Generac Power Systems 005792-0 Bedienungsanleitung

L: 005792-

inverterGenerator

AccessoryBox..............................................insideFrontCover

introduction..............................................................................1

Readthis ManualThoroughly..................................................1

SafetyRules............................................................................1

StandardsIndex...............................................................3

Section 1 - Generalinformation..............................................4

Specifications...........................................................................4

UnitIdentification......................................................................4

ControlPanel....................................................................4

ACCESSORYBOX

Checkall contents. If anyparts are missingor damagedlocate an

authorizeddealerat 1=888=436=3722.

Contentsinclude:

• 1 bottleSAE30 Oil • Oil Funnel

• SparkPlugWrench • Screwdriver

• BatteryChargeCable

Section 2 - Operation...............................................................5

Pre=UseCheck..........................................................................5

Starting theGenerator...............................................................5

Adding Loads............................................................................6

Usingthe FlexPowerTM Switch...................................................7

Usingthe 12 VDCBatteryCharger............................................7

Shutting Down..........................................................................7

LowOil LevelShutdown............................................................7

Fuelingthe Generator................................................................8

ToFilltheFuelTank..........................................................8

Adding EngineOil......................................................................8

ToAdd EngineOilto the Crankcase..................................8

Section 3 - Maintenance..........................................................g

GeneratorMaintenance.............................................................9

GeneratorMaintenanceSchedule..............................................9

Cleaningthe Generator..............................................................9

EngineMaintenance..................................................................9

Changingthe EngineOil..........................................................10

Changingthe FuelFilter...........................................................10

Changingthe SparkPlug.........................................................10

Transportationand Storage.....................................................11

Section 4 - Troubleshooting...................................................12

TroubleshootingGuide.............................................................12

Section 5 - Notes...................................................................13

Section 6 - Warranty..............................................................12

iNTRODUCTiON

Thankyou for purchasingthis modelby GeneracPowerSystems,

Inc. This model is a compact, high performance, air-cooled,

engine driven generatordesigned to supply electrical power to

operateelectrical loads where no utility power is availableor in

placeof utility dueto a poweroutage.

BEADTHiSMANUALTHOROUGHLY

If anyportion ofthis manualis notunderstood,contactthenearest

AuthorizedDealerfor starting, operatingandservicingprocedures.

The operator is responsible for proper and safe use of the

equipment.We strongly recommendthat the operator read this

manualandthoroughlyunderstandall instructionsbeforeusingthe

equipment.Wealsostronglyrecommendinstructingotherusersto

properlystart andoperatethe unit.This preparesthem ifthey need

to operatetheequipmentin an emergency.Savethese instructions

for future reference.If you loanthis unitto someone,ALWAYSloan

these instructionsto the individualaswelt.

Thegeneratorcan operatesafely,efficiently and reliablyonly if it

is properlylocated,operatedand maintained.Beforeoperatingor

servicingthe generator:

•Becomefamiliar with and strictly adhereto all local, stateand

nationalcodes and regulations.

•Study all safety warnings in this manual and on the product

carefully.

•Becomefamiliar with this manualandthe unitbeforeuse.

Themanufacturercannot anticipateevery possible circumstance

that might involvea hazard.Thewarnings in this manual,and on

tags and decalsaffixedto the unit are,therefore,not all inclusive.

If usinga procedure,work method or operatingtechniquethat the

manufacturerdoes not specifically recommend,ensurethat it is

safe for others. Also make sure the procedure,work method or

operatingtechnique utilizeddoes not renderthe generatorunsafe.

THE INFORMATIONCONTAINEDHEREIN WAS BASED ON

MACHINESIN PRODUCTIONAT THE TIME OF PUBLICATION.

GENERACRESERVESTHERIGHTTOMODIFYTHISMANUALAT

ANYTIME.

