APRILIA SCARABEO 250 Bedienungsanleitung

DEALER INSTRUCTION SHEET

SCARABEO 250

Page 1

INSTRUCTIONS FOR REMOVING

MOTORCYCLE FROM CRATE

SAFETY MESSAGES

The following warning messages are used on

all instruction sheets to draw your attention to

the situations described below.

Safety warning symbol. When you see this

symbol on the motorcycle or on

instruction sheets, beware of potential

injury hazards. Failure to observe the

instructions that come after these symbols

may affect your safety, the safety of others

and that of the motorcycle!

Risk of serious injury or death.

Possible risk of slight injury or damage to

motorcycle.

WARNING

Risk of serious injury or death.

CAUTION

Possible risk of slight injury or damage to

motorcycle.

NOTE The word "NOTE" is written before

any important information on the instruction

sheet.

For the sake of safety, perform a thorough

preliminary check before starting the

vehicle. See the PRELIMINARY CHECK

LIST IN THE VEHICLE OPERATION AND

MAINTENANCE HANDBOOK.

Failure to carry out these checks may lead

to serious injury or damage to the vehicle.

The checks require very little time, but the

benefits in terms of safety are enormous.

The components in this handbook are

supplied disassembled and must be fitted on

to the motorcycle. These instruction sheets for

dealers describe the correct assembly

procedures.

Read the instructions in the sheets to avoid

breakage or incorrect assembly.

Remove the rear storage box containing wing

mirrors and other components not on the

bodywork.

After removing the nailed-on supports and

crosspieces from the crate (used for transport

purposes), push the motorcycle off the bottom

of the crate and position it on the stand.

You may now proceed with the operations

below.

Scarabeo 250

Pre_DeliveryScarabeo 250USA.fm Page 1 Wednesday, July 13, 2005 10:56 AM

DEALER INSTRUCTION SHEET

Page 2

SCARABEO 250

BATTERY

Battery electrolyte is toxic, caustic and

contact with the skin may cause serious

burns due to the sulfuric acid. Wear

protective clothing, a face shield and/or

tight fitting goggles when working around

the battery. In case of contact with the

skin, flush immediately with plenty of

water.

In case of contact with the eyes, flush with

plenty of water for at least 15 minutes.

Immediately consult an ophthalmologist.

If the electrolyte is accidentally swallowed,

drink large quantities of water or milk, then

milk of magnesia or vegetable oil.

Immediately consult a health professional.

The battery gives off noxious and

explosive gases; keep it away from

cigarettes, flames, sparks and any other

source of heat. During recharging or use,

make sure that the room is properly

ventilated and avoid inhaling the gases

released during the recharging process.

KEEP AWAY FROM CHILDREN.

Do not tilt either the vehicle or battery too

much to avoid electrolyte from leaking out.

CAUTION

The battery fluid is corrosive. Do not pour

or spray it, particularly on plastic parts.

When the battery has been removed it

must be placed in a safe place out of the

reach of children. The battery is very

dangerous and may cause serious injury

or death.

INITIAL BATTERY CHARGING

◆Fill the battery with electrolyte to a level

between the "MIN" and "MAX" lines.

CAUTION

When topping up the electrolyte use only

distilled water. Do not fill higher than the

"MAX" level, as the level rises during

recharging.

◆Top up with distilled water.

◆Make sure the level is between "MIN" and

"MAX" printed on the side of the battery.

FITTING THE BATTERY

◆Make sure the ignition key is in the ""

position.

◆Place the battery into its housing.

◆Connect the positive cable (+) first, then the

negative (-).

◆Use neutral grease or vaseline to grease

terminals.

◆Connect the gas breather hose (1).

◆Fit the battery support (2) using the screw

(3)TCEI M6x16.

◆Tighten the front hood (5) with the screws

(4).

CAUTION

Always connect the battery breather hose

to ensure that sulfuric acid fumes do not

corrode electric plant, paintwork, rubber

parts and gaskets.

MAX

MIN

Pre_DeliveryScarabeo 250USA.fm Page 2 Wednesday, July 13, 2005 10:56 AM

DEALER INSTRUCTION SHEET

Page 3

SCARABEO 250

FITTING THE BATTERY AFTER FIRST

RECHARGE

CAUTION

Wait 5-10 minutes after recharging before

fitting the battery, since it continues to

produce gas for a time after recharging.

FITTING THE MIRRORS

Fit the mirrors as follows.

