Dometic PerfectWall PW1000 Bedienungsanleitung

2.6m

3.0m

3.5m

4.0m

4.5m

5.0m

5.5m

6.0m

1215

1415

1585

120 1585

1250

1500 1500

200 1010 1250

1500

1750

2450

240 1430

530

1500

1750

2450

1215

1415

280

4 5 6 7 8 9 10

11 12 13 14 15 16 17 18

1500/

1750

15 – 20 Nm

PW1000,

PW1500, PW1750

ab c

leaflet_figures.fm Seite 1 Montag, 8. Oktober 2018 11:00 11

More information https://www.caravansplus.com.au

www.dometic.com

Dometic WAECO International GmbH

Hollefeldstrasse 63

D-48282 Emsdetten

dometic.com

Ø3 mm

2. 3.

Ø 3 mm

T15A

T3A

D+

bnbu

810 11

+12 Vg

def l

4445101839 0700297 09/2018

leaflet_figures.fm Seite 2 Montag, 8. Oktober 2018 11:00 11

More information https://www.caravansplus.com.au

PW1000, PW1500, PW1750

Awning

Installation Manual. . . . . . . . . . . . . . . . . . . . . 3

Markise

Montageanleitung. . . . . . . . . . . . . . . . . . . . 15

Store extérieuru

Instructions de montage . . . . . . . . . . . . . . .28

Toldo

Instrucciones de montaje . . . . . . . . . . . . . . 41

Tol do

Instruções de montagem . . . . . . . . . . . . . .54

Ten da d a sole

Indicazioni di montaggio . . . . . . . . . . . . . .67

Zonnescherm

Montagehandleiding . . . . . . . . . . . . . . . . .80

Markise

Monteringsvejledning. . . . . . . . . . . . . . . . .92

Markis

Monteringsanvisning. . . . . . . . . . . . . . . . .104

Markise

Monteringsanvisning. . . . . . . . . . . . . . . . . 116

Markiisi

Asennusohje . . . . . . . . . . . . . . . . . . . . . . .128

Синусоидальный инвертор

Инструкция по монтажу. . . . . . . . . . . . . . 140

Markiza

Instrukcja montażu . . . . . . . . . . . . . . . . . . 153

Markíza

Návod na montáž. . . . . . . . . . . . . . . . . . . 166

Markýza

Návod k montáži . . . . . . . . . . . . . . . . . . . . 178

Előtető

Szerelési útmutató . . . . . . . . . . . . . . . . . . 190

Markiza

Navodilo za montažo . . . . . . . . . . . . . . . . 202



 

AWNINGS

PERFECTWALL



More information https://www.caravansplus.com.au

PerfectWall Explanation of symbols

Table of contents

1Explanationofsymbols...........................................3

2Importantsafetyandinstallationinstructions..........................4

3Scopeofdelivery...............................................4

4Accessories....................................................5

5Intendeduse...................................................6

6Installingtheawning.............................................6

7Connectingtheawning(PW1500andPW1750).....................12

8Disposal......................................................14

1 Explanation of symbols

WARNING!

This operating manual must be read and understood before

installation, set up, operation and servicing. This device must be

installed by a specialist. Improper installation can lead to serious

injury. Alterations to the device can be extremely dangerous and

lead to serious injury or damage to the device.

Keep this operating manual with the device. The owner must read it

carefully.

WARNING!

Safety instruction: Failure to observe this instruction can cause fatal or

serious injury.

NOTICE!

Failure to observe this instruction can cause material damage and impair

the function of the product.

NOTE

Supplementary information for operating the product.



More information https://www.caravansplus.com.au

Important safety and installation instructions PerfectWall

2 Important safety and installation

instructions

Please observe the safety instructions and stipulations issued by the

vehicle manufacturer and service workshops.

The manufacturer accepts no liability for damage in the following cases:

Faulty assembly or connection

Damage to the product resulting from mechanical influences

Alterations to the product without express permission from the manufacturer

Use for purposes other than those described in the operating manual

!WARNING!

If you do not have sufficient technical knowledge for installing

components in vehicles, you should have a specialist fit the awning to

your vehicle.

3Scopeofdelivery

No. in

fig. 1,

page 1

Awning width

Description

2.6 m,

3m,3.5m 4m,4.5m 5m,5.5m

11x1x1xAwning

2 – – 2x Mounting plate (400 mm)

3 – 2x 2x Mounting plate (160 mm)

4 2x 2x – Mounting plate (80 mm)

5 1x – – Mounting plate (35 mm)

6 5x 8x 12x Counter plate

7 5x 8x 12x Square-head bolt

8 2x 4x 6x Countersunk bolt

9 7x 12x 18x Serrated lock washer

10 7x 12x 18x Hexagon nut

11 5x 8x 12x Cover for the counter plate

12 11x 14x 18x Self-tapping screw



More information https://www.caravansplus.com.au

PerfectWall Accessories

4Accessories

Available as accessories (not included in the scope of delivery):

13 2x 2x 2x Mounting bracket (lower section)

14 2x 2x 2x Mounting bracket (upper section)

15 1x 1x 1x Crank bracket (lower section)

16 1x 1x 1x Crank bracket (upper section)

(only PW1500, PW1750)

17 4x 4x 4x Rivets

18 4x 4x 4x Pegs

19 1x 1x 1x Crank (only awnings without

motor)

20 – 1x 1x Latch for tension rafter

21 – 1x 1x Hexagon head bolt

22 – 1x 1x Tension rafter

23 – 1x 1x Hexagon nut

24 1x 1x 1x Remote control with connection

material (only PW1500, PW1750,

optional)

25 1x 1x 1x Switch (only PW1500, PW1750,

optional)

Description

TieDown Kit

Straps for anchoring the awning

CampRoom

Awning tent front panel and sides for various models with support legs in different sizes

RainProtect

Front panel and sides available in different sizes

No. in

fig. 1,

page 1

Awning width

Description

2.6 m,

3m,3.5m 4m,4.5m 5m,5.5m



More information https://www.caravansplus.com.au

Intended use PerfectWall

If you have questions regarding the accessories, please contact your local service

partner.

5 Intended use

The PerfectWall PW1000, PW1500 and PW1750 awnings are suitable for installing

on motorhomes or caravans.

The awnings must only be used whilst the vehicle is stationary. Please observe the

operating manual.

6 Installing the awning

6.1 Required installation material

For the installation of the awning, you will need:

Various tools, e.g. screwdriver

A suitable flexible adhesive/sealant, e.g. Sikaflex®-252

SunProtect

Front panel and sides available in different sizes

Rollo+ (not for PW1750)

Roller blind

Dometic Light LK120

LED light kit with remote control for installation on the awning arms

LED LightStrip

LED strip available in different lengths for installation on the underside of the awning

Led Profile

LED lighting available in different lengths for installation on the underside of wall-mounted

awnings

Awning cleaner

Special awning cleaner

Repair Kit

Awning repair patch

Description



More information https://www.caravansplus.com.au

PerfectWall Installing the awning

A cleaning agent that is recommended for use with the adhesive

A primer that is recommended for use with the adhesive

Acid-free silicone

6.2 Notes on the installation position

When choosing the installation location, observe the following:

!WARNING!

Keep a sufficient distance from objects or other vehicles. Once it is

retracted, it should be at least 40 cm away from other objects and

vehicles.

Ensure the wall of the motorhome can safely take the weight of the

awning before installation. Otherwise, the awning may become

unstable and bend or break.

ANOTICE!

Make sure that the inner screw joints are accessible.

Only attach the awning to flat and vertical wall surfaces (fig. 2and

fig. 3, page 1). On curved wall surfaces, the mounting plates need to

be adequately lined under the fastening points.

