Champion Power Equipment 100463 Bedienungsanleitung

OPERATOR'S MANUAL

MODEL #100463

7500W ELECTRIC START GENERATOR

REV 20221019 Champion Power Equipment, Inc., Santa Fe Springs, CA USA

or visit championpowerequipment.com

READ AND SAVE THIS MANUAL. This manual contains important safety precautions which should be read and understood before operating the product.

Failure to do so could result in serious injury. This manual should remain with the product.

Speciﬁcations, descriptions and illustrations in this manual are as accurate as known at the time of publication, but are subject to change without notice.

at championpowerequipment.com

100463 - 7500W ELECTRIC START GENERATOR TABLE OF CONTENTS

TABLE OF CONTENTS

Introduction................................................ 3

Safety Deﬁnitions ....................................... 3

Important Safety Instructions.................... 4

Fuel Safety ...................................................... 6

Safety Symbols.................................................. 7

Operation Symbols .............................................. 8

Safety Labels...................................................10

Controls and Features ...............................11

Generator .......................................................11

Control Panel ...................................................12

Parts Included ..................................................12

Tools Needed ...................................................12

Assembly...................................................13

Unpacking ......................................................13

Install the Wheel Kit............................................13

Connect the Battery............................................13

Add Engine Oil..................................................13

Add Fuel ........................................................14

Grounding ......................................................15

Operation...................................................16

Generator Location.............................................16

Surge Protection ...............................................16

Starting the Engine.............................................16

Connecting Electrical Loads ...................................17

Do Not Overload Generator ....................................18

Stopping the Engine............................................18

Operation at High Altitude .....................................18

Maintenance..............................................19

Cleaning the Generator ........................................19

Changing the Engine Oil .......................................19

Cleaning and Adjusting the Spark Plug(s) .....................19

Cleaning the Air Filter ..........................................20

Cleaning the Spark Arrestor ...................................20

Adjusting the Governor.........................................20

Generator Battery ..............................................20

Maintenance Schedule.........................................21

Storage ..................................................... 21

Short Term Storage (up to 1 year) .............................21

Long Term Storage (more than 1 year)........................22

Removing from Storage........................................22

Speciﬁcations........................................... 23

Generator Speciﬁcations.......................................23

Engine Speciﬁcations ..........................................23

Oil Speciﬁcations...............................................23

Fuel Speciﬁcations .............................................23

Spark Plug Speciﬁcations......................................23

Valve Speciﬁcations............................................23

Battery Speciﬁcations..........................................23

Temperature Speciﬁcations....................................23

ICES–002 Warning.............................................23

Troubleshooting........................................ 24

100463 - 7500W ELECTRIC START GENERATOR INTRODUCTION

INTRODUCTION

Congratulations on your purchase of a Champion Power

Equipment (CPE) product. CPE designs, builds, and supports

all of our products to strict speciﬁcations and guidelines. With

proper product knowledge, safe use, and regular maintenance,

this product should bring years of satisfying service.

Every effort has been made to ensure the accuracy and

completeness of the information in this manual at the time

of publication, and we reserve the right to change, alter and/

or improve the product and this document at any time without

prior notice.

Since CPE highly values how our products are designed,

manufactured, operated and are serviced, and also highly

value your safety and the safety of others, we would like you to

take the time to review this product manual and other product

materials thoroughly and be fully aware and knowledgeable

of the assembly, operation, dangers and maintenance of the

product before use. Fully familiarize yourself, and make sure

others who plan on operating the product fully familiarize

themselves too, with the proper safety and operation

procedures before each use. Please always exercise common

sense and always err on the side of caution when operating

the product to ensure no accident, property damage, or injury

occurs. We want you to continue to use and be satisﬁed with

your CPE product for years to come.

When contacting CPE about parts and/or service, you will

need to supply the complete model and serial numbers of your

product. Transcribe the information found on your product’s

nameplate label to the table below

CPE TECHNICAL SUPPORT TEAM

1-877-338-0999

MODEL NUMBER

100463

SERIAL NUMBER

DATE OF PURCHASE

PURCHASE LOCATION

SAFETY DEFINITIONS

The purpose of safety symbols is to attract your attention to

possible dangers. The safety symbols, and their explanations,

deserve your careful attention and understanding. The safety

warnings do not by themselves eliminate any danger. The

instructions or warnings they give are not substitutes for proper

accident prevention measures.

DANGER

DANGER indicates a hazardous situation which,if not

avoided, will result in death or serious injury.

WARNING

WARNING indicates a hazardous situation which, if not

avoided, could result in death or serious injury.

