Bradley S19-210SS Bedienungsanleitung

P.O. Box 309, Menomonee Falls, WI USA 53052-0309

PHONE 1-800-BRADLEY FAX (262) 251-5817

http://www.bradleycorp.com

215-604 Rev. U; EN 06-532G

Page 1 of 5 6/21/07

S19-210SS

Pedestal-Mounted Stainless

Steel Eyewash with Foot Pedal

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . .2

Installation Instructions . . . . . . . . . . . . . . . . . .3

Assembly of Components . . . . . . . . . . . . . . . .4

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

Installation

S19-210SS Installation

6/21/07 Bradley Corporation • 215-604 Rev. U; EN 06-532G

WARNING

Read this installation manual completely to ensure proper installation, then file it

with the owner or maintenance department. Compliance and conformity to drain

requirements and other local codes and ordinances is the responsibility of the

installer.

Separate parts from packaging and make sure all parts are accounted for before

discarding any packaging material. If any parts are missing, do not begin

installation until you obtain the missing parts.

Flush the water supply lines before beginning installation and after installation is

complete. Test the unit for leaks and adequate water flow. Main water supply to

the eyewash should be “ON” at all times. Provisions shall be made to prevent

unauthorized shutoff.

The ANSI Z358.1 standard requires an uninterruptible supply of flushing fluid at a

minimum 30 PSI (0.21 MPa) flowing pressure. Flushing fluid should be tepid per

ANSI Z358.1.

The inspection and testing results of this equipment should be recorded weekly

to verify proper operation. This equipment should be inspected annually to

ensure compliance with ANSI Z358.1.

Workers who may come in contact with potentially hazardous materials should be

trained regarding the placement and proper operation of emergency equipment

per ANSI Z358.1.

For questions regarding the operation or installation of this product, visit

www.bradleycorp.com or call 1-800-BRADLEY.

Product warranties may also be found under ”Product Information” on our web

site at www.bradleycorp.com.

Installation

THIS

SIDE

Packing List

P.O.Box309, MenomoneeFalls, WI 53051

TESTTHISUNITEACHWEEK

Test-operatevalve(s) each week and sign below.

Reportany malfunctions immediately.

Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt

durchUnterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1STWÖCHENTLICHZUPRÜFEN.

ESSAIHEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signeen bas. S'il y à quelque chose qui ne va pas fait

unrapport immédiatement.

P.O.BOX309, MENOMONEE FALLS,WI 53052-0309 USA

TEL:1-800-BRADLEY FAX: (262-251-5817)

http://www.bradleycorp.com

114-051

Installation

NOTE: Flush the water supply line before

beginning installation.

Supplies Required:

• (3) 3/8" floor anchors and bolts

• Pipe sealant

• Piping to 1/2" IPS water supply inlet on unit

• Piping to 1-1/4" IPS drain outlet for eyewash

• Sign-mounting hardware

Step 1: Secure base to floor

1. Install three suitable anchors (supplied by

installer) for 3/8" bolts in the floor (see

Figure 1).

2. Bolt the base to the floor anchors using 3/8"

bolts (supplied by installer).

Step 2: Assemble eyewash

1. Assemble eyewash components as shown in

Figure 2 on page 4.

• Apply pipe sealant (supplied by installer)

to all male-threaded pipe joints.

• Use the rubber grip pad provided or a strap

wrench around pipes when tightening to

prevent marring. Place the grip pad on the

pipe, then put the wrench over the grip pad

and turn the pipe with the wrench.

• When connecting the chain, first connect

the chain to the foot treadle “S” hook on

the valve handle. Make sure the chain is

pulled tight (the length of chain used will vary).

Step 3: Connect water supply

1. Connect the water supply piping (supplied by installer) to the 1/2" IPS inlet on the eyewash.

2. Connect the drain piping (supplied by installer) to the 1-1/4" IPS drain outlet on the eyewash.

3. Mount the safety sign to the wall using sign-mounting hardware (supplied by installer).

4. Open the water supply lines. Test for leaks and adequate water flow.

Installation S19-210SS

Bradley Corporation • 215-604 Rev. U; EN 06-532G 6/21/07

15-3/8"

(391mm)

35"

(890mm)

40-3/4"

(1035mm)

5-1/8"

(130mm)

(152mm)

Figure 1

NOTE: All dimensions assume standard thread

engagement. Variations in manufacturing allow

for +/- 1/8" (3mm) per threaded joint. To find

the tolerance of a dimension, add the number

of thread joints in between a dimension and

multiply it by 1/8" (3mm).

