Nokia RM-11 Series Montageanleitung

CC Technical Documentation

RM-11 Series Transceivers

Issue 2 09/2005 Confidential ©2005 Nokia Corporation

Disassembly

RM-11

Disassembly CC Technical Documentation

Page 2 ©2005 Nokia Corporation Confidential Issue 2 09/2005

Step-by-Step Disassembly Instructions

Always use ESD protection when assembling or dissasembling a phone.

Figure 1: ESD protection equipment

Disassembly Instructions

Step-by-Step Disassembly Instructions (Model 3205)

1. Hold the phone with the top down, facing you.

Press the Release Key and push the battery cover

out from the phone in the direction indicated (see

arrows in the above photo).

2. Remove the A-Cover by gently pulling from the top

end in the direction indicated by the above arrow.

3. Remove the Keymat. 4. Use SRT-10 camera removal tool to remove the

Antenna.

Note: Be careful not to damage mechanical parts. Do

not touch the antenna plate inside unless you are wear-

ing proper ESD gloves.

CC Technical Documentation Disassembly

RM-11

Issue 2 09/2005 ©2005 Nokia Corporation Confidential Page 3

5. Remove the six screws that hold the C-Cover in

place (torque 21Ncm and speed 480rpm).

6. Remove the PWB/UI module from the C-Cover.

7. Remove the UI module from the engine module.

Note: The UI module and the engine board are linked

together by two board-to-board connectors. Be careful

not to touch them.

UI module and engine module after separation.

8. Remove the microphone by gently pressing on its

edge or by placing tweezers between the frame and

the microphone and lifting it out of the frame.

9. Remove the speaker by lifting it from the guiding

pin.

Note: The speaker is attached into the frame with adhe-

sive tape. Therefore, it may not loosen easily.

Step-by-Step Disassembly Instructions (Model 3205)

RM-11

Disassembly CC Technical Documentation

Page 4 ©2005 Nokia Corporation Confidential Issue 2 09/2005

10. Open the snaps on both sides of the Display shield

and remove the shield.

Note: Be careful not to damage the shield.

11. Remove the LCD Module by holding the UI module

in one hand while loosening the LCD frame a little at

the same time at one side. Press the LCD module gently

from the same side you are loosening until the LCD

Module detaches.

Note: Be careful not to damage the sensitive parts. Do

not press the LCD Module too hard.

12. Remove the UI board from the LCD frame.

Note: Be careful not to damage the LCD frame.

13. Remove the Power Key.

Power Key removal. 14. Lift the Vibra to remove it.

Step-by-Step Disassembly Instructions (Model 3205)

CC Technical Documentation Disassembly

RM-11

Issue 2 09/2005 ©2005 Nokia Corporation Confidential Page 5

15. Lift the DC Jack out of its place.

Note: Be careful not to damage the C-Cover when

removing the DC Jack.

16. Use tweezers to lift the Release Spring.

17. Remove the Release Key. 18. Remove the A-cut cover from the A-Cover.

19. Remove the B-cut cover from the B-Cover. 20. Pry the battery out of the phone as indicated.

Step-by-Step Disassembly Instructions (Model 3205)

RM-11

Disassembly CC Technical Documentation

Page 6 ©2005 Nokia Corporation Confidential Issue 2 09/2005

Andere Handbücher für RM-11 Series

5

Andere Nokia Transceiver Handbücher

Nokia

Nokia NSB-1 Series Bedienungsanleitung

Nokia

Nokia NPM-10 Series Leitfaden

Nokia

Nokia N92 RM-100 Bedienungsanleitung

Nokia

Nokia NME-2A Series Bedienungsanleitung

Nokia

Nokia NSB-9 Leitfaden

Nokia

Nokia NHM-2nx Series Betriebsanleitung

Nokia

Nokia NSE-5 Series Montageanleitung

Nokia

Nokia NHM-1 Series Leitfaden

Nokia

Nokia RH-21 Series Bedienungsanleitung

Nokia

Nokia NME-3 Series Bedienungsanleitung

Nokia

Nokia RH-41 Series Leitfaden

Nokia

Nokia NSM-1 Series Leitfaden

Nokia

Nokia RH-21 Series Kurzanleitung

Nokia

Nokia RH-27 Series Leitfaden

Nokia

Nokia NPD-4 Series Bedienungsanleitung

Nokia

Nokia NPM–9 Series Montageanleitung

Nokia

Nokia RH-30 Series Leitfaden

Nokia

Nokia RM-11 Series Betriebsanleitung

Nokia

Nokia RH-41 Series Montageanleitung

Nokia

Nokia RH-34 Series Kurzanleitung

Nokia

Nokia RH-57 Series Betriebsanleitung

Nokia

Nokia NME-2A Series Bedienungsanleitung

Nokia

Nokia NSW-6 Series Montageanleitung

Nokia

Nokia NKC-1X Series Leitfaden

Beliebte Transceiver Handbücher anderer Marken

Yaesu

Yaesu FT-7B Bedienungsanleitung

Kenwood

Kenwood ProTalk TK-3201 Bedienungsanleitung

Texas Instruments

Texas Instruments TLK10232 Bedienungsanleitung

Mizuho

Mizuho MX-2 Produkthandbuch

Kenwood

Kenwood TK-3180 Bedienungs- und Wartungshandbuch

Blitz

Blitz MJ-398U Bedienungsanleitung

Utilicom

Utilicom LongRanger 2050 Bedienungsanleitung

Standart

Standart HX290UKA Bedienungsanleitung

Altronix

Altronix Pace1PTM Bedienungsanleitung

Kirisun

Kirisun PT2208 Bedienungsanleitung

ELECRAFT

ELECRAFT KX2 Bedienungsanleitung

Zodiac

Zodiac K3 Bedienungsanleitung

Assa Abloy

Assa Abloy SecureComm HKC GSM-WIFI U Bedienungsanleitung

Kenwood

Kenwood TK-2217 Bedienungsanleitung

Siemens

Siemens PSO 4000 Bedienungsanleitung

Kenwood

Kenwood TS-590SG Bedienungsanleitung

Midland

Midland G8E-BT Handbuch

ComNav

ComNav Mariner X2 Bedienungsanleitung