COBHAM SAILOR 6120 Bedienungsanleitung

SAILOR 6120/30/40/50

Installation manual

SAILOR 6120/30/40/50

Installation manual

Document number: 98-154541-A

Release date: November 15, 2017

Disclaimer

Any responsibility or liability for loss or damage in connection with the use of

this product and the accompanying documentation is disclaimed by Thrane &

Thrane A/S. The information in this manual is provided for information

purposes only, is subject to change without notice and may contain errors or

inaccuracies. Manuals issued by Thrane & Thrane A/S are periodically revised

and updated. Anyone relying on this information should acquire the most

current version e.g. from www.cobham.com/satcom, Cobham SYNC

Partner Portal, or from the distributor.Thrane & Thrane A/S is not

responsible for the content or accuracy of any translations or reproductions,

in whole or in part, of this manual from any other source. In the event of any

discrepancies, the English version shall be the governing text.

Thrane & Thrane A/S is trading as Cobham SATCOM.

Manufacturer address

Thrane & Thrane A/S, Lundtoftegaardsvej 93 D, DK-2800, Kgs. Lyngby,

Denmark

Trademark Acknowledgements

•Inmarsat is a registered trademark of the International Maritime Satellite

Organisation (IMSO) and is licensed by IMSO to Inmarsat Limited and

Inmarsat Ventures plc.

•SAILOR is a registered trademark of Thrane & Thrane A/S in the European

Union, the United States and other countries.

• Other product and company names mentioned in this manual may be

trademarks or trade names of their respective owners.

iii

Safety summary

The following general safety precautions must be observed during all

phases of operation, service and repair of this equipment. Failure to

comply with these precautions or with specific warnings elsewhere in this

manual violates safety standards of design, manufacture and intended

use of the equipment. Thrane & Thrane A/S assumes no liability for the

customer's failure to comply with these requirements.

Observe marked areas

Under extreme heat conditions do not touch areas

of units that are marked with this symbol, as it may

result in injury.

Microwave radiation hazards

During transmission the antenna in this system radiates Microwave

Power.This radiation may be hazardous to humans close to the antenna.

When the system is powered, make sure that nobody gets closer than the

recommended minimum safety distance of 0.3 m (1 ft.).

Dangers de rayonnements micro-ondes

Lors de transmissions, l'antenne émet des rayons micro-ondes puissants.

Ce rayonnement peut être dangereux pour les personnes à proximité de

l'antenne. Lorsque le système est sous tension, assurez-vous que personne

ne s’approche à moins de 0,3 m (1 pi.) de l’antenne, la distance de sécurité

minimale recommandée.

Keep away from live circuits

Operating personnel must not remove equipment covers. Only qualified

maintenance personal must make component replacement and internal

adjustment. Under certain conditions, dangerous voltages may exist even

with the cable removed. To avoid injuries, always disconnect power and

discharge circuits before touching them.

Compass safe distance

Minimum safety distance: 5 m from the SAILOR 3027 mini-C terminal.

About the manual

Naming conventions

This manual covers four different types of system. For information that

applies to all four types, the following naming conventions are used:

Intended readers

This manual is an installation manual for the SAILOR 6120/30/40/50

mini-C systems. The manual is intended for installers of the system and

service personnel. Personnel installing or servicing the system must be

properly trained and authorized by Cobham SATCOM. It is important that you

observe all safety requirements listed in the beginning of this manual, and

install the system according to the guidelines in this manual.

Common name Used for

mini-C system SAILOR 6120 SSA System

SAILOR 6130 LRIT System

SAILOR 6140 Maritime System

SAILOR 6150 Non-SOLAS System

SAILOR 3027 SAILOR 3027 SSA Terminal

SAILOR 3027 LRIT Terminal

SAILOR 3027 Maritime Terminal

SAILOR 3027 Non-SOLAS Terminal

Table 1: Naming conventions for terminal and system

Manual overview

Note that this manual does not cover how to use the system. For information

on usage refer to the user manual [1].

This manual covers the SAILOR 6120/30/40/50 with the SAILOR 6018

Message Terminal. For information specific to the SAILOR 6006 Message

Terminal, refer to the manuals [4], [5] and [6].

Part numbers for related manuals are listed in the next section.

This manual has the following chapters:

•Introduction contains an overview of the system.

•Install the system explains how to mount the units.

•Connect the system explains how to connect the units in the system

and shows wiring, pin-out and cable requirements.

•Configuration describes the tools available and explains the initial

configuration of the system.

•Installation check and test contains a check list for verifying the

physical installation and guidelines for testing the installation.

•Service and maintenance contains guidelines for handling, maintaining

and repacking the SAILOR 6120/30/40/50.

Related documents

Ref Title and description Document number

[1] SAILOR 6120/30/40/50, User manual

(with SAILOR 6018 Message Terminal)

98-154542

[2] SAILOR 6018 Message Terminal, Installation

manual

98-150478

[3] SAILOR 6194 Terminal Control Unit,

Installation and user manual

98-131593

[4] SAILOR 6120/30/40/50, User manual

(with SAILOR 6006 Message Terminal)

98-131590

Table 2: Related documents

Typography

In this manual, typography is used as indicated below:

Bold is used for the following purposes:

•Toemphasizewords.

Example: “Do not touch the antenna”.

• To indicate what the user should select in the user interface.

Example: “Select SETTINGS > LAN”.

Italic is used to emphasize the paragraph title in cross-references.

Example: “For further information, see Connecting Cables on page...”.

COURIER is used to indicate low level commands or text in the display.

Example: “The display shows Distress”.

Online training for Cobham SATCOM partners

As a Cobham SATCOM Partner you have access to free of charge technical

training in this SAILOR product covering installation, commissioning and

repair.

For details on available training classes please consult the Training Academy.

