Oase Biotec 30 Handbuch

Biotec 30Biotec 30

Biotec 30

Gebrauchsanweisung

Directions for use

Mode d’emploi

Gebruiksaanwijzing

29739-06C

Product description

Biotec 30 is a multi-zone filter for large ponds up to 130 m³, or up

to 65 m³ for fish ponds. The arrangement of brushes, mats and

sponges in this filter accelerates the filtration of larger dirt parti-

cles. This allows the microorganisms to break down harmful nu-

trients more effectively.

Assembly

In order to use the Biotec filter, it is necessary to fit the connect-

ing parts and washers. See Illustrations 1-4 at the end.

1. Inlet (Illustration 1):

Attach matching gasket (2) to the stepped hose adapter 1½"

(1) then screw together with inlet nozzle (3) from the inside.

Attach air hose (4). Fit matching gasket 2"(6) and reducer (7)

to the 2” stepped hose adapter 2" (5) and fit in the same way

as the 1½” stepped hose adapter. Caution: Slit opening of

inlet nozzle must point downwards!

2. Dirt outlet (Illustration 1):

Attach matching gasket (9) to outlet (8) and push into hole at

bottom of container. Screw tightly into place from the inside

using enclosed screws (10).

3. Clear water outlet (Illustration 2):

Push thread nipple (11) with washer (12) and matching gasket

1" (13) through the hole of the container from the inside. Fit a

gasket from the outside, too, and screw on ball cock (14).

4. Outlet (Illustration 2):

Insert seal ring (15) into borehole and push in outlet pipe DN

100 x 150 (16).The sealing lip must point to the inside. The

outlet pipe DN 100 x1 50 can be extended with 2 enclosed

pipes DN 100 x 500 (37).

5. Bitron 15/12 (Illustration 3):

In order to connect the Bitron 15/25, another 2 gaskets per

Bitron outlet have to be fitted (included in Biotec 30 inlet set) in

addition to the extension components included with the Bitron

15/25. Put the gasket 1½" (2) on the Bitron outlet and then fit

the spacer ring (17) and O-ring 48 x 4mm (18). Attach Bitron

15/25 at the boreholes in the container and press the O-Ring

48 x 4 (18) against the container wall from the inside. Screw

on inlet nozzle (3).

Direction for use

Directions for use

Start-up

1. Connect pump in pond via a hose to the adapter on the filter.

•Cut adapter to right size to fit hose

•If necessary, briefly dip ends of hose in boiling water

before attaching

•Lay hose without twists and so that it cannot be stepped on

•Affix hose clips to ends of hose

2. Lay domestic DN 100 drainage pipes from the filter outlet to

the pond inlet with a gradient of at least 1%. If the pipes are

not UV-resistant, possibly cover them with earth.Extend the

wastewater outlet with DN 70 drainage pipes.

3. Switch on pump and test water flow.

Special guidelines:

•The hose connections on the filter must be fitted with care.

•The filter must never overflow (e.g. due to a clogged drain).

Danger of pond emptying.

•The filter system is a biological system and requires a few

weeks after initial installation to become fully effective.

•The filter should be in permanent operation and never run dry.

Installation

Place filter on a firm level base. If using a UVC lamp, leave a gap

of at least 2 m to the water. You might wish to do this in any

case, should you wish to add a Bitron later on.

6. Bitron 36/72 (Illustration 4)

Put one 48 x 4 O-ring (18) on each Bitron outlet. Attach the

Bitron 36/72 through the boreholes in the container and press

a 48 x 4 O-ring (18) against the container wall from the inside

for each attachment. Screw the inlet nozzle (3) on. See also the

instructions for the Bitron 36/72.

Maintenance and cleaning (Illustration 5)

Biotec filters are maintenance-free, however they should be

cleaned whenever necessary.

To drain off the wastewater, pull out the slide valve (19). This lets

the wastewater drain away freely. If necessary, some clean water

can be drained via the clear water outlet (14). This significantly

reduces the amount of dirty water.

1. Clean the filter brushes (20) as often as possible. To do this,

rinse the brush frame. This can be done inside or outside the

container. The bottom end of the brushes should rest on the

black filter mat.(Illustration 6)

2. Only clean the filter mats (21) when necessary. They become

more effective as bacterial growth increases. The filter mats

can also be cleaned inside or outside the container. The filter

mats 1-5 must be fitted in the correct order. Filter mat # 5 has

a sealing lip. This must rest on the intermediate base (25).

(Illustration 6)

3. Clean the blue (22) and red (23) sponges when the water

through-flow is no longer adequate and the water level rises

above the sponges. The sponge holders can be easily pulled

out of the intermediate base (25) to facilitate cleaning.

Only rinse filter elements with water. Do not use chemical

cleansing agents!

Directions for use

Winter

Clean filter, empty container and hoses and leave to dry.

Guarantee

A function guarantee of 3 years is given on this OASE device.

The guarantee begins with the day the device is sold or prior to this

with the day it was first put into operation. The certificate is only

valid together with the receipt of purchase.

Our guarantee covers faults in material or defects of fabrication.

Our guarantee does not apply to claims resulting from installation

andoperationfaultsaswellaslackofmaintenance,effectsoffrost,

furring or inexpert repair attempts, as well as all wear parts.

Ourmanufacturing department exclusively uses quality materials.

Should the device, in spite of this, give rise to a justified claim, you

will be entitled to have the device retouched free of charge or the

defective parts replaced. We reserve the right to charge assembly

costs.Allguaranteerepairsarecarried out by us or by a repair shop

authorised by us. We do not accept liability for subsequent

damage resulting from the failure of this device. Should you ever

have to make a guarantee claim, please send the device under

Directions for use

objectionordevicecomponenttogetherwithyourreceipt,guarantee

cardand specificationof thedefect tous, freightprepaid. Complaints

due to damage in transit can only be referred to the appropriate

quarter if the damage was ascertained and confirmed on receipt of

the goods on behalf of the forwarding agent, the railway or post

office. Only then is it possible to lodge claims against the

forwarding agent, railway or post office.

15. Gasket DN100

16. Outlet pipe DN 100 x 150

20. Brush frame

22. Filter sponge - blue

23. Filter sponge - red

24. Container

25. Intermediate base

26. Sponge holder

27. Lid

28. Inlet set

29. Filter mat T - black

30. Filter mat H - black

31. Filter mat T - green

32. Filter mat H - green

33. Filter mat with sealing lip

34. Base outlet set

35. Spacer

36. 1“ outlet set

37. Outlet pipe DN 100 x 500

Directions for use

34353615

37 2225

Afb. 1

Afb. 2

7 6

2 1

1112131314

1516

innen

inside

dedans

binnen

Afb. 4

Afb. 3 1718

18318

18 2

318 18

Afb. 5

Afb. 6

25 #5

Andere Handbücher für Biotec 30

Inhaltsverzeichnis

Andere Oase Wasserfiltersystem Handbücher

Oase

Oase Filtoclear 3000 Bedienungsanleitung

Oase

Oase BioSmart 18000 Bedienungsanleitung

Oase

Oase Bitron Eco 120W Bedienungsanleitung

Oase

Oase FiltoClear 5000 Bedienungsanleitung

Oase

Oase BioPlus 50 Bedienungsanleitung

Oase

Oase ProfiClear Premium Bedienungsanleitung

Oase

Oase Filtoclear 3000 Wartungs- und Serviceanleitung

Oase

Oase Bitron 36C Bedienungsanleitung

Oase

Oase Complete Filter Kit 1300 Bedienungsanleitung

Oase

Oase BioSmart 5000 Bedienungsanleitung

Oase

Oase BioSmart 30000 Bedienungsanleitung

Oase

Oase Pontec Multi Clear Set 5000 Bedienungsanleitung

Oase

Oase ProfiClear Premium XL Bedienungsanleitung

Oase

Oase BioTec Premium 80000 Bedienungsanleitung

Oase

Oase FiltoClear 20000 Bedienungsanleitung

Oase

Oase ProfiClear Premium Compact-L EGC Bedienungsanleitung

Oase

Oase ProfiClear Premium XL Moving Bed Modul Bedienungsanleitung

Oase

Oase Filtral 2500 UVC Bedienungsanleitung

Oase

Oase FiltoMatic CWS 7000 Bedienungsanleitung

Oase

Oase Aquarius Universal Classic 1000 / 12 V Bedienungsanleitung

Oase

Oase Vitronic 11 W Bedienungsanleitung

Oase

Oase Filtral 1500 UVC Bedienungsanleitung

Oase

Oase BioTec 32000 Bedienungsanleitung

Oase

Oase FiltoSmart 100 Bedienungsanleitung

Beliebte Wasserfiltersystem Handbücher anderer Marken

Wisy

Wisy LineAir 100 Bedienungsanleitung

Schaffner

Schaffner Ecosine FN3446 Series Betriebsanleitung

Pentair

Pentair FLECK 4600 SXT Benutzerhandbuch

H2O International

H2O International H20-500 Bedienungsanleitung

Renkforce

Renkforce 2306241 Bedienungsanleitung

Neo-Pure

Neo-Pure TL3-A502 Bedienungsanleitung

FLTR

FLTR OBF Bedienungsanleitung

STA-RITE

STA-RITE VERTICAL GRID DE FILTERS S7D75 Bedienungsanleitung

Applied Membranes

Applied Membranes W-G844EM Bedienungsanleitung

BEGA

BEGA 116 Bedienungsanleitung

WATA

WATA Standard Bedienungsanleitung

Price

Price FFU series Handbuch

Gaggenau

Gaggenau BRITA INTENZA 467873 Bedienungsanleitung

Brita

Brita SAFF-100 Bedienungsanleitung

HEISSNER

HEISSNER FPU24000-00 Bedienungsanleitung

BGS technic

BGS technic 1518 Bedienungsanleitung

Reverse Osmosis

Reverse Osmosis RF Series Bedienungsanleitung

ubbink

ubbink Filtramax Series Bedienungsanleitung