DENTSPLY Cavitron Handbuch
DENTSPLY®CAVITRON®ULTRASONIC INSERTS
DIRECTIONS FOR USE and INFECTION CONTROL PROCEDURES
INSERTS ULTRASONIQUES
DENTSPLY®CAVITRON®
MODE D’EMPLOI et PROCÉDURES DE CONTRÔLE DE L’INFECTION
INSERTOS ULTRASÓNICOS
DENTSPLY®CAVITRON®
INSTRUCCIONES DE USO y PROCEDIMIENTOS PARA EL CONTROL DE INFECCIONES
INSERTI ULTRASONICI
DENTSPLY® CAVITRON®
ISTRUZIONI PER L'USO e PROCEDURE DI CONTROLLO DELLE INFEZIONI
DENTSPLY®CAVITRON®
ULTRASCHALL-INSTRUMENTENEINSÄTZE
GEBRAUCHSANLEITUNG und INFEKTIONSKONTROLLVERFAHREN
Cavitron
УЛЬТРАЗВУКОВЫЕ ВКЛАДЫШИ DENTSPLY®CAVITRON®
УКАЗАНИЯ ПО ПРИМЕНЕНИЮ и ПРОЦЕДУРЫ ПРОФИЛАКТИКИ ИНФЕКЦИЙ
2
DIRECTIONS FOR USE
ENGLISH
INDICATIONS FOR USE
Cavitron®inserts are to be used with magnetostrictive
ultrasonic scalers to perform:
• All general supra and subgingival scaling applications.
• Periodontal debridement for all types of periodontal diseases.
• Endodontic Procedures.
CONTRAINDICATIONS
• Cavitron inserts should not be used for restorative dental
procedures involving condensation of amalgam.
WARNING
• Tips with high usage which exceed the warranty period
should be discarded to avoid possible in-use breakage and
possible injury.
• Handle insert with care. Improper handling of insert,
specifically the insert tip, may result in injury and/or cross
contamination.
• It is strongly recommended that this insert be used in
accordance with the current CDC Guidelines for Infection
Control in dental healthcare settings.
• Failure to follow properly validated sterilization processes and
approved aseptic techniques for Cavitron inserts may result
in cross contamination.
PRECAUTIONS
• It is the responsibilty of the Dental Healthcare Professional
to determine the approriate uses of this product and to
understand:
• The health of each patient;
• The dental procedures being undertaken;
• The applicable industry and government agency
recommendations for the infection control in dental
3
ENGLISH
healthcare settings;
• The requirements, and regulations for the safe practice
of dentistry, and;
•These Directions For Use in their entirety.
• Operate the inserts only at the recommended power
settings.
• Check water spray to verify fluid is reaching the working
end of the insert tip. Adjust the water lavage control until
the water (lavage) flows with a rapid drip or small spray
(approximately 35mL). Higher water flow settings provide
cooler irrigation.
• Do not bend or reshape insert. Inserts should be handled
with care at all times. Ultrasonic Inserts tips that have been
bent, reshaped or otherwise damaged are susceptible
to in-use breakage and should be discarded and replaced
immediately.
• Cavitron ultrasonic scaling units and Cavitron ultrasonic
inserts are designed and tested for safety and efficacy as a
system. Use of any other brand ultrasonic equipment with
Cavitron equipment has not been tested and may have
a negative effect on the safety and effectiveness of your
Cavitron equipment and their warranties. Please review the
warranty statement enclosed before use.
• Like bristles of a toothbrush, ultrasonic inserts “wear” with
use. Refer to the Efficiency Wear Indicators supplied with
your Cavitron system or insert and the How to Use the
Efficiency Indicator section of these Directions for Use. If
excessive wear is noted, discard the insert immediately.
ADVERSE REACTIONS: None Known.
UNIT POWER SETTINGS
• PEC, PEC-2, Focused Spray® Slimline®-10S,
L&R and Slimline®-10S, L&R inserts should only be used up
to medium power.
• All other Cavitron inserts may be used up to maximum
power.