If there is insufficient space above the door after the awning is

mounted, the door must remain closed when retracting or extending

to avoid the door making contact with the arms or the lead rail.

The required space depends on the design of the door (door width,

swing or sliding door) as well as the set awning angle of inclination

(fig. 4, page 1).

The cables and cabinets in the interior of the vehicle may not be

damaged by drilling the holes.

INOTE

Ensure the user of the vehicle is aware that the screwson the rear hinge

(fig. 5, page 1) must be tightened up (see operating manual). The

arms must not bear any load. This must be doneby the service partner.

6.3 Installing the awning

During installation, observe the following general information:

The awning can be attached in two ways:

– to the side of the vehicle using mounting plates

– to the existing piping rail on the side of the vehicle



More information https://www.caravansplus.com.au

Installing the awning PerfectWall

The mounting plates are bolted to the vehicle in the area of the rear hinge. In

addition, they are glued with installation adhesive (e.g. Sikaflex®-221 or a similar

product) to ensure the load is evenly spread and an optimal level of protection

from moisture is maintained.

Observe the sealant manufacturer's instructions.

Before installation, check the access to the screw joints. Make sure no cables or

cabinets are damaged when drilling.

Contact your local service partner if you wish to have an angle of inclination

different to the default setting.

If you want to use an awning tent with the awning at a later date, ensure that the

vent windows and hatches remain accessible with erected tent when choosing

the awning size and installation position (fig. 6, page 1).

Clean the adhesive surfaces on the mounting rails and the wall.

Prepare the adhesive surfaces with the primer.

After gluing, wait until the adhesive has set. For further details, please refer to the

information provided by the sealant manufacturer.

Carefully seal the drill holes to prevent moisture from entering the motorhome

wall.

Do not open the awning or leave it unattended, before the awning has been

fastened to the mounting rails.

As part of the regular maintenance procedure, the screwson the rear hinge must

be tightened up by a service partner. Ensure the users of the vehicle are aware of

this.

Installing the awning with mounting plates

➤Select the location of the installation.

In particular, check that there is enough space in the interior to mount the counter

plates at the points where the screws will be.

➤Align the mounting plates on the vehicle and mark where the holes are to be

drilled (fig. 8, page 1).

➤At the marked points, drill holes with a diameter of 6.5 mm from the outside

through the external wall.

NOTE

Recommended mounting position for each counter plate: fig. 7,

page 1.



More information https://www.caravansplus.com.au

PerfectWall Installing the awning

➤Clean the outer sides of the mounting plates and the installation surface on the

vehicle.

➤Fill the drill holes in the vehicle wall with an acid-free silicone.

➤Insert the square-head bolts through the relevant holes in the mounting plates

(fig. 9, page 1).

➤To glue and seal, apply an elastic adhesive, such as Sikaflex®-221 for example, to

the back of the mounting plates (fig. 9, page 1).

➤Place all of the mounting plates through the drill holes and fasten them with

counter plate, serrated lock washers and hexagon head bolts (fig. 0, page 1).

➤Only for awnings with a width of 2.6 m to 3.5 m:

Fasten all of the mounting plates using a countersunk bolt, counter plate,

serrated lock washer and hexagon nut (fig. a, page 1).

➤Only for awnings with a width of 4 m to 5.5 m:

Fasten the inner (narrow) mounting plates using a countersunk bolt, counter

plate, serrated lock washer and hexagon nut (fig. a, page 1).

➤Wait until the glue has set. For further details, please refer to the information

provided by the sealant manufacturer.

➤Use two people to hook the awning on to the mounting plates (fig. b, page 1).

➤Extend the awning about 50 cm using the crank.

➤Only for awnings with a width of 4 m to 5.5 m:

Drill one hole with a diameter of 6.5 mm through the left and the right side of the

awning. The hole has to be in a distance of 280 mm to the respective edge of the

awning and be on the same level as its counterpart in the long mounting plate

(fig. c, page 1).

