Eco-Smart ECO MINI 1 Benutzerhandbuch

Electric Mini Tank Water Heaters

ECO MINI 1– ECO MINI 2.5 – ECO MINI 4 –

ECO MINI 6

Page%!%of%""%

Installation and Operating Instruction

Manual

Table of Contents

Important Safety Instructions

Technical Data

General Information

Technical Description

Installation Instructions

Plumbing Connections

Temperature & Pressure Relief Valve

Filling the Water Heater

Electrical Connections

Instructions For Use

Maintenance Instructions

Trouble Shooting

Schematic Disassembly & Parts List

Warranty

Page%#%of%""%

IMPORTANT SAFETY

INSTRUCTIONS

WARNING: When using electrical appliances, safety precautions to reduce

the risk of fire, electric shock or injury to persons should be followed,

including:

1. READ ALL INSTRUCTIONS BEFORE USING THIS WATER

HEATER.

2. This water heater must be grounded. Connect only to properly

grounded power supply. See “GROUNDING INSTRUCTIONS” found on

page 10.

3. Install or locate this water heater only in accordance with the provided

installation instructions.

4. Use this water heater only for its intended use as described in this

manual.

5. Do not use an extension cord set with this water heater. If no

receptacle is available adjacent to the water heater, contact a qualified

electrician to have one properly installed.

6. As with any appliance, close supervision is necessary when used by

children.

7. Do not operate this water heater if it has damaged electrical

connections, if it is not working properly, or if it has been damaged or

dropped.

8. This water heater should be serviced only by qualified service

personnel. Contact nearest authorized service facility for examination,

repair, or adjustment.

SAVE THESE INSTRUCTIONS

The manufacturer and/or distributor is not responsible for damages caused

by improper installation, or by non-observance of the instructions in this

manual.

Page%$%of%""%

A QUALIFIED, LICENSED TECHNICIAN MUST ALWAYS INSTALL THE WATER

HEATER AND CONDUCT ALL SUBSEQUENT SERVICE WORK AND/OR

MAINTENANCE.

IMPORTANT!!!

NEVER TURN THE WATER HEATER POWER ON UNTIL THE TANK IS

COMPLETELY FULL AND WATER IS FLOWING OUT OF THE HOT WATER

FAUCET.

Technical Data

MODEL ECO MINI 1 ECO MINI 2.5 ECO MINI 4

ECO MINI 6

Capacity

1.5 gallons%

2.5 gallons%

4.0 gallons%

6.0 gallons%

Voltage Phases

1440

Power at 120 Vac

110-120

Max Water Pressure

150 psi

Weight (empty)

11.68 lbs

15.48 lbs

19.29 lbs

24.91 lbs

Amperage Amps

Phases

NO%plug%for%ECO%MINI%6%

Page%%%of%""%

Dimensions

Model

ECO MINI

2.5

ECO MINI

A (inch)

14.19

15.98

17.41

19.81

B (inch)

9.71

10.89

12.27

13.85

C (inch)

9.95

11.23

12.88

14.36

Page%"%of%""%

Wiring Diagram

ECO MINI 1, ECO MINI 2.5, ECO MINI 4

Wiring Diagram

ECO MINI 6

GENERAL INFORMATION

The Ecosmart Mini Tank water heaters can be used in most under the

counter, point of use applications. ECO MINI models are designed to supply

hot water for all hand wash and kitchen sinks.

ECO MINI models can replace traditional central hot water heaters thereby

conserving water and reducing energy waste.

The Ecosmart Mini tank water heaters are lightweight and compact and

manufactured for easy installation. ECO MINI models are designed to be

mounted on the wall.

Page%&%of%""%

ECO MINI models are designed to operate at 150 psi maximum water

pressure.

CAUTION!: The manufacturer cannot be responsible for the damage caused

by improper installation or by failure to follow instructions in this manual.

Comply with the Installation Instructions before connecting to electrical

supply.

CAUTION!: The thermostat has been pre-set at the factory between 50°F

(10°C) and 140°F (60°C).

CAUTION!: Hydrogen gas can be produced in a hot water system served by

this heater that has not been used for a long period of time (generally 2

weeks or more). Hydrogen gas is extremely flammable. To reduce the risk of

injury under these conditions, it is recommended that the hot water faucet

be opened for several minutes at the nearest and most distant sink being

served by this water heater before using any electrical appliance connected

to the hot water system i.e. Dishwasher. If hydrogen gas is present, there

will probably be an unusual sound such as air escaping through the faucet as

the water begins to flow. There should be no smoking or open flame near

the faucet at this time.

WARNING: Installer should review the contents of this manual with the

owner upon completion of the installation, and the manual should remain

with the owner and placed in a location close to the water heater.

Page%'%of%""%

TECHNICAL DESCRIPTION

There are four Ecosmart Mini tank models, a 1.5 gallon, a 2.5 gallon, a 4

gallon and a 6 gallon model. The pressure vessel (water tank) is welded,

glass lined steel and is equipped with an anode rod.

The water heater is equipped with a thermostat and a high limit temperature

switch. A temperature/pressure relief valve is supplied with the unit.

INSTALLATION INSTRUCTIONS

ECO MINI 1- ECO MINI 2.5 - ECO MINI 4 -

ECO MINI 6

The installation must be completed by a licensed professional. All state and

local codes must be adhered to. The manufacturer will not be liable for any

damages because of failure to comply with these installation instructions or

because of improper installation performed by an unqualified installer.

CHOOSE A LOCATION that allows ease of access for maintenance or

servicing, ideally installed at least 8” to 9” from the ceiling (inside top of

cabinet) or any adjacent walls.

WALL MOUNTING

Fasten the supplied mounting bracket to the wall. Use screws that are

suitable for the wall material and the weight of the water heater filled to

capacity (ECO MINI 1= 25 lbs. - ECO MINI 2.5 = 37 lbs. - ECO MINI 4 = 52

lbs. - ECO MINI 6 = 80 lbs.). Hang the water heater on the bracket and pull

downwards on the water heater to insure that both “fingers” of the bracket

are seated in the mounting slots. Confirm your water piping orientation (hot

and cold) before wall mounting. ONLY INSTALL IN VERTICAL POSITION.%

Heater can sit on the floor. Confirm water piping orientation before finalizing

on floor. ONLY INSTALL IN VERTICAL POSITION! ECO MINI models

can be installed under the sink.

Page%(%of%""%

PLUMBING CONNECTIONS

Connect the cold water inlet pipe to the inlet nipple (marked with a blue

ring) and the hot water outlet pipe to the outlet nipple (marked with a red

ring).

IMPORTANT: If Water pipes are copper or bronze, use dielectric

connections to prevent corrosion. Failure to provide dielectric insulation may

result in premature tank or nipple failure and may void your warranty.

Insure that the water heater is installed in a level position. Install a shut off

valve on the cold water side of the water heater. The valve is for servicing

and the valve should be in the open position when the water heater is in

operation. In order to protect the water heater from heat damage due to

soldering, solder a piece of tubing to a threaded UNION fitting before

screwing the UNION to the tank. DO NOT APPLY HEAT DIRECTLY TO

INLET OR OUTLET CONNECTIONS.

TEMPERATURE AND PRESSURE RELIEF VALVE:

CAUTION!: To reduce the risk of excessive pressures and

temperatures in this water heater, install temperature and pressure

protective equipment required by local codes, but no less than a

combination temperature and pressure relief valve certified as

meeting the requirements for Relief Valves and Automatic Gas

Shutoff Devices for Hot Water Supply Systems, ANSI Z21.22, by a

nationally recognized testing laboratory that maintains periodic

inspection of production of listed equipment or materials. The valve

must be oriented, provided with tubing, or otherwise installed so

that discharge can exit only within 6 inches above, or at any

distance below, the structural floor, and cannot contact any live

electrical part.

Install a discharge pipe from the temperature/pressure relief valve

terminating at a sink or drain. DO NOT CAP OR PLUG THE END OF

THE DISCHARGE PIPE. THE DISCHARGE PIPE MUST BE

UNOBSTRUCTED AND FULL SIZED.

The T/P valve is certified by a nationally recognized test lab that maintains

periodic inspections of the listed equipment and meets the requirements for

Page%)%of%""%

relief valves and automatic shut off devices for hot water supply systems

ANSI Z21.22.

The T/P valve is marked with a maximum pressure, which does not exceed

the maximum working pressure of the water heater (150 PSI).

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Sprachen:

Andere Eco-Smart Boiler Handbücher

Eco-Smart

Eco-Smart ESGH-95-DVLN-2 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO-6 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO 36 Service-Handbuch

Eco-Smart

Eco-Smart ECO 27 Bedienungsanleitung

Eco-Smart

Eco-Smart Eco Spa 5.5 Fehlerbehebungshandbuch

Eco-Smart

Eco-Smart ECO 18 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO-8 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO POU 3.5 Bedienungsanleitung

Eco-Smart

Eco-Smart ECO Series Bedienungsanleitung

Eco-Smart

Eco-Smart ECO 21 Bedienungsanleitung

Eco-Smart

Eco-Smart POU 3.5 kW Bedienungsanleitung

Eco-Smart

Eco-Smart ECOS 12 Bedienungsanleitung

Eco-Smart

Eco-Smart POU 4T Service-Handbuch

Beliebte Boiler Handbücher anderer Marken

Kenmore

Kenmore 153.582400 Bedienungsanleitung

Applimo

Applimo Edel AIR Bedienungsanleitung

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Bedienungsanleitung

clage

clage E-Mini Series Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-180 Bedienungsanleitung

Bradford White

Bradford White EF Series Bedienungsanleitung

Eccotemp

Eccotemp 40-H Bedienungsanleitung

Dimplex

Dimplex ECSd125-580 Leitfaden

Dux

Dux 32FCR6N Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Fehlerbehebungshandbuch

Noritz

Noritz N-132M Gebrauchsanweisung

TESY

TESY GCV7/4S 10047 Technisches Datenblatt

A.O. Smith

A.O. Smith Gphe 50 Bedienungsanleitung

Koryo

Koryo KWHZF15Y Bedienungsanleitung

Pentair

Pentair PSC-14-4-02 Bedienungsanleitung

GE 40M06AAG Montageanleitung

Thermor

Thermor AEROMAX SPLIT 2 Bedienungsanleitung

American Hometec

American Hometec AHQ-B03X Bedienungsanleitung