Bradley S19-230T Bedienungsanleitung

Installation

P.O. Box 309, Menomonee Falls, WI USA 53052-0309

PHONE 800.BRADLEY (800.272.3539) FAX 262.251.5817

bradleycorp.com

215-160T Rev. G; ECN 12-05-003C

Page 1 of 4 10/18/2012

S19-230T

Freestanding Eye/Face Wash

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . . . . . . . . . . . . 2

Installation Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Assembly of Components . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

S19-230T Installation

10/18/2012 Bradley • 215-160T Rev. G; ECN 12-05-003C

IMPORTANT

Read this installation manual completely to ensure proper installation, then file it with the

owner or maintenance department. Compliance and conformity to drain requirements and

other local codes and ordinances is the responsibility of the installer.

Separate parts from packaging and make sure all parts are accounted for before discarding

any packaging material. If any parts are missing, do not begin installation until you obtain the

missing parts.

Flush the water supply lines before beginning installation and after installation is complete.

Test the unit for leaks and adequate water flow. Main water supply to the eyewash should be

“ON” at all times. Provisions shall be made to prevent unauthorized shutoff.

The ANSI Z358.1 standard requires an uninterrupted supply of flushing fluid. Bradley plumbed

emergency fixtures require a minimum of 30 PSI (0.21 MPa) flowing pressure. Flushing fluid

should be tepid per ANSI Z358.1.

The inspection and testing results of this equipment should be recorded weekly to verify

proper operation. This equipment should be inspected annually to ensure compliance with

ANSI Z358.1.

Workers who may come in contact with potentially hazardous materials should be trained

regarding the placement and proper operation of emergency equipment per ANSI Z358.1.

For questions regarding the operation or installation of this product, visit www.bradleycorp.

com or call 1-800-BRADLEY.

Product warranties may also be found under “Product Information” on our web site at www.

bradleycorp.com.

Installation

THIS

SIDE

Packing List

•

P.O.Box309, Menomonee Falls, WI 53051

TESTTHISUNIT EACHWEEK

Test-operatevalve(s) each week and sign below.

Reportany malfunctions immediately.

Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt

durchUnterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1ST WÖCHENTLICH ZU PRÜFEN.

ESSAIHEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signeen bas. S'il y à quelque chose qui ne va pas fait

unrapport immédiatement.

P.O.BOX 309, MENOMONEE FALLS, WI 53052-0309 USA

TEL:1-800-BRADLEY FAX: (262-251-5817)

http://www.bradleycorp.com

114-051

Installation S19-230T

Bradley • 215-160T Rev. G; ECN 12-05-003C 10/18/2012

Installation Instructions

NOTICE! Avoid cleaners containing organic solvents,

alcohols, and hydrocarbons. Rinse with

water after cleaning.

Flush the water supply line before beginning

installation.

Supplies Required:

• Pipe sealant

• Piping to ½" NPT water supply inlet on unit

• Piping to 1¼" NPT drain outlet for eyewash

• Sign-mounting hardware

Step 1: Assemble eyewash components

1. Assemble eyewash components as shown on page 4.

• Apply pipe sealant (supplied by installer) to all

male-threaded pipe joints.

The top of the eyewash heads should be 33"–45"

(838mm–1143mm) from the floor.

Step 2: Connect water supply

1. Connect the water supply piping (supplied by

installer) to the ½" NPT inlet on the eyewash.

2. Connect the tailpiece to the 1¼" NPT drain outlet on

the eyewash.

3. Mount the safety sign to the wall using sign-

mounting hardware (supplied by installer).

4. Open the water supply lines. Test for leaks and

adequate water flow.

29½"

(749mm)

Suggested

Height To

Floor

36"

(914mm)

Suggested

Height To

Floor

15½" (394mm)

8¹⁄₈"

(206mm)

5¼"

(133mm)

7½"

(191mm)

Ø 10¾" (273mm)

Figure 1

S19-230T Installation

10/18/2012 Bradley • 215-160T Rev. G; ECN 12-05-003C

Assembly of Components and Parts List

P.O. Box 309, Menomonee Falls, WI 53051

TEST THIS UNIT EACH WEEK

Test-operate valve(s) each week and sign below.

Report any malfunctions immediately.

Ventil(e) wöchentlich im Testbetrieb prüfen, bestätigt

durch Unterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESES GERÄT 1ST WÖCHENTLICH ZU PRÜFEN.

ESSAI HEBDOMADAIRE

Test le fonctionnement des valves chaque semaine et

signe en bas. S'il y à quelque chose qui ne va pas fait

un rapport immédiatement.

P.O. BOX 309, MENOMONEE FALLS,WI 53052-0309 USA

TEL:1-800-BRADLEY FAX:(262-251-5817)

http://www.bradleycorp.com

114-051

1.5

1.4

1.3

1.2

1.1

45.1

2.2

2.3

2.1

Items 1.1–1.5 come preassembled as Item 1.

Items 2.1–2.3 come preassembled as Item 2.

Prepack S45-122 includes Items 5, 5.1, 6, 7

Prepack S45-123 includes Items 5.1, 6, 7

Prepack S45-1789 includes Items 1.2, 1.4, 1.5

Item Part No. Qty Description

1 S90-094 1 Eyewash Bowl Assembly

1.1 111-039 1 Inlet Drain Fitting

1.2 124-028 1 Center Seal Gasket

1.3 187-053 1 Stainless Steel Eyewash Bowl

1.4 173-009 1 Cup Strainer

1.5 113-1150 1 Supply Pipe

2 S05-064D 1 EFW Sprayhead Assembly

2.1 S05-091P 1 EFW Yoke Assembly

2.2 S45-2453 1 Service Kit EFW - Black

Sprayheads

2.3 S53-063 2 Dust Cover

Item Part No. Qty Description

3 113-006LQ 1 Pipe 1/2" x 3-1/2"

4 169-025 1 Street Elbow 1/2"

5 S27-282 1 1/2" Ball Valve w/Nut

5.1 110-215 1 Nut Only

6 128-135 1 Plastic Eyewash Handle

7 142-002DA 1 Lockwasher

8 204-421 1 Emergency Inspection Tag

9 114-051 1 Safety Sign

10 269-167 1 Tailpiece

1¼" NPT

Drain Outlet

½" NPT

Supply Inlet

Figure 2

Inhaltsverzeichnis

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley LC840 Bedienungsanleitung

Bradley

Bradley S19-465EFW Bedienungsanleitung

Bradley

Bradley SN2013/AST4 Bedienungsanleitung

Bradley

Bradley Indoor Furnishings Kurzanleitung

Bradley

Bradley EXPRESS SS-3/AST/JUV Bedienungsanleitung

Bradley

Bradley Verge WashBar LVQ Series Bedienungsanleitung

Bradley

Bradley EXPRESS SS-2/AST/JUV Bedienungsanleitung

Bradley

Bradley Express SS-2 Infrared-to-Touch Time Bedienungsanleitung

Bradley

Bradley Terreon WF3204 Bedienungsanleitung

Bradley

Bradley S19-465EFW Bedienungsanleitung

Bradley

Bradley Terreon TDB3104 Bedienungsanleitung

Bradley

Bradley Express MG Series Bedienungsanleitung

Bradley

Bradley S19-230 Bedienungsanleitung

Bradley

Bradley S19-220HFP Bedienungsanleitung

Bradley

Bradley Terreon Classic WF2500 Series Bedienungsanleitung

Bradley

Bradley Terreon Classic WF2500 Series Bedienungsanleitung

Bradley

Bradley Express MG-2/NDT Bedienungsanleitung

Bradley

Bradley Terrazzo WF2613 Bedienungsanleitung

Bradley

Bradley Aerada 900 Series Bedienungsanleitung

Bradley

Bradley S19-310PVC Bedienungsanleitung

Bradley

Bradley S19-460EFW Bedienungsanleitung

Bradley

Bradley Advocate LA Series Bedienungsanleitung

Bradley

Bradley S19-125BF Bedienungsanleitung

Bradley

Bradley Advocate AV Series Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema