Mercia Garden Products 03BRN0705-V4 Gebrauchsanweisung

P 1

03BRN0705-V4

7X5 BOURNEMOUTH SUMMERHOUSE

2mm Drill bit

x2 Winter = High Moisture = Expansion

Summer = Low Moisture = Contraction

All building’s should be

erected by two adults

For ease of assembly, you

MUST pilot drill all screw

holes and ensure all screw

heads are countersunk.

For assistance please contact customer care on: 01636 880514

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

CAUTION

Every eort has been made during the

manufacturing process to eliminate the

prospect of splinters on rough surfaces of the

timber. You are strongly advised to wear gloves

when working with or handling rough sawn

timber.

**Protim Aquatan T5 (621)**

Your building has been treated with Aquatan.

Aquatan is a water-based concentrate which is diluted with water, the building as been treated by the correct

application of Aquatan solution and then allowed to dry.

Aquatan is a decorative nish to colour the wood, which is applied industrially to timber fence panels and

garden buildings.

Aquatan undiluted contains: boric acid, sodium hydroxide 32% solution, aqueos mixture of sodium dioctyl

sulphosuccinat and alcohols: 2, 4, 6-trichlorophenol.

Please retain product label and instructions for future reference

General Instructions

BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY

- Check the pack and make sure you have all the parts listed.

- When you are ready to start, make sure you have the right tools at hand (not supplied)

including a Phillips screwdriver, Stanley knife, wood saw, step ladder and drill with 2mm

bit.

- Ensure there is plenty of space and a clean dry area for assembly.

TIMBER

As with all natural materials, timber can be aected during various weather conditions.

For the duration of heavy or extended periods of rain, swelling of the wood panels may

occur. Warping of the wood may also occur during excessive dry spells due to an interior

moisture loss. Unfortunately, these processes cannot be avoided but can be helped. It is

suggested that the outdoor building is sprayed with water during extended periods of

warm sunshine and sheltered as much as possible during rain or snow.

Our buildings are pre treated with a water based treatment**; this only helps to protect

the product during transit and for upto 3 months against mould. To validate your

guarantee and ensure longevity of the product, it is ESSENTIAL the building is treated

with a wood preserver within the rst three months of assembly and thereafter in

accordance with the manufactures recommendations. Care must be taken to ensure

the product is placed on a suitable base.

BUILDING A BASE

When thinking about where the building and base is going to be constructed:

Ensure that there will be access to all sides for maintenance work and annual

treatment.

Ensure the base is level and is built on rm ground, to prevent distortion. Refer to

diagrams for the base dimensions, The base should be slightly smaller than the external

measurement of the building, i.e. The cladding should overlap the base, creating a run

o for water. It is also recommended that the oor be at least 25mm above the

surrounding ground level to avoid ooding.

TYPES OF BASE

- Concrete 75mm laid on top of 75mm hard-core.

- Slabs laid on 50mm of sharp sand.

Whilst all products manufactured are made to the highest standards of Safety and in

the case of childrens products independently tested to EN71 level, we cannot accept

responsibility for your safety whilst erecting or using this product.

Refer to the instructions pages for you specic product code

1 2 3 4 5

Pre Assembly

Remove the transportation blocks

from the bottom of each panel

before beginning the assembly.

5 6 7

Pre drill

hole

25mm

screw

50mm Screw x32

40mm Screw x22

Felt Tacks x78

25mm Screw x38

30mm Screw x56

35mm Bolt x4

10mm Screw x10

Nail Bag

16mm Black Screw x2

16mm Screw x4

P 2

03BRN0705-V4

Overall Dimensions:

Length = 1768mm

Width = 2291mm

Height = 2168mm

Base Dimensions:

Length = 1448mm

Width = 2082mm

Please retain product label and instructions for future reference

Before assembly

please make sure you have a

suitable base ready to erect your

building

MADE IN GREAT BRITAIN

Door Gable Plain Side

QTY 2

Plain Gable Floor Roof

Sheet QTY 2

Ridge Bar - 1457mm

Eaves Frame - 1720mm QTY 2

Cover Trim - 1682mm QTY 4

Fascia - 1227mm QTY 4

Angled Fascia Block - 340mm

Fascia Block - 140mm

Finial QTY 2

“L” Bracket QTY 2

Butt Hinge QTY 6

Turn Button QTY 2

Barrel Bolt QTY 2

Presslock

Door Handle QTY 2

Step 1

Place the oor onto a rm and

level base. Ensure the base has

suitable drainage & is free from

areas where standing water can

collect.

Master

Door

Slave

Door

Step 2

Attach the doors to the door

gable with 3x butt hinges

per door using 36x25mm

screws.

Ensure to screw the hinges

into the framing.

36x25mm Screws

Pre drill

hole

50mm

screw

P 3

Please retain product label and instructions for future reference

Step 3

Place the plain gable and the rst plain

side onto the oor.

Fix the corners with 50mm screws

as shown in the illustration,

making sure the gable sits inside

the panel.

Do not secure the building to the

oor until the roof is tted.

3x50mm Screws

Pre drill

hole

50mm

screw

Step 4

Place the door gable and the second plain

side onto the oor.

Fix the corners with 50mm screws

as shown in the illustration,

making sure the gable sits inside

the panel.

Do not secure the building to the

oor until the roof is tted.

9x50mm Screws

Step 5

Attach the “L”brackets centrally

to the ridge bar using 2x30mm

screws per bracket.

*Measure 67mm from each side

of the ridge bar and mark with

a pencil. Align the front edge of

the bracket with the pencil mark

as shown in the illustration.

4x30mm Screws

Pre drill

hole

30mm

screw

Step 6

Place the assembled ridge bar inbetween

the gables, resting on top of the blocks.

