Bradley S19-220DCPT Bedienungsanleitung

P.O. Box 309, Menomonee Falls, WI USA 53052-0309

PHONE 1-800-BRADLEY FAX (262) 251-5817

http://www.bradleycorp.com

Installation

215-1255 Rev. D; EN 06-532G

Page 1 of 4 4/30/07

S19-220DCPT

Wall-Mounted Eyewash with

Dust Cover

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . . .2

Installation Instructions . . . . . . . . . . . . . . . . . . . .3

Assembly of Components . . . . . . . . . . . . . . . . . .4

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

S19-220DCPT Installation

4/30/07 Bradley Corporation • 215-1255 Rev. D; EN 06-532G

WARNING

Read this installation manual completely to ensure proper installation, then file it

with the owner or maintenance department. Compliance and conformity to drain

requirements and other local codes and ordinances is the responsibility of the

installer.

Separate parts from packaging and make sure all parts are accounted for before

discarding any packaging material. If any parts are missing, do not begin

installation until you obtain the missing parts.

Flush the water supply lines before beginning installation and after installation is

complete. Test the unit for leaks and adequate water flow. Main water supply to

the eyewash should be “ON” at all times. Provisions shall be made to prevent

unauthorized shutoff.

The ANSI Z358.1 standard requires an uninterruptible supply of flushing fluid at a

minimum 30 PSI (0.21 MPa) flowing pressure. Flushing fluid should be tepid per

ANSI Z358.1.

The inspection and testing results of this equipment should be recorded weekly

to verify proper operation. This equipment should be inspected annually to

ensure compliance with ANSI Z358.1.

Workers who may come in contact with potentially hazardous materials should be

trained regarding the placement and proper operation of emergency equipment

per ANSI Z358.1.

For questions regarding the operation or installation of this product, visit

www.bradleycorp.com or call 1-800-BRADLEY.

Product warranties may also be found under ”Product Information” on our web

site at www.bradleycorp.com.

Installation

THIS

SIDE

Packing List

P.O.Box309, MenomoneeFalls, WI 53051

TESTTHISUNITEACHWEEK

Test-operatevalve(s) each week and sign below.

Reportany malfunctions immediately.

Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt

durchUnterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1STWÖCHENTLICHZUPRÜFEN.

ESSAIHEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signeen bas. S'il y à quelque chose qui ne va pas fait

unrapport immédiatement.

P.O.BOX309, MENOMONEE FALLS,WI 53052-0309 USA

TEL:1-800-BRADLEY FAX: (262-251-5817)

http://www.bradleycorp.com

114-051

Installation S19-220DCPT

Bradley Corporation • 215-1255 Rev. D; EN 06-532G 4/30/07

Installation Instructions

NOTE: Flush the water supply line

before beginning installation.

Supplies Required:

• (3) 3/8" wall fasteners and bolts

• Pipe sealant

• Piping to 1/2" IPS water supply inlet

on unit

• Sign-mounting hardware

Step 1: Install inlet drain fittings

NOTE: Top of eyewash heads should be

33"-45" (838mm-1142mm) from floor.

1. Position the inlet drain fitting over

the 1-1/4" drain outlet pipe from

wall.

2. Using the inlet drain fitting as a

template, mark the bolt hole

locations on wall OR install three

suitable fasteners (supplied by

installer) for 3/8" bolts in the wall

at the marked hole locations (see

Figure 1).

3. Bolt the inlet drain fitting to the

wall or wall fasteners using 3/8"

bolts (supplied by installer).

Step 2: Assemble eyewash

1. Assemble eyewash components as

shown in Figure 2 on page 4.

• Apply pipe sealant (supplied by

installer) to all male-threaded

pipe joints.

• Use a strap wrench around pipes

when tightening to prevent

marring.

Step 3: Connect water supply

1. Connect the water supply piping

(supplied by installer) to the 1/2"

IPS inlet on the eyewash.

2. Connect the P-trap and tailpiece to

the 1-1/4 IPS drain outlet on the

eyewash.

3. Mount the safety sign to a wall or

pipe using sign-mounting hardware (supplied by installer).

4. Open the water supply lines. Test for leaks and adequate water flow.

17-1/4"

(438mm)

8-3/4"

(222mm)

5-1/4"

133mm)

13-5/8"

(346mm)

8-1/4"

(210mm)

8-3/4"

(222mm)

14"

(357mm)

2-1/4"

(57mm)

5/16"

(8mm)

MTG.