CAUTION

CAUTION indicates a hazardous situation which, if not

avoided, could result in minor or moderate injury.

NOTICE

NOTICE is used to address practices not related to physical

injury.

100463 - 7500W ELECTRIC START GENERATOR IMPORTANT SAFETY INSTRUCTIONS

IMPORTANT SAFETY INSTRUCTIONS

DANGER

Generator exhaust contains carbon monoxide, a colorless,

odorless, poison gas. Breathing carbon monoxide will cause

nausea, dizziness, fainting or death. If you start to feel dizzy

or weak, get to fresh air immediately.

OPERATE GENERATOR OUTDOORS ONLY IN A WELL

VENTILATED AREA.

DO NOT operate the generator inside any building, including

garages, basements, crawlspaces and sheds, enclosure or

compartment, including the generator compartment of a

recreational vehicle.

DO NOT allow exhaust fumes to enter a conﬁned area

through windows, doors, vents or other openings.

DANGER

Using a generator indoors CAN KILL YOU IN MINUTES.

Generator exhaust contains carbon monoxide. This is a

poison you cannot see or smell.

NEVER use inside a home or garage, EVEN IF doors and

windows are open.

ONLY use OUTSIDE and far away from windows, doors,

and vents.

Install battery-operated carbon monoxide alarms or plug-in

carbon monoxide alarms with battery back-up according to

the manufacturer’s instructions.

DANGER

Rotating parts can entangle hands, feet, hair, clothing and/

or accessories. Traumatic amputation or severe laceration

can result.

Keep hands and feet away from rotating parts.

Tie up long hair and remove jewelry.

Operate equipment with guards in place.

DO NOT wear loose-ﬁtting clothing, dangling drawstrings or

items that could become caught.

WARNING

Operation of this equipment may create sparks that can

start ﬁres around dry vegetation.

A spark arrestor may be required. The operator should

contact local ﬁre agencies for laws or regulations relating to

ﬁre prevention requirements.

DANGER

Generator produces powerful voltage.

DO NOT touch bare wires or receptacles.

DO NOT use electrical cords that are worn, damaged or

frayed. Use Champion electrical cords only for proper

application.

DO NOT operate generator in wet weather.

DO NOT allow children or unqualiﬁed persons to operate or

service the generator

Use a ground fault circuit interrupter (GFCI) in damp areas

and areas containing conductive material such as metal

decking.

Connection to your home’s electrical system requires a

listed 30A transfer switch installed by a licensed electrician

and approved by the local authority having jurisdiction. The

connection must isolate the generator from the utility power

and must comply with all applicable laws and electrical

codes.

WARNING

Sparks can result in ﬁre or electrical shock.

When servicing the generator:

Disconnect the spark plug wire and place it where it cannot

contact the plug or any other metal object.

DO NOT check for spark with the plug removed.

Use only approved spark plug testers.

100463 - 7500W ELECTRIC START GENERATOR IMPORTANT SAFETY INSTRUCTIONS

WARNING

Running engines produce heat. Severe burns can occur on

contact. Combustible material can catch ﬁre on contact.

DO NOT touch hot surfaces.

Avoid contact with hot exhaust gases.

Allow equipment to cool before touching.

Maintain at least 3 ft. (91.4 cm) of clearance on all sides to

ensure adequate cooling.

Maintain at least 5 ft. (1.5 m) of clearance from combustible

materials.

WARNING

Rapid retraction of the starter cord will pull hand and arm

towards the engine faster than you can let go. Unintentional

startup can result in entanglement, traumatic amputation or

laceration. Broken bones, fractures, bruises or sprains could

result.

When starting engine, pull the starter cord slowly until

resistance is felt and then pull rapidly to avoid kickback.

DO NOT start or stop the engine with electrical devices

plugged in and turned on.

CAUTION

Exceeding the generator’s running capacity can damage the

generator and/or electrical devices connected to it.

DO NOT overload the generator.

DO NOT tamper with the governed speed.

DO NOT modify the generator in any way.

CAUTION

Start the generator and allow the engine to stabilize before

connecting electrical loads.

Connect electrical equipment in the off position, and then

turn them on for operation.

Turn electrical equipment off and disconnect before

stopping the generator.

CAUTION

Improper treatment or use of the generator can damage it,

shorten its life and void your warranty.

Use the generator only for intended uses.

Operate only on level surfaces.

DO NOT expose generator to excessive moisture, dust,

or dirt.

DO NOT allow any material to block the cooling slots.

If connected devices overheat, turn them off and disconnect

them from the generator.

DO NOT use the generator if:

–Electrical output is lost

–Equipment sparks, smokes or emits ﬂames

–Equipment vibrates excessively

WARNING

Medical and life support uses.

In case of emergency, call 911 immediately.

NEVER use this product to power life support devices or life

support appliances.

NEVER use this product to power medical devices or

medical appliances.

Inform your electricity provider immediately if you or anyone

in your household depends on electrical equipment to live.

Inform your electrical provider immediately if a loss of power

would cause you or anyone in your household to experience

a medical emergency.

100463 - 7500W ELECTRIC START GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Fuel Safety

DANGER

GASOLINE AND GASOLINE VAPORS ARE HIGHLY

FLAMMABLE AND EXPLOSIVE.

Fire or explosion can cause severe burns or death.

Gasoline and gasoline vapors:

–Gasoline is highly ﬂammable and explosive.

–Gasoline can cause a ﬁre or explosion if ignited.

–Gasoline is a liquid fuel but it’s vapors can ignite.

–Gasoline is a skin irritant and needs to be cleaned up

immediately if spilled on skin or clothes.

–Gasoline has a distinctive odor, this will help detect potential

leaks quickly.

–In any petroleum gas ﬁre, ﬂames should not be extinguished

unless by doing so the fuel supply valve can be turned OFF.

This is because if a ﬁre is extinguished and a supply of

fuel is not turned OFF, then an explosion hazard could be

created.

–Gasoline expands or contracts with ambient temperatures.

Never ﬁll the gasoline tank to full capacity, as gasoline

needs room to expand if temperatures rise.

When adding or removing gasoline:

Turn the generator off and let it cool for at least two minutes

before removing the gasoline cap. Loosen the cap slowly to

relieve pressure in the tank.

Only ﬁll or drain gasoline outdoors in a well-ventilated area.

DO NOT pump gasoline directly into the generator at the gas

station. Use an approved container to transfer the fuel to the

generator.

DO NOT overﬁll the gasoline tank.

Always keep gasoline away from sparks, open ﬂames, pilot

lights, heat and other sources of ignition.

DO NOT light or smoke cigarettes.

When starting the generator:

DO NOT attempt to start a damaged generator.

Make certain that the gasoline cap, air ﬁlter, spark plug, fuel

lines and exhaust system are properly in place.

Allow spilled gasoline to evaporate fully before attempting to

start the engine.

Make certain that the generator is resting ﬁrmly on level

ground.

When operating the generator:

DO NOT move or tip the generator during operation.

DO NOT tip the generator or allow fuel or oil to spill.

When transporting or servicing the generator:

Make certain that the fuel valve is in the OFF position,

the gasoline tank is empty.

Disconnect the spark plug wire.

When storing the generator:

Store away from sparks, open ﬂames, pilot lights, heat and

other sources of ignition.

Do not store generator or gasoline near furnaces, water heaters,

or any other appliances that produce heat or have automatic

ignitions.

WARNING

Never use a gasoline container, gasoline tank, or any other

fuel item that is damaged or appears damaged.

100463 - 7500W ELECTRIC START GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Safety Symbols

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of

these symbols will allow you to more safely operate the product.

SYMBOL MEANING

Read Operator’s Manual. To reduce the risk of injury, user must read and understand operator’s

manual before using this product.

Clearance. Keep all objects at least 5 feet from this machine. Heat from the mufﬂer and exhaust

gas can ignite combustible objects.

Ground. Consult with local electrician to determine grounding requirements before operation.

Electric Shock. Failure to use in dry conditions and to observe safe practices can result in electric

shock. Improper connections to a building can allow current to backfeed into utility lines, creating an

electrocution hazard. A transfer switch must be used when connecting to a building.

Fire/Explosion. Fuel and its vapors are extremely ﬂammable and explosive. Fire or explosion can

cause severe burns or death. Operation of this equipment may create sparks that can start ﬁres

around dry vegetation. A spark arrestor may be required. The operator should contact local ﬁre

agencies for laws or regulations relating to ﬁre prevention requirements.

Hot Surface. To reduce the risk of injury or damage, avoid contact with any hot surface.

Open Flame Alert. Fuel and its vapors are extremely ﬂammable and explosive. Keep fuel away from

smoking, open ﬂames, sparks, pilot lights, heat, and other ignition sources.

Wet Conditions Alert. Do not expose to rain or use in damp locations.

100463 - 7500W ELECTRIC START GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Operation Symbols

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of

these symbols will allow you to more safely operate the product.

SYMBOL MEANING

Engine START

Engine ON

Engine STOP

Locking Receptacle

Circuit Breaker Reset: Push

Circuit Breaker Reset: Flip

Neutral Bonded to Frame. Neutral

circuit IS electrically connected to the

frame/ground of the generator.

