Fujitsu MHT2060BH - Mobile 60 GB Hard Drive Bedienungsanleitung

C141-E203-02EN 3-1

CHAPTER 3 Installation Conditions

3.1 Dimensions

3.2 Mounting

3.3 Cable Connections

This chapter gives the external dimensions, installation conditions, surface

temperature conditions, cable connections, and switch settings of the hard disk

drives.

Installation Conditions

3-2 C141-E203-02EN

3.1 Dimensions

Figure 3.1 illustrates the dimensions of the disk drive. All dimensions are in mm.

*1 The PCA and connectors are not included in these dimensions.

*2 Dimension from the center of the user tap to the base of the connector pins

*3 Length of the connector pins

*4 Dimension from the outer edge of the user tap to the center of the connector

pins

*5 Dimension from the outer edge of the user tap to the innermost edge of the

connector pins

Figure 3.1 Dimensions

3.2 Mounting

C141-E203-02EN 3-3

3.2 Mounting

For information on mounting, see the "FUJITSU 2.5-INCH HDD

INTEGRATION GUIDANCE (C141-E144)."

(1) Orientation

Figure 3.2 illustrates the allowable orientations for the disk drive.

(a) Horizontal –1

(b) Horizontal –1

(d) Vertical –2

(e) Vertical –3

(f) Vertical –4

Figure 3.2 Orientation

gravity

Installation Conditions

3-4 C141-E203-02EN

(2) Frame

The MR head bias of the HDD disk enclosure (DE) is zero. The mounting frame

is connected to Signal Ground (SG).

IMPORTANT

Use M3 screw for the mounting screw and the screw length should

satisfy the specification in Figure 3.3.

The tightening torque must be 0.49N•m (5kgf•cm).m (5kgf•cm).

When attaching the HDD to the system frame, do not allow the

system frame to touch parts (cover and base) other than parts to

which the HDD is attached.

(3) Limitation of mounting

Note) These dimensions are recommended values; if it is not possible to satisfy

them, contact us.

Screw

Details of A

3.0 or less

Frame of system

cabinet

Frame of system

cabinet

PCA

2.52.5

2.5

Side surface

mounting

Bottom surface mounting

Figure 3.3 Mounting frame structure

3.2 Mounting

C141-E203-02EN 3-5

IMPORTANT

Because of breather hole mounted to the HDD, do not allow this to

close during mounting.

Locating of breather hole is shown as Figure 3.4.

For breather hole of Figure 3.4, at least, do not allow its around

φ 2.4 to block.

Figure 3.4 Location of breather

Installation Conditions

3-6 C141-E203-02EN

(4) Ambient temperature

The temperature conditions for a disk drive mounted in a cabinet refer to the

ambient temperature at a point 3 cm from the disk drive. The ambient

temperature must satisfy the temperature conditions described in Section 1.4, and

the airflow must be considered to prevent the DE surface cover temperature from

exceeding 60 °C.

Provide air circulation in the cabinet such that the PCA side, in particular,

receives sufficient cooling. To check the cooling efficiency, measure the surface

cover temperatures of the DE. Regardless of the ambient temperature, this

surface cover temperature must meet the standards listed in Table 3.1. Figure 3.5

shows the temperature measurement point.

•

Figure 3.5 Surface cover temperature measurement points

Table 3.1 Surface temperature measurement points and standard values

No. Measurement point Temperature

1 DE cover 60 °C max

3.2 Mounting

C141-E203-02EN 3-7

(5) Service area

Figure 3.6 shows how the drive must be accessed (service areas) during and after

installation.

Mounting screw hole

Cable connection

Figure 3.6 Service area

Data corruption: Avoid mounting the disk drive near strong

magnetic sources such as loud speakers. Ensure that the disk drive

is not affected by external magnetic fields.

Damage: Do not press the cover of the disk drive. Pressing it too

hard, the cover and the spindle motor contact, which may cause

damage to the disk drive.

Static: When handling the device, disconnect the body ground

(500 kΩor greater). Do not touch the printed circuit board, but

hold it by the edges.

(6) Handling cautions

Please keep the following cautions, and handle the HDD under the safety

environment.

Installation Conditions

3-8 C141-E203-02EN

- General notes

Figure 3.7 Handling cautions

- Installation

(1) Please use the driver of a low impact when you use an electric driver.

HDD is occasionally damaged by the impact of the driver.

(2) Please observe the tightening torque of the screw strictly.

M3 ······· 0.49N•m (5 kgf•cm).

- Recommended equipments

Contents Model Maker

Wrist strap JX-1200-3056-8 SUMITOMO 3MESD

ESD mat SKY-8A (Color Seiden Mat) Achilles

Shock Low shock driver SS-6500 HIOS

Place the shock absorbing mat on the

operation table, and place ESD mat on it.

Use the Wrist stra

Do not hit HDD each other. Do not stack when carr

Do not

lace HDD verticall

to avoid fallin

down. Do not dro

Shock absorbing mat

ESD mat

Wrist strap

3.3 Connections with Host System

C141-E203-02EN 3-9

3.3 Connections with Host System

3.3.1 Device connector

The disk drive has the SATA interface connectors listed below for connecting

external devices. Figure 3.8 shows the locations of these connectors and

terminals.

SATA interface

and power

connectors

PCA

Figure 3.8 Connector locations

Installation Conditions

3-10 C141-E203-02EN

3.3.2 Signal segment and power supply segment

Figure 3.9 shows each segment of the SATA interface connector and pin

numbers.

Power suppl

segment

P1 pins in the power

supply segment

S1 pins in the si

nal

segment

View from the

connector side

View from the

PCA side

nal se

ment

Figure 3.9 Power supply pins (CN1)

3.3.3 Connector specifications for host system

Table 3.2 lists the recommended specifications for the host interface connectors.

Table 3.2 The recommended connector specifications for the host system

Segment Name Model (Manufacturer)

SATA interface

and power supply Host receptacle 67492-0220 (Molex) or compatibles

Inhaltsverzeichnis

Andere Fujitsu Lagerung Handbücher

Fujitsu

Fujitsu ETERNUS DX500 S4/DX600 S4 Leitfaden

Fujitsu

Fujitsu ETERNUS DX60 S2 Bedienungsanleitung

Fujitsu

Fujitsu ETERNUS DX Disk Bedienungsanleitung

Fujitsu

Fujitsu MAG3182FC SERIES Bedienungsanleitung

Fujitsu

Fujitsu ETERNUS DX Disk Bedienungsanleitung

Fujitsu

Fujitsu ETERNUS DX60 Bedienungsanleitung

Fujitsu

Fujitsu GP5-HD9G3 Bedienungsanleitung

Fujitsu

Fujitsu GRANPOWER 5000 GP5-HDH461 Bedienungsanleitung

Fujitsu

Fujitsu DYNAMO 640AI Bedienungsanleitung

Fujitsu

Fujitsu MHV2060AT Bedienungsanleitung

Fujitsu

Fujitsu MBA3300NC Bedienungsanleitung

Fujitsu

Fujitsu MHV2100BH Bedienungsanleitung

Fujitsu

Fujitsu MHW2040AT - Mobile 40 GB Hard Drive Bedienungsanleitung

Fujitsu

Fujitsu Eternus DX600 S3 Montageanleitung

Fujitsu

Fujitsu ETERNUS DX Disk Bedienungsanleitung

Fujitsu

Fujitsu FD-1100MT Bedienungsanleitung

Fujitsu

Fujitsu PG-HD9G1C Bedienungsanleitung

Fujitsu

Fujitsu MHW2060BK - Mobile 60 GB Hard Drive Bedienungsanleitung

Fujitsu

Fujitsu ETERNUS DX S2, ETERNUS DX S3, ETERNUS DX S4, ETERNUS... Bedienungsanleitung

Fujitsu

Fujitsu Eternus DX80 S2 Bedienungsanleitung

Fujitsu

Fujitsu MHT2080BH Bedienungsanleitung

Fujitsu

Fujitsu MHW2040BS Bedienungsanleitung

Fujitsu

Fujitsu P3AM-5382-03ENZ0 Anleitung zur Verwendung

Fujitsu

Fujitsu MAP3147NC - Enterprise - Hard Drive Bedienungsanleitung

Beliebte Lagerung Handbücher anderer Marken

QNAP

QNAP TS 32PXU Series Bedienungsanleitung

LaCie

LaCie RUGGED RAID Bedienungsanleitung

Freecom

Freecom CLS DOCK Bedienungsanleitung

PNY

PNY Attache P-FD64MBATT3 Bedienungsanleitung

HP StorageWorks MSL2024 Bedienungsanleitung

OLT

OLT 6x6 Maximizer Bedienungsanleitung

Transcend

Transcend JetFlash 160 Bedienungsanleitung

LaCie

LaCie RUGGED MINI Bedienungsanleitung

Thunderbolt

Thunderbolt 600 Bedienungsanleitung

Panasonic

Panasonic LB-DH8 series Handbuch

Intel

Intel RAID High Availability Bedienungsanleitung

LaCie

LaCie 12big Thunderbolt 3 Bedienungsanleitung

Spectra Logic

Spectra Logic T-Series Spectra T50e Bedienungsanleitung

Panasonic

Panasonic LKM-F931-1 Bedienungsanleitung

Tabernus

Tabernus Enterprise Erase E2400 Bedienungsanleitung

Rocstor

Rocstor COMMANDER 3F series Bedienungsanleitung

Western Digital

Western Digital Ultrastar Data60 Bedienungsanleitung

HP P9000 Bedienungsanleitung