Elkay EHFRA7FC*A Installationshandbuch

97160C (Rev. C - 10/02)

EHFRA7C*A EHFRA7FC*A

Installation/Care/Use Manual

Fully Recessed Refrigerated

Fountain with FLEXI-GUARD®

IMPORTANT

ALL SERVICE TO BE PERFORMED BY AN AUTHORIZED SERVICE PERSON

To assure you install this model easily and correctly, PLEASE READ THESE SIMPLE

INSTRUCTIONS BEFORE STARTING THE INSTALLATION. CHECK YOUR INSTALLA-

TION FOR COMPLIANCE WITH PLUMBING, ELECTRICAL AND OTHER APPLICABLE

CODES. After installation, leave these instructions inside the fountain for future reference.

SEE FIG. 9

35, 36

SEE FIG. 5

IMPORTANT! INSTALLER PLEASE NOTE.

THE GROUNDING OF ELECTRICAL EQUIPMENT SUCH AS TELEPHONE, COMPUTERS, ETC. TO

WATER LINES IS A COMMON PROCEDURE. THIS GROUNDING MAY BE IN THE BUILDING OR MAY

OCCUR AWAY FROM THE BUILDING. THIS GROUNDING CAN CAUSE ELECTRICAL FEEDBACK

INTO A FOUNTAIN, CREATING AN ELECTROLYSIS WHICH CAUSES A METALLIC TASTE OR AN

INCREASE IN THE METAL CONTENT OF THE WATER. THIS CONDITION IS AVOIDABLE BY USING

THE PROPER MATERIALS AS INDICATED. ANY DRAIN FITTINGS PROVIDED BY THE INSTALLER

SHOULD BE MADE OF PLASTIC TO ELECTRICALLY ISOLATE THE FOUNTAIN FROM THE BUILDING

PLUMBING SYSTEM.

Installer

97160C (Rev. C - 10/02)

EHFRA7C*A EHFRA7FC*A

FIG. 1

EHFRA7C ROUGH-IN

PAGE 2

LEGEND:

A = RECOMMENDED WATER SUPPLY LOCATION 3/8" O.D. UNPLATED COPPER TUBE CONNECT

STUB 1-1/2" (38mm) OUT FROM WALL, SHUT OFF BY OTHERS (BOTH SIDES).

B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4" O.D. DRAIN (BOTH SIDES).

C = 1-1/4" TRAP NOT FURNISHED.

D = ELECTRICAL SUPPLY LOCATION (BOTH SIDES).

E = ACCESS TO TRAP MUST BE PROVIDED. IF REAR ACCESS IS NOT POSSIBLE, INSTALLATION

CAN BE MADE THROUGH OPTIONAL ACCESS PANEL AP-99.

FINISHED

FLOOR LINE

97160C (Rev. C - 10/02)

EHFRA7C*A EHFRA7FC*A

PAGE 3

FIG. 3FIG. 2

EHFRA7C EHFRA7FC

INSTALLATION INSTRUCTIONS

1. Remove shipping brace from mounting box and discard.

2. Fasten mounting box into wall cutout using screws or bolts (provided by others) through holes or knockouts

provided on each side of the mounting box. (See Fig. 1)

3. Place refrigeration package into mounting box and connect water lines. (See Fig. 1)

4. Remove access panel (on bottom of mounting box) and install fountain body.

5. Connect water outlet tube on refrigeration package to water in tube on regulator holder (Item 19) with tubing and fitting

provided. (See Fig. 2)

** For glassfiller models see fig. 3.

6. Water inlet is 3/8" O.D. and waste tube is 1-1/4" O.D. Contractor is to supply waste trap and service stop valve in

accordance with local codes.

7. Connecting lines to be unplated copper and thoroughly flushed to remove all foreign matter before connecting to refrigeration

package. The furnished strainer (Item 28) should be added to the supply line.

8. Connect the refrigeration package to the supply line with a shut off valve and install a 3/8" (10mm) unplated copper water line

between the valve and the cooler. Remove burrs from outside of waterline. Insert water line straight into the fittings until they

reach a positive stop, approximately 3/4". (See Figs. 6 and 7) DO NOT SOLDER TUBES INSERTED INTO THE STRAINER AS

DAMAGE TO THE O-RINGS MAY RESULT.

9. Electrical: Insure power supply is identical in voltage, hertz, and phase to that specified on the refrigeration package serial

plate. Never wire compressor directly to the power supply.

10. Turn water supply on and check thoroughly for leaks.

11. Release air from tank by depressing push bar; a steady stream of water assures all air is removed.

12. Re-check for leaks.

13. Stream height is factory set at 35 PSI. If supply pressure varies greatly from this, turn adjustment screw on regulator (Item

22). Clockwise adjustment will raise the stream height and counter-clockwise adjustment will lower stream height. For best

adjustment, stream should hit basin approximately 6-1/2" from the bubbler.

14. Rotate fan blade on refrigeration package to insure proper clearance and free fan action.

15. Connect power supply.

16. Replace access panel and install grill using #8 x 1.00" (25mm) PH screws and small clips provided.

TROUBLE SHOOTING AND MAINTENANCE

1. Orifice Assy: Mineral deposits on orifice can cause water flow to spurt or not regulate. Mineral deposits may be removed

from orifice with a small round file not over 1/8 diameter or a small diameter wire. CAUTION: Do not file or cut orifice

materials.

2. Actuation of Quick Connect Water Fittings: Cooler is provided with lead-free connectors which utilize an o-ring water

seal. To remove tubing from the fitting, relieve water pressure, push in on the gray collar while pulling on the tubing (See Fig. 7).

To insert tubing, push tube straight into the fitting until it reaches a positive stop, approximatley 3/4".

3. CAUTION: Cleaning of Bronzetone models requires special care. Outer surfaces must be cleaned with a mild detergent or a

mixture of vinegar and water only, rinsed and wiped dry. Abrasive and acidic cleaners may eventually damage the Bronzetone

finish.

97160C (Rev. C - 10/02)

EHFRA7C*A EHFRA7FC*A

PAGE 4

DESCRIPTION

PARTNO.ITEM NO.

PARTS LIST

15005C

21705C

21708C

21695C

21696C

31525028

40045C

40206000

40322C

40493C

72000833

40038C

40619C

40628C

50074C

55997C

50198C

56011C

50986C

56073C

55001089

EHFRADF

61314C

62084C

70002C

70012C

70278C

70378C

55996C

70682C

70683C

70379C

112627543890

75555C

EG25

74070030

74070032

74130045

NUT - RETAINING

CLIP - PUSH ROD

PUSH BAR ASSY

BRKT - LEVER PUSH

BRKT - PUSH BAR MTG

O-RING

HEX NUT - UNPLTD

RETAINER

ORIFICE ASSY

GLASS FILLER

WASTE ARM ASSY

STRAINER

FERRULE

WASTE ARM

GASKET -TAILPIPE

PEDESTAL

BUSHING - SNAP

HOUSING ASSY

HOLDER - REGULATOR

BUBBLER ASSY

FOUNTAIN

FOUNTAIN W/GF

REGULATOR

TUBE ASSY - GF

SCREW-#10 X .50 HHSM

NUT - 3/8-18 LKNT

ROD - SUPPORT

ROD - PUSH

STRAINER

TEE - 1/4 (EHFRA7FC)

UNION- 1/4 (EHFRA7C)

ROD - PIVOT

SCREW - #10-24 X .50 PHTC

CLIP -.125 STUD LOCK

GRILL

SCREW - #8 X 1.00 PH

SPEED NUT #8

CLIP - TINNERMAN

20 9

106

NOTE: WHEN INSTALLING

REPLACEMENT BUBBLER

AND PEDESTAL, TIGHTEN

NUT (ITEM 25) ONLY TO HOLD

PARTS SNUG IN POSITION.

DO NOT OVER TIGHTEN.

FIG. 6

FIG. 7

FIG. 4

FIG. 5

FIG. 8 FIG. 9

NOTE: WATER FLOW

DIRECTION

BUILDING WATER

INLET

SERVICE STOP

(NOT FURNISHED)

1/4" O.D. TUBE

WATER INLET

TO COOLER

3/8" O.D. UNPLATED

COPPER TUBE CONNECT

COLD WATER SUPPLY

www.DrinkingFountainDoctor.com 800-518-5388

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Elkay Freiluftbrunnen Handbücher

Elkay

Elkay LK4420BF1UDBFRKBLK Bedienungsanleitung

Elkay

Elkay EHW214FP Series Installationshandbuch

Elkay

Elkay 4405BFFR Bedienungsanleitung

Elkay

Elkay EDFPVR217RC Installationshandbuch

Elkay

Elkay EDFPB114C Gebrauchsanweisung

Elkay

Elkay LK4410BFFR FTN A Series Bedienungsanleitung

Elkay

Elkay 4405BFFR Bedienungsanleitung

Elkay

Elkay LZO8WSS2KWN Bedienungsanleitung

Elkay

Elkay EHFRA72K Installationshandbuch

Elkay

Elkay 4420FR FTN A Series Bedienungsanleitung

Elkay

Elkay FLEXI-GUARD ESRC8,13 1D Series Installationshandbuch

Elkay

Elkay EFRP12CDC_2 Installationshandbuch

Elkay

Elkay Swirlflo EDFPB114FPC Installationshandbuch

Elkay

Elkay EDFP19C series Installationshandbuch

Elkay

Elkay LEXI-GUARD EDFP19C B Series Installationshandbuch

Elkay

Elkay SOFT SIDES EZLMSN-EDFPVM217DK Gebrauchsanweisung

Elkay

Elkay ERPA2-8C*A Installationshandbuch

Elkay

Elkay SWIRLFLO LRPBD2 8WSC Series Gebrauchsanweisung

Elkay

Elkay 4590 Series Bedienungsanleitung

Elkay

Elkay 4430FR Bedienungsanleitung

Elkay

Elkay EZH2O VRCGN8WS 1C Series Leitfaden

Elkay

Elkay Soft Sides FLEXI-GUARD ERO28C C Series Installationshandbuch

Elkay

Elkay Soft Sides ECDFPW314FP Gebrauchsanweisung

Elkay

Elkay EHW214C A Series Installationshandbuch

Beliebte Freiluftbrunnen Handbücher anderer Marken

Sunnydaze Decor

Sunnydaze Decor XSS-578 Bedienungsanleitung

Campania International

Campania International Bibendum FT-400 Bedienungsanleitung

S.R.Smith

S.R.Smith Color Light Stream 2CLSLBK Bedienungsanleitung

Hozelock Cyprio

Hozelock Cyprio Cascade 1500 Bedienungsanleitung

Campania International

Campania International Juliet Fountain Bedienungsanleitung

YARDART

YARDART FT-155 Bedienungsanleitung

Alpine

Alpine WIN732 Bedienungsanleitung

Campania

Campania Valencia Bedienungsanleitung

Campania International

Campania International FT-320 Bedienungsanleitung

GardenWize

GardenWize SWGSL230 Bedienungsanleitung

Kelkay

Kelkay Easy Fountain Rustic Windmill Bedienungsanleitung

Alpine

Alpine WIN258 Bedienungsanleitung

Bond

Bond Signature Series Bedienungsanleitung

Kenroy Home

Kenroy Home 51112COPBL Installationsanleitung

EasyPro

EasyPro Tranquil Décor HBB39 Bedienungsanleitung

Angelo Decor

Angelo Decor Castillo Bedienungsanleitung

Campania International

Campania International Girona FT-102A Bedienungsanleitung

Campania International

Campania International FT-271 Bedienungsanleitung