Advantech MIO-5375 Installations- und Betriebshandbuch

MIO-5375 Startup Manual 1

Before you begin installing your board, please make sure

that the following items have been shipped:

• 1 x MIO-5375 SBC

• 1 x SATA cable 30cm (P/N: 1700006291)

• 1 x SATA power cable 35cm (P/N: 1700031583-01)

• 1 x USB2.0 cable 20cm (P/N: 1700030406-01)

• 1 x Audio cable 20cm (P/N: 1700019584-01)

• 2 x COM RS-232/422/485 cable 20cm (P/N: 1700030404-

01)

• 2 x COM RS-232 cable 20cm (P/N: 1700031582-01)

• 1 x Cooler (heatsink) (P/N:1970004884T001/

1970004794T001)

• 1 x Startup manual (P/N: 2046537500)

• 1 x Mini jumper (10pcs package)

• 1 x Screw kit (2 x sets screws and post for M.2 device & 4

setsofscrewsandstand-o󰀨)

• 1 x DeviceOn package

If any of these items are missing or damaged, please con-

tact your distributor or sales representative immediately.

General

• CPU:

- Intel®Core™ i7-1185G7E (Quad-Core, 4.40 GHz)

- Intel®Core™ i5-1145G7E (Quad-Core, 4.10 GHz)

- Intel®Core™ i3-1115G4E (Quad-Core, 3.90 GHz)

• Systemmemory: Dual Channel/SODIMM DDR4-3200

MT/s, up to 64 GB

• BIOS: AMI EFI 256Mbit

• Watchdogtimer:65536 level, 0~65535 sec

MIO-5375 3.5” MI/O-Compact SBC, 11th Gen.

Intel®Core™ U-series (i7/i5/i3/Celeron®)

Startup Manual

• TPM2.0

• iManager3.0:Yes

• Expansioninterface:

- M.2:

1 x E-Key 2230 (PCIe x1, USB2.0)

1 x B-Key 3042 (USB2.0) w/Nano-SIM

1 x M-Key 2280 (PCIe x4 Gen.4 for PCIe SSD), optional

SATA

- MI/O Extension connector: 4 x PCIe x1, 1 x PCIe x4,

1 x USB 2.0, LPC, SMBus, Line-out, and 12V/5V Power

supply

• Battery:Lithium 3 V/210 mAH

• Audio:SupportsHighDenitionAudio(HD),line-in,line-

out, and Mic-in

Display

• Controller:

- Intel®SoC integrated for HDMI/DP/Type-C display output

- 48-bit LVDS display output

• Maximumresolution:

- LCD:

LVDS dual channel 48-bit up to 1920x1200

Optional: eDP 1.4 up to 4096x2304@60 Hz

- HDMI/DP:

1 x Port HDMI 2.0 up to 4096x2160@60 Hz

1 x Port DP 1.4a up to 4096x2160@60 Hz

- USB Type-C:

1 x USB3.2 Gen. 2x2 20 Gbps, supports DP1.4a via alt.

mode

• Multipledisplay:Four simultaneous displays via 48-bit

LVDS/eDP+HDMI+DP+Type-C

EthernetInterface

• Speed:10/100/1000 Mbps

• Controller:GbE1 - Intel i219, GbE2 - Intel i210-AT

• Connector:RJ45 x 2

I/O

• InternalI/O:1 x SATA 6 Gb/s, 2 x USB 2.0, 2 x

RS232/422/485, 8-bit GPIO, Inverter, SMBus, CANBus

I2C*, HD audio, LVDS, and system fan.

• RearI/O: 4 x USB 3.2, HDMI, DP, USB type-C, 2 x RJ-45,

1 x DC-Jack (*optional).

• MI/Oexpansion:4 x PCIex1, 1 x PCIe x4, USB 2.0, LPC,

SMBus, line-out, and 12 V/5 V power supply.

• Powerconnectortype:Default support 2 x 2 pin ATX

power connector, DC jack is supported upon by request.

MechanicalandEnvironmental

• Dimensions(LxW): 146 x 102 mm (5.7 x 4 in)

• Powersupplytype:ACPI support for ATX only

• Powerrequirements: Vin: 12 V-24 V +/- 5%

Specications(Cont.)PackingList

For more information on this and other Advantech

products, please visit our website at:

http://www.advantech.com

http://www.advantech.com/eplatform

For technical support and service, please visit our

support website at:

http://support.advantech.com.tw/

This manual is for MIO-5375.

Part No. 2046537500

Printed in China

1st Edition

June 2021

Specications

2 MIO-5375 Startup Manual

• Powerconsumption:

- Max: i7-1185G7E: 43.31 W (12 V)/46.78W (24 V)

- Typical: Idle mode in Windows 10.

i7-1185G7E: 16.56W (12 V)/19.2W (24 V)

• Operatingtemperature: 0 ~ 60 °C (32 ~ 140 °F)

• Weight:0.67 kg/1.47 lb (reference weight of total package)

The board has a number of connectors and jumpers that

allowyoutocongureyoursystemtosuityourapplication.

The table below lists the function of each of the jumpers and

connectors.

