Elkay Soft Sides ECDFPW314FP Gebrauchsanweisung

Page 1 98011C (Rev. L - 02/18)

ECDFPW314FP

Installation & Use Manual

Soft Sides®Freeze Resistant Fountain

Elkay Fountains are among the easiest to install Fountains on the market today. To assure you install these

models easily and correctly, PLEASE READ THESE SIMPLE INSTRUCTIONS BEFORE STARTING THE

INSTALLATION. CHECK YOUR INSTALLATION FOR COMPLIANCE WITH PLUMBING, ELECTRICAL,

AND OTHER APPLICABLE CODES. After installation, leave these instructions with the Fountain for future

reference. This Freeze Resistant Fountain is shipped in two separate cartons. The second carton(s) contains

the Freeze Resistant Package(s) LKFRB1 that are installed on an interior heated wall. The interior space must

maintain a minimium temperature of 50° F (10° C). Refer to the Freeze Resistant Package for the rough-in

dimensions for installation.

INSTALLER

IMPORTANT

ALL SERVICE TO BE PERFORMED BY AN AUTHORIZED SERVICE PERSON.

IMPORTANT! INSTALLER PLEASE NOTE.

THE GROUNDING OF ELECTRICAL EQUIPMENT SUCH AS TELEPHONE, COMPUTERS, ETC. TO WATER LINES

IS A COMMON PROCEDURE. THIS GROUNDING MAY BE IN THE BUILDING OR MAY OCCUR AWAY FROM

THE BUILDING. THIS GROUNDING CAN CAUSE ELECTRICAL FEEDBACK INTO A FOUNTAIN, CREATING AN

ELECTROLYSIS WHICH CAUSES A METALLIC TASTE OR AN INCREASE IN THE METAL CONTENT OF THE

WATER. THIS CONDITION IS AVOIDABLE BY USING THE PROPER MATERIALS AS INDICATED. ANY DRAIN

FITTINGS PROVIDED BY THE INSTALLER SHOULD BE MADE OF PLASTIC TO ELECTRICALLY ISOLATE THE

FOUNTAIN FROM THE BUILDING PLUMBING SYSTEM.

WWW.RESTROOMDIRECT.COM 704

•

937

•

2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115

Page 2

98011C (Rev. L - 02/18)

ECDFPW314FP

LEGEND

A = RECOMMENDED WATER SUPPLY LOCATION. 3/8 O.D. UNPLATED COPPER TUBE CONNECT STUBBED 1-1/2" (38mm) FROM WALL. SHUT OFF BY OTHERS.

B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4" (44 mm) O.D. DRAIN.

C = RECOMMENDED LOCATION FOR OPERATING CABLE 7/8" (22 mm) DIA. HOLE

NOTE: REINFORCE THE WALL IN THE SHADED AREAS.

ECDFPW314FPC

MOUNTING BOLT AND ACCESS HOLE LAYOUT

FIG. 1

23 1/16"

586mm

152mm

39 9/16"

1005mm

26 7/16"

672mm

25 3/16"

640mm

16"

406mm

1/2"

13mm

BACK PANEL

WALL PLATE

ASSEMBLY

1/4" (6mm) DIA HOLES FOR

MOUNTING PLATE TO WALL

3/8" (10mm) DIA HOLES

FOR MOUNTING PLATE

TO WALL (10)

5 1/4"

133mm

5 1/4"

133mm

203mm

12"

305mm

MAX. WALL

THICKNESS

7 1/4"

184mm

12 1/8"

307mm

FINISHED FLOOR

25mm

WWW.RESTROOMDIRECT.COM 704

•

937

•

2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115

Page 3 98011C (Rev. L - 02/18)

ECDFPW314FP

ECDFPW314FPC

ROUGH-IN DRAWING

1. Wall should already be framed for the fountains using dimensions shown in Fig. 1. Shown dimensions pertain to installation location.

These dimensions are required for compliance with ANSI Standard A117.1. and ADA (Framing shown for reference only).

2. Remove bottom covers from fountains and save the screws.

3. Install the fountains using bolts and washers (provided). Tighten securely.

4. Attach drain tubes to fountains and cut to required length using the freeze resistant boxes as guides.

5. Install freeze-resistant boxes - see box instructions.

6. Replace bottom covers. FIG. 2

WWW.RESTROOMDIRECT.COM 704

•

937

•

2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115

Page 4

98011C (Rev. L - 02/18)

ECDFPW314FP

FIG. 6 FIG. 7

FIG. 3 FIG. 4

See Fig. 7

See Fig. 3 FIG. 5

CABLE SHEATH ADJUSTMENT

To Increase Free Play

To Reduce Free Play

WWW.RESTROOMDIRECT.COM 704

•

937

•

2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115

Page 5 98011C (Rev. L - 02/18)

ECDFPW314FP

The freeze resistant package must be mounted on an interior wall in a heated area. The room temperature of the

interior heated area must be 50° F (10° C) or higher. The freeze resistant package may be surface or recessed

mounted. If recess mounted the surface of the cover must be ush with the interior wall surface. The package is

furnished with screws for mounting the cover to the box. If the box is recess mounted, do not fasten the top and bottom

of the cover to the box. Use the holes on the front only.

1. Assemble the operating cable to the fountain bracket. (Fountain should be mounted to exterior wall). The

adjustment nuts should be in the middle of threaded area on the operating cable. See Figure 3. Create a loop in

the cable and thread the free end of the cable through the wall into the freeze resistant box

2. Connect free end of operating cable to the valve-operating bracket in the freeze resistant box.

3. Remove cable free play by adjusting the jam nuts on the ends of the operating cable. See Figure 4.

4. Connect water line from fountain bubbler into freeze resistant box. The connection to the box uses a quick

connect water tting. Position the water line, in the fountain, to drain back into interior mounted box. Any water left

standing, in the exterior line, can freeze.

To insert tubing, push tube straight into tting until it reaches a positive stop. To remove tubing from the ttings,

relieve water pressure, push in on dark gray collar while pulling out on the tubing. See Figure 9.

5. Connect drain and water supply lines to the freeze resistant fountain. Refer to Figure 1 for component positions.

Inline strainer must be used on the inlet water line. See Figure 8.

Start-up

1. Turn on building water supply and check all connections for leaks. Repair as required.

2. Stream height is factory set at 35 PSI. If stream height needs to be changed adjust the regulator in the freeze

resistant package. Clockwise adjustment raises stream height, counter clockwise adjustment will lower stream.

3. Adjust operating cable as required. Cable system should have a minimal amount of free play to allow for proper

valve operation. If the system is too tight the valve will stay in the on position creating constant water ow. Too

much free play will result in non-operation of the valve with the push-buttons.

4. Note: Water from the drain back tube in the freeze resistant package, will continue to run while the valve is

actuated.

5. After cable system is adjusted properly stuff exible insulation into any openings between the outside wall and the

interior box.

6. Recheck all connections. If all connections are leak free replace cover on the freeze resistant box and fountain.

FIG. 8

NOTE: WATER FLOW DIRECTION

BUILDING WATER

INLET

SERVICE STOP

(NOT FURNISHED)

1/4" O.D. TUBE

WATER INLET

3/8" O.D. UNPLATED COP-

PER TUBE CONNECT

COLD WATER SUPPLY

TUBE IS SECURED

IN POSITION

SIMPLY PUSH IN

TUBE TO ATTACH

PUSH IN COLLET

TO RELEASE TUBE

PUSHING TUBE IN BEFORE

PULLING IT OUT HELPS TO

RELEASE TUBE

FIG. 9

OPERATION OF QUICK CONNECT FITTINGS

WWW.RESTROOMDIRECT.COM 704

•

937

•

2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115

Page 6

98011C (Rev. L - 02/18)

ECDFPW314FP

PART NO.ITEM NO.

PARTS LIST

Drain - Strainer

Bracket-Regulator Mounting

Push Button

Push Button Sleeve

Bracket-Basin

Bracket-Basin Pivot

Retainer

Snap Bushing

Bumper-Reg. Valve Assy

Cap Screw

Kit - Pinned Torx Screw/T-25 Bit

Fountain Arm - Long

Bottom Cover Plate - Long

Back Panel

Hex Nut

Push Button (Extension)

Screw - Mach. 5/16-18 x 3/4

Washer - Flat .339/.359ID Steel

VR Bubbler Assembly

Poly Tubing (Cut To Length)

Mounting Plate Assy

Kit - Drain/Tailpipe

Drain Adapter

Gasket - Tail Pipe

Pivot Rod

40575C

28824C

45662C

45663C

27945C

27946C

40206000

50198C

51667C

75672C

0000001190

28790C

55000665

28290C

40045C

55919C

111577243890

75541C

97446C

56092C

28286C

0000000930

45805C

50074C

70379C

DESCRIPTION

FIG. 13

FIG. 11

FIG. 12

FIG. 10

11 13 22,23,24

17, 18

BASIN

REPAIR SERVICE INFORMATION TOLL FREE NUMBER 1.800.260.6640

FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.834.4816

ELKAY MANUFACTURING COMPANY • 2222 CAMDEN COURT • OAK BROOK, IL 60523 • 630.574.8484 • www.elkay.com

PRINTED IN U.S.A.

WWW.RESTROOMDIRECT.COM 704

•

937

•

2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115

Inhaltsverzeichnis

Andere Elkay Freiluftbrunnen Handbücher

Elkay

Elkay ERPA2-8C*A Installationshandbuch

Elkay

Elkay EFRP12CDC_2 Installationshandbuch

Elkay

Elkay Soft Sides ERO8C C Series Installationshandbuch

Elkay

Elkay EFAVR Installationshandbuch

Elkay

Elkay FLEXI-GUARD SOFT SIDES ezH2O EDFP217WS F... Gebrauchsanweisung

Elkay

Elkay EDFP19C*A Installationshandbuch

Elkay

Elkay Soft Sides ECDFPW314FPC Installationshandbuch

Elkay

Elkay EZO Series Bedienungsanleitung

Elkay

Elkay 4420 Series Bedienungsanleitung

Elkay

Elkay FGDF710-10-1H-MDN Installationshandbuch

Elkay

Elkay SOFT SIDES EZLMSN-EDFPVM217DK Gebrauchsanweisung

Elkay

Elkay 4420FR FTN A Series Bedienungsanleitung

Elkay

Elkay 4420 Series Bedienungsanleitung

Elkay

Elkay LK4410FR FTN A Series Bedienungsanleitung

Elkay

Elkay Soft Sides ERFPD28C Installationshandbuch

Elkay

Elkay 4400FR Series Bedienungsanleitung

Elkay

Elkay 4420BF1LDBFR Bedienungsanleitung

Elkay

Elkay Soft Sides ERFP8C C Series Installationshandbuch

Elkay

Elkay LK4420BF1UDBFRKBLK Bedienungsanleitung

Elkay

Elkay SWIRLFLO Series Installationshandbuch

Elkay

Elkay HEW1 1K Series Bedienungsanleitung

Elkay

Elkay VRCTL8 2C Series Installationshandbuch

Elkay

Elkay EFRC8CDC-A Installationshandbuch

Elkay

Elkay SWIRLFLO ENOBM28K Gebrauchsanweisung

Beliebte Freiluftbrunnen Handbücher anderer Marken

Sunnydaze Decor

Sunnydaze Decor XSS-578 Bedienungsanleitung

Campania International

Campania International Bibendum FT-400 Bedienungsanleitung

S.R.Smith

S.R.Smith Color Light Stream 2CLSLBK Bedienungsanleitung

Hozelock Cyprio

Hozelock Cyprio Cascade 1500 Bedienungsanleitung

Campania International

Campania International Juliet Fountain Bedienungsanleitung

YARDART

YARDART FT-155 Bedienungsanleitung

Alpine

Alpine WIN732 Bedienungsanleitung

Campania

Campania Valencia Bedienungsanleitung

Campania International

Campania International FT-320 Bedienungsanleitung

GardenWize

GardenWize SWGSL230 Bedienungsanleitung

Kelkay

Kelkay Easy Fountain Rustic Windmill Bedienungsanleitung

Alpine

Alpine WIN258 Bedienungsanleitung

Bond

Bond Signature Series Bedienungsanleitung

Kenroy Home

Kenroy Home 51112COPBL Installationsanleitung

EasyPro

EasyPro Tranquil Décor HBB39 Bedienungsanleitung

Angelo Decor

Angelo Decor Castillo Bedienungsanleitung

Campania International

Campania International Girona FT-102A Bedienungsanleitung

Campania International

Campania International FT-271 Bedienungsanleitung