Jackson Grills Patio Fire Bedienungsanleitung

PLEASE KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE

JACKSON GRILLS PATIO

FIRE

Tested by:

Tested to: ANSI Z21.97-2010 & CSA CAN 1-2.21-M85

WARNING: For Outdoor Use

Only.

WARNING: If the information in this manual is not followed exactly, a fire or

explosion may result causing property damage, personal injury or loss of life.

-Do not store or use gasoline or other flammable vapors and liquids in the vicinity of

this or any other appliance.

- WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switches; do not use the phone in your building.

• Immediately call your gas supplier from a neighbor’s phone. Follow the gas

supplier’s instructions.

• If you cannot reach your gas supplier, call the fire department.

- Installation and service must be performed by a qualified installer, service agency or

the gas supplier.

WARNING: Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage. Read the

installation, operation and maintenance instructions thoroughly before

installing or servicing this equipment.

TABLE OF CONTENTS

Safety Precautions.......................................................................................... ……… 3

Specifications................................................................................................. ……… 4

Assembly........................................................................................................ ……… 4

Campfire Placement........................................................................................ ……… 4

Lighting Instructions........................................................................................ ……… 5

Turning Off Gas To Campfire............................................................................ ……… 6

Log & Ember Placement......................................................................................... 6

Natural Gas Conversion…………………………………………………………………………………………. 8

Care & Maintenance............................................................................................... 9

Storage........................................................................................................... ……… 10

Warranty.............................................................................................................. 11

Parts List....................................................................................................... ……… 12

SAFETY PRECAUTIONS

FOR SAFE INSTALLATION AND OPERATION OF THE JACKSON GRILLS PATIO FIRE,

PLEASE CAREFULLY READ THE FOLLOWING INFORMATION:

GENERAL

• The Patio Fire must be installed in accordance with their instructions. Carefully read all the

instructions in this manual first. Consult the building authority having jurisdiction to

determine the need for a permit prior to commencing the installation.

• NOTE: Failure to follow these instructions could cause a malfunction of the campfire, which

could result in death, serious bodily injury, and/or property damage.

• Failure to follow these instructions may also void your fire insurance and/or warranty.

• Installation and repair should be done by a qualified service person. The

appliance should be inspected before the first use and, at least, annually by a

qualified service person. More frequent cleaning may be required as necessary. It

is imperative the controls, burners and circulating air passageways of the

appliance be kept clean.

Children and adults should be alerted to the hazards of high surface temperatures

and should stay away to avoid burn or clothing ignition.

• Young children should be carefully supervised when they are in the area of the

appliance.

FOR YOUR SAFETY

• Installation and service must be performed by a qualified installer, service agency or gas

supplier.

• This installation must conform to local codes or, in the absence of local codes, with the

B149.1 Natural Gas and Propane Installation Code in Canada or the National Fuel Gas Code,

ANSI Z223.1 in the USA

• To prevent injury, do not allow anyone who is unfamiliar with this appliance to operate it.

• Always keep the area around these appliances clear of combustible material, gasoline and

other flammable liquids and vapours.

• Clothing or other flammable materials should not be hung from the appliance, or

placed near the appliance.

• Due to the paint curing on the campfire, a faint odour and slight smoking will likely be

noticed when the appliance is first used.

• Never use solid fuels such as wood, paper, cardboard, coal, or any flammable liquids, etc., in

this appliance.

• Do not use this heater if any part has been under water. Immediately call a qualified service

technician to inspect the heater and to replace any part of the control or gas control

systems that have been under water.

SPECIFICATIONS

Input: 48,500 BTU•h (4.12 KW•h)

Manifold Pressure: 11 inch W.C. (2.74 KPa)

Maximum Gas Supply Pressure: 13 inch W.C. (3.50 KPa)

LP Orifice Size: # 47. NG Orifice Size: # 35

Recommended LP-gas supply cylinder size: 20 lbs

Hours of operation using a 20 lb Cylinder of Propane: 8 to 10 hours

ASSEMBLY

1. Remove the lid by twisting the tee handle counter clockwise until the lid assembly is

released from the body.

2. Set aside the two bags of embers for the next step then remove and discard the packing

material.

3. Check that the hose and regulator assembly is securely fastened to the campfire body (for

use with Propane).

The LP-gas supply cylinder must be disconnected when this appliance is not in use.

CAUTION: The gas pressure regulator provided with this appliance must be used. This

regulator is set for an outlet pressure of 11 inch W.C. (2.74 kPa).