Jumpers

Label Function

J3 AT mode /Load BIOS default

VDD1 LCD Power

Connector

Label Function

CN11 Power Input

DIMM1 SO-DIMM 9.2mm

DIMM2 SO-DIMM 5.2mm

Battery1 RTC Battery

CN4 CAN BUS

CN5 Front Panel

AUDIO1 Audio

CN8 I2C

COM1 COM1

COM2 COM2

COM3 COM3

COM4 COM4

CN7 GPIO

LAN1 RJ45_2x1_W/XFMR&LED

BL1 Inverter Power output

LVDS1 48 bit LVDS

EDP1 eDP/MIPI DSI

HDMI1 HDMI

DP1 DP

TYPEC1 TYPEC

M2_1 M.2 E-key

M2_2 M.2 M-key

M2_3 M.2 B-key

SIM NANO SIM

J3:ATmode/LoadBIOSdefault

Function JumperSetting

Auto Power On

(1-2)

Reserve

(3-4)

Short: Load BIOS default

Open: Normal

(5-6)

Toloadfactorydefaults,dothis:

Step1:Powero󰀨

Step 2 : Remove the Jumper (3-4) and add to (5-6), then

power on.

BIOS will load factory defaults (does not clear time or clear

CMOS), a message will remind user to shut down system

and restore Jumper (3-4)

Step 3 : Power on again.

If you want to Clear CMOS, remove battery (battery 1).

System will pop up a message...wait for 3 seconds. RTC

time will clear but keep the BIOS settings.

VDD1:LCDPower

Function JumperSetting

+3.3V

(1-3)

+5V

(3-5)

+12V

(3-4)

Caution! The computer is provided with a battery-powered

real-time clock circuit. There is a danger of explo-

sion if battery is incorrectly replaced. Replace

only with same or equivalent type recommended

by the manufacturer. Discard used batteries ac-

cording to manufacturer’s instructions.

Specications(Cont.)

JumpersandConnectors(Cont.)

JumpersandConnectors

MIO-5375 Startup Manual 3

Figure 1: MIO-5375 Connector Locations (Top Side)

Figure 2: MIO-5375 Connector Locations (Bottom Side)

Figure 3: MIO-5375 Connector Locations (Coastline)

ConnectorsLocations

4 MIO-5375 Startup Manual

1. There is a Cooler/Heatsink in the white box, please take it out and remove the release paper from the thermal pads.

2. There are four screws inside the white box, follow the installation sequence demonstrated below to secure the cooler/

heatsink:

Cooler Heatsink



QuickInstallationGuide

Andere Handbücher für MIO-5375

Andere Advantech Computerhardware Handbücher

Advantech

Advantech AIMC-3202 Installations- und Betriebshandbuch

Advantech

Advantech SOM-6883 Bedienungsanleitung

Advantech

Advantech USM-500R Bedienungsanleitung

Advantech

Advantech FWA-3033-00A1R Installations- und Betriebshandbuch

Advantech

Advantech HPC-8000 Bedienungsanleitung

Advantech

Advantech PCL-734 Bedienungsanleitung

Advantech

Advantech PCLD-8811 Installations- und Betriebshandbuch

Advantech

Advantech AIMB-786 Installations- und Betriebshandbuch

Advantech

Advantech PCA-6144S Bedienungsanleitung

Advantech

Advantech MIO-5376 Bedienungsanleitung

Advantech

Advantech ASMB-785 Installations- und Betriebshandbuch

Advantech

Advantech MIC-3393 Bedienungsanleitung

Advantech

Advantech POC-824 Bedienungsanleitung

Advantech

Advantech AMAX-4870 Installations- und Betriebshandbuch

Advantech

Advantech MIC-300 Installations- und Betriebshandbuch

Advantech

Advantech ASMB-830 Series Bedienungsanleitung

Advantech

Advantech PCE-7B17-00A1E Installations- und Betriebshandbuch

Advantech

Advantech IPC-610B Bedienungsanleitung

Advantech

Advantech PCA-6143P Bedienungsanleitung

Advantech

Advantech UNO-2172 Bedienungsanleitung

Advantech

Advantech COASTIPC PPC-412 Bedienungsanleitung

Advantech

Advantech PCE-GIGE2 Installations- und Betriebshandbuch

Advantech

Advantech PCA-6179 Bedienungsanleitung

Advantech

Advantech FWA-1211 Installations- und Betriebshandbuch

Beliebte Computerhardware Handbücher anderer Marken

EMC2

EMC2 VNX Series Betriebsanleitung

Panasonic

Panasonic DV0PM20105 Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric Q81BD-J61BT11 Bedienungsanleitung

Gigabyte

Gigabyte B660M DS3H AX DDR4 Bedienungsanleitung

Raidon

Raidon iT2300 Bedienungsanleitung

National Instruments

National Instruments PXI-8186 Bedienungsanleitung

Hauppauge

Hauppauge WinTV-HVR-2250 Bedienungsanleitung

Kontron

Kontron CP6002 Bedienungsanleitung

Manhattan

Manhattan 702843 Bedienungsanleitung

Aphex

Aphex 230 Bedienungsanleitung

AMD

AMD Phenom II Betriebshandbuch

Intel

Intel NUC 12 Pro Bedienungsanleitung

dbx

dbx Zone Pro 1260 Bedienungsanleitung

Galaxy

Galaxy GHDX2-2430S-24F4D Bedienungsanleitung

Intel

Intel AXXRMFBU4 Bedienungsanleitung

Kontron

Kontron DIMM-PC/MD Bedienungsanleitung

ST X-NUCLEO-SAFEA1B Betriebsanleitung

STEINWAY LYNGDORF

STEINWAY LYNGDORF SP-1 Bedienungsanleitung