◆Fit the mirror into its housing and secure

with the block nut as shown.

◆Do the same for the righthand mirror.

CAUTION

The right nut has a slot to show that it

tightens counter-clockwise.

FITTING THE CUP

◆Fit the cup (1).

◆Secure the screws TBEI M5x25 (2).

Pre_DeliveryScarabeo 250USA.fm Page 3 Wednesday, July 13, 2005 10:56 AM

DEALER INSTRUCTION SHEET

Page 4

SCARABEO 250

FITTING THE STORAGE BOX

Follow the assembly instructions for the

storage box.

◆Fit the three screws TBEI M6x40 (1) and

spacer bushes (2).

◆Fit the storage box and secure to the

support with the nuts (3) provided.

aprilia part #8104822-07/05-USA

Pre_DeliveryScarabeo 250USA.fm Page 4 Wednesday, July 13, 2005 10:56 AM

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere APRILIA Motorrad Handbücher

APRILIA

APRILIA RALLY 50 - 2002 Bedienungsanleitung

APRILIA

APRILIA MANA 850 ABS Bedienungsanleitung

APRILIA

APRILIA Tuono V4 Bedienungsanleitung

APRILIA

APRILIA SPORTCITY ONE 50 4T Bedienungsanleitung

APRILIA

APRILIA SXV 4.5 Bedienungsanleitung

APRILIA

APRILIA RSV MILLE Bedienungsanleitung

APRILIA

APRILIA DORSODURO 750 - Bedienungsanleitung

APRILIA

APRILIA RSV mille TUONO Bedienungsanleitung

APRILIA

APRILIA RSV MILLE Bedienungsanleitung

APRILIA

APRILIA 2010 MXV 450 Bedienungsanleitung

APRILIA

APRILIA SCARABEO 300 SPECIAL - 2009 Bedienungsanleitung

APRILIA

APRILIA RS4 50 Bedienungsanleitung

APRILIA

APRILIA RXV - BROCHURE 2009 Bedienungsanleitung

APRILIA

APRILIA SCARABEO 50 4T - 2006 Bedienungsanleitung

APRILIA

APRILIA SR 50 - USE AND MAINTENANCE BOOK Leitfaden

APRILIA

APRILIA PEGASO 650 IE - PART2 01-2001 Bedienungsanleitung

APRILIA

APRILIA DORSODURO 750 - Bedienungsanleitung

APRILIA

APRILIA PEGASO 650 STRADA TRAIL 2005 Stücklistenhandbuch

APRILIA

APRILIA SCARABEO 100 4T - 2007 Bedienungsanleitung

APRILIA

APRILIA SR MAX 300 i.e. Bedienungsanleitung

APRILIA

APRILIA SL 750 SHIVER Leitfaden

APRILIA

APRILIA SCARABEO 125 - 2003 Bedienungsanleitung

APRILIA

APRILIA ATLANTIC 125 - Bedienungsanleitung

APRILIA

APRILIA QUASAR 50 Bedienungsanleitung

Beliebte Motorrad Handbücher anderer Marken

OHVALE

OHVALE GP-0 Stücklistenhandbuch

Yamaha

Yamaha Star XV19CTSZ 2009 Bedienungsanleitung

KTM

KTM 350 XCF-W USA Bedienungsanleitung

HYOSUNG

HYOSUNG ST7 Bedienungsanleitung

Husqvarna

Husqvarna FC 250 2016 Bedienungsanleitung

Ducati

Ducati SCRAMBLER 800 Gebrauchsanweisung

Yamaha

Yamaha 2006 YZF-R1V Bedienungsanleitung

KTM

KTM Freeride E-XC 2021 Bedienungsanleitung

Fantic

Fantic Enduro 125 Bedienungsanleitung

Ducati

Ducati Supersport 750 desmodue Bedienungsanleitung

MV Agusta

MV Agusta 2008 F4 312RR 1078 Gebrauchsanweisung

Yamaha

Yamaha XVS650A Bedienungsanleitung

Yamaha

Yamaha YZF-R6T(C) Handbuch

Ducati

Ducati 748 monoposto strada Bedienungsanleitung

ATK

ATK 1988 250 Bedienungsanleitung

Excelsior-HENDERSON

Excelsior-HENDERSON 1999 HCX Bedienungsanleitung

Triumph

Triumph Thunderbird Bedienungsanleitung

Yamaha

Yamaha 2006 FJR1300A Bedienungsanleitung