4
ENGLISH
INSERT SELECTION
Base insert selection on the following:
• Patient’s health or disease status.
• Root anatomy, considering concavities and furcations.
• Type and location of deposits to be removed.
For Gross Deposit Removal
Classic P, TFI®, and Focused Spray® Powerline™ Inserts
For Fine Definitive Debridement
Focused Spray Slimline® and Slimline®straight inserts and
Cavitron THINsert®for light calculus removal and deplaquing
pockets <4 mm deep.
Focused Spray Slimline and Slimline®left and right inserts for
fine periodontal debridement, excellent access and adaptation
to root anatomy in pockets >4 mm deep.
For Endodontic Procedures
PEC and PEC2 Endosonic® Inserts used with DENTSPLY
Professional Endosonic Files for root canal therapy.
OPERATING INSTRUCTIONS
1. Select the appropriate insert for the tooth or root to be
treated.
2. Use the lowest effective power setting.
3. Adjust the water control until the water (lavage) flows with a
rapid drip or small spray.
4. Use very light pressure with a light pen or modified pen
grasp.
5. Use a light but stable intraoral or extraoral fulcrum.
6. Adapt the insert so the point is not directed into root surface.
5
ENGLISH
7. Use a light, smooth gentle touch.
8. Keep the insert tip in motion at all times, using overlapping
horizontal, vertical or oblique brush-like strokes.
9. Use the inactivated insert to explore/evaluate root surface.
O-RING CARE
Before placing the insert into the handpiece, performing the
following steps will increase the o-ring life on Cavitron inserts:
• Fill entire handpiece with water.
• Lubricate o-ring (black or green rubber material) with water.
• Gently twist the insert down into the handpiece until the
insert is fully seated in place.
WARNINGS
• Instruments are not sterile upon receipt and must be sterilized
prior to use in accordance with the following instructions.
• The use of cleaning and disinfectant solutions is not
recommended.
LIMITATIONS ON PROCESSING
• Repeated cleaning and sterilization cycles have minimum
effect on these instruments. End of life is normally determined
by wear and damage due to use.
• Do not use chemical disinfectants prior to sterilization or rapid
deterioration of the material may occur.
• Cold liquid disinfection/sterilization, chemical vapor
sterilization, and dry heat sterilization methods have not been
tested or validated for efficacy and are not recommended for
use.
INSTRUCTIONS
Point of use:
Remove excess soil with disposable cloth or paper.
Containment and Transportation:
Protect instruments from damage. Instruments should be
reprocessed as soon as is reasonably practical following use.
Instruments left standing wet may stain or corrode.
INFECTION CONTROL PROCEDURES
6
Cleaning: Automated
• May be cleaned using an ultrasonic water bath for
15 minutes.
Cleaning: Manual
• Rinse all instruments under running water to remove any
gross debris.
Disinfection:
Additional disinfection is not necessary prior to sterilization.
Packaging:
Place instrument in a paper or paper/plastic steam sterilization
pouch. Instruments may be loaded into dedicated instrument
trays. Remove Endosonic Files from PEC and PEC2 inserts
prior to packaging.
Sterilization:
Use a steam autoclave. Place bagged instruments into the
steam autoclave, paper side up when using a paper/plastic
pouch.
Gravity Steam Sterilization
Full Cycle: Bagged -135°C (275°F) for 3.5 minutes
Pre-vacuum Steam Sterilization
Full Cycle: Bagged -132°C (270°F) for 3 minutes
Alternate Method:
Place non-bagged instruments into the steam autoclave and
run at the listed cycles.
NOTE: Instruments sterilized unbagged should be used
immediately.
Drying:
To dry, use the drying cycle of the autoclave. Set cycle for
20-30 minutes.
Maintenance, inspection and testing:
• Visually inspect to ensure all contamination is removed.
ENGLISH
7
• Visually inspect all o-rings for wear. Replace worn o-rings
(Refer to O-Ring Replacement Kit Instructions). Lubricate
o-rings with water before use.
• Check for distortion, damage and wear (Refer to Efficiency
Wear Indicator Instructions). Discard damaged, worn or
corroded instruments.
Storage:
To maintain sterility, instruments should remain bagged until
ready for use.
1) For cards with notches, place the insert tip flat against the
applicable Insert Tip diagram with the engraved line aligned
with the edge of the card. For cards without notches, match
the insert to the appropriate graphic. Hold the top of the
grip flush against the edge of the wear guide. Rotate the
insert so the tip is flat against the card.
2) Compare length to the red and blue lines.
3) Evaluate tip shape. If shape does not match profile, discard
the insert.
To re-order Inserts, call your local DENTSPLY Professional
Distributor or call Customer Service 800-989-8826
To order efficiency indicator cards for Cavitron®inserts: Call
DENTSPLY Professional Customer Service at 1-800-989-8826.
Cavitron® ultrasonic inserts manufactured by DENTSPLY
Professional are warranted against defects arising from faulty
ENGLISH
HOW TO USE THE EFFICIENCY WEAR INDICATOR
Tip touches
blue line
Reorder
Tip touches
red line
Discard
Tip extends beyond
blue line
Optimal Efficiency
Red Blue
WARRANTY
8
ENGLISH
materials or workmanship for ninety days from the date of
purchase. This warranty extends to inserts purchased from
an authorized DENTSPLY distributor and only to the original
purchaser and is valid only for inserts purchased in the United
States (U.S.) and for those countries without specific warranty
requirements. For inserts purchased outside the U.S. in
countries with specific warranty requirements, those applicable
country warranties will apply. This warranty is subject to the
following conditions:
1) Inserts must not be subjected to abuse or improper use or
application.
2) Inserts must not be subjected to abuse or improper cleaning,
disinfection, or sterilization procedures.
3) Bending or reshaping the inserts will void the warranty.
4) Using inserts in units other than CAVITRON ultrasonic
systems will void the warranty.
There are no warranties, expressed or implied beyond the
description on the face hereof. DENTSPLY neither assumes,
nor authorizes any person to assume for it, any other liability for
incidental and consequential damages resulting from the use
of the insert.
To receive reimbursement for any defective Cavitron ultrasonic
insert, you must send the defective product within the warranty
period to the dealer or manufacturer with specification of the
defect and receipt of purchase.
FOR TECHNICAL SUPPORT:
Call DENTSPLY PROFESSIONAL PRODUCT SERVICES
DEPARTMENT at 1-800-989-8826.
9
FRANÇAIS
MODE D'EMPLOI
INDICATIONS
Les inserts Cavitron®doivent être utilisés avec des détartreurs
ultrasoniques magnétostrictifs afin d’effectuer les procédures
suivantes:
• Toutes les procédures générales de détartrage sus- et
sous-gingival.
• Débridement parodontal pour tous les types de maladies
parodontales.
• Les procédures endodontiques.
CONTRE-INDICATIONS
Les inserts Cavitron ne doivent pas être utilisés pour
des procédures de restauration dentaire nécessitant la
condensation d’un amalgame.
AVERTISSEMENT
• Les embouts fortement usagés et dont la période de garan-
tie a expiré doivent être jetés afin d’éviter leur éventuelle
cassure en cours d’utilisation et des blessures potentielles.
• Manipuler l’insert avec soin. Une mauvaise manipulation de
l’insert, en particulier de l’embout, risque de provoquer des
blessures et/ou une contamination croisée.
• Il est fortement recommandé d’utiliser cet insert conformé-
ment aux directives du CDC (“Center for Disease Control”,
ou Centre américain de veille sanitaire) relatives au contrôle
des infections en cabinet dentaire.
• Tout manquement aux procédures de stérilisation validées
et aux techniques d’aseptisation homologuées pour les
inserts Cavitron risque de provoquer une contamination
croisée.
10
FRANÇAIS
PRÉCAUTIONS
• Il est de la responsabilité du praticien dentaire de déterminer
les cas dans lesquels ce produit peut être utilisé, et d’être au
fait de :
• l’état de santé du patient ;
• les procédures de soins dentaires actuellement entreprises;
• les recommandations professionnelles et officielles en
matière de contrôle des infections dans le cadre des soins
dentaires ;
• es exigences et la réglementation nécessaires à une
pratique sans danger de sa profession ; et
• le présent Mode d’emploi dans son intégralité.
• Vaporiser un peu d’eau pour s’assurer que le liquide atteint
l’extrémité de l’embout de l’insert. Régler le débit de lavage
jusqu’à ce que l’eau (de lavage) s’égoutte rapidement ou
s’écoule en un mince jet (environ 35 mL). Un débit d’eau plus
important entraîne une irrigation plus froide.
• Ne pas tordre et ne pas déformer l’insert. Prendre garde
à toujours le manipuler avec soin. Les pointes d’insert
ultrasonique qui ont été tordues, endommagées ou
déformées sont susceptibles de se casser en cours
d’utilisation et doivent être jetées et remplacées
immédiatement.
• Les unités de détartrage à ultra-sons Cavitron et les
inserts Cavitron sont conçus et testés pour une utilisation
sans danger et un fonctionnement efficace du système.
L’utilisation d’un dispositif à ultra-sons d’une autre marque
avec le matériel Cavitron n’a pas été testée, des effets
néfastes sont donc possibles pour la sécurité et l’efficacité
du système Cavitron, ainsi que pour les garanties. Veuillez
lire attentivement la déclaration de garantie ci-jointe avant
toute utilisation.
• Tout comme les poils d’une brosse à dents, les pointes
d’insert ultrasonique s’émoussent avec l’usage. Utilisez
Andere Handbücher für Cavitron
2
Inhaltsverzeichnis
Sprachen:
Andere DENTSPLY Dentalgeräte Handbücher
DENTSPLY
DENTSPLY Biodent K+B Plus Bedienungsanleitung
DENTSPLY
DENTSPLY AutoMate III Bedienungsanleitung
DENTSPLY
DENTSPLY Midwest E Electric Handpiece System Handbuch
DENTSPLY
DENTSPLY Cavitron Prophy-Jet Handbuch
DENTSPLY
DENTSPLY Dispersalloy Handbuch
DENTSPLY
DENTSPLY CAVITRON JET AIR Series Handbuch
DENTSPLY
DENTSPLY Spectrum 800 Series Bedienungsanleitung
DENTSPLY
DENTSPLY Cavitron JET Handbuch
DENTSPLY
DENTSPLY Cavitron SPS G98A Handbuch
DENTSPLY
DENTSPLY ORTHORALIX 9200 Bedienungsanleitung
DENTSPLY
DENTSPLY AEU-25T Handbuch
DENTSPLY
DENTSPLY Rhino XE K-Style Bedienungsanleitung
DENTSPLY
DENTSPLY X-SMART Endo Motor Bedienungsanleitung
DENTSPLY
DENTSPLY Cavitron Handbuch
DENTSPLY
DENTSPLY ProMix 400 Montageanleitung
DENTSPLY
DENTSPLY CEREC MC X Konfigurationshandbuch
DENTSPLY
DENTSPLY Cavitron Built-In Steri-Mate G90 Handbuch
DENTSPLY
DENTSPLY Cavitron Handbuch
DENTSPLY
DENTSPLY SmartLite PS Handbuch
DENTSPLY
DENTSPLY Sani-Tip Handbuch
Beliebte Dentalgeräte Handbücher anderer Marken
Vatech
Vatech EzRay Air VEX-P300 Bedienungsanleitung
KaVo
KaVo GENTLEpower LUX Contra-angle 25 LP Bedienungsanleitung
LM
LM ProPower CombiLED Bedienungsanleitung
Owandy Radiology
Owandy Radiology RX-AC Bedienungsanleitung
mectron
mectron Piezosurgery Bedienungsanleitung
Belmont
Belmont CREDIA G1 Bedienungsanleitung
