Kohler K-5664 Montageanleitung

Installation and Care Guide

Kitchen Sinks

Français, page “Français-1”

Español, página “Español-1”

K-5664, K-5826, K-6486, K-6488 K-6426

1217971-2-B

Tools and Materials

Important Information

CAUTION: Risk of personal injury. Cast iron sinks are

heavy. Get help when lifting or moving.

IMPORTANT! Refer to the ″Roughing-In and Preparation″section

for cabinet dimensional requirements.

IMPORTANT! The cabinet must be installed and secured, and must

be plumb and level.

IMPORTANT! Long screws may damage adjacent cabinets. Ensure

the screws are long enough to secure the support framing, but short

enough not to extend through the walls of adjacent cabinets.

Due to the nature of under-mount installations, Kohler Co.

recommends that under-mount sink installations be performed by

trained and experienced installers.

Use proper fasteners and techniques to ensure the frame will

support a minimum of 300 lbs (136 kg). Locate the fasteners for

easy access in the event the sink needs to be removed.

For K-5664 Only: This sink is intended for installation into a

standard 24″base cabinet.

For K-5826 Only: This sink is intended for installation into a

standard 33″base cabinet.

For K-6426 and K-6488: This sink is intended for installation into

a standard 36″base cabinet.

For K-6486 Only: This sink is intended for installation into a

standard 30″base cabinet.

Observe all local plumbing and building codes.

Painter's

Tape

Plus:

• Suitable support framing material

[1/2" (13 mm)] max thickness

• Screws

Silicone

Sealant

Construction

Adhesive

1217971-2-B 2 Kohler Co.

1. Roughing-In and Preparation

IMPORTANT! Before installing this sink, verify the opening height

(A) is less than the apron height, and the distance to the top of the

doors (B) is greater than the apron height.

NOTE: For cabinets with ﬂat fronts (no false drawer openings),

proceed to the ″Prepare the Cabinet - Flat Front″section.

Remove the false drawer front from your cabinet. Use care not to

damage the cabinet.

TIP: Apply painter’s tape to the cabinet to mark cuts and protect

cabinet surfaces when cutting.

Measure and mark 7/8” (22 mm) in from the outside edge of the

cabinet. Repeat for the other side.

Cut along each marked line until the cut extends slightly beyond

the top of the drawer opening/top rail of the cabinet.

Following the bottom edge of the rail, extend your cut until it

intersects with the previous cut. Repeat for the other side.

6-11/16"

(170 mm)

A = Top of Cabinet to Bottom of

Drawer Opening

B =

Drawer Opening

False Drawer Front

Apron

Top of Cabinet to Top of Doors

Rail

Center

Support

Rail 7/8" (22 mm)

Inside Wall

Cut Line

Kohler Co. 3 1217971-2-B

Roughing-In and Preparation (cont.)

If your cabinet has a center support, cut along the bottom of the

support, even with the drawer opening.

Remove and discard the rail.

1217971-2-B 4 Kohler Co.

2. Prepare the Cabinet - Flat Front

TIP: Apply painter’s tape to the cabinet to mark cuts and protect

the cabinet surfaces when cutting.

Position the template on the front of the cabinet ﬂush with the

top and centered left to right; secure with tape.

Trace the template and remove.

Cut the cabinet along the traced line.

Trace the template

onto the cabinet.

Cut along

the traced line.

Kohler Co. 5 1217971-2-B

3. Install the Support Framing

NOTICE: For proper countertop installation, the top of the sink

must not extend above the top of the cabinet.

Cut two lengths of support framing to extend horizontally along

the inside walls on each side of the cabinet.

Measure and mark the support mounting locations; ensure the

sink rim will sit at or slightly below the top of the cabinet.

Position and level the supports.

TIP: Use clamps to hold the supports in position.

Secure the supports with construction adhesive and screws (not

provided).

Optional Vertical Supports

Cut four lengths of support framing to extend from the bottom of

the horizontal supports to the ﬂoor of the cabinet.

Secure the vertical supports with construction adhesive and

screws (not provided).

5/8"

(16 mm)

Optional Vertical

Supports

1217971-2-B 6 Kohler Co.

4. Install the Sink

Lower the sink onto the supports; verify the sink is supported by

the frame.

Push the sink in to ensure the apron is ﬂush to the front of the

cabinet.

Verify the sink is level; make any adjustments and shim as

needed.

Kohler Co. 7 1217971-2-B

5. Install the Countertop

Apply a bead of silicone sealant around the side and back of the

sink.

Install the countertop.

Apply a thin bead of silicone sealant where the sink meets the

countertop and cabinet.

Immediately wipe away any excess sealant.

6. Complete the Installation

Install the faucet and the strainers, according to the installation

instructions.

Connect the trap to the strainers.

Care and Cleaning

For best results, keep the following in mind when caring for your

KOHLER product:

1217971-2-B 8 Kohler Co.

Care and Cleaning (cont.)

•Always test your cleaning solution on an inconspicuous area

before applying to the entire surface.

•Wipe surfaces clean and rinse completely with water immediately

after applying cleaner. Rinse and dry any overspray that lands on

nearby surfaces.

•Do not allow cleaners to soak on surfaces.

•Use a soft, dampened sponge or cloth. Never use an abrasive

material such as a brush or scouring pad to clean surfaces.

•Be careful not to leave staining materials in contact with the

surface for extended periods of time.

•The ideal cleaning technique is to rinse thoroughly and blot dry

any water from the surface after each use.

For detailed cleaning information and products to consider, visit

www.kohler.com/clean. To order Care & Cleaning information, call

1-800-456-4537.

Warranty

KOHLER

Enameled Cast Iron Kitchen Sink Lifetime Limited

Warranty

Kohler Co. warrants the enameled cast iron component of kitchen,

entertainment, or utility sinks manufactured after April 29, 2008, to be

free of defects in material and workmanship during normal residential

use for as long as the original consumer purchaser owns his or her

home. Kohler Co. further warrants that the enameled cast iron

component of the product will not chip, crack or burn for as long as

the original consumer purchaser owns his or her home. Gloss

reduction, scratching, staining and alkaline etching of the ﬁnish over

time due to use, cleaning practices or water or atmospheric conditions,

are not manufacturing defects but are indicative of normal wear and

tear. This warranty applies only to KOHLER Cast Iron kitchen,

entertainment and utility sinks installed in the United States of

America, Canada or Mexico (″North America″).

If a defect is found in normal residential use, Kohler Co. will, at its

election, replace the defective cast iron component, or make other

appropriate adjustment. Damage caused by misuse or abuse is not

covered by this warranty. Improper care and cleaning will void the

warranty. Proof of purchase (original sales receipt) must be provided to

Kohler Co. with all warranty claims. Kohler Co. is not responsible for

removal, installation, labor charges, or other incidental or consequential

Kohler Co. 9 1217971-2-B

Warranty (cont.)

costs. In no event shall the liability of Kohler Co. exceed the purchase

price of the kitchen, entertainment or utility sink.

If the cast iron kitchen, entertainment or utility sink is used

commercially or is installed outside of North America, Kohler Co.

warrants that for one (1) year from the date the product is installed the

cast iron product will be free from defects in material and

workmanship, and will not chip, crack or burn. All other terms of this

warranty apply except for duration. All other components other than

the enameled cast iron component carry Kohler Co.’s one-year limited

warranty unless otherwise speciﬁed.

If you believe that you have a warranty claim, contact your Dealer,

Plumbing Contractor, Home Center or E-tailer, or by writing Kohler

Co., Attn.: Customer Care Center, 444 Highland Drive, Kohler, WI

53044, USA. Please be sure to provide all pertinent information

regarding your claim, including a complete description of the problem,

the product, model number, color, ﬁnish, and the date the product was

purchased and from whom the product was purchased. Also include

your original invoice. For other information, or to obtain the name and

address of the service and repair facility nearest you, call

1-800-4KOHLER (1-800-456-4537) from within the USA and Canada,

and 001-877-680-1310 from within Mexico or visit www.kohler.com

within the USA, www.ca.kohler.com from within Canada, or

www.mx.kohler.com in Mexico.

KOHLER CO. AND/OR SELLER ARE PROVIDING THIS

WARRANTY IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED

OR IMPLIED, INCLUDING BUT NOT LIMITED TO THE IMPLIED

WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A

PARTICULAR PURPOSE. KOHLER CO. AND/OR SELLER

DISCLAIMS ANY LIABILITY FOR SPECIAL, INCIDENTAL OR

CONSEQUENTIAL DAMAGES. Some states/provinces do not allow

limitations on the duration of an implied warranty or the exclusion

or limitation of such damages, so these limitations and exclusions

may not apply to you. This warranty gives the consumer speciﬁc

legal rights. You may also have other rights that vary from

state/province to state/province. This warranty is extended to the

original consumer purchaser only, and excludes product damage due

to installation error, or product abuse or product misuse, whether

attributable to the consumer, a contractor, service company or other

third party.

This is Kohler Co.’s exclusive written warranty.

1217971-2-B 10 Kohler Co.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Sprachen:

Andere Kohler Sanitärprodukte Handbücher

Kohler

Kohler STRAYT 45370M Bedienungsanleitung

Kohler

Kohler STILLNESS Bedienungsanleitung

Kohler

Kohler 1114111 Bedienungsanleitung

Kohler

Kohler K-2282 Bedienungsanleitung

Kohler

Kohler K-13925 Bedienungsanleitung

Kohler

Kohler CUFF 45532M Bedienungsanleitung

Kohler

Kohler K-3099 Montageanleitung

Kohler

Kohler ENGLEFIELD CORNER CONTOUR PLUS Bedienungsanleitung

Kohler

Kohler Rada T4 Series Bedienungsanleitung

Kohler

Kohler Mira Moto Bedienungsanleitung

Kohler

Kohler 23776T-7 Bedienungsanleitung

Kohler

Kohler Avid T97367-4-BN Bedienungsanleitung

Kohler

Kohler WaterTile K-8030 Bedienungsanleitung

Kohler

Kohler K-7213 Montageanleitung

Kohler

Kohler K-7465 Montageanleitung

Kohler

Kohler Karbon K-6227A Bedienungsanleitung

Kohler

Kohler K-10280 Bedienungsanleitung

Kohler

Kohler Elate 13963X-4 Bedienungsanleitung

Kohler

Kohler K-6227 Montageanleitung

Kohler

Kohler K-7166-AF Montageanleitung

Kohler

Kohler K-2972 Montageanleitung

Kohler

Kohler K-352 Montageanleitung

Kohler

Kohler k-2815 Bedienungsanleitung

Kohler

Kohler BEAM K-30939T Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema

Crosswater

Crosswater Heir 18-31 Bedienungsanleitung

Sanela

Sanela SLVN 07 Bedienungsanleitung

Glacier bay

Glacier bay DORIND HD67478W-6001 Montageanleitung

Sterling Plumbing

Sterling Plumbing C741 Bedienungsanleitung