whalen Evanston MNFP60ES26GA Bedienungsanleitung

Whalen

Whalen Shelby WSF36SY23C Bedienungsanleitung

Whalen

Whalen Linwood MNFP48LW23IO Bedienungsanleitung

Whalen

Whalen WMFP54HL-23 Bedienungsanleitung

Whalen

Whalen Evanston MNFP48ES23GA Bedienungsanleitung

Whalen

Whalen Barston WMFP48EC-25DC Bedienungsanleitung

Whalen

Whalen Bookcase Media Fireplace Bedienungsanleitung

Whalen

Whalen Ashton MNFP54AS-18 Bedienungsanleitung

Whalen

Whalen WSLWFP54-6 Bedienungsanleitung

Whalen

Whalen SUMCMF-23 Bedienungsanleitung

Whalen

Whalen WMFP48FH-10-KD Bedienungsanleitung

Whalen

Whalen Farmstead WSF60FM23R-AO Bedienungsanleitung

Whalen

Whalen Millstead WSF60MS26GAO Bedienungsanleitung

Whalen

Whalen MNFP60PV26WT Bedienungsanleitung

Whalen

Whalen Barston Laminated Fireplace Handbuch

Whalen

Whalen WSF36SH23C Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch