Cornelius Liquid Base Beverage Dispenser Bedienungsanleitung

P/N 630460068

July 8, 1998

IMI Cornelius Inc; 1998

IMI CORNELIUS INC.

One Cornelius Place

Anoka, MN. 55303–6234

Telephone (612) 421–6120

Facsimile (612) 422–3232

INSTALLATION MANUAL

Liquid Base Beverage Dispenser

DRIP

TRAY

CUP

REST

FRONT

ACCESS PANEL

SUPPLY INLET

Design data

Width 10 3/4”

Height 21”

Depth 9 1/8”

Electrical Requirements:(if applicable)

15 Amp Circuit, 115v 60hz

.52 Amp Unit Current Draw

24v 60hz, Dispensing valves

Installation Check List :

Counter Top with access to route

concentrate supply lines.

15 Amp,115v60hz Outlet, Within 5’

(if applicable)

Cold Water Supply, With Shutoff

Overall Dimensions:

Weight: 12 lbs

24 VOLT

TRANSFORMER

(24 Volts) cord to

dispensing valves

RECEIVING

Each Unit is completely tested under operating conditions and thoroughly inspected before shipment. At time of

shipment, the carrier accepts the Unit and any claim for damage in transit must be made with the carrier. Upon

receiving Unit from the delivering carrier, carefully inspect the carton for visible indication of damage. Any dam-

age or irregularities should be noted at time of delivery (or not later than 15 days from date of delivery) and im-

mediately reported to the delivering carrier. Request a written inspection report from the Claims Inspector to

substantiate claim. File claim with the delivering carrier, not with IMI Cornelius Inc.

INSTALLATION

Place Unit in selected location to install unit.

Use mounting template (See page No. 3), to drill mounting holes for installing unit to counter top.

Liberally apply a sealant, such as Dow Corning RTV 731 or equivalent, to the unit flange bottom surface,per

(NSF) requirements, the unit must be sealed to the counter top.

Make connections as follows:

Plain Water Source Connections:

TO THE INSTALLER

It is the responsibility of the installer to ensure that the water supply to the dispensing equipment is

provided with protection against backflow by an air gap as defined in ANSI/ASME A112. 1.2-1979; or an

approved vacuum breaker or other such method as proved effective by test.

P/N 630460068

Water pipe connections and fixtures directly connected to a potable water supply shall be sized,

installed, and maintained according to Federal, State, and Local laws.

1. Flush plain water source thoroughly before connecting to Unit.

2. Connect plain water source to water inlet tube labeled ‘‘WATER’’.

Concentrate Line Connection:

1. Connect concentrate source lines to inlet lines from dispenser, labeled ‘‘1 or 2 etc’’. DO NOT CONNECT

SOURCE LINES TO CONCENTRATE AT THIS TIME.

Transformer Connections:(for electric valve units)

1. Connect Unit cord two-pin connector to the mating connector on the transformer output (24V) cord.

Steps of final installation:

1. Plug transformer into electrical outlet with proper electrical requirements.

2. Open shutoff valve in plain water source line.

3. Inspect connections for leaks.

4. Place a waste container under each nozzle and operate valve(s) to remove air from the plain water line.

5. Connect concentrate supply to concentrate system.

6. Open cylinder shutoff valve to apply the calculated pressure (approx. 40 PSI) to the concentrate system.

7. Operate each dispensing valve to remove air from the lines.

8. Check all lines for leaks.

9. Adjust Dispensing Valves for Water-To-Concentrate “Ratio”of dispensed drinks as instructed on ”BRIXING

VALVES”instructions.

NOTE: Concentrate system must be sanitized before Unit is put into operation. Refer to

Owner/Operator Manual for procedure.