If the above link does not work, go to cobham.com/satcom. Select Cobham

SYNC Partner Portal. Then select Training. Enter email and password and

log into the Cobham SATCOM Training Academy.

To learn more on CAN-bus as used with this product you may take the

eLearning course “Introduction to CAN-bus” available at the Training

Academy.

[5] SAILOR 6120/30/40/50, Installation manual

(with SAILOR 6006 Message Terminal)

98-131589

[6] SAILOR 6006/6007 Message Terminal,

Installation manual

98-130088

[7] Software Interface Reference Manual for the

TT-3027C/D/M/LT/SSA mini-C transceivera98-147405

a. Only available for certified partners.

Ref Title and description Document number

Table 2: Related documents

vii

Table of contents

Chapter 1 Introduction

1.1 SAILOR 6120/30/40/50 system overview.........................1

1.2 Units in the system ...................................................................6

Chapter 2 Install the system

2.1 Unpack ......................................................................................... 10

2.2 General installation requirements .................................. 12

2.3 Install the SAILOR 3027..............................................................14

Chapter 3 Connect the system

3.1 Connect the units............................................................................21

3.2 Ground the units ..............................................................................29

3.3 The CAN backbone ................................................................ 32

3.4 Connect power ........................................................................ 33

3.5 Connectors and pinout ........................................................ 40

Chapter 4 Configuration

4.1 Register your SAILOR 3027 ......................................................48

4.2 Configuration tools ........................................................................50

4.3 Configuration using easyMail ........................................... 51

4.4 Configuration using SAILOR 6018 (only for SAILOR

6150)55

4.5 Configuration using commands ...................................... 62

4.6 SSA buttons configuration (SAILOR 6120 only) ..... 65

Table of contents

viii

Chapter 5 Installation check and test

5.1 Installation check list ............................................................ 74

5.2 Test the SAILOR 6130 LRIT System...................................75

5.3 Test the system with easyMail ........................................ 76

5.4 Test the system with SAILOR 6018....................................79

Chapter 6 Service and maintenance

6.1 Update the software ............................................................. 86

6.2 Maintenance guidelines..............................................................89

6.3 Service and repair ................................................................... 90

6.4 Available parts .......................................................................... 91

App. A Technical specifications

A.1 SAILOR 6120/30/40/50 specifications.............................93

A.2 SAILOR 3027 specifications .............................................. 94

Glossary ..................................................................................................................................97

Index ............................................................................................................................... 101

Andere Handbücher für SAILOR 6120

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere COBHAM Antenne Handbücher

COBHAM

COBHAM Sea Tel Tracker 6000 Bedienungsanleitung

COBHAM

COBHAM HGA-6000 Bedienungsanleitung

COBHAM

COBHAM HGA-7001 Bedienungsanleitung

COBHAM

COBHAM SAILOR 1000 XTR Ku 8W Bedienungsanleitung

COBHAM

COBHAM EXPLORER 6100 Ku Bedienungsanleitung

COBHAM

COBHAM EXPLORER 7100GX Bedienungsanleitung

COBHAM

COBHAM Sea Tel 4010W-17 Bedienungsanleitung

COBHAM

COBHAM SAILOR 60 GX-R2 4.5 W Bedienungsanleitung

COBHAM

COBHAM Explorer 3075 Bedienungsanleitung

COBHAM

COBHAM Sea Tel Bedienungsanleitung

COBHAM

COBHAM SEA TEL 9711IMA-70 Bedienungsanleitung

COBHAM

COBHAM SAILOR 600 Viasat Ka Bedienungsanleitung

COBHAM

COBHAM EXPLORER 3075GX Leitfaden

COBHAM

COBHAM SAILOR 800 VSAT Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM SAILOR 800 VSAT Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM Sea Tel 09 Series Handbuch

COBHAM

COBHAM SAILOR 6120 Bedienungsanleitung

COBHAM

COBHAM EXPLORER 8100 Bedienungsanleitung

COBHAM

COBHAM EXPLORER 3075GX Bedienungsanleitung

COBHAM

COBHAM S-67-175992 Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM SAILOR XTR Ku Bedienungsanleitung

COBHAM

COBHAM EXPLORER 6075LX Bedienungsanleitung

COBHAM

COBHAM SAILOR 1000 XTR Ku 8W Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM Sea Tel Bedienungsanleitung

Beliebte Antenne Handbücher anderer Marken

Alfa Network

Alfa Network APA-L01 Bedienungsanleitung

Naval

Naval PR-422CA Bedienungsanleitung

Feig Electronic

Feig Electronic ID ISC.ANTH200/200 Series Bedienungsanleitung

TERK Technologies

TERK Technologies TV44 Bedienungsanleitung

Directive Systems & Engineering

Directive Systems & Engineering DSE2324LYRMK Bedienungsanleitung

HP J8999A Bedienungsanleitung

MobilSat

MobilSat MSP-S Bedienungsanleitung

Steren

Steren ANT-UHF 13 Bedienungsanleitung

Novatel

Novatel 600-G Bedienungsanleitung

Radio Shack

Radio Shack Amplified VHF/UHF/FM Indoor Antenna Bedienungsanleitung

TRENDnet

TRENDnet TEW-AO12O Bedienungsanleitung

Radio Shack

Radio Shack 15-1837 Bedienungsanleitung

CommScope

CommScope CMAX-OMFX-43M-I53 Bedienungsanleitung

Ramsey Electronics

Ramsey Electronics DAP25 Bedienungsanleitung

Trango Systems

Trango Systems AD900-9 Bedienungsanleitung

Steren

Steren ANT-100 Bedienungsanleitung

IWCS

IWCS iriBelt II Einrichtungshandbuch

Labgear

Labgear LABHG32T Bedienungsanleitung