Hertz. Shown on Intelligauge as

“F##.#”

Volts. Shown on Intelligauge as

“U###”

Runtime. Shown on Intelligauge as

“###.#”

Ground Terminal

Fuel Valve ON.

Fuel Valve OFF.

SYMBOL MEANING

Choke

Run

Check Oil Level. Recommended oil is

5W-30. The engine can be seriously

damaged without oil. Always check

the oil level before using. The

machine must be resting ﬁrmly on

level ground when checking.

Check Fuel Level. Use clean, fresh,

regular unleaded gasoline with a

minimum octane rating of 87 and an

ethanol content of less than 10% by

volume.

Fuel Valve ON.

Fuel Valve OFF.

Ignition Switch ON. Press the

Ignition Switch to “ON” position.

Ignition Switch OFF. Press the

Ignition Switch to “OFF” position.

Choke. Move choke lever to “CHOKE”

position.

Choke. Move choke lever to “RUN”

position.

Recoil Starter. Pull recoil starter to

start the engine.

100463 - 7500W ELECTRIC START GENERATOR IMPORTANT SAFETY INSTRUCTIONS

SYMBOL MEANING

Plug In. Plug in desired devices.

Unplug. Unplug devices when turning

generator off.

See Manual for Electric Start.

Follow instruction in operator’s

manual to start the generator

electrically.

100463 - 7500W ELECTRIC START GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Top

Safety Labels

These labels warn you of potential hazards that can cause serious injury. Read them carefully.

If a label comes off or becomes hard to read, contact Technical Support Team for possible replacement.

Back

LABEL DESCRIPTION

PELIGRO

El uso de un generador en

interiores PUEDE MATARLO EN

MINUTOS. El escape del

generador contiene monóxido de

carbono. Éste es un veneno que no

se puede ver ni oler.

•NUNCA lo use dentro del hogar ni

el garaje, INCLUSO SI las puertas

y ventanas están abiertas.

•Úselo SÓLO a la INTEMPERIE

lejos de ventanas, puertas, y

oriﬁcios de ventilación.

DANGER

Utiliser une génératrice à l’intérieur

PEUT VOUS TUER EN QUELQUES

MINUTES. L’échappement de la

génératrice contient du monoxyde de

carbone. Il s’agit d’un poison que vous

ne pouvez ni voir ni sentir.

•Ne l’utilisez JAMAIS dans la

maison ou le garage MÊME SI les

portes et les fenêtres sont ouvertes.

•Utilisez la UNIQUEMENT À

L’EXTÉRIEUR, loin des fenêtres,

portes et trappes de ventilation.

NEVER use inside a

home or garage,

EVEN IF doors and

windows are open.

ONLY use OUTSIDE

and far away from

windows, doors,

and vents.

DANGER

Using a generator indoors CAN KILL

YOU IN MINUTES. Generator exhaust

contains carbon monoxide. This is a

poison you cannot see or smell.

1028-L-SF-E

K2945 109 485 ---

ColorsAPN 1028-L-SF

Rev E

Size 163 x 113 mm

Artwork Notes

3mm corner radius; 2mm safe margin

Revision Changes

B: Fix bo ld for “ONLY OUTS IDE” in Frenc h

C: Need a dd the text h eight

D: upd ated “gene rator” wo rd in French

E: updated utilisez-le to utilisez la

This ar twork belongs to C hampion Power Equi pment. The conte nts are conﬁden tial and privileg ed and shall not be disc losed to or used by or fo r

outside p arties withou t the explicit conse nt of Champion Power E quipment.

Safety Icons/

CO Danger

UNLEADED FUEL ONLY. Minimum octane rating

of 87. Maximum 10% ethanol.

GASOLINA REGULAR SOLAMENTE. 87 octanos

como mínimo. Máximo de etanol de 10%.

ESSENCE SANS PLOMB SEULEMENT. Indice

d’octane minimal de 87. Maximum 10 % d'éthanol.

1032-L-OP-B

K109 --- --- ---

ColorsLPN 1032-L-OP

Rev B

Size 78 x 20 mm

Artwork Notes

3mm corner radius; 2mm safe margin

Revision Changes

B: -Changed Octane rating from 85 to 87 (20200421)

This artwork belongs to Champion Power Equipment. The contents are conﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment.

Fuel

WARNING

DO NOT TOUCH!

Exhaust gases, mufﬂer

and engine components

are extremely HOT and

cause burns.

Operation of this equipment may create sparks that can start

ﬁres around dry vegetation. A spark arrestor may be

required. The operator should contact local ﬁre agencies for

laws and regulations relating to ﬁre prevention requirements.

If installed, clean every 100 hours or every season.

ADVERTENCIA

¡NO TOCAR! Los gases de

escape, el silenciador y los

compnonentes del motor están

extremadamente CALIENTES y

causan quemaduras.

La operación de este equipo puede producir chispas que pueden provocar

incendios alrededor de la vegetación seca. Un supresor de chispas puede que

sea necesario. El operador debe comunicarse con las agencias locales de

bomberos para las leyes y reglamentos relativos a los requisitos de prevención

de incendios. Si está instalado, limpie cada 100 horas o cada temporada.

AVERTISSEMENT

NE PAS TOUCHER! Les gaz

d’échappement, le silencieux

et les pièces du moteur sont

extrêmement CHAUDS et

peuvent causer des brûlures.

Cet équipement peut créer des étincelles et provoquer un incendie dans la

végétation sèche. Un pare-étincelles peut être requis. L’utilisateur doit

communiquer avec le service d’incendie local pour connaître les lois et

les règlements en matière de prévention des incendies. Si elle est

installée, nettoyez la génératrice toutes les 100 heures ou chaque saison.

1035-L-SF-C

ColorsLPN 1035-L-SF

Rev C

Size 369 x 2 6 mm

Artwork Notes

3mm corner radius; 2mm safe margin

UL969 certiﬁcation

Revision Changes

C: updated some FR translation words.

This art work belongs to Cham pion Power Equipment. T he contents are con ﬁdential and privi leged and shall not be disc losed to or used by or for

outside p arties withou t the explicit consen t of Champion Power E quipment.

K485 152 --- ---

Hot Surface

Inhaltsverzeichnis

Andere Champion Power Equipment Tragbarer Generator Handbücher

Champion Power Equipment

Champion Power Equipment CSA42412 Handbuch

Champion Power Equipment

Champion Power Equipment Cabela's Outdoorsman Series Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment Cabela's Outdoorsman Series Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment CSA40032 Handbuch

Champion Power Equipment

Champion Power Equipment 75536i Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment 75531i Systemhandbuch

Champion Power Equipment

Champion Power Equipment 201078 Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment 42431 Handbuch

Champion Power Equipment

Champion Power Equipment 41331 Handbuch

Champion Power Equipment

Champion Power Equipment 100155 Systemhandbuch

Champion Power Equipment

Champion Power Equipment 41351 Handbuch

Champion Power Equipment

Champion Power Equipment 40023 Handbuch

Champion Power Equipment

Champion Power Equipment 100331 Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment C41255 Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment 46539 Systemhandbuch

Champion Power Equipment

Champion Power Equipment CSA40037 Handbuch

Champion Power Equipment

Champion Power Equipment CSA40015 Handbuch

Champion Power Equipment

Champion Power Equipment 71531 Systemhandbuch

Champion Power Equipment

Champion Power Equipment 100396 Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment 73001I-DF Systemhandbuch

Champion Power Equipment

Champion Power Equipment 100306 Service-Handbuch

Champion Power Equipment

Champion Power Equipment 201066 Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment 70008 Handbuch

Champion Power Equipment

Champion Power Equipment 100102 Systemhandbuch

Beliebte Tragbarer Generator Handbücher anderer Marken

Kohler

Kohler 20EORZ Bedienungsanleitung

Powerhorse

Powerhorse 83171 Bedienungsanleitung

HURST

HURST ML-630-SI Bedienungsanleitung

ETQ

ETQ TG4000 Bedienungsanleitung

Briggs & Stratton

Briggs & Stratton 40265 Einrichtungshandbuch

evertz

evertz 7700 Series Bedienungsanleitung

Firefly

Firefly Cygnus CYG2400/460/24 Bedienungsanleitung

Owon

Owon Waveform Generator Bedienungsanleitung

Draper

Draper PG950S Firmware-Update

SDMO

SDMO SH 4000 Bedienungsanleitung

EINHELL

EINHELL STE 5500 Bedienungsanleitung

Wanco

Wanco WI3000P Bedienungsanleitung

Full Boar

Full Boar FBT-3300 Bedienungsanleitung

Dwyer Instruments

Dwyer Instruments ASG Bedienungsanleitung

Westinghouse

Westinghouse WH1000i Series Bedienungsanleitung

Wallenstein

Wallenstein GF5000A Bedienungsanleitung

Leroy-Somer

Leroy-Somer LSA 49.1 Bedienungsanleitung

Yamakoyo

Yamakoyo SH2900DX Bedienungsanleitung