Secure to the gables using 2x30mm

screws per side.

*Adjust the “L” brackets if needed.

4x30mm Screws

Pre drill

hole

30mm

screw

P 4

Please retain product label and instructions for future reference

Step 7

Fix an eaves frame to the

edge of each roof sheet

with 4x30mm screws per

frame.

8x30mm Screws

Pre drill

hole

30mm

screw 9

Step 8

Place the assembled roof panels

onto the building as shown in

the illustration.

Fix into place using 8x30mm

screws per side, ensuring the

roofs are ush with the top of

the gables.

*The roof panels should be level

with the back of the building

leaving an overhang over the

front.

16x30mm Screws

Pre drill

hole

30mm

screw

Step 9

Once the roof is xed in place,

secure the building to the oor

using 18x50mm screws.

*Ensure to screw through the

framing into the oor bearers.

18x50mm Screws

Pre drill

hole

50mm

screw

For assistance please contact customer care on: 01636 880514

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

Felt

tacks

HANDLE

WITH CARE

Step 10

Attach the cover trims to

each corner of the building

using 3x30mm screws per

cover trim.

12x30mm Screws.

P 5

Please retain product label and instructions for future reference

12 13

Step 11

Fit the angled fascia block to

the apex of the roofs, making

sure it is ush with the roof

sheet, securing in place with

4x40mm screws.

Attach the rectangular blocks

approximately half way along

each roof sheet, xing into

place with 2x40mm screws

per block.

8x40mm Screws

Pre drill

hole

40mm

screw

Step 12

Cut the felt into 3 sheets and lay onto

the roof as shown in the illustration

ensuring there is approximately 50mm

of overhang around the building.

Fix onto the building using 75x felt tacks

at 100mm intervals.

75x Felt Tacks

*Felt size: 1870mm

Pre drill

hole

30mm

screw

P 6

Please retain product label and instructions for future reference

11 11

Step 13

Fix the fascias and nials to the

building using 6x40mm screws

per side, ensuring to screw

through the boards into the

fascia blocks.

12x40mm Screws

Pre drill

hole

40mm

screw

Step 14

Attach the door handles to

the doors using the 35mm

bolts included with the

door handle.

Pre drill a hole approximately

3mm and x the handle from

the inside with the provided

bolts

4x35mm Bolt

Pre drill

hole

35mm

bolt 19

Step 15

Fix the presslock to the inside of the

master door, making sure to align the

barrel and the key hole.

Secure to the master door with

4x16mm screws.

*Ensure the key turns fully without

any restrictions.

4x16mm Screws

Pre drill

hole

16mm

screw

Step 16

Attach to the barrel bolts to

the top and bottom of the

slave door using 4x10mm

screws per bolt.

*Mark the position of the bolt

with a pencil on the framing

and drill a hole to site the

bolts.

8x10mm Screws

Pre drill

hole

10mm

screw

Slave Door

Locking Door

Step 17

Fix the turn buttons into

place at the top and

bottom of door as shown in

the diagram.

The turn buttons help to

keep the doors alligned

during high and low levels

of moisture.

2x16mm Black Screws

Pre drill

hole

16mm

screw

It is ESSENTIAL that you apply wood

treatment immediately after the building

has been assembled.

AFTER TREATMENT:

score around protective

cover on glazing and

carefuly peel

covering back

Please retain product label and instructions for future reference

Inhaltsverzeichnis

Andere Mercia Garden Products Gartenhaus Handbücher

Mercia Garden Products

Mercia Garden Products 03DTSHHP1206HGD4MW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01GRO1008DD-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products BOURNEMOUTH 03BRN0807-V4 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 03DTSHCR0808FGD2TW-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 10DTBARK0804-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products OSB APEX Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03DTSHAX0608FGD4MW-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 0644LOG133-V4 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01OVLPA0806SDFW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03DTSHCR0707FGD2TW-V2 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01OVLPP0705SDFW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 02DTTWR0605-V1-PEFC Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 06LOG015-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0644CSNE0303HGDD2SW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products Groundsman Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTOVAX0705SDFW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products Groundsman Dutch Barn 8x8 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products CARLTON ARBOUR ESDXL21PT050 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 03TGCOR0808-V3 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 03OVLPBRN0705-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 02PLAY511511-V2-PEFC Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03DTSHPN0806PA-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0644RANE4535FGDD2TW1SW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01GRO0705-V2 Gebrauchsanweisung

Beliebte Gartenhaus Handbücher anderer Marken

Lemeks

Lemeks Palmako PA120-5930-6 Installationshandbuch

Rion

Rion Hobby Gardener Bedienungsanleitung

Gartenhaus-King

Gartenhaus-King Valery Bedienungsanleitung

Select

Select ISAAC E9682 Bedienungsanleitung

Palmako

Palmako Saale Bedienungsanleitung

Lemeks

Lemeks Palmako Kira EL16-3623 Installationshandbuch

Palmako

Palmako Roger FR44-5953-2 Bedienungsanleitung

Pergola kits USA

Pergola kits USA PREMIUM VINYL PAVILION Bedienungsanleitung

G21

G21 Boston 882 Bedienungsanleitung

Lemeks

Lemeks Palmako Grace PM56-4529 Installationshandbuch

Shire

Shire Salcey Bedienungsanleitung

Rutland County

Rutland County Burley 6ft Bedienungsanleitung

Palmako

Palmako Roger 27,7 Bedienungsanleitung

Lemeks

Lemeks Palmako PA120-5930-9 Installationshandbuch

Lemeks

Lemeks Palmako PM70-6436 Installationshandbuch

Lemeks

Lemeks Palmako PM56-4435 Installationshandbuch

Lemeks

Lemeks 106214 Installationshandbuch

POD

POD Camping 480 Bedienungsanleitung