Dometic PERFECTWALL PW3800 Bedienungsanleitung

4.0m

4.5m

5.0m

5.5m

6.0m

1315

1490

1640

1705

1880

1315

1490

1640

1705

1880

200

1200

1350

1550

1600

1750

4 5 6 7 8

9 10 11 12 13

14 15 16



15 – 20 Nm

PW3800

leaflet_figures.fm Seite 1 Montag, 7. Mai 2018 3:58 15

Dometic WAECO International GmbH

Hollefeldstrasse 63

D-48282 Emsdetten

dometic.com

T15A

T3A

D+

810 11

+12 Vg

Ø3 mm

Ø 3 mm

cd g

4445102497 0700298 03/2018

leaflet_figures.fm Seite 2 Montag, 7. Mai 2018 3:58 15

PW3800

Awning

Installation Manual. . . . . . . . . . . . . . . . . . . . . 3

Markise

Montageanleitung. . . . . . . . . . . . . . . . . . . . 14

Store extérieuru

Instructions de montage . . . . . . . . . . . . . . .25

Told o

Instrucciones de montaje . . . . . . . . . . . . . .36

Told o

Instruções de montagem . . . . . . . . . . . . . .47

Tend a da so le

Indicazioni di montaggio . . . . . . . . . . . . . .58

Zonnescherm

Montagehandleiding . . . . . . . . . . . . . . . . .69

Markise

Monteringsvejledning. . . . . . . . . . . . . . . . .80

Markis

Monteringsanvisning. . . . . . . . . . . . . . . . . . 91

Markise

Monteringsanvisning. . . . . . . . . . . . . . . . . 101

Markiisi

Asennusohje . . . . . . . . . . . . . . . . . . . . . . . .111

Синусоидальный инвертор

Инструкция по монтажу. . . . . . . . . . . . . . 121

Markiza

Instrukcja montażu . . . . . . . . . . . . . . . . . . 132

Markýza

Návod k montáži . . . . . . . . . . . . . . . . . . . . 143

Markiza

Navodilo za montažo . . . . . . . . . . . . . . . . 153

ȉȑȞĲĮ

ȅįȘȖȓİȢ ĲȠʌȠșȑĲȘıȘȢ. . . . . . . . . . . . . . 163

AWNINGS

PERFECTWALL

PW3800-I-16s.book Seite 1 Donnerstag, 12. April 2018 3:24 15

PW3800-I-16s.book Seite 2 Donnerstag, 12. April 2018 3:24 15

PW3800 Explanation of symbols

Table of contents

1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

2 Important safety and installation instructions. . . . . . . . . . . . . . . . . . . . . . . . . .4

3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

4 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

5 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

6 Installing the awning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

7 Connecting the awning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

8 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

1 Explanation of symbols

WARNING!

•This instruction manual must be read and understood before

installation, set up, operation and servicing. This device must be

installed by a specialist. Improper installation can lead to serious

injury. Alterations to the device can be extremely dangerous and

lead to serious injury or damage to the device.

•Keep this operating manual with the device. The owner must read it

carefully.

WARNING!

Safety instruction: Failure to observe this instruction can cause fatal or

serious injury.

NOTICE!

Failure to observe this instruction can cause material damage and impair

the function of the product.

NOTE

Supplementary information for operating the product.

PW3800-I-16s.book Seite 3 Donnerstag, 12. April 2018 3:24 15

Important safety and installation instructions PW3800

2 Important safety and installation

instructions

Please observe the safety instructions and stipulations issued by the

vehicle manufacturer and service workshops.

The manufacturer accepts no liability for damage in the following cases:

•Faulty assembly or connection

•Damage to the product resulting from mechanical influences

•Alterations to the product without express permission from the manufacturer

•Use for purposes other than those described in the operating manual

!WARNING!

•If you do not have sufficient technical knowledge for installing

components in vehicles, you should have a specialist fit the awning to

your vehicle.

3Scopeofdelivery

No. in

fig. 1,

page 1

Awning width

Description

4 m, 4.5 m,

5 m, 5.5 m, 6 m

1 1x Awning

2 2x Mounting plate (400 mm)

3 2x Mounting plate (160 mm)

4 12x Counter plate

5 12x Square-head bolt

6 6x Countersunk bolt

7 18x Serrated lock washer

8 18x Hexagon nut

9 12x Cover for the counter plate

10 18x Self-tapping screw

11 2x Mounting bracket (lower section)

12 2x Mounting bracket (upper section)

PW3800-I-16s.book Seite 4 Donnerstag, 12. April 2018 3:24 15

PW3800 Accessories

4Accessories

Available as accessories (not included in the scope of delivery):

If you have questions regarding the accessories, please contact your local service

partner.

13 1x Crank bracket (lower section)

14 1x Crank bracket (upper section)

15 4x Rivets

16 4x Pegs

17 1x Crank (only awnings without motor)

Emergency crank (only awnings with motor)

18 1x Receiver with connection material

19 1x Remote control with holder

Description

TieDown Kit

Straps for anchoring the awning

Dometic Light LK120

LED light kit with remote control for installation on the awning arms

LED LightStrip

LED strip available in different lengths for installation on the underside of the awning

LED Profile

LED lighting available in different lengths for installation on the underside of wall-mounted

awnings

Awning cleaner

Special awning cleaner

Repair Kit

Awning repair patch

Wall switch

No. in

fig. 1,

page 1

Awning width

Description

4 m, 4.5 m,

5 m, 5.5 m, 6 m

PW3800-I-16s.book Seite 5 Donnerstag, 12. April 2018 3:24 15

Intended use PW3800

5 Intended use

The PerfectWall PW3800 awning is suitable for installing on motorhomes or

caravans.

The awning must only be used whilst the vehicle is stationary. Please observe the

operating manual.

6 Installing the awning

6.1 Required installation material

For the installation of the awning, you will need:

•Various tools, e.g. screwdriver

•A suitable flexible adhesive/sealant, e.g. Sikaflex®-252

•A cleaning agent that is recommended for use with the adhesive

•A primer that is recommended for use with the adhesive

•Acid-free silicone

6.2 Notes on the installation position

When choosing the installation location, observe the following:

!WARNING!

•Keep a sufficient distance from objects or other vehicles. Once it is

retracted, it should be at least 40 cm away from other objects and

vehicles.

•Ensure the wall of the motorhome can safely take the weight of the

awning before installation. Otherwise, the awning may become

unstable and bend or break.

ANOTICE!

•Make sure that the inner screw joints are accessible.

•Only attach the awning to flat and vertical wall surfaces (fig. 2and

fig. 3, page 1). On curved wall surfaces, the mounting plates need to

be adequately lined under the fastening points.

PW3800-I-16s.book Seite 6 Donnerstag, 12. April 2018 3:24 15

PW3800 Installing the awning

•If there is insufficient space above the door after the awning is

mounted, the door must remain closed when retracting or extending

to avoid the door making contact with the arms or the lead rail.

The required space depends on the design of the door (door width,

swing or sliding door) as well as the set awning angle of inclination

(fig. 4, page 1).

•The cables and cabinets in the interior of the vehicle may not be

damaged by drilling the holes.

INOTE

•Ensure the user of the vehicle is aware that the screws on the rear hinge

(fig. 5, page 1) must be tightened up (see operating manual). The

arms must not bear any load. This must be doneby the service partner.

6.3 Installing the awning

During installation, observe the following general information:

•The mounting plates are bolted to the vehicle in the area of the rear hinge. In

addition, they are glued with installation adhesive (e.g. Sikaflex®-221 or a similar

product) to ensure the load is evenly spread and an optimal level of protection

from moisture is maintained.

•Observe the sealant manufacturer's instructions.

•Before installation, check the access to the screw joints. Make sure no cables or

cabinets are damaged when drilling.

•Contact your local service partner if you wish to have an angle of inclination

different to the default setting.

•If you want to use an awning tent with the awning at a later date, ensure that the

vent windows and hatches of the erected tent remain accessible when choosing

the awning size and installation position (fig. 6, page 1).

•Clean the adhesive surfaces on the mounting rails and the wall.

•Prepare the adhesive surfaces with the primer.

•After gluing, wait until the adhesive has set. For further details, please refer to the

information provided by the sealant manufacturer.

•Carefully seal the drill holes to prevent moisture from entering the motorhome

wall.

PW3800-I-16s.book Seite 7 Donnerstag, 12. April 2018 3:24 15

Installing the awning PW3800

•Do not open the awning or leave it unattended, before the awning has been

fastened to the mounting rails.

•As part of the regular maintenance procedure, the screwson the rear hinge must

be tightened up by a service partner. Ensure the users of the vehicle are aware of

this.

Installing the awning with mounting plates

➤Select the location of the installation.

In particular, check that there is enough space in the interior to mount the counter

plates at the points where the screws will be.

➤Align the mounting plates on the vehicle and mark where the holes are to be

drilled (fig. 8, page 1).

➤At the marked points, drill holes with a diameter of 6.5 mm from the outside

through the external wall.

➤Clean the outer sides of the mounting plates and the installation surface on the

vehicle.

➤Fill the drill holes in the vehicle wall with an acid-free silicone.

➤Insert the square-head bolts through the relevant holes in the mounting plates

(fig. 9, page 1).

➤To glue and seal, apply an elastic adhesive, such as Sikaflex®-221 for example, to

the back of the mounting plates (fig. 9, page 1).

➤Place all of the mounting plates through the drill holes and fasten them with

counter plate, serrated lock washers and hexagon head bolts (fig. 0, page 1).

➤Fasten the inner (narrow) mounting plates using a countersunk bolt, counter

plate, serrated lock washer and hexagon nut (fig. a, page 1).

➤Wait until the glue has set. For further details, please refer to the information

provided by the sealant manufacturer.

➤Use two people to hook the awning on to the mounting plates (fig. b, page 1).

➤Insert the cover caps on the counter plates (fig. c, page 2).

➤Drill two holes with a diameter of 3 mm through the awning and each of the long

mounting plates (fig. d, page 2).

NOTE

Recommended mounting position for each counter plate: fig. 7,

page 1.

PW3800-I-16s.book Seite 8 Donnerstag, 12. April 2018 3:24 15

Andere Handbücher für PERFECTWALL PW3800

Inhaltsverzeichnis

Sprachen:

Andere Dometic Zubehör Handbücher

Dometic

Dometic Two Step Bedienungsanleitung

Dometic

Dometic PERFECTROOF PR2000 Bedienungsanleitung

Dometic

Dometic PERFECTWALL PW1100 Bedienungsanleitung

Dometic

Dometic SC Series Bedienungsanleitung

Dometic

Dometic Coolfreeze CF11 Bedienungsanleitung

Dometic

Dometic CFX3 35 Bedienungsanleitung

Dometic

Dometic PerfectWall PW1750 Bedienungsanleitung

Dometic

Dometic CFX3 25 Bedienungsanleitung

Dometic

Dometic PerfectWall PW1500 Bedienungsanleitung

Dometic

Dometic CFX3 Series Bedienungsanleitung

Dometic

Dometic LA-03 Bedienungsanleitung

Dometic

Dometic PERFECTROOF PR2000 Bedienungsanleitung

Dometic

Dometic CFX65 Bedienungsanleitung

Dometic

Dometic PERFECTWALL PW3800 Bedienungsanleitung

Dometic

Dometic 9108672221 Bedienungsanleitung

Dometic

Dometic 3316736.000 Handbuch

Dometic

Dometic TROPICOOL TF14 Bedienungsanleitung

Dometic

Dometic PERFECTVIEW VS400N Bedienungsanleitung

Dometic

Dometic 9108853211 Bedienungsanleitung

Dometic

Dometic 8952 series Bedienungsanleitung

Dometic

Dometic ACX Series Bedienungsanleitung

Dometic

Dometic SUNSHINE AIR 300 Bedienungsanleitung

Dometic

Dometic 8700 Series MasterFlush Bedienungsanleitung

Dometic

Dometic Solar Shade 200 Bedienungsanleitung

Beliebte Zubehör Handbücher anderer Marken

Hillco

Hillco 2810 Bedienungsanleitung

Siemens

Siemens QSA2700D Bedienerhandbuch

Contours

Contours ZY024 Bedienungsanleitung

Saivod

Saivod VS621 Bedienungsanleitung

SCE

SCE ENVIRO-THERM SCE-TE170B24VSS Bedienungsanleitung

Z-Wave

Z-Wave HSD-200Z Bedienungsanleitung

turck

turck FMX-IM-2UPLI63FX Bedienungsanleitung

Decagon Devices

Decagon Devices 10HS Bedienungsanleitung

UPPAbaby

UPPAbaby Cup Holder Bedienungsanleitung

Elko

Elko SmartSensor Leakage Wireless Bedienungsanleitung

Grizzly

Grizzly H8371 Bedienungsanleitung

Panasonic

Panasonic HG-T Series Bedienungsanleitung

IFM Electronic

IFM Electronic Efector 250 Series Referenzhandbuch

Virtuox

Virtuox VirtuCLEAN 2.0 Bedienungsanleitung

DigiDesign

DigiDesign 888/24 I/O Bedienungsanleitung

PROZIS

PROZIS QUAY Bedienungsanleitung

patagonia

patagonia PSI Vest Bedienungsanleitung

SFC Energy

SFC Energy EFOY GO! Bedienungsanleitung