BMW 54 34 Series Bedienungsanleitung

54 34 ... Overview of mechanical convertible top components

1 Front bow 6 Main link

2 Roof crossbar 7 Main bearing

3 Bow 8 Main pillar

4 Rear window 9 Guide rail

5 Tension bar

RA Overview of mechanical convertible top components BMW AG - TIS 14.07.2010 22:31

Issue status (12/2007) Valid only until next DVD is issued Copyright Page - 1 -

54 34 337 Removing and installing/replacing front left

or right seal

Necessary preliminary tasks:

Remove panel on guide rail

Unfasten screws.

Installation:

Replace screws and insert with Loctite.

Remove front seal (1).

Carry out function check:

Align front seal to A-pillar seal and roof frame seal.

Side window must run into seal correctly and rest in seal over

entire width.

Build date up to 10/2005:

If necessary, adjust seal by way of hexagon nuts (1).

Installation:

Seal (1) must rest cleanly in pocket of cowl panel seal (2).

Pocket (2) must not be crushed.

RA Removing and installing/replacing front left or right seal BMW AG - TIS 14.07.2010 22:34

Issue status (12/2007) Valid only until next DVD is issued Copyright Page - 1 -

54 34 357 Removing and installing/replacing left or

right guide rail panel

Necessary preliminary tasks:

Open folding roof

Release screws (1).

Remove panel (2).

RA Removing and installing/replacing left or right guide rail panel BMW AG - TIS 14.07.2010 22:34

Issue status (12/2007) Valid only until next DVD is issued Copyright Page - 1 -

54 34 211 Replacing left or right tension cable

Necessary preliminary tasks:

Open folding roof approx. halfway

Remove seals

Detach convertible top fabric (1) from front bow (rear).

If necessary, lever convertible top fabric (1) with plastic wedge out

of front bow (front).

Detach convertible top fabric (1) from front bow.

Installation:

Attach double-sided adhesive tape to front bow and stick on

convertible top from inside outwards.

Detach tension cable (1) at side from roof frame.

RA Replacing left or right tension cable BMW AG - TIS 14.07.2010 22:33

Issue status (12/2007) Valid only until next DVD is issued Copyright Page - 1 -

Disengage roof bow (1).

Unscrew nuts (1).

Pull convertible top fabric (1) out of roof crossbar.

Note:

Do not pull out convertible top fabric by the pockets.

Convertible top fabric is secured on each side with 3 retainers to

roof crossbar.

Detach convertible top fabric (1) from convertible top frame.

RA Replacing left or right tension cable BMW AG - TIS 14.07.2010 22:33

Issue status (12/2007) Valid only until next DVD is issued Copyright Page - 2 -

Feed out tension cable (1) and lever spring (2) out of pin.

Installation:

Press spring circlip correctly onto pin groove.

Check for secure seating.

Remove tension cable from fabric pockets and feed in new tension

cable.

Carry out function check.

RA Replacing left or right tension cable BMW AG - TIS 14.07.2010 22:33

Issue status (12/2007) Valid only until next DVD is issued Copyright Page - 3 -

54 34 001 Checking function of EH convertible top

Warning!

You are exposed to the risk of trapping body parts when

working on the installed or removed convertible top.

Convertible top is centered by pin (1) during insertion into

guide (2) and locked by rotary latch (3).

Carefully close convertible top until rotary latch (3) has retracted

by approx. 1/3 into striker.

Rotary latch (3) and pin (1) must close correctly and virtually

silently.

If necessary, adjust convertible top.

Open and close convertible top at least 3 times.

Check all line connections for fluid leaks.

If necessary, check fluid level.