Assembly of Components

S19-210SS Installation

6/21/07 Bradley Corporation • 215-604 Rev. U; EN 06-532G

4.1

4.2

4.3

4.4

4.5

4.6

4.7

4.8

4.9

4.10

4.11 4.12

9.3

P.O. BO X 309,MENOMONEE FALLS, WI 53052-0309USA

TEL:1-800-BRADLEY FAX:(262-251-5817)

http://www.bradleycorp.com

114-051

P.O. Bo x 309, Menomonee Falls,W I 53051

TESTTHISUNIT EACH WEEK

Test-operate valve(s)each week and sign below.

Reportany malfunctionsimmediately.

Ventil(e)wöchentlich im Testbetriebprüfen, bestätigt

durchUnterschrift. Jegliche Störungsofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1ST WÖCHENTLICH ZU PRÜFEN.

ESSAIHEBDOMADAIRE

Test le fonctionnementdesvalveschaque semaine et

signeen bas. S'il y à quelque chose qui ne va pasfait

unrapport immédiatement.

9.7

9.8

9.6

9.1 9.5

9.4

9.2

9.1

1-1/4" IPS

DRAIN OUTLET

7.1

1/2" IPS

SUPPLY INLET

FLOW CONTROL

THISEND

NOTE: Items 4.1–4.12 come preassembled as Item 4.

Figure 2

Installation S19-210SS

Bradley Corporation • 215-604 Rev. U; EN 06-532G 6/21/07

Parts List

1 131-062 1 Base

2 269-237 5 Pipe Tee 1-1/4" IPS

3 113-584 1 Pipe 1-1/4" IPS x 26-1/2"

4 S90-317 1 Stainless Steel Spray Ring Assy.

4.1 111-049 1 Inlet-Drain Fitting

4.2 124-028 1 Center Seal Gasket

4.3 187-053 1 Stainless Steel Bowl

4.4 173-009 1 Cup Strainer

4.5 S21-074 1 Supply Pipe

4.6 113-1159 1 Spacer, Drain

4.7 S05-131 1 Eyewash Yoke

4.8 107-371 2 Dust Cover

4.9 269-912 1 Swivel Stem

4.10 124-055 2 Quad Ring

4.11 S57-148 1 Spray Ring Assembly

4.12 110-209 1 Acorn Nut

5 113-965 1 Pipe, Stainless Steel 1/2" x 3-1/2"

6 269-241 1 Elbow

7 S27-287 1 1/2" Ball Valve with Jam Nut

7.1 161-151 1 Jam Nut only

8 S08-338 1 Handle Assembly

9 S45-1314SS 1 HFSO Prepack

9.1 269-646 2 “S” Hook

9.2 134-009A 1 Stainless Steel Chain

9.3 181-008SS 1 Treadle

9.4 160-401 1 Screw

9.5 161-137 1 Nut, Acorn

9.6 147-026 1 Eye Bolt

9.7 142-002BT 1 Lockwasher

9.8 161-025 1 Hex Nut

10 114-051 1 Safety Sign

11 204-421 1 Emergency Tag

12 269-915 1 Grip Pad (not shown)

13 142-002DA 1 Lockwasher

Item Part No. Qty Description Item Part No. Qty Description

Inhaltsverzeichnis

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley Terreon Quadra-Fount MF2944/IR Bedienungsanleitung

Bradley

Bradley Express SS Series Bedienungsanleitung

Bradley

Bradley WS-1X Bedienungsanleitung

Bradley

Bradley S19-120BF Bedienungsanleitung

Bradley

Bradley Terrazzo WF2600 Series Bedienungsanleitung

Bradley

Bradley Express SS Series Bedienungsanleitung

Bradley

Bradley Verge Crestt Series Kurzanleitung

Bradley

Bradley TDB3108 Bedienungsanleitung

Bradley

Bradley Terreon Quadra-Fount MF2949/IR Bedienungsanleitung

Bradley

Bradley S19-304D1 Bedienungsanleitung

Bradley

Bradley S19-125SBF Bedienungsanleitung

Bradley

Bradley S59-2005 Bedienungsanleitung

Bradley

Bradley WS-1X Bedienungsanleitung

Bradley

Bradley Express SS Series Bedienungsanleitung

Bradley

Bradley Advocate AV Series Bedienungsanleitung

Bradley

Bradley S19-120FM Bedienungsanleitung

Bradley

Bradley S19-220SC Bedienungsanleitung

Bradley

Bradley S19-230T Bedienungsanleitung

Bradley

Bradley S19-120 Bedienungsanleitung

Bradley

Bradley Aerada 1200 Series Bedienungsanleitung

Bradley

Bradley 594 Bedienungsanleitung

Bradley

Bradley Bradmar 700 Series Bedienungsanleitung

Bradley

Bradley Equa-Flo Pressure Balancing Valve Bedienungsanleitung

Bradley

Bradley Verge LVQD1 Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema