Eco-Smart ECO-6 Bedienungsanleitung

INSTALLATION INSTRUCTIONS

ECOSMART ELECTRIC TANKLESS WATER HEATER

MODELS: ECO-6 / ECO-8 / ECO-11

The most technologically advanced tankless hot water heater in today's market.

99.8% Energy-efficient

1 / 17

“No Tank, No Wait, No Comparison”

IMPORTANT SAFETY INFORMATION

As when installing or operating any high voltage electrical appliance,

basic safety precautions must always be followed.

ALWAYS shut off all power to the Ecosmart unit directly at the electrical

breaker box before attempting to clean, install, inspect, repair,

disassemble, or otherwise service this unit.

SERIOUS BODILY INJURY OR DEATH COULD OCCUR IF

SAFETY PRECAUTIONS ARE NOT FOLLOWED. THIS PRODUCT MUST BE

PROFESSIONALLY INSTALLED BEFORE USE.

FAILURE TO DO SO COULD CAUSE PROPERTY DAMAGE,

SERIOUS PERSONAL INJURY OR DEATH, AND WILL VOID THE WARRANTY.

THIS WATER HEATER MUST BE INSTALLED BY A

LICENSED ELECTRICIAN OR PLUMBER.

PROOF OF INSTALLATION MUST ACCOMPANY

THE WARRANTY REGISTRATION CARD.

PLEASE FOLLOW ALL RECOMMENDATIONS AND LOCAL CODE AND PERMIT REQUIREMENTS

TURN OFF ELECTRICAL SUPPLY MAIN AND WATER SUPPLY BEFORE

ATTEMPTING INSTALLATION OR SERVICING THE UNIT.

DO NOT TURN ON ELECTRICAL SUPPLY OR WATER SUPPLY UNTIL

INSTALLATION IS PROPERLY COMPLETED.

FAILURE TO FOLLOW PROPER PROCEDURES IS HAZARDOUS.

IT MAY ALSO DAMAGE THE WATER HEATER AND WILL VOID THE WARRANTY.

●DO NOT remove the heater cover, open the unit, or break the seal. This could cause DEATH OR INJURY and will VOID THE

WARRANTY.

●DO NOT install the electric tankless water heater unit in a shower or in any location where it might come into contact with

water or where it can be reached or adjusted by anyone while using water.

●DO NOT attempt to install yourself. Although installation is simple, it should only be done by a licensed plumber or

electrician.

●DO NOT operate the unit if water ceases to flow during use. Discontinue use and contact technical support at:

WWW.ECOSMARTUS.COM

phone: 305-623-7900 or 877-47-GOGREEN

2 / 17

3 / 17

PART IDENTIFICATION

The Ecosmart electric tankless water heater is supplied with 1/2” compression fittings.

Do not weld or use paste or use Teflon on fittings.

Connect the cold water supply line to the right side of the unit ("cold water inlet” in diagram on

page 3).

Connect the hot water supply line to the left side of the unit (“hot water inlet” in diagram on

page 3).

After both water lines are fastened securely, run water through the unit for at least 2 to 3

minutes to flush out any air pockets in the lines (purging). It is recommended that all faucets,

showers, etc. be run during this process. Failure to purge the lines of air can cause permanent

damage to the unit. This procedure MUST be performed before the electrical power is turned on.

4 / 17

PLUMBING

●The Ecosmart electric tankless water heater unit must be installed to independent

double pole breakers.

●Each Ecosmart model comes supplied with the required wires for installation.

●Breaker size and wire gauge must meet all applicable local, state, provincial, and

national electrical codes for your area – these are only guidelines that will apply to

most installations.

●Some codes require use of electrical sub-panel for installation, especially when heater

is not mounted within line-of-sight of the main electrical panel. Wiring should be sized

to maintain a voltage drop of less than 3% under load.

●If your home is already equipped with a large number of electrical appliances, you may

require a larger electrical service than the one recommended.

●Check all wires to make sure that they are tightly fastened.

●Before turning the power on, the system must be flushed as required in the plumbing

instructions.

●When the unit is powered up the green LED indicator light will turn ON and then OFF.

This is normal.

5 / 17

ELECTRICAL CONNECTION

ELECTRICAL SPECIFICATIONS BY MODEL #

MODEL REQUIRED BREAKER MAX AMP DRAW AWG CABLE

ECO-6 1x30 AMP 28 #8

ECO-8 1x40 AMP 37 #8

ECO-11 1x60 AMP 54 #6

VERIFY ALL VOLTAGE & AMPERAGE INFORMATION LISTED BELOW WITH THE ACTUAL LABEL

SPECIFICIATIONS ON YOUR UNIT, IN CASE OF CHANGES OR VARIATIONS.

MODEL KW VOLTS AMPS BATHS

SUPPLIED FLOW RATE

IN GALLONS

PER MINUTE

RISE IN WATER

TEMP.

FULLCAP. IS

LOWER TEMP.

ECO-6 6.0KW 220V 28 1 UP TO 1.7GPM 17 - 43º

ECO-8 8.2KW 220V 37 UP TO 1.5 UP TO 2.2GPM 16 - 56º

ECO-11 11.8KW 220V 54 UP TO 2.5 UP TO 3GPM 22 - 80º

MODEL KW VOLTS AMPS BATHS

SUPPLIED FLOW RATE

IN GALLONS

PER MINUTE

RISE IN WATER

TEMP.

FULLCAP. IS

LOWER TEMP.

ECO-8 7.3KW 240V 34 UP TO 1.5 UP TO 2.2GPM 16 - 56º

ECO-11 13.9KW 240V 58 UP TO 2.5 UP TO 3GPM 22 - 80º

6 / 17

WIRE GAUGE AND BREAKER SIZE CAN VARY BASED ON A NUMBER OF FACTORS,

INCLUDING SUPPLIED VOLTAGE AND LENGTH OF CIRCUIT.

CHECK LOCAL REQUIREMENTS.

MODEL WIRE GAUGE VOLTAGE & AMPERAGE BREAKER SIZE

ECO-6 #8 2-30 AMP 110V HOT

+ 1 GROUND 30 AMP DOUBLE POLE

ECO-8 #8 2-40 AMP 110V HOT

+ 1 GROUND 40 AMP DOUBLE POLE

ECO-11 #6 2-60 AMP 110V HOT

+1 GROUND 60 AMP DOUBLE POLE

7 / 17

POWER KNOB:

•Click the power knob once to turn the unit ON.

•Click the power knob again to turn the unit OFF.

ºC/ ºF CONVERSION:

•Press the knob for 3 seconds to change the display from ºC/

ºF.

TEMPERATURE CONTROLLER KNOB:

•Turn the knob clockwise to increase the temperature set on the thermostat.

•This will increase the water outlet temperature.

•Turn the knob counterclockwise to decrease the temperature set on the thermostat.

•This will decrease the water outlet temperature.

•The water temperature can be adjusted at any time to between 0º-125ºF ( 0º-51ºC).

•The temperature indicator light will stay on only when there is hot water in use.

ECOSMART US LLC

3315 NW 167th Street

Miami Gardens, FL 33056

www.ecosmartus.com

Telephone: 305-623-7900

8 / 17

HOW TO USE THE KNOB

Fax: 305-623-7923

Toll Free: 877-47-GOGREEN

Congratulations on the purchase of your Tankless Water Heater! You have purchased the most

technologically-advanced tankless water heater in the market today. Your ECOSMART Tankless Water

Heater is backed by the industry’s most comprehensive warranty.

Your new tankless water heater features advanced water flow rate and temperature sensors designed to

modulate power to the heating elements to maintain a precise user-selected output water temperature

between 85F and 140F (subject to incoming water temperature and power of the selected model). To get

the best performance and energy savings from your tankless water heater, it is important that it be

installed in accordance with our instructions and the electrical and plumbing codes applicable to your

area, and that you read this manual thoroughly for important operating instructions and tips.

At any time, if you have any questions, please contact your Authorized Dealer, or contact us directly at:

ECOSMART US, L.L.C.

3315 NW 167TH

STREET, MIAMI GARDENS, FLORIDA 33056

Toll Free: 1-877-474-6473

9 / 17

ABOUT YOUR TANKLESS WATER HEATER

For the most part, operating your new tankless water heater is very similar to using any traditional water

heating system. However, it is very important that you carefully read all of the set-up procedures and

operating instructions and tips to ensure the maximum performance and energy savings from your new

water heater. We recommend that all members of the household read these General Operating

Instructions.

How your new water heater works: Your Tankless Water Heater does not store hot water like a

conventional tank-type water heater. It contains very high powered heating elements that are capable of

heating water instantly on-demand as you need it. As soon as you turn on a hot water faucet, a

sophisticated flow sensor recognizes that you have turned on the water. This sensor measures the water

flow rate while another sensor measures the incoming water temperature. This information is transmitted

continually to the computer logic controls which decide how much power to send to the heating elements

to heat the water to your desired temperature.

Since your new water heater works on a demand basis, it will absolutely never run out of hot water no

matter how many back to back showers you run!

It is important to keep in mind that all tankless water heaters are subject to a maximum flow rate that

they can handle all at once. If you exceed this flow rate, the heater will not be capable of fully heating the

water. How much water you will be able to demand from your water heater at any given time will depend

on the model you have selected and your incoming water temperature. If you live in an area of the

country where inlet water temperatures average 55º F or you have cold winters, you will probably NOT be

able to run multiple large water demands at the same time, however, you will be able to run all your hot

water applications back to back without ever having to wait. You will enjoy UNLIMITED HOT WATER.

10 / 17

GENERAL OPERATING INSTRUCTIONS

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Eco-Smart Boiler Handbücher

Eco-Smart

Eco-Smart ECOS 12 Bedienungsanleitung

Eco-Smart

Eco-Smart POU 4T Service-Handbuch

Eco-Smart

Eco-Smart ECO 18 Bedienungsanleitung

Eco-Smart

Eco-Smart Eco Spa 5.5 Fehlerbehebungshandbuch

Eco-Smart

Eco-Smart ESGH-95-DVLN-2 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO-8 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO 27 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO Series Bedienungsanleitung

Eco-Smart

Eco-Smart POU 3.5 kW Bedienungsanleitung

Eco-Smart

Eco-Smart ECO MINI 1 Benutzerhandbuch

Eco-Smart

Eco-Smart ECO POU 3.5 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO 21 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO 36 Service-Handbuch

Beliebte Boiler Handbücher anderer Marken

Kenmore

Kenmore 153.582400 Bedienungsanleitung

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Bedienungsanleitung

clage

clage E-Mini Series Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-180 Bedienungsanleitung

Bradford White

Bradford White EF Series Bedienungsanleitung

Eccotemp

Eccotemp 40-H Bedienungsanleitung

Dimplex

Dimplex ECSd125-580 Leitfaden

Dux

Dux 32FCR6N Bedienungsanleitung

Noritz

Noritz N-132M Gebrauchsanweisung

TESY

TESY GCV7/4S 10047 Technisches Datenblatt

A.O. Smith

A.O. Smith Gphe 50 Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Fehlerbehebungshandbuch

Koryo

Koryo KWHZF15Y Bedienungsanleitung

Pentair

Pentair PSC-14-4-02 Bedienungsanleitung

GE 40M06AAG Montageanleitung

Thermor

Thermor AEROMAX SPLIT 2 Bedienungsanleitung

American Hometec

American Hometec AHQ-B03X Bedienungsanleitung

PVI

PVI MAXIM Bedienungsanleitung