10. Apply flavor decals to valve covers.

P/N 630460068

ONE SINGLE-FLAVOR

DISPENSING VALVE

ADJUSTABLE CONCENTRATE

FLOW REGULATOR

CONCENTRATE NO. ”2” IN

CONCENTRATE NO. ”1” IN

”WATER” IN

TWO SINGLE-FLAVOR

DISPENSING VALVES

”WATER” IN

CONCENTRATE NO. ”1” IN

CONCENTRATE NO. ”3” IN

CONCENTRATE NO. ”4” IN

TWO TWO-FLAVOR

DISPENSING VALVES

ADJUSTABLE WATER

FLOW REGULATOR

CONCENTRATE NO. ”2” IN

FLOW DIAGRAMS

”WATER” IN

CONCENTRATE NO. ”1” IN ”WATER” IN

”WATER” IN

Andere Handbücher für Liquid Base Beverage Dispenser

Inhaltsverzeichnis

Andere Cornelius Getränkespender Handbücher

Cornelius

Cornelius A8530 Einrichtungshandbuch

Cornelius

Cornelius Ice Cooled Dispensers Bedienungsanleitung

Cornelius

Cornelius REMCOR R-134A Beilage

Cornelius

Cornelius A.B.S. Unit Bedienungsanleitung

Cornelius

Cornelius Impulse Non-Carbonated Post-Mix Beverage... Bedienungsanleitung

Cornelius

Cornelius IntelliCarb Cold Beverage Dispenser Installationsanleitung

Cornelius

Cornelius JETSPRAY LT1 Bedienungsanleitung

Cornelius

Cornelius Flavorfusion Ice Drink Dispenser with Flavor... Bedienungsanleitung

Cornelius

Cornelius 300026000 Bedienungsanleitung

Cornelius

Cornelius ABS 2.0 Bedienungsanleitung

Cornelius

Cornelius Quest Juice Dispenser Bedienungsanleitung

Cornelius

Cornelius V4 Betriebsanleitung

Cornelius

Cornelius ED 300 BC Bedienungsanleitung

Cornelius

Cornelius VANGUARD 245 Bedienungsanleitung

Cornelius

Cornelius Enduro 200 Bedienungsanleitung

Cornelius

Cornelius FCB V4 Technische Daten

Cornelius

Cornelius R-404A REFRIGERANT Bedienungsanleitung

Cornelius

Cornelius PRISM Bedienungsanleitung

Cornelius

Cornelius Tea Tower Bedienungsanleitung

Cornelius

Cornelius ED 300 BN Bedienungsanleitung

Cornelius

Cornelius Enduro-200/250 Bedienungsanleitung

Cornelius

Cornelius IDC PRO 255 Bedienungsanleitung

Cornelius

Cornelius Flavorfusion TP01070 Installationsanleitung

Cornelius

Cornelius FCB Pinnacle Bedienungsanleitung

Beliebte Getränkespender Handbücher anderer Marken

PEGAS

PEGAS Evolution Bedienungsanleitung

Ugolini

Ugolini MT micro Bedienungsanleitung

Bunn

Bunn SLCA-7 Montageanleitung

Gekkeikan

Gekkeikan Sake Machine Bedienungsanleitung

Olympia

Olympia DH709 Bedienungsanleitung

Marco

Marco ECOSMART PB10 Bedienungsanleitung

Marvel

Marvel ML24BN Series Handbuch

Cecilware

Cecilware 2K-GB-LD Handbuch

Sure Vend

Sure Vend 673 Bedienungsanleitung

Nostalgia Electrics

Nostalgia Electrics KEG7000SS Bedienungsanleitung

Bunn

Bunn LCR-3 HV Fehlerbehebungshandbuch

Servend

Servend SV-200 Bedienungsanleitung

EdgeStar

EdgeStar VBR440 Bedienungsanleitung

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C Bedienungsanleitung

Siemens

Siemens GA 3000 Gebrauchsanweisung

Selbach

Selbach Fruit Juice dispenser Bedienungsanleitung

Taylor

Taylor C302NP Bedienungsanleitung

Vinotemp

Vinotemp VT-WINEDISP2 Bedienungsanleitung