Function conditions, folding roof:

Opening and closing of folding roof is only possible when:

- battery voltage is sufficient, start engine if necessary

- tension brackets are lowered and locked

- speed does not exceed 120 km/h

- outside temperature is between -10 C and +80 C

- from ignition lock position "R" (radio setting)

- control switch is pressed

Function conditions, convertible top:

Opening and closing of convertible top is only possible when:

- battery voltage is sufficient, start engine if necessary

- folding roof is in proper working condition

- rear side windows are lowered completely

- front side windows are lowered slightly

- tension brackets are lowered and locked

- stowage shelf is engaged in lower position

- speed does not exceed 4 km/h

- outside temperature is between -10 C and +80 C

RA Checking function of EH convertible top BMW AG - TIS 14.07.2010 22:32

Issue status (12/2007) Valid only until next DVD is issued Copyright Page - 1 -

- from ignition lock position "R" (radio setting)

- hydraulic pump motor is not overheated

- control switch is pressed

In event of function problems:

Convertible top actuation in event of a technical fault

Repair instructions hydraulic system

Only when you have excluded the function conditions as fault

sources can you start convertible top diagnosis.

RA Checking function of EH convertible top BMW AG - TIS 14.07.2010 22:32

Issue status (12/2007) Valid only until next DVD is issued Copyright Page - 2 -

Inhaltsverzeichnis

Andere BMW Autozubehör Handbücher

BMW

BMW FXX ATM Emulator Betriebsanleitung

BMW

BMW E38 Bedienungsanleitung

BMW

BMW 84 64 0 025 810 Bedienungsanleitung

BMW

BMW 325i 1991 Programmierhandbuch

BMW

BMW Multi Tool Bedienungsanleitung

BMW

BMW R50 Bedienungsanleitung

BMW

BMW Z3 roadster Bedienungsanleitung

BMW

BMW 84 64 0 021 187 Bedienungsanleitung

BMW

BMW F23 Soft Top Technology Bedienungsanleitung

BMW

BMW 54 13 086 Bedienungsanleitung

BMW

BMW 84 64 0 153 227 Bedienungsanleitung

BMW

BMW AG/ICOM Bedienungsanleitung

BMW

BMW Profil 2000 Service-Handbuch

BMW

BMW 84 64 0 302 016 Bedienungsanleitung

BMW

BMW 84 64 0 303 121 Bedienungsanleitung

BMW

BMW SA640 Bedienungsanleitung

BMW

BMW 71 60 0 009 711 Bedienungsanleitung

BMW

BMW 84 63 0 017 895 Bedienungsanleitung

BMW

BMW 84 64 0 398 228 Bedienungsanleitung

BMW

BMW 84 64 0 153 493 Bedienungsanleitung

BMW

BMW Wallbox Bedienungsanleitung

BMW

BMW 1 Series Bedienungsanleitung

BMW

BMW AccessPORT Bedienungsanleitung

BMW

BMW M Performance Bedienungsanleitung

Beliebte Autozubehör Handbücher anderer Marken

James Baroud

James Baroud Odyssey Bedienungsanleitung

Motorola

Motorola i50sx Bedienungsanleitung

Yakima

Yakima 9MM STANDARD BIKE MOUNT Bedienungsanleitung

Feniex

Feniex T3 Bedienungsanleitung

Kia

Kia E8300-4D000 Bedienungsanleitung

Brink

Brink 756843 Bedienungsanleitung

Whispbar

Whispbar K085W Bedienungsanleitung

v.link

v.link CI-VL2-PC-HSD Bedienungsanleitung

Viking

Viking Stack-Rack Kurzanleitung zur Einrichtung

Aries

Aries 203015 Bedienungsanleitung

Choetech

Choetech AT0005 Bedienungsanleitung

ZZ2

ZZ2 ZZAIR-PRO Bedienungsanleitung

Holman

Holman 4A80L Bedienungsanleitung

Thule

Thule 2075 Bedienungsanleitung

Motorola

Motorola T325 Bedienungsanleitung

TAUBENREUTHER

TAUBENREUTHER 16-3950 Installationsanleitung

DV8

DV8 FBJL-02 Bedienungsanleitung

Prorack

Prorack K1163 Bedienungsanleitung