HOLE

(102mm)

36" (914mm)

Suggested

Height

To Floor

30-1/2" (775mm)

Suggested

Height

To Floor

4-5/8"

(119mm)

Ø10-3/4"

(273mm)

21-1/2"

(546mm)

Figure 1

Assembly of Components and Parts List

S19-220DCPT Installation

4/30/07 Bradley Corporation • 215-1255 Rev. D; EN 06-532G

1 S90-301 1 Dust Cover /Receptor Assembly

1.1 111-061 1 Inlet-Drain Fitting

1.2 124-028 1 Gasket

1.3 S90-009 1 Dust Cover Assembly

1.4 173-009 1 Cup Strainer

1.5 S21-071 1 Supply Stem

1.6 S05-091 1 Eyewash Yoke

1.7 269-447 1 Bumper

1.8 161-025 1 Hex Nut

1.9 113-1159 1 Spacer, Drain

2 113-006LQ 1 Pipe 1/2" IPS x 3-1/2" Long

3 169-025 1 Elbow 1/2" IPS Street

4 S30-072 1 1/2" Valve/Handle Prepack

4.1 S27-282 1 1/2" Ball Valve with Nut

4.11 110-215 1 Nut only

4.2 S08-056 1 Handle Assembly

4.3 142-002DA 1 Lockwasher

4.4 153-372R 1 Adapter

5 269-167 1 Tailpiece

6 269-142 1 Trap

7 114-051 1 Safety Sign

8 204-421 1 Emergency Tag

Item Part No. Qty Description Item Part No. Qty Description

P.O.Box 309, Menomonee Falls, WI 53051

TESTTHISUNIT EACHWEEK

Test-operate valve(s) each week and sign below.

Report any malfunctionsimmediately.

Ventil(e) wöchentlichim Testbetrieb prüfen, bestätigt

durch Unterschrift.Jegliche Störungsofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1ST WÖCHENTLICH ZU PRÜFEN.

ESSAI HEBDOMADAIRE

Test le fonctionnement desvalveschaque semaine et

signe en bas. S'il y à quelque chose qui ne va pasfait

un rapport immédiatement.

P.O.BOX 309, MENOMONEE FALLS,W I 53052-0309 USA

TEL:1-800-BRADLEY FAX:(262-251-5817)

http://www.bradleycorp.com

114-051

4.1

4.3

4.11

4.2

4.4

1/2" IPS

Supply Inlet

1-1/4" IPS

Drain Outlet

HANDLE NOTE:

Close the cover and

put the pin through

the clip to keep closed.

1.6

1.5

Flow Control

ThisEnd

1.4

1.3

1.2

1.1

1.8

1.7 1.9

NOTE: Items 1.1 -1.9 come presasembled as Item 1.

Figure 2

Prepack S30-087 includes items 4.11, 4.2, 4.3, 4.4

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley TouchTime MG Series Bedienungsanleitung

Bradley

Bradley Aerada 1100 Series Bedienungsanleitung

Bradley

Bradley Express SS-Series Express SS-3N/BIR3/STD Bedienungsanleitung

Bradley

Bradley FREQUENCY FL-1H Bedienungsanleitung

Bradley

Bradley S19-110SS Bedienungsanleitung

Bradley

Bradley Terreon MF2922 Kurzanleitung

Bradley

Bradley LC840 Bedienungsanleitung

Bradley

Bradley Express SS-2N/BIR3/STD Bedienungsanleitung

Bradley

Bradley FL-3H Bedienungsanleitung

Bradley

Bradley S45-1986 Bedienungsanleitung

Bradley

Bradley Express MG Series Bedienungsanleitung

Bradley

Bradley 594 Bedienungsanleitung

Bradley

Bradley Terreon Deep Bowl WF3200 Series Bedienungsanleitung

Bradley

Bradley Express ELX Series Bedienungsanleitung

Bradley

Bradley Express SS Series Bedienungsanleitung

Bradley

Bradley Terreon WF3204 Bedienungsanleitung

Bradley

Bradley Aerada 1000 Series Bedienungsanleitung

Bradley

Bradley MG-2/TT Bedienungsanleitung

Bradley

Bradley S19-220FW Bedienungsanleitung

Bradley

Bradley S19-230T Bedienungsanleitung

Bradley

Bradley S19-240 Bedienungsanleitung

Bradley

Bradley Verge LVGD Series Bedienungsanleitung

Bradley

Bradley Terreon TDB3103 Bedienungsanleitung

Bradley

Bradley S19-130F Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema