Bradley S19-210SC Bedienungsanleitung

P.O. Box 309, Menomonee Falls, WI USA 53052-0309

PHONE 1-800-BRADLEY FAX (262) 251-5817

http://www.bradleycorp.com

Installation

215-155SC Rev. L; EN 06-532D

Page 1 of 5 6/20/07

S19-210SC

Pedestal-Mounted Stainless

Steel Eyewash with Dust Cover

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . . .2

Installation Instructions . . . . . . . . . . . . . . . . . . .3

Assembly of Components . . . . . . . . . . . . . . . . .4

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

S19-210SC Installation

6/20/07 Bradley Corporation • 215-155SC Rev. L; EN 06-532D

WARNING

Read this installation manual completely to ensure proper installation, then file it

with the owner or maintenance department. Compliance and conformity to drain

requirements and other local codes and ordinances is the responsibility of the

installer.

Separate parts from packaging and make sure all parts are accounted for before

discarding any packaging material. If any parts are missing, do not begin

installation until you obtain the missing parts.

Flush the water supply lines before beginning installation and after installation is

complete. Test the unit for leaks and adequate water flow. Main water supply to

the eyewash should be “ON” at all times. Provisions shall be made to prevent

unauthorized shutoff.

The ANSI Z358.1 standard requires an uninterruptible supply of flushing fluid at a

minimum 30 PSI (0.21 MPa) flowing pressure. Flushing fluid should be tepid per

ANSI Z358.1.

The inspection and testing results of this equipment should be recorded weekly

to verify proper operation. This equipment should be inspected annually to

ensure compliance with ANSI Z358.1.

Workers who may come in contact with potentially hazardous materials should be

trained regarding the placement and proper operation of emergency equipment

per ANSI Z358.1.

For questions regarding the operation or installation of this product, visit

www.bradleycorp.com or call 1-800-BRADLEY.

Product warranties may also be found under ”Product Information” on our web

site at www.bradleycorp.com.

Installation

THIS

SIDE

Packing List

P.O.Box309, MenomoneeFalls, WI 53051

TESTTHISUNITEACHWEEK

Test-operatevalve(s) each week and sign below.

Reportany malfunctions immediately.

Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt

durchUnterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1STWÖCHENTLICHZUPRÜFEN.

ESSAIHEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signeen bas. S'il y à quelque chose qui ne va pas fait

unrapport immédiatement.

P.O.BOX309, MENOMONEE FALLS,WI 53052-0309 USA

TEL:1-800-BRADLEY FAX: (262-251-5817)

http://www.bradleycorp.com

114-051

Installation S19-210SC

Bradley Corporation • 215-155SC Rev. L; EN 06-532D 6/20/07

Installation

NOTE: Flush the water supply line

before beginning installation.

Supplies Required:

• (3) 3/8" floor anchors and bolts

• Pipe sealant

• Piping to 1/2" IPS water supply

inlet on unit

• Piping to 1-1/4" IPS drain outlet for

eyewash

• Sign-mounting hardware

Step 1: Secure base and

brackets to floor

1. To secure base to floor, install

three suitable anchors (supplied

by installer) for 3/8" bolts in the

floor (Figure 1).

2. Bolt the base to the floor anchors

using 3/8" bolts (supplied by

installer).

Step 2: Assemble eyewash

components

1. Assemble eyewash components as

shown in Figure 2 on page 4.

• Apply pipe sealant (supplied by

installer) to all male-threaded

pipe joints.

• Use the rubber grip pad

provided or a strap wrench

around pipes when tightening

to prevent marring. Place the

grip pad on the pipe, then put

the wrench over the grip pad

and turn the pipe with the

wrench.

Step 3: Connect water supply

1. Connect the water supply piping (supplied by installer) to the 1/2" IPS inlet on the eyewash.

2. Connect the drain piping (supplied by installer) to the 1-1/4" IPS drain outlet on the eyewash.

3. Mount the safety sign to the wall using sign-mounting hardware (supplied by installer).

4. Open the water supply lines. Test for leaks and adequate water flow.

7-1/4"

(184mm)

21-1/2"

(546mm)

40-1/2"

(1029mm)

5-1/4"

(133mm)

35"

(889mm)

(152mm)

8-3/4"

(222mm)

Ø 10-3/4"

(273mm)

17-1/4"

(438mm)

Figure 1

NOTE: All dimensions assume standard thread

engagement. Variations in manufacturing allow

for +/- 1/8" (3mm) per threaded joint. To find

the tolerance of a dimension, add the number

of thread joints in between a dimension and

multiply it by 1/8" (3mm).

Assembly of Components

S19-210SC Installation

6/20/07 Bradley Corporation • 215-155SC Rev. L; EN 06-532D

P.O.Box 309, Menomonee Falls, WI 53051

TESTTHISUNIT EACHWEEK

Test-operate valve(s) each week and sign below.

Report any malfunctionsimmediately.

Ventil(e) wöchentlichim Testbetrieb prüfen, bestätigt

durch Unterschrift.Jegliche Störungsofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1ST WÖCHENTLICH ZU PRÜFEN.

ESSAI HEBDOMADAIRE

Test le fonctionnement desvalveschaque semaine et

signe en bas. S'il y à quelque chose qui ne va pasfait

un rapport immédiatement.

P.O. B OX 309, MENOMONEE FALLS,W I 53052-0309 USA

TEL:1-800-BRADLEY FAX: (262-251-5817)

http://www.bradleycorp.com

114-051

4.7

4.5

Flow Control

ThisEnd

4.4

4.3

4.2

4.1

7.1

1/2" IPS

Supply Inlet

1-1/4" IPS

Drain Outlet

4.11

4.12

4.8

4.9

4.10

HANDLE NOTE:

Close the cover and

put the pin through

the clip to keep closed.

4.6

Figure 2 NOTE: Items 4.1–4.12 come preassembled as Item 4.

Items 8.1–8.5 come preassembled as Item 8.

Installation S19-210SC

Bradley Corporation • 215-155SC Rev. L; EN 06-532D 6/20/07

Parts List

1 131-062 1 Base

2 269-237 1 Pipe Tee 1-1/4"

3 113-584 1 Pipe Tee 1-1/4" x 26-1/2"

4 S90-319 1 Eyewash w/Dust Cover

4.1 111-049 1 Inlet Drain Fitting

4.2 124-028 1 Center Seal Gasket

4.3 S90-009 1 Dust Cover Assembly

4.4 173-009 1 Cup Strainer

4.5 S21-072 1 Supply Pipe

4.6 113-1159 1 Spacer, Drain

4.7 S05-131 1 Eyewash Yoke

4.8 115-141 2 Sprayhead

4.9 153-333 1 Pipe Plug

4.10 269-874 1 Cap Plug

4.11 269-447 1 Bumper

4.12 161-025 1 Nut, Hex

5 113-965 1 Pipe, Stainless Steel 1/2" x 3-1/2"

6 269-241 1 Street Elbow 1/2"

7 S27-287 1 Stay-Open Ball Valve w/Nut

7.1 161-151 1 Nut Only

8 S08-337 1 Flag Handle Assembly

9 114-051 1 Safety Sign

10 204-421 1 Emergency Inspection Tag

11 269-915 1 Grip Pad (not shown)

12 142-002DA 1 Washer

Item Part No. Qty Description Item Part No. Qty Description

Prepack S45-1787 includes Items 4.2, 4.4, 4.5, 4.6

Inhaltsverzeichnis

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley Aerada 90-80 Series Bedienungsanleitung

Bradley

Bradley Terreon Quadra-Fount MF2949/IR Bedienungsanleitung

Bradley

Bradley S19-460EFW Bedienungsanleitung

Bradley

Bradley Express SS-2N/AST/STD Bedienungsanleitung

Bradley

Bradley S59-2005 Bedienungsanleitung

Bradley

Bradley S19-222 Bedienungsanleitung

Bradley

Bradley S19-220DCPT Bedienungsanleitung

Bradley

Bradley S19-130F Bedienungsanleitung

Bradley

Bradley S19-120FM Bedienungsanleitung

Bradley

Bradley WS-1X Bedienungsanleitung

Bradley

Bradley S96-051 Bedienungsanleitung

Bradley

Bradley Verge LVA Series Bedienungsanleitung

Bradley

Bradley S19-230 Bedienungsanleitung

Bradley

Bradley S19-130SSBF Bedienungsanleitung

Bradley

Bradley S19-310BF Bedienungsanleitung

Bradley

Bradley S19-270C Bedienungsanleitung

Bradley

Bradley S19-230FW Bedienungsanleitung

Bradley

Bradley S96-050 Bedienungsanleitung

Bradley

Bradley Equa-Flo Pressure Balancing Valve Bedienungsanleitung

Bradley

Bradley E19-120A Bedienungsanleitung

Bradley

Bradley Terreon MG Series Produktinformationsblatt

Bradley

Bradley S19-220DC Bedienungsanleitung

Bradley

Bradley S19-310PVC Bedienungsanleitung

Bradley

Bradley 1C TouchTime Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema