MasterChef 085-3133-4 Bedienungsanleitung
Tools required:
Star-head Screwdriver
OWNER’S MANUAL
Kamado Charcoal Grill
Model No. 085-3133-4
FOR CUSTOMER SERVICE:
Call toll-free helpline: 1-855-803-9313
Made from 75% Bagasse
(environmentally-friendly sugar
cane pulp by-product)
IMPORTANT HEALTH & SAFETY INFORMATION
1. WARNING
FOR OUTDOOR USE ONLY! DO NOT USE INDOORS
• Please read these instructions carefully prior to assembly and use.
•
property.
• Do not use the barbeque if there is any doubt over the correct assembly or lighting procedure.
• These instructions should be retained for future reference.
• The barbeque must have a minimum side, back and front clearance from any combustible
material of at least 3’ 3”(1 m). Additionally there must be a clearance of at least 6’ 6”(2 m) clear
above the cooking surface of the barbeque.
• Flammable materials and liquids must be stored well away from the barbeque.
• Aerosols must not be used near the barbeque.
• The barbeque should not be moved when lit or hot.
• A lit barbeque should be attended at all times.
• Avoid dousing the barbeque with water.
• Ensure the barbeque charcoal is completely extinguished when the barbeque is not in use.
• Always allow the barbeque to completely cool down before covering.
•
•
• Please dispose of all packing materials and carefully and keep plastic bags out of the reach of
children.
SETTING UP THE BARBEQUE
THIS APPLIANCE SHALL ONLY BE USED IN AN ABOVE GROUND OPEN AIR SITUATION WITH
NATURAL VENTILATION, WITHOUT STAGNANT AREAS, WHERE PRODUCTS OF COMBUSTION ARE
RAPIDLY DISPERSED BY WIND AND NATURAL CONVECTION
FOR OUTDOOR USE ONLY
1. POSITIONING
• Please make sure that the barbeque is NOT positioned underneath any combustible material or
surface.
• There MUST be a clearance of at least 3’ 3”(1 m) from the sides, back and front of the barbeque to
any combustible materials or surfaces. There must also be a clearance of at least 6’ 6”(2 m) above
the cooking surfaces to any combustible surface.
• Flammable materials of any description MUST be kept well away from the barbeque.
• The barbeque must be positioned to avoid walkways, gangways and general pedestrian access.
• The nature of a barbeque is such that many of the surfaces are hot to touch, the positioning of the
barbeque should take into consideration the possibility of accidental hand or body contact.
Any enclosure in which the appliance is used shall comply with one of the following:
•An enclosure with walls on all sides, but at least one permanent opening at ground level and no
overhead cover.
SEE EXAMPLE 1
• Within a partial enclosure that includes an overhead cover and no more than two walls.
SEE EXAMPLE 2 & 3
• Within a partial enclosure that includes an overhead cover and more than two walls, the
following shall apply-
• at least 25% of the total wall area is completely open; and
• at least 30% of the remaining wall area is open and unrestricted
SEE EXAMPLE 4 & 5
• In the case of balconies, at least 20% of the total of the side, back and front wall areas shall be and
remain open and unrestricted
BURNING CHARCOAL INSIDE CAN KILL. IT GIVES OFF CARBON MONOXIDE WHICH HAS NO ODOUR.
EXAMPLE 1
EXAMPLE 4
30% or more in total
of the remaining wall
area in open is unrestricted
Open side at least 25% of
total wall area
EXAMPLE 5
Open side at least 25% of
total wall area
30% or more in total
of the remaining wall
area in open is unrestricted
EXAMPLE 3
EXAMPLE 2
Both ends open
ASSEMBLY INSTRUCTIONS
PARTS LIST
Part QTY Part QTY Part QTY
ABody Assembly 1 pc K Damper 1 pc U 1 pc
B Warming Rack 1 pc L Damper O-ring Seal 1 pc V Right Leg - FRON 1 pc
C Cooking Grill outer 1 pc M 1 pc W Right Leg - BAC 1 pc
D Cooking Grill inner 1 pc N 1 pc X Wheel 2 pcs
E Charcoal Grate 1 pc O 1 pc Y Axle 1 pc
F Trivet 1 pc P 1 pc Z Ashpan Suppor
G1 pc Q 1 pc AB
H Handle Bracket - LEFT 1 pc R 2 pcs
Ash Pan Handle 2 pcs
IHood Handle 1 pc S 2 pcs
J Handle Bracket-RIGHT 1 pc T 2 pcs
R
1 pc
Fire Bowl
Ashpan
Table - LEFT
Table - RIGHT
Table Handle
Space
Foot
ASSEMBLY INSTRUCTIONS
HARDWARE LIST
AA: 28 PCS BB: 4 PCS CC: 3 PCS
KK: 4 PCS EE: 26 PCS FF: 26 PCS
GG: 2 PCS HH: 6 PCS II: 1 PC
Fibre Washer Tool Hook Screw (M6) Split Pin
Spring Washer(Φ 6.2)
Flat Washer
(Φ 16 x Φ 6.2 x 1.0)
Bolt (M5 x 16)
Bolt (M6 x 16) Bolt (M6 x 12) Bolt (M4 x 12)
ASSEMBLY INSTRUCTIONS
Step 1
a) Fit Foot (T) to both of the Left Legs (S) as shown in the diagram.
Step 2
a) Attach three Tool Hook Screws (HH) onto the Table - LEFT (O) and Table - RIGHT ( P) as shown.
P
x 6
HH
ASSEMBLY INSTRUCTIONS
Step 3
Step 4
a) Take the pre-assembled Table Handle (Q) and attach it onto Table - LEFT (O). Secure it with two
bolts (BB) as shown below.
O
Q
a) Install one Ash Pan Handle (AB) onto each side of the previously prepared Ashpan Assembly (N).
b) Secure each Ash Pan Handle (AB
AB
) with two bolts (KK).
x 2
x 4
ASSEMBLY INSTRUCTIONS
Step 5
a) Attach the Ashpan Support (Z) onto the Ashpan Assembly (N) and secure it with three bolts (CC).
Step 6
a) Start from the left side of the Body Assembly (A), attach two prepared Left Legs (S) from step 1 onto the left
of the Body Assembly (A) each with two Flat Washers (FF), two Spring Washers (EE) and two bolts (AA).
b) Repeat the same procedure on the right side of the Body Assembly (A) with Right Leg - FRONT (V) and Right
Leg - BACK (W).
c) Ensure all bolts are properly tightened.
S
SV
W
FF
EE
AA
A
x 12
x 12
x 12
x 3
ASSEMBLY INSTRUCTIONS
Step 7
a) Stand the assembly upright as shown and attach the Bottom Shelf (U) onto the BBQ legs.
b)
(AA).
Step 8
R
II
X
Y
Spacer (R), then through the BBQ legs as shown in the digram below.
b) After attaching both wheels and the axle to the BBQ legs, secure it with the Split Pin (II) on the end of the
axle as shown below.
x 8
x 8
x 8
x 1
(U)
ASSEMBLY INSTRUCTIONS
Step 9
a) Align the Hood Handle (I) with Handle Bracket - LEFT (H) and Handle Bracket - RIGHT (J) as shown.
b)
(EE) and two Bolts (AA) on each handle bracket.
c) Ensure all screws are properly tightened.
Step 10
a) Open the BBQ and attach the Damper (K) and Damper O-Ring Seal (L) onto the hood.
b) Secure from inside with two Fibre Washers (GG), two Flat Washers (FF), two Spring Washers (EE) and two
Bolts (BB).
x 4
x 4
x 4
x 2
x 2
x 2
x 2
Secure it to the four pre-drilled holes on the BBQ hood front with two Flat Washers (FF), two Spring Washers
Inhaltsverzeichnis
Andere MasterChef Grill Handbücher
MasterChef
MasterChef GRILL TURISMO P40101 Bedienungsanleitung
MasterChef
MasterChef T480 Bedienungsanleitung
MasterChef
MasterChef T360 Kurzanleitung
MasterChef
MasterChef S380 Bedienungsanleitung
MasterChef
MasterChef 280 Bedienungsanleitung
MasterChef
MasterChef S482 Bedienungsanleitung
MasterChef
MasterChef T405 Kurzanleitung
MasterChef
MasterChef G36402 Bedienungsanleitung
MasterChef
MasterChef 085-3175 Bedienungsanleitung
MasterChef
MasterChef G32012 Bedienungsanleitung
MasterChef
MasterChef Grill Turismo G75001 Bedienungsanleitung
MasterChef
MasterChef G49201 Bedienungsanleitung
MasterChef
MasterChef RSH015050 Bedienungsanleitung
MasterChef
MasterChef 85-1208-0 Kurzanleitung
MasterChef
MasterChef RSH-014257 Bedienungsanleitung
MasterChef
MasterChef 85-3138-4 / G45329 Bedienungsanleitung
MasterChef
MasterChef 85-1027-0 Kurzanleitung
MasterChef
MasterChef E500 Bedienungsanleitung
MasterChef
MasterChef 085-4090-8 Bedienungsanleitung
MasterChef
MasterChef S405 Bedienungsanleitung
