C-Aire NewLife Elite Bedienungsanleitung

MN240-1 Rev C

NewLife Family Technical Manual MN240-1

MN240-1 Rev C

Table of Contents

Section 1.0

Introduction

1.1 Important Notice and Symbol Explanations 5

1.2 Equipment Provider Responsibility 12

1.3 Functional Specifications 13

Section 2.0

Operation Check and

Oxygen Concentration Test

2.1 Description of Operation 17

2.2 Operation Check 17

2.3 Alarm System 18

2.3.1 Start Up Test 19

2.3.2 Power Failure Alarm Test 19

2.3.3 General Malfunction Alarm Test 19

2.3.4 Low O2Alarm Test 19

2.3.5 Oxygen Concentration Test and Specifications 20

Section 3.0

Patient Instructions

3.1 Instructions 21

3.2 Routine Maintenance by the Patient 21

3.2.1 Cleaning the Air Intake

Gross Particle Filter 21

Section 4.0

Provider Instructions

4.1 Instructions 22

4.1.1 Air Intake Gross Particle Filter/GPF 22

4.1.2 Product Filter 22

4.1.3 Recording Maintenance 23

4.2 Preparing for New Patient Use/Method of 23

Cleaning and Infection Control

MN240-1 Rev C

Section 5.0

Main Components 5.1 Components 24

5.2 Cabinet Removal 24

5.2.1 Removing Side Panel(s) 24

5.2.2 Removing Back Panel 24

5.2.3 Removing Lower Front Panel 24

5.2.4 Removing Control Panel 24

5.2.5 Superstructure 24

5.2.6 Caster Replacement 24

5.3 Compressor 25

5.3.1 Compressor Replacement 26

5.3.2 Capacitor Replacement 26

5.4 Solenoid Valves 27

5.4.1 Feed/Waste Valve Replacement 27

5.4.2 Solenoid Valve Coil Replacement 28

5.5 Sieve Beds 29

5.5.1 Sieve Bed Replacement 29

5.6 Cabinet Fan 30

5.6.1 Cabinet Fan Replacement 30

5.7 Circuit Board 31

5.7.1 Circuit Board Replacement 31

5.8 Product Tank Replacement 32

5.9 Product Regulator Check and Setting 33

5.9.1 Setting Product Regulator for Normal Operation 33

5.9.2 Product Regulator Cleaning or 34

Rebuilding

5.10 Circuit Breaker Replacement 35

5.11 ON/OFF Power Switch Replacement 35

5.12 Buzzer Replacement 35

MN240-1 Rev C

5.13 Hour Meter Replacement 36

5.14 Flowmeter Replacement 36

5.15 Power Cord Replacement 37

5.16 Oxygen Monitor Circuit Board Replacement 37

Section 6.0

Troubleshooting

6.1 Operating Pressure Test 38

6.1.1 High Operating Pressure 38

6.1.2 Low Operating Pressure 39

6.2 General Troubleshooting 39

6.3 Troubleshooting Chart 40

6.4 Tool Kit and Pressure Test Gauge 43

Section 7.0

EMC TESTING

7.1 EMC Testing 44

MN240-1 Rev C

1.0 Introduction

1.1 Important Notice and Symbol Explanations

As you read the manual, pay special attention to the WARNING, CAUTION, and NOTE

messages. They identify safety guidelines or other important information as follows:

Describes a hazard or unsafe practice that can result in severe bodily injury or

death.

Describes a hazard or unsafe practice that can result in minor bodily injury or

property damage.

Provides information important enough to emphasize or repeat.

Symbols are frequently used on equipment in preference to words with the intention of

lessening any possibility of misunderstanding caused by language differences. Symbols

can also permit easier comprehension of a concept within a restricted space.

The following table is a list of symbols and definitions that may be used with the NewLife

Oxygen Concentrator. These symbols are referenced from the appropriate International

Electro-technical Commission (IEC) standards:

MN240-1 Rev C

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere C-Aire Medizinische Geräte Handbücher

C-Aire

C-Aire Liberator G4 Series Betriebsanleitung

C-Aire

C-Aire Companion C1000 Betriebsanleitung

C-Aire

C-Aire Eclipse 5 with autoSAT Betriebsanleitung

C-Aire

C-Aire Companion 5 Bedienungsanleitung

C-Aire

C-Aire Eclipse 5 Bedienungsanleitung

C-Aire

C-Aire NewLife Series Bedienungsanleitung

C-Aire

C-Aire FreeStyle Bedienungsanleitung

C-Aire

C-Aire 300 Bedienungsanleitung

C-Aire

C-Aire Eclipse 5 Bedienungsanleitung

C-Aire

C-Aire EMS 20 Bedienungsanleitung

C-Aire

C-Aire Focus Bedienungsanleitung

C-Aire

C-Aire Eclipse 5 Bedienungsanleitung

C-Aire

C-Aire SPRINT Bedienungsanleitung

C-Aire

C-Aire Companion 5 Bedienungsanleitung

C-Aire

C-Aire HELiOS Plus Betriebsanleitung

C-Aire

C-Aire HELiOS Bedienungsanleitung

C-Aire

C-Aire Companion 5 Bedienungsanleitung

C-Aire

C-Aire Eclipse with autoSat Bedienungsanleitung

C-Aire

C-Aire FOCUS Bedienungsanleitung

C-Aire

C-Aire AirSep FreeStyle 5 Bedienungsanleitung

C-Aire

C-Aire NewLife Series Bedienungsanleitung

C-Aire

C-Aire Companion 5 Bedienungsanleitung

C-Aire

C-Aire HELiOS PLUS H300-50 Betriebsanleitung

C-Aire

C-Aire Hi Flow Stroller Betriebsanleitung

Beliebte Medizinische Geräte Handbücher anderer Marken

TekTone

TekTone Tek-CARE160 Bedienungsanleitung

NeuroMetrix

NeuroMetrix Quell 2.0 Bedienungsanleitung

AMT

AMT XLR8 Bedienungsanleitung

EDAN

EDAN SONOTRAX Pro Bedienungsanleitung

Restorative Therapies

Restorative Therapies RT300 Bedienungsanleitung

Gendex

Gendex Expert DC Bedienungsanleitung

Dexcowin

Dexcowin ADX4000W Bedienungsanleitung

Libelium

Libelium MySignals Bedienungsanleitung

Acelity

Acelity V.A.C.ULTA 4 Bedienungsanleitung

Caputron

Caputron ActivaDose II tDCS Bedienungsanleitung

Plinth 2000

Plinth 2000 93CDT Bedienungsanleitung

GE SENOGRAPHE 800T Bedienungsanleitung

GE Definium 5000 Bedienungsanleitung

Kanmed

Kanmed GE-1380 Bedienungsanleitung

Huntleigh

Huntleigh FD1 Bedienungsanleitung

Stryker

Stryker SPR Plus Bedienungsanleitung

Tobii Dynavox

Tobii Dynavox I-Series Bedienungsanleitung

S-Capepod

S-Capepod Evac Cocoon Bedienungsanleitung