➤Only for awnings with a width of 4 m to 5.5 m:

Fasten the awning using a countersunk bolt, counter plate, serrated lock washer

and hexagon nut (fig. d, page 2).

➤Insert the cover caps on the counter plates (fig. e, page 2).

➤Drill two holes with a diameter of 3 mm through the awning and each of the long

mounting plates (fig. f, page 2).

➤Drill one hole with a diameter of 3 mm through the awning and each of the short

mounting plates (fig. f, page 2).

➤Fasten the awning with drill screws (fig. f, page 2).

➤Retract the awning completely using the crank.



More information https://www.caravansplus.com.au

Andere Handbücher für PerfectWall PW1000

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Dometic Zubehör Handbücher

Dometic

Dometic PERFECTWALL PW1100 Bedienungsanleitung

Dometic

Dometic Weather Pro Bedienungsanleitung

Dometic

Dometic A&E Systems 828 Series Leitfaden

Dometic

Dometic 9200 Series Bedienungsanleitung

Dometic

Dometic CFX3 Series Bedienungsanleitung

Dometic

Dometic WAECO TC07 Bedienungsanleitung

Dometic

Dometic Power Awning Pro 3316554 Series Handbuch

Dometic

Dometic CoolFreeze Bedienungsanleitung

Dometic

Dometic PerfectWall PW3500 Bedienungsanleitung

Dometic

Dometic Coolfreeze CF16 Bedienungsanleitung

Dometic

Dometic CFX3 Series Bedienungsanleitung

Dometic

Dometic 915 series Bedienungsanleitung

Dometic

Dometic CFX3 Series Bedienungsanleitung

Dometic

Dometic RTX1000 Bedienungsanleitung

Dometic

Dometic TCX Series Bedienungsanleitung

Dometic

Dometic CFX Series Bedienungsanleitung

Dometic

Dometic TROPICOOL TCX07 Bedienungsanleitung

Dometic

Dometic Cabana Lightweight RV Dome Awning Bedienungsanleitung

Dometic

Dometic WAECO BordBar TB08 Bedienungsanleitung

Dometic

Dometic LA-03 Bedienungsanleitung

Dometic

Dometic SUNCHASER 8500 Bedienungsanleitung

Dometic

Dometic A&E Horizon Handbuch

Dometic

Dometic BORDBAR AS25 Bedienungsanleitung

Dometic

Dometic TROPICOOL TF14 Bedienungsanleitung

Beliebte Zubehör Handbücher anderer Marken

Hillco

Hillco 2810 Bedienungsanleitung

Siemens

Siemens QSA2700D Bedienerhandbuch

Contours

Contours ZY024 Bedienungsanleitung

Saivod

Saivod VS621 Bedienungsanleitung

SCE

SCE ENVIRO-THERM SCE-TE170B24VSS Bedienungsanleitung

Z-Wave

Z-Wave HSD-200Z Bedienungsanleitung

turck

turck FMX-IM-2UPLI63FX Bedienungsanleitung

Decagon Devices

Decagon Devices 10HS Bedienungsanleitung

UPPAbaby

UPPAbaby Cup Holder Bedienungsanleitung

Elko

Elko SmartSensor Leakage Wireless Bedienungsanleitung

Grizzly

Grizzly H8371 Bedienungsanleitung

Panasonic

Panasonic HG-T Series Bedienungsanleitung

IFM Electronic

IFM Electronic Efector 250 Series Referenzhandbuch

Virtuox

Virtuox VirtuCLEAN 2.0 Bedienungsanleitung

DigiDesign

DigiDesign 888/24 I/O Bedienungsanleitung

PROZIS

PROZIS QUAY Bedienungsanleitung

patagonia

patagonia PSI Vest Bedienungsanleitung

SFC Energy

SFC Energy EFOY GO! Bedienungsanleitung