SAFETYRULES

Throughoutthis publication,and on tags and decals affixedto the

generator,DANGER,WARNING,CAUTIONand NOTEblocks are

usedto alert personnelto special instructionsabout a particular

operation that may be hazardous if performed incorrectly or

carelessly.Observethem carefully.Theirdefinitionsareasfollows:

iNDICATES A HAZARDOUS SiTUATiON OR

ACTION WHICH, IF NOT AVOIDED, WiLL RESULT

IN DEATH OR SERIOUS iNJURY.

indicates ahazardous situation or action which,

if not avoided, could result in death or serious

injury.

_,CAUTION!

indicates ahazardous situation or action which,

if not avoided, could result in minor or moderate

injury.

NOTE:

Notes containadditional informationimportantto a procedure

and will be found withinthe regulartextbody of thismanual.

These safety warnings cannot eliminate the hazardsthat they

indicate. Common sense and strict compliancewith the special

instructionswhileperforming theaction or serviceareessentialto

preventingaccidents.

Four commonly used safety symbols accompany the DANGER,

WARNINGand CAUTIONblocks. The type of information each

indicatesis asfollows:

This symbol points out important safety

information that, if not followed, could

endanger personal safety and/or property of

others.

This symbol points out potential explosion

hazard.

//_This symbol points out potential fire hazard.

/i_This symbol points out potential electrical

shock hazard.

GENERAL HAZARDS

•Neveroperateinan enclosedareaor indoorsEVENIFdoorsand

windows areopen.

•For safety reasons, the manufacturer recommends that the

maintenanceof this equipmentis carried out by an Authorized

Dealer.Inspectthe generatorregularly,and contactthe nearest

AuthorizedDealerfor parts needingrepairor replacement.

•Operategeneratoronly on levelsurfacesandwhereit will notbe

exposedto excessivemoisture,dirt, dust or corrosivevapors.

•Keep hands, feet, clothing, etc., away from drive belts, fans,

and othermoving parts. Neverremoveany fan guardor shield

whilethe unit isoperating.

•Certain parts of the generator get extremely hot during

operation. Keepclear of the generator until it has cooled to

avoidsevereburns.

•Do NOToperategeneratorinthe rain.

•Do not alter the construction of the generator or change

controlswhich might createan unsafeoperatingcondition.

•Never start or stop the unit with electrical loads connected

to receptaclesAND with connecteddevicesturned ON. Start

the engine and let it stabilize before connecting electrical

loads. Disconnectall electricalloads beforeshutting downthe

generator.

•Do notinsert objectsthrough unit's cooling slots.

•When working on this equipment, remain alert at all times.

Never work on the equipment when physically or mentally

fatigued.

*Neverusethe generatoror anyof its parts as a step. Stepping

on the unit can stress and break parts, and may result in

dangerousoperating conditions from leakingexhaust gases,

fuel leakage,oil leakage,etc.

*On electricstart models,disconnectthe POSITIVE(+) battery

cable from the engine starter ORthe NEGATIVE(=) battery

cable from the battery terminal, whichever is easier, before

transportingthe generator.

EXHAUST& LOCATIONHAZARDS

•NEVER use inside, or in partly enclosed areas such as

garages,EVENIF doorsand windowsare open! ONLYuse

outdoorsand farfromwindows,doorsand vents.Onlyusein

anarea thatwillnot accumulatedeadlyexhaust.

*The engine exhaustfumes contain carbon monoxide, which

you cannot see or smell. This poisonous gas, if breathedin

sufficientconcentrations,can causeunconsciousnessor even

death.

*Adequate, unobstructed flow of cooling and ventilating air

is critical to correct generator operation. Do not alter the

installation or permit even partial blockage of ventilation

provisions, as this can seriously affect safe operationof the

generator.ThegeneratorMUSTbeoperatedoutdoors.

*This exhaustsystemmust be properlymaintained.Do nothing

that mightrendertheexhaustsystemunsafeorinnoncompliance

with any localcodes and/orstandards.

*Alwaysusea batteryoperatedcarbonmonoxidealarmindoors,

installedaccordingto themanufacturersinstructions.

*If you start to feet sick, dizzy,or weak after the generatorhas

beenrunning,moveto fresh air IMMEDIATELY.Seea doctor,as

you couldhavecarbonmonoxidepoisoning.

ELECTRICALHAZARDS

*The generator produces dangerously high voltage when in

operation.Avoidcontactwith barewires,terminals,connections,

etc., while the unit is running,even on equipmentconnected

to the generator. Ensureall appropriate covers, guards and

barriersarein placebeforeoperatingthegenerator.

*Never handle any kind of electrical cord or device while

standinginwater,while barefootorwhile handsor feet arewet.

DANGEROUSELECTRICALSHOCKMAYRESULT.

. TheNationalElectricCode(NEC)requirestheframe andexternal

electrically conductive parts of the generator be properly

connectedto an approvedearthground.Local electricalcodes

may also require proper grounding of the generator.Consult

with a localelectricianfor groundingrequirementsin thearea.

*Use a ground fault circuit interrupter in any damp or highly

conductivearea(such as metaldecking or steelwork).

*Do not useworn, bare,frayed or otherwisedamagedelectrical

cord setswith the generator.

*Beforeperforminganymaintenanceonthegenerator,disconnect

the enginestarting battery (if equipped)to prevent accidental

start up. Disconnectthe cablefrom the batterypost indicated

by a NEGATIVE,NEGor (-) first. Reconnectthat cable last.

*In caseof accidentcausedby electricshock, immediatelyshut

down the source of electrical power. If this is not possible,

attempt to free the victim from the live conductor. AVOID

DIRECTCONTACTWITH THE VICTIM. Use a non-conducting

implement,such asa rope or board,to freethevictim from the

live conductor.If the victim is unconscious,applyfirst aid and

getimmediatemedical help.

FiREHAZARDS

• GasolineishighlyFLAMMABLEand itsvaporsare EXPLOSIVE.

Do not permitsmoking,open flames, sparksor heat in the

vicinitywhile handlinggasoline.

•Neveraddfuel whileunit isrunning or hot. Allow engineto cool

completelybeforeaddingfuel.

•Never fill fuel tank indoors, Comply with all laws regulating

storageand handlingof gasoline.

•Do not overfill the fuel tank. Always allow roomfor fuel

expansion. If tank is over=filled,fuel can overflow onto a hot

engineandcauseFIREor an EXPLOSION.Neverstoregenerator

with fuel in tank where gasolinevapors might reachan open

flame, spark or pilot light (as on a furnace, water heateror

clothes dryer). FIREor EXPLOSIONmay result. Allow unit to

cool entirelybeforestorage.

• Wipe up any fuel or oil spills immediately.Ensure that no

combustiblematerialsareleft on or nearthegenerator.Keepthe

areasurroundingthe generatorcleanandfree from debrisand

keepa clearanceof five (5) feet on all side to allow for proper

ventilationofthe generator.

*Do notinsert objectsthrough unit's cooling slots.

* Do not operatethe generatorif connected electrical devices

overheat,if electricaloutputislost, if engineor generatorsparks

or ifflames or smokeare observedwhileunit is running.

*Keepafire extinguishernearthe generatoratall times.

STAtVDARDS/NDEX

Intheabsenceof pertinentstandards,codes,regulationsandtaws,

the publishedinformationlistedbelowmay be usedas a guideline

foroperationofthis equipment.Alwaysreferencethelatestrevision

availablefor the standardslisted.

1. NFPANo. 70, NFPAHANDBOOKOF NATIONALELECTRIC

CODE.

2. Article X, NATIONALBUILDINGCODE,available from the

American InsuranceAssociation, 85 John Street, New York,

N.Y 10038.

3. AGRICULTURALWIRINGHANDBOOK,availablefrom the Food

and EnergyCouncil, 909 UniversityAvenue, Columbia, MO

65201.

4. ASAE EP-3634, INSTALLATIONAND MAINTENANCEOF

FARMSTANDBYELECTRICALSYSTEMS,availablefrom the

AmericanSocietyof AgriculturalEngineers,2950 NilesRoad,

St. Joseph,MI 49085.

MODELNO:

SERIALNO:

Fig.re 1 - Generator/D P/ate

ID PLATE

CALIFORNIAPROPOSITION65 WARNING

Engineexhaustand someof its constituentsareknown

to theStateof Californiato causecancer,birth defects

andotherreproductiveharm.

CALIFORNIAPROPOSITION65 WARNING

This productcontainsor emitschemicalsknown tothe

Stateof Californiato causecancer,birth defectsand

otherreproductiveharm.

SPECiFiCATiONS

EngineType........................ SingleCylinder,4-Stroke

EngineSize....................................... 99c0

StarterType...................................... Recoil

FuelCapacity/Type................... 0.8 Ca](3.04L)/Unleaded

OilCapacity................................ 0.03Qt(O.CL)

RuntimeFull/HalfLoad........................ 2.5/4.9Hours

SparkPlugType............ DensoU16FSR-UBor NGKCR5H88

SparkPlugGap..................................... 030"

DimensionsLx Wx H (in)...................... 22x 12x 18

WeightLb/kg.................................. 43.5/19.7

MaximumACOutput.............................. 1600W

SurgeACOutput................................. 1650W

ACVolts....................................... 120VAC

RatedACCurrent.................................. 13.3A

Frequency....................................... 60 Hz

THD............................................. 3.0%

InsulationClass.................................. ClassF

Outlets.............................. (2) 5-15R,(1) 12VDC

DCVolts........................................ 12VDC

RatedDCCurrent.................................... 5 A

NOTE:

Power output and runtime are influenced by many factors,

someofwhich are fuel quality,ambient temperatureand engine

condition.Outputdecreases approximately 3.5% for each1,O00

feet abovesea level and 1% for every10 degrees above60°F.

UNITIDENTIFICATION(Figure2)

1. CarryingHandle:Lift the generatorby this handleonly.

2. SparkPlugCover:Allows accessto the enginespark plug.

3. Fuel System Primer: Used to prime the fuel system for

starting.

4. FuelCapPressureValve: Allows air to enterthe fuel tank to

equalizepressure.

5. FuelTankCap:Accessto fuel tankfor filling.

6. Control Panel: location of generator controls and output

receptacles.

7. Air IntakeSlats:Allows for cooling airto enterthe housing.

8. Muffler: Lowers engineexhaustnoise.

9. Choke:Coldenginestartingaid

10. Left Side ServiceCover:Allows access to air filter,fuel filter

and oil fill.

11. VentHoses:Hosesallowventing ofthe carburetor.

12. FuelShutoff:Controlsfuel supply to thecarburetor.

13. Starter Rope:Pullropefor startingengine.

Figure2- UnitIdentification

CONTROLPANEL Fi ure3

14. LOWOIL LEVELLED (yellow): Lights up when oil level is

belowsafe operatinglevelandthe engineshuts down..

15. OVERLOADLED(red): Lights up if the generatorexperiences

a load greaterthanthe ratedoutput, lowvoltage,overheatsor

thepoweredcircuitexperiencesa short.Theoutputis stopped

eventhoughthe enginekeeps running.

16. READY LED (green): Indicates output from the generator

unlessthereis a low oil or overloadcondition.

17. 12 VDCPlug:Connectionfor re-charging12VDCautomotive-

style batterieswhile generatoris in operation.

18. FlexPowerTM Switch: This switch slows the engine speed

whenthe loadis reducedto savefuel and enginewear.

19. 12 VDC Circuit Breaker:Overloadprotectionfor the 12 VDC

chargingsystem.

20. Ground (Earth) Connection Lug: Grounding point for the

generator;consultstateand local electricalcodes beforeuse

(floatingground).

21. 120 VAC Receptacles:Two (2) receptaclesfor connecting

accessories.

NOTE:

Donot exceedthe ratedoutputof the generator.

Figure3 - ControlPanel

14_

15--

16--

17--

18--

0 0

o19 20

PRE-USECHECK

Prior to starting the generatorand adding loads, perform the

following tasks:

1. Make surethe generatorin on a firm, level,non-combustible

surfacewith at leastfive (5) feet of clearanceon all sides.

Never operate in an enclosed area or

indoors! NEVER use in the home, or in

partly enclosed areas such as garages,

even if doors and windows are open! ONLY

use outdoors and far from open windows,

doors, vents, and in an area that will not

accumulate deadly exhaust.

4. Replaceand securethe left sideservicecover.

5. Makesurethereare no loadsconnectedto the generator.

6. The National Electric Code (NEC) requires the frame and

external electrically conductive parts of the generator be

properly connected to an approved earth ground. Proper

grounding of the generatorwill prevent electrical shock in

the event of a ground fault condition in the generatoror in

connected electrical devices. Proper grounding also helps

dissipatestatic electricity,which often builds up in unguarded

devices.

7. Local electricalcodes may also require proper grounding of

thegenerator.

,ACAUTION!

_1 Starting the generator with accessories

connected to the 120 VAC outlets will damage

the generator and the connected accessories.

STARTINGTHEGENERATOR

Oncethe fuel and oil levels have beenchecked and it has been

verified there are no loads connected, the generator may be

started. Turnthe FlexPowerSwitchOFF(0).

1. Openthe fuel valve (Figure4), locatedbelowthe starter rope

pull, byturningto thevalve90°counter-clockwisetothe "ON"

(I) position.

Figure4-FuelVa/ve

Removethefuel capandcheckthefuellevel. Iffuel isneeded,

seethesection "FUELINGTHEGENERATOR".

Removethe left side service cover and check the oil level

by removingthe oil filler cap. The oil level should be to the

bottom of thethreadson the oil fill pipe. If oil is needed,see

thesection "ADDINGENGINEOIL:'.

2. Pull up on the center of the fuel fill cap and prime the fuel

systemby depressingthe plungerupto five (5) timeswith the

vent closed (Figure5 on nextpage).

3. Openthefueltankvent onthetop ofthefuelfill capbyturning

thecenter portionto the "ON" mark (Figure6 on nextpage).

4. If theengineiscold or hasnot beenrunfor sometime,engage

thechoke by pushingthe choke leverto theright.

5. Gripthe handlefor the pull starter andbraceyour other hand

againstthe generator.Pull the rope slowly until resistanceis

felt,then pullthe rope rapidly.

6. If the enginedoes not start, repeatsteps2-5 untilthe engine

fires and beginsto run.

7. Carefullyadjustthechoketoapproximatelythe1/2position

untiltheenginebeginstorunsmoothly,thenpushtheleverall

thewaytotheleft(Figure6).

8. Makesurethebottomofthegeneratorisnotblockedbysand,

leaves,grass,etc.asthecoolingventsarelocatedonthe

bottomoftheunit.

Figure 5 - Prime Fuel System

PLUNGER

FUEL

SYSTEM

VENT

Figure 5-Adjust Choke

..... czz: ::

ADDINGLOADS

Oncethe generatorhas been running smoothly for 2-3 minutes,

electricalloadscan beadded.

Do not use worn, bare, frayed or otherwise

damaged electrical cord sets with the

generator. De not handle any kind of

electrical device while standing in water,

while barefoot, or while hands or feet are

wet.

1. Thereare two grounded 120 VACduplexoutletson the front

of thegenerator.

2. DO NOT overloadthe generator; if the red "overload" LED

lights up and the accessories attached to the generator

stop operating, stop the engine and reduce the load to the

generator.Restartand applyreducedloads.

3. Consultthe following tableto estimate what can be powered

by thegenerator.

Device ................................ BanningWatts

*Air Conditioner(12,000Btu) ......................... 1700

*Air Conditioner(24,000Btu) ......................... 3800

*Air Conditioner(40,000Btu) ......................... 6000

BatteryCharger(20Amp) ............................. 500

BeltSander(3").................................... 1000

ChainSaw........................................ 1200

CircularSaw(6-1/2").......................... 800to 1000

*ClothesDryer(Electric)............................. 5750

*ClothesDryer(Gas)................................. 700

*ClothesWasher................................... 1150

CoffeeMaker...................................... 1750

*Compressor(1 HP)................................ 2000

*Compressor(3/4HP)............................... 1800

*Compressor(1/2HP)............................... 1400

CurlingIron........................................ 700

*Dehumidifier...................................... 650

DiscSander(9") ................................... 1200

EdgeTrimmer...................................... 500

ElectricBlanket..................................... 400

ElectricNailGun.................................... 1200

ElectricRange(perelement).......................... 1500

ElectricSkillet ..................................... 1250

*Freezer........................................... 700

*FurnaceFan(3/5HP)................................ 875

*GarageDoorOpener........................... 500to 750

HairDryer ........................................ 1200

HandDrill................................... 250to 11O0

HedgeTrimmer..................................... 450

ImpactWrench ..................................... 500

Iron............................................. 1200

*Jet Pump......................................... 800

LawnMower...................................... 1200

LightBulb ......................................... 1O0

MicrowaveOven............................. 700to 1000

*Milk Cooler...................................... 1100

OilBurneron Furnace................................. 300

OilFiredSpaceHeater(140,000Btu)..................... 400

OilFiredSpaceHeater(85,000Btu)...................... 225

OilFiredSpaceHeater(30,000Btu)...................... 150

*PaintSprayer,Airless(1/3HP)......................... 600

PaintSprayer,Airless(handheld)........................ 150

Radio........................................ 50to 200

*Refrigerator....................................... 700

SlowCooker....................................... 200

*SubmersiblePump(1-1/2HP)........................ 2800

*SubmersiblePump(1 HP)........................... 2000

*SubmersiblePump(1/2HP).......................... 1500

*Sump Pump................................ 800to 1050

* Allowthree(3)timesthelistedrunningwattsforstartingthesesdevices.

NOTE: NOTE:

Whenan electricmotoris started,the "OVERLOAD"LEDmay

lightup for up tofive (5) seconds(this is normal),if itstayson,

a fault has0ccured. Removeall loadsand shutdowngenerator

to resetthe alarm. Restart the generator, if the "OVERLOAD"

LEDremainslit, contactaGeneracDealerfor assistance.

USINGTHEFLEXPOWERTM SWITCH

Whenthe accessoriesconnected to the generator are going to

be used intermittently (such as a hand drill), the FtexPowerTM

switch canbe pushedto the "ON" (I) position. Thiswill lowerthe

generatorenginespeedwhen loadsare not being applied,saving

fuel, reducingenginewearand extendingruntime.

USINGTHE12VDC BATTERYCHARGER

The 12 VDC receptacle may be used to recharge 12 VDC

automotivebatteriesonly.TheDCchargingoutput isnot regulated.

Thecircuit protectordoesnot preventover-charginga battery.

1. Connectthe charging cable to the generatorfirst, then the

battery,ALWAYSconnectingthe red leadto positive (+) and

the blackto negative(-).

ADo not permit smoking, open flame, sparks

or any other source of heat around a battery.

Wear protective goggles, rubber apron and

rubber gloves when working around a battery.

Battery electrolyte fluid is an extremely

corrosive sulfuric acid solution that can cause

severe burns, if a spill occurs, flush area with

clear water immediately.

_Sterage batteries give off explosive hydrogen

gas while recharging. An explosive mixture

will remain around the battery for a long

time after it has been charged. The slightest

spark can ignite the hydrogen and cause an

explosion. Such an explosion can shatter the

battery and cause blindness or other serious

injury.

_1 NEVER reverse the polarity when connecting

the battery terminals to the charging jack.

Severe damage may occur to the generator

and battery.

2. Keepthe FlexPowerTM switch in the "OFF"(O) position.

3. Start the generatorand use it as normal. Chargingtime will

vary with batterysize andcondition. Checkthe voltageatthe

batteryterminalsoncethe chargingcablehasbeenunplugged

or the generatorhasbeenshut down.

This receptacle can not recharge 6=Volt batteries

and can net be used to crank an engine having a

discharged battery.

SHUTTINGDOWN

Oncethegeneratoris no longerneededit can be shut down.

1. Switchoff anyaccessoriesconnectedto thegenerator.Unplug

anycords to the 120 VACduplexoutletsor the 12 VDCplug.

2. Turnthe fuel valve to the "OFF" (0) position (Figure 7). A

switch behind the fuel valve grounds the ignition system,

stoppingthe engineand thefuel supply is shut off.

3. Closethevent on thefuel cap.

4. Allowthe generatorto cool beforemoving or storing.

ACAUTION!

_1 Always allow the generator to cool off before

storing. High temperatures will be present

at the rear of the unit for some time after

shutdown.

Figure 7- Turn Off Fue/

If'ill lli,!ll li

TURNING THE FUEL OFF

LOWOILLEVELSHUTDOWN

Thisgeneratoris equippedwith alow oil levelshut down. If theoil

levelin the enginecrankcasedrops belowa pre-determinedlevel,

the enginewill stop automaticallyand the "LOWOIL LEVEL'LED

will lightup.

Removethe Left Side Service Cover and check the oil level of

theengine.Add or drain oil as necessary;referto seethe section

"ADDINGENGINEOIE'.

FUELINGTHEGENERATOR

Use carewhen fuelingthe generator. Onlyfill the fuel tank when

the generatorhascooledentirely.Usefresh unleadedgasolinewith

a minimum ResearchOctaneNumber (RON)of 87.

NOTE:

Do not use any gas01inecontainingmore than 10% Ethanol.

NEVERfillthefueltankwith E85or a mixtureof 0il and gasoline

designatedfor tw0-cycleengines.

Do not light acigarette or smoke when filling the

fuel tank.

_Gasoline is highly FLAMMABLE and its vapors

are EXPLOSIVE. Do not permit smoking, open

flames, sparks or heat in the vicinity while

handling gasoline.

_Never fill fuel tank indoors, never fill fuel

thank when engine is running or hot. avoid

spilling gasoline on a hot engine, allow engine

to cool entirely before filling fuel tank.

ADo not overfill the fuel tank. Always allow

room for fuel expansion, if tank is over=filled,

fuel can overflow onto ahot engine and cause

FIRE or an EXPLOSION. Wipe up fuel spills

immediately!

TOFILLTHEFUELTANK

I. Removethefueltankcap.

Figure 8- Fuel Tank Cap

FUEL

TANK

CAP

FILL TANK UNTIL

FUEL IS TWO (2)

INCHES

THE TOP

2. Addfuel slowly, stopping abouttwo (2) inches belowthe top

of thefiller neck.

3. Replacethefueltankcap. Makesurethevalveonthefuelcap

is in the "OFF"position.

4. If the generatoris going to be started, refer to the section

"STARTINGTHE GENERATOR"for additional directions on

primingthefuel system.

ADDINGENGINE01L

All oil should meet minimum American PetroleumInstitute (API)

Service Class SJ, SL or better. Do not use any aftermarket

additives.

Selecttheoil's viscosity gradeaccordingtothe expectedoperating

temperature,onlya littlemorethan one-halfquart is needed.

• Above40° F,useSAE30

• Below40° Fto 10° F,use10W-30

• Below10° F,use synthetic5W-30

mE ,m

°F =20 -10 0 10 20 32 40 60

°c-3'o -2'0 -lo 0 1'o 2'0

Temperature Range of Expected Use

80 100

3'0 _

TOADDENGINEOILTOTIlECRANKCASE

1. Placethe uniton afirm, levelsurface.

2. Removethe Left Side ServiceCover.

3. Removethe oil fill cap located on the bottom of the engine

crankcase.

4. Add the recommendedengineoil slowly, stoppingfrequently

to check the level.Thefull levelis the baseof the threads in

thefiller neck.DONOTOVERFILL!

5. Replacethe oil fill cap andtighten.

6. Always check the oil level before starting the generator

engine.

_,CAUTION!

ALi-AoDIONOT overfill the engine crankcase with

High oil pressure may result, causing

premature engine wear and damage.

Andere Handbücher für 005792-0

Inhaltsverzeichnis

Sprachen:

Andere Generac Power Systems Tragbarer Generator Handbücher

Generac Power Systems

Generac Power Systems 7 kW NG Merkblatt

Generac Power Systems

Generac Power Systems 006001-0 Bedienungsanleitung

Generac Power Systems

Generac Power Systems GP8000E Bedienungsanleitung

Generac Power Systems

Generac Power Systems GP8000 Bedienungsanleitung

Generac Power Systems

Generac Power Systems Protector Series Bedienungsanleitung

Generac Power Systems

Generac Power Systems 006719-0 Bedienungsanleitung

Generac Power Systems

Generac Power Systems GP7000E GP SERIES Bedienungsanleitung

Generac Power Systems

Generac Power Systems SVP5000 97193 Bedienungsanleitung

Generac Power Systems

Generac Power Systems 5.6 kVA PowerPact Bedienungsanleitung

Generac Power Systems

Generac Power Systems IX 800 Bedienungsanleitung

Generac Power Systems

Generac Power Systems D2.5L G2 Extended Tank Merkblatt

Generac Power Systems

Generac Power Systems PWRgenerator 9 kW Bedienungsanleitung

Generac Power Systems

Generac Power Systems MAGNUM MMG25IF4 Bedienungsanleitung

Generac Power Systems

Generac Power Systems IX 800 Bedienungsanleitung

Generac Power Systems

Generac Power Systems XD5000E Bedienungsanleitung

Generac Power Systems

Generac Power Systems 005778-0 Bedienungsanleitung

Generac Power Systems

Generac Power Systems MLG15 Bedienungsanleitung

Generac Power Systems

Generac Power Systems 5500EXL Bedienungsanleitung

Generac Power Systems

Generac Power Systems QT06030GNSNR Bedienungsanleitung

Generac Power Systems

Generac Power Systems iQ2000 Bedienungsanleitung

Generac Power Systems

Generac Power Systems Guardian ULTRA SOURCE 004583-0 Bedienungsanleitung

Generac Power Systems

Generac Power Systems Mobile Power MMG465 Bedienungsanleitung

Generac Power Systems

Generac Power Systems 005467-1 Bedienungsanleitung

Generac Power Systems

Generac Power Systems GP Series Bedienungsanleitung

Beliebte Tragbarer Generator Handbücher anderer Marken

Kohler

Kohler 20EORZ Bedienungsanleitung

Powerhorse

Powerhorse 83171 Bedienungsanleitung

HURST

HURST ML-630-SI Bedienungsanleitung

ETQ

ETQ TG4000 Bedienungsanleitung

Briggs & Stratton

Briggs & Stratton 40265 Einrichtungshandbuch

evertz

evertz 7700 Series Bedienungsanleitung

Firefly

Firefly Cygnus CYG2400/460/24 Bedienungsanleitung

Owon

Owon Waveform Generator Bedienungsanleitung

Draper

Draper PG950S Firmware-Update

SDMO

SDMO SH 4000 Bedienungsanleitung

EINHELL

EINHELL STE 5500 Bedienungsanleitung

Wanco

Wanco WI3000P Bedienungsanleitung

Full Boar

Full Boar FBT-3300 Bedienungsanleitung

Dwyer Instruments

Dwyer Instruments ASG Bedienungsanleitung

Westinghouse

Westinghouse WH1000i Series Bedienungsanleitung

Wallenstein

Wallenstein GF5000A Bedienungsanleitung

Leroy-Somer

Leroy-Somer LSA 49.1 Bedienungsanleitung

Yamakoyo

Yamakoyo SH2900DX Bedienungsanleitung