The LP-gas supply cylinder(s) to be used with this campfire must be arranged for vapor

withdrawal and must include a collar to protect the cylinder valve.

The LP-gas supply cylinder(s) must be constructed and marked in accordance with the

specifications for LP-gas cylinders Standards,

CAN/CSA B339, Cylinders, Spheres and Tubes for

Transportation of Dangerous Goods.

CAMPFIRE PLACEMENT

IMPORTANT: This appliance must only be used outdoors in a well-ventilated space and cannot

be used in a building, garage, or any other enclosed areas.

These minimum distances to combustibles must be maintained:

- 16” (406 mm) to all sides of fireplace.

- 84” (2134 mm) above the fireplace.

Position the gas hose out of pathways where people may trip over it or in areas where the

hose may be subject to accidental damage.

LIGHTING INSTRUCTIONS

1. Inspect the hose and burner for wear or damage. DO

NOT LIGHT THE FIRE PIT IF DAMAGE OR WEAR IS

FOUND.

2. Attach the regulator assembly to your propane cylinder.

MAKE SURE YOUR PROPANE CYLINDER VALVE IS

CLOSED

3. Attach the campfire regulator assembly to your propane

cylinder by threading the QCC fitting clockwise onto the

cylinder valve until hand tight snug (see Figure 1).

After the first time this is hooked up use a soap and water

solution to perform a leak test. NEVER USE AN OPEN

FLAME FOR A LEAK TEST.

a) Place the solution on the connections at either end of the hose and regulator assembly.

b) Open the LP cylinder valve, if bubbles start to form between the valve and the hose there

is a leak. Close the LP cylinder valve, unscrew the connection then re-attach. Re-open the

LP cylinder valve, if bubbles start to form between the valve and the hose there is still a

leak, see your dealer. If no bubbles are seen continue to c.

c) Open the gas line valve, if bubbles start to form

between the valve and the hose there is a leak. Close the

gas line valve, unscrew the connection then re-attach. Re-

open the gas line valve, if bubbles start to form between

the valve and the hose there is still a leak, see your dealer.

If no bubbles are seen continue lighting the campfire.

4. Check that the gas line valve is in the “OFF” position.

Open LP tank valve (see Figure 3).

5. Place a lit match or equivalent on the log set near a

burner port (see Figure 2).

6. STAND CLEAR AND SLOWLY OPEN THE GAS LINE

VALVE TO THE “ON” POSITION (Figure 3 is shown in the

“OFF” position). This campfire may light with a “WOOF’;

this is NORMAL and is not dangerous.

7. The flame intensity can be lowered by slowly closing the

gas line valve until the desired setting is reached.

Figure 1

Figure 2

Figure 3

TURNING OFF GAS TO

CAMPFIRE

Turn the gas line valve to the “OFF” position.

NOTE: This unit must be completely shut off for 5 minutes before restart is permitted.

LOG &EMBER PLACEMENT

CAUTION: The logs are fragile; handle with care.

Install the logs and embers by following the pictures in

this section, use care to align the logs onto the pins in

their existing holes.

Figure 4 shows the Jackson Grills Patio Fire burner

clean and empty. The burner ports and alignment pins

are highlighted for reference. When placing the logs

ensure that they do not cover any of the burner ports.

WARNING: Installing the logs and embers in

any arrangement other than shown here WILL

result in UNSAFE burn characteristics.

Figure 5: Place the first log gently over the center tube

and alignment pin. Burner ports outline the log.

Figure 6: The second log has two (2) alignment pins.

Figure 4

Figure 5

Figure 6

Figures 7 through 10: Place logs 3 to 6 using the images below.

Figure 9

Figure 10

Figure 7

Figure 8

Place the ember fibers over the burner making sure to cover all the

burner slots.

NATURAL GAS CONVERSION

Tools required to convert this unit from propane gas to natural gas:

# 2 Phillips screwdriver

8 and 18 mm wrenches

Adjustable wrench

The outdoor gas appliance and its individual shut off

valve must be disconnected from the gas supply

piping system during any pressure testing of that

system at test pressures in excess of ½ psi (3.5 kPa).

1. Remove the lid by twisting the tee handle counter

clockwise until the lid assembly is released from the

body.

2. Remove logs & embers from unit (if already installed).

3. Using a # 2 Philips screwdriver, remove 2 screws

holding the burner in place.

4. Slide back and lift burner out of the fire pit body (see

Figure 11).

5. Using the Philips screwdriver, loosen the screw on the

air shutter located on the burner, turn the shutter so

that it is completely closed. Re-tighten the screw.

Re-install burner in reverse order.

6. Using a 18 mm wrench, remove propane hose

assembly from fire pit body (see Figure 12).

7. Using a 8 mm wrench, remove the brass propane

orifice from the tip that was installed into the fire pit

body. Set it aside, and install the supplied natural gas

orifice. DO NOT OVER TIGHTEN.

8. Remove brass assembly with orifice from the propane

hose, and install into the open end of the rubber flex

hose on the natural gas hose assembly (see Figure

13).

9. Re-install natural gas hose assembly with new NG orifice

into the fire pit. Re-install logs & embers.

REMEMBER TO LEAK CHECK ALL FITTINGS AND ORIFICE AFTER ALL OF THE

CONVERSION IS COMPLETED, LEAK CHECK ALL FITTINGS AND TEST FIRE UNIT TO

ENSURE PROPER, SAFE OPERATION.

Figure 11

Figure 12

Figure 13

CARE &MAINTENANCE

- Should your campfire be left out in the rain, simply light it as usual and burn until the log

set and embers have dried out and begin to glow.

- Scratches and stains on the wind guard can be buffed out using a Scotch-Brite pad. Be sure

to buff “with the grain” to restore the stainless steel’s natural luster.

- The hose assembly must be checked every time the campfire is lit. If evidence is found of

excessive abrasion or wear, or if the hose is damaged the hose must be replaced prior to

lighting. Replace with part number TPR18HRA.

- The burner assembly must be checked every time the campfire is lit. If evidence is found of

damage the burner must be replaced prior to lighting. Replace with part number

TPR18LPB.

- The burner may be removed, for cleaning or maintenance by removing the two (2)

mounting screws and lifting the burner from the campfire body.

- To clean the burner wait until the campfire has completely cooled. Gently remove the log

set and embers. CAREFULLY LIFT each log STRAIGHT UP off of the center tube and

alignment pins starting from the top down (in the reverse order shown in Figures 5-10).

Pour off and SAVE THE EMBERS. The burner may then be removed. Use a soft brush

attachment on a vacuum to clean the whole unit. Re-install the burner and refer to the

section

Log & Ember Placement

to re-install the logs and embers.

- This campfire, hose, and regulator assembly must be disconnected from the gas supply

piping system during any pressure testing of the gas supply piping system at test pressures

in excess of 1⁄2 psi (3.5kPa).

This campfire must be isolated from the gas supply piping system by closing its individual

manual shutoff valve during any pressure testing of the gas supply piping system at test

pressures in equal to or less than 1⁄2 psi (3.5kPa).

- Should carbon deposits appear on the log set simply vacuum it off using the soft brush

attachment on your vacuum.

STORAGE

When the appliance is not in use the LP cylinder must be

disconnected. Store your campfire in a dry place. This

appliance may be stored indoors but the LP cylinder must be

stored outdoors in a well-ventilated area out of reach or

children.

If the Patio Fire is to be transported or stored, the hose and

regulator assembly must be wrapped around the center of

the base. Do not wrap so tight as to kink the hose at the

base connection end. Hook one end of the supplied bungee

cord onto the hand wheel of the regulator (see Figure 14)

making sure the end of the POL nipple points inward (for

protection). Stretch the other end of the bungee around to

where the hose attaches to the base and hook on as shown

in Figure 15.

Disconnected cylinders must have threaded valve plugs

tightly installed and must not be stored in a building, garage

or any other enclosed area.

Enclosures for LP-gas supply cylinders shall be ventilated by

openings at the level of the cylinder valve and at floor level.

The effectiveness of the opening(s) for the purposes of

ventilation shall be determined with the LP-gas supply

cylinder(s) in place. This shall be accomplished by one of the

following:

a) One side of the enclosure shall be completely open; or

b) For an enclosure having four (4) side, a top and a bottom:

1. At least two (2) ventilation openings at cylinder valve level shall be provided in the side

wall, equally sized, spaced at 180 degrees (3.14 rad), and unobstructed. Each opening

shall have a total free area of not less than 1⁄2 square inch per pound (3.2 sq. cm/kg)

of stored fuel capacity and not less than a total free area of 10 square inches (64.5 sq.

cm).

2. Ventilation opening(s) shall be provided at floor level and shall have a total free area of

not less than 1⁄2 square inch per pound (3.2 sq. cm/kg) of stored fuel capacity and not

less than a total free area of 10 square inches (64.5 sq. cm). If ventilation openings at

floor level are in a sidewall, there shall be at least two (2) openings. The bottom of the

openings shall be at floor level and the upper edge no more than 5 inches (127 mm)

above the floor. The openings shall be equally sized, spaced at 180 degrees (3.14 rad),

and unobstructed.

3. Every opening shall have minimum dimensions so as to permit the entrance or a 1⁄8

inch (3.2 mm) diameter rod.

The cylinder’s valve shall be readily accessible for hand operation. A door on the enclosure to gain

access to the cylinder valves is acceptable, provided it is non-locking and can be opened without

the use of tools.

There shall be a minimum clearance of 2 inches (50.8 mm) between the lower surface of the floor

of the LP-gas supply cylinder enclosure and the ground.

Figure 14

Figure 15

Inhaltsverzeichnis

Andere Jackson Grills Grill Handbücher

Jackson Grills

Jackson Grills LUX700 Bedienungsanleitung

Jackson Grills

Jackson Grills JENC-LP Bedienungsanleitung

Jackson Grills

Jackson Grills LUX550 Bedienungsanleitung

Jackson Grills

Jackson Grills JLS550BI-LP Bedienungsanleitung

Jackson Grills

Jackson Grills Classic PG-50403SRL Bedienungsanleitung

Jackson Grills

Jackson Grills PREMIER700-BI Bedienungsanleitung

Jackson Grills

Jackson Grills Keystone Series Bedienungsanleitung

Jackson Grills

Jackson Grills JLS400-LP Lux Bedienungsanleitung

Jackson Grills

Jackson Grills JLS700-LP Lux Bedienungsanleitung

Jackson Grills

Jackson Grills JGSBSEAR Bedienungsanleitung

Jackson Grills

Jackson Grills JSS550BI-LP Bedienungsanleitung

Jackson Grills

Jackson Grills Classic PG-50403SRL Leitfaden

Jackson Grills

Jackson Grills Premier 700 Bedienungsanleitung

Jackson Grills

Jackson Grills 700 Series Bedienungsanleitung

Jackson Grills

Jackson Grills Premier JPG700 series Bedienungsanleitung

Jackson Grills

Jackson Grills Keystone Black JKS400BLK-LP Bedienungsanleitung

Jackson Grills

Jackson Grills Premier JPG700 series Bedienungsanleitung

Jackson Grills

Jackson Grills Versa 100 JPG100-PKG1 Bedienungsanleitung

Jackson Grills

Jackson Grills 700 Series Bedienungsanleitung

Jackson Grills

Jackson Grills JLS700BI Bedienungsanleitung

Jackson Grills

Jackson Grills JLS400 Lux Bedienungsanleitung

Jackson Grills

Jackson Grills JG3 Bedienungsanleitung

Jackson Grills

Jackson Grills JLS700-LP Lux Bedienungsanleitung

Jackson Grills

Jackson Grills JPG75 Versa Bedienungsanleitung

Beliebte Grill Handbücher anderer Marken

Orbegozo

Orbegozo GR 2300 Bedienungsanleitung

bora

bora PT11 Bedienungsanleitung

Klarstein

Klarstein 10031664 Bedienungsanleitung

Garland

Garland MWE3W Bedienungsanleitung

Char-Broil

Char-Broil 463722714 Bedienungsanleitung

Nexgrill

Nexgrill 720-0830HK Bedienungsanleitung

Kenmore

Kenmore 415.16123800 Bedienungsanleitung

Camp Chef

Camp Chef PG24CLAU Bedienungsanleitung

Tucker Barbecues

Tucker Barbecues GTR Series Montageanleitung

Monogram

Monogram ZGG540NCP1SS Bedienungsanleitung

Equipex

Equipex Sodir Savoy Bedienungsanleitung

Gaggenau

Gaggenau VR 414 610 Bedienungsanleitung

Miele

Miele KM 408-1 Bedienungsanleitung

George Foreman

George Foreman GGR50B Bedienungsanleitung

AOG

AOG T series Bedienungsanleitung

Gorenje

Gorenje TG2000CB Bedienungsanleitung

Weber

Weber Genesis Silver-B Permamount NG 051701 Bedienungsanleitung

Glen

Glen SA 3037 